IllustrationI WAS BRAKING WHILE EXITING THE FREEWAY AND LOST THE REAR BRAKES. AFTER AN INSPECTION, I FOUND THE BRAKE LINE BROKE ABOUT MIDWAY THROUGH THE CHASSE. I ALSO FOUND THAT THE BRAKE LINES WOULD CRACK WHERE EVER YOU BENT THEM. I HAD TO HAVE ALL THE BRAKE SYSTEM REPLACED BECAUSE OF CORROSION AT A COST OF $2143.00.
1996 Chevrolet Express 1500
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Express 1500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 4 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
Service Brakes complaints
2 reportsWIFE COMPLAINED OF PULSATING BRAKE PEDAL, TOOK VEHICLE FOR A SHORT TEST DRIVE, ON THE WAY BACK WHILE TRAVELING IN A STRAIGHT LINE AT APPROX. 30 MPH MADE A STOP APPLYING MODERATE PEDAL PRESSURE, BRAKE PEDAL WENT TO FLOOR. CAREFULLY DROVE THE REMAINING 1/8TH MILE HOME AND CRAWLED UNDERNEATH VAN. BRAKE LINES A MASS OF RUST, LINE TH…
Read full complaint
WIFE COMPLAINED OF PULSATING BRAKE PEDAL, TOOK VEHICLE FOR A SHORT TEST DRIVE, ON THE WAY BACK WHILE TRAVELING IN A STRAIGHT LINE AT APPROX. 30 MPH MADE A STOP APPLYING MODERATE PEDAL PRESSURE, BRAKE PEDAL WENT TO FLOOR. CAREFULLY DROVE THE REMAINING 1/8TH MILE HOME AND CRAWLED UNDERNEATH VAN. BRAKE LINES A MASS OF RUST, LINE THAT RUNS BACK ALONG LEFT SIDE RAIL FROM WHAT LOOKS LIKE AN ABS UNIT BURST UPON PEDAL APPLICATION AND WAS DRIPPING BRAKE FLUID, MASTER CYLINDER WAS ALMOST EMPTY UPON INSPECTION. THE MOST UNSAFE AND UNRELIABLE VEHICLE I HAVE EVER OWNED. AT 40,000 MILES A REAR LINE FROM THE PROPORTIONING VALVE ALSO RUSTED THROUGH BUT AT LEAST DID NOT BURST SUDDENLY, STARTED DRIPPING. IT AND THE 2 REAR WHEEL CYLINDERS WHICH WERE ALSO A MASS OF RUST NEEDED REPLACEMENT. *TR
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.