IllustrationINSIDE DOOR PANEL SHOWING RUST ON ALL 4 DOORS, SOME MORE THAN OTHERS. COMING FROM BOTTOM WHERE SKINS CLIP ONTO DOOR FRAME. SHOULD NOT HAPPEN ON A 6 YEAR OLD CAR.
2012 Chevrolet Equinox
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2012 Chevrolet Equinox do not stand out strongly from the model-year median of 382.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Equinox years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
510–25K
5325–50K
11450–75K
11375–100K
137100–150K
30150K+
498 reports with mileage · 185 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 354 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility/wiper. Review the 121 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 84 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
16 crash reports6 fire reports11 injury reports
What owners actually said
683 reportsCHECK ENGINE LIGHT GOES OFF AND ON. VEHICLE OFTEN STALLS UPON STOPPING AND AT TIMES HAS AN EXTREMELY HARD DECEL, WHICH CONTINUES AFTER THE KEY IS TAKEN OUT OF THE IGNITION. VEHICLE IDLES HARD. UPON PARKING, VEHICLE HAS SUDDENLY REPORTED REDUCED ENGINE POWER" AND " CHECK STABILI TRAK" NOT ALLOWING THE VEHICLE TO GO OVER 40 MP…
Read full complaint
CHECK ENGINE LIGHT GOES OFF AND ON. VEHICLE OFTEN STALLS UPON STOPPING AND AT TIMES HAS AN EXTREMELY HARD DECEL, WHICH CONTINUES AFTER THE KEY IS TAKEN OUT OF THE IGNITION. VEHICLE IDLES HARD. UPON PARKING, VEHICLE HAS SUDDENLY REPORTED REDUCED ENGINE POWER" AND " CHECK STABILI TRAK" NOT ALLOWING THE VEHICLE TO GO OVER 40 MPH.
I PURCHASED A 2012 GM EQUINOX ON SEPT. 6, 2017 SEPT 9 MY CHECK ENGINE LIGHT CAME ON AND VEHICLE WAS LOW ON OIL ' WE ADDED OIL SEPT 13 I HAD A TIRE CLAIM DUE TO TIRES BEING 'DRY ROTTED' PER DEALERSHIP. OCT 19 CAR STARTED DRIVING FUNNY, STALLING ' STOPPED IN MIDDLE OF ROAD WITH MY 18 MONTH OLD SON AND MY 8 YEAR OLD DISABLE…
Read full complaint
I PURCHASED A 2012 GM EQUINOX ON SEPT. 6, 2017 SEPT 9 MY CHECK ENGINE LIGHT CAME ON AND VEHICLE WAS LOW ON OIL ' WE ADDED OIL SEPT 13 I HAD A TIRE CLAIM DUE TO TIRES BEING 'DRY ROTTED' PER DEALERSHIP. OCT 19 CAR STARTED DRIVING FUNNY, STALLING ' STOPPED IN MIDDLE OF ROAD WITH MY 18 MONTH OLD SON AND MY 8 YEAR OLD DISABLED DAUGHTER. HAD TO CALL SOMEONE TO COME. WHEN CHECKED VEHICLE HAD ALMOST NO OIL IN IT AGAIN. OCT 29 ' BRINGING DISABLED DAUGHTER TO SCHOOL WHEN CAR STALLED IN MIDDLE OF ROAD. CHECKED AND THERE WAS ALMOST NO OIL IN IT. WE HAVE HAD TO ADD OIL TO VEHICLE AT LEAST ONCE A WEEK SINCE JUST TO MAKE SURE I DIDN'T BREAK DOWN TAKING MY DAUGHTER TO SCHOOL. WE DID THIS EVERY MONDAY JUST AS PREVENTATIVE MAINTENANCE BECAUSE OBVIOUSLY THERE WAS A PROBLEM WITH THE MOTOR. FEB 6 ' EVEN AFTER KEEPING OIL IN VEHICLE WEEKLY MY CAR WOULDN'T START THIS MORNING. CHECKED OIL ETC. IT FINALLY STARTED UP LATER THAT DAY AND I WENT TO GET MY STEP DAUGHTERS. WHEN WE GOT READY TO LEAVE AND TRIED TO CRANK CAR IT MADE A LOUD WHINY KIND OF SOUND AND IT SMELLED LIKE WIRES OR SOMETHING BURNING. STEERING LOCKED UP AND IT WOULDN'T TURN OVER AGAIN AND I COULDN'T REMOVE KEY FROM IGNITION. THE VEHICLE WOULDN'T CRANK BACK. CALLED SOMEONE TO COME. THEY CHECKED BATTERY, FUSES, ETC. I ENDED UP HAVING TO LEAVE MY CAR WHERE IT WAS OVERNIGHT BELIEVING IT WAS AN IGNITION PROBLEM. FEB 7 ' MECHANIC WAS CALLED TO CHECK CAR. REAR MAIN SEALED WAS BUSTED, TIMING CHAIN HAD BROKEN AND SEVERELY DAMAGED ENTIRE MOTOR. ENTIRE ENGINE WAS COMPLETELY SHOT AND HAD NUMEROUS BROKEN PIECES! I WAS TOLD THERE WAS NO WARRANTY ON THIS AND DEALERSHIP COULDN'T DO ANYTHING ABOUT IT. I DECIDED TO DO SOME RESEARCH. THERE ARE LITERALLY HUNDREDS OF COMPLAINTS WITH DETAILS VERY SIMILAR TO MY OWN AND END RESULTS THE SAME AS MY OWN.
WHILE DRIVING ON THE INTERSTATE MY POWER STEERING GAVE OUT ALMOST CAUSING ME TO CRASH INTO A BRICK WALL WITH MY CHILDREN THIS IS A KNOWN ISSUE AND SOMETHING HAS TO BE DONE ABOUT THIS.
THERE SEEMS TO BE AN ISSUE WITH THE FUEL PUMP CLOGGING/NOT WORKING PROPERLY. I HAVE RESEARCHED IT AND EVEN CONTACTED CHEVY ABOUT THE INFERIOR FUEL PUMPS IN ALL THE EQUINOX MODELS
WAS ALL DAY WITH MY WINDSHIELD WIPERS WORKING THEN I WENT TO THE MOVIES AT NIGHT TIME AND WHEN I WAS LEAVING IT STARTED POURING AND MY WI DAGWOOD WIPERS WORKED FOR 20 SECONDS THEN CUT OFF. I HAD TO DRIVE 20 MILES ON THE HIGHWAY WITH NO WINDSHIELD WIPERS WHILE IT WAS PORING DOWN RAIN.
MY VEHICLE WAS BURNING EXCESSIVE AMOUNTS OF OIL. I TOOK IT IN BECAUSE IT WAS RUNNING POORLY, THEY DISCOVERED IT WAS 3 QUARTS LOW ON OIL, AND THEN HAD ME TRACK MY OIL CONSUMPTION (BY CHECKING THE OIL ONCE A WEEK FOR 2,000 MILES). CHEVROLET HAD A RECALL FOR THIS ISSUE (ONLY IF YOUR CAR WAS EXPERIENCING THIS) AND LUCKILY IT WAS COV…
Read full complaint
MY VEHICLE WAS BURNING EXCESSIVE AMOUNTS OF OIL. I TOOK IT IN BECAUSE IT WAS RUNNING POORLY, THEY DISCOVERED IT WAS 3 QUARTS LOW ON OIL, AND THEN HAD ME TRACK MY OIL CONSUMPTION (BY CHECKING THE OIL ONCE A WEEK FOR 2,000 MILES). CHEVROLET HAD A RECALL FOR THIS ISSUE (ONLY IF YOUR CAR WAS EXPERIENCING THIS) AND LUCKILY IT WAS COVERED TO BE FIXED. HOWEVER, BECAUSE OF THE EXCESSIVE OIL CONSUMPTION, I HAVE HAD OTHER ISSUES AND PROBLEMS WITH MY CAR. ALL DURING THE SAME TIME PERIOD, MY MANIFOLD CRACKED AND I NEED A NEW CATALYTIC CONVERTER. I DEFINITELY THINK (AND THE SERVICE ADVISOR AGREED) THAT THE REASON THAT MY EMISSIONS SYSTEM IS RUNNING INEFFICIENTLY, IS BECAUSE MY ENGINE WAS BURNING SO MUCH OIL. ALL OF THE OIL SOOT AND FUMES RUN THROUGH THE ENGINE AND EMISSION SYSTEM, THEREFORE CLOGGING UP MY CATALYTIC CONVERTER. SEEMS TO ME, THAT THE CATALYTIC CONVERTER SHOULD BE COVERED UNDER THE OIL CONSUMPTION RECALL. I CAN UNDERSTAND IF IT WERE ON A CASE TO CASE BASIS (JUST LIKE THE OIL CONSUMPTION RECALL IS), BUT IT SHOULD BE REPLACED IF YOUR CAR IS EXPERIENCING THOSE ISSUES. ALL STEMMING BACK TO THE OIL CONSUMPTION.
I WAS DRIVING WITH MY WIFE AND DOG IN THE CAR LATE AT NIGHT IN COLD ICIEY CONDITIONS IN WYOMING. CAR BEGAN TO LOSE POWER DRAMATICALLY, STEERING WAS TIGHT, LIGHTS DIMMED, ALSO ENGINE STALLED AFTER A BIT A OF A SLIDE AND SAFELY PULLING OVER. WE COULD HAVE WRECKED IN THE MIDDLE OF NOWHERE IN THE ICEY COLD TEMPERATURES. ENGINE LIG…
Read full complaint
I WAS DRIVING WITH MY WIFE AND DOG IN THE CAR LATE AT NIGHT IN COLD ICIEY CONDITIONS IN WYOMING. CAR BEGAN TO LOSE POWER DRAMATICALLY, STEERING WAS TIGHT, LIGHTS DIMMED, ALSO ENGINE STALLED AFTER A BIT A OF A SLIDE AND SAFELY PULLING OVER. WE COULD HAVE WRECKED IN THE MIDDLE OF NOWHERE IN THE ICEY COLD TEMPERATURES. ENGINE LIGHT WAS ONE. TRACTION CONTROL LIGHT WAS ON. DASH READS 'SERVICE STABILITRAK' AND 'ENGINE POWER REDUCED !'. I COULD NOT GET THE CAR TO QUIT STALLING. I WASN'T SAFELY ABLE TO DRIVE IT. SO I THEN DID A ECU RESET. (DISCONNECT ECU AND BATTERY). SAT FOR 20 MINUTES. RESTARTED AND STILL SAME PROBLEM AFTER IT IDLED ROUGH FOR 5 MINUTES ROUGHLY. SO NEXT I DISCONNECTED THE ECU FUSE NUMBER 42 IN THE ENGINE FUSE BOX. I THEN TURNED KEY IN FIRST POSITION AND HAD SAME READINGS. NEXT I RESET THE CODE WITH MY OBD SCAN TOOL. REPEATED THE FUSE METHOD AGAIN... STILL SAME READING BUT WITHOUT STARTING THE MOTOR ONCE DURING THIS.... MY GUESS IS THE ECU IS VOLITIL TO THIS VEHICLE MOTOR CLASS. SERVICE BULLETIN STATES IT NEEDS A REFLASH. UPDATES FOR ENGINE OIL CONSUMPTION AS WELL. VERY INTERESTING AS WE CONSUME TOO MUCH OIL. I BELIEVE ALL MOTOR ISSUES IN OUR VEHICLE WE HAVE NOW (WORN PISTON RINGS ETC) ARE DUE TO A FAULTY ECU. THE FACT THAT THE WARNING SHOWS WHEN RESET AND NOT CONNECTED BECAUSE THE FUSE IS REMOVED PROVES TO ME THE ECU IS HAVING SOFTWARE ISSUE IN RENDERING PROPER DIAGNOSTICS AS WELL AS SAFE ENGINE PERFORMANCE. THIS INCIDENT TOOK PLACE IN AUGUST OF 2017. PROBLEM STILL PERSISTS IN DRY CLIMATES WHERE WE LIVE IN TEXAS. SAME ISSUES. SAME SYMPTOMS. NEW SENSORS, BATTERY, SPARK PLUGS AND OIL CHANGE REGULARLY. THIS VEHICLE IS UNSAFE AND WILL TAKE LIVES IF NOT RECALLED. IMAGINE DRIVING ON ICE WITH YOUR KIDS INSIDE AND THEN YOUR STEERING GOES OUT AND THE ENGINE LOSES POWER AND BRAKES.... IS THAT WHAT IT WILL TAKE?
WHILE DRIVING ON INTERSTATE ON 2/1/18 MY OIL LIGHT CAME ON SO I PULLED OVER AS QUICK AS I COULD AND SHUT OFF THE CAR. I LIVE IN ND AND IT WAS BELOW ZERO AND IT HAS BEEN EXTREMELY COLD. NOT SURE WHAT HAPPENED OR WHY THERE WAS A PILE OF OIL UNDER MY CAR I GOT IT TOWED TO THE SHOP TO FIND OUT MY REAR MAIN SEAL BLEW OUT. THE TECHNIC…
Read full complaint
WHILE DRIVING ON INTERSTATE ON 2/1/18 MY OIL LIGHT CAME ON SO I PULLED OVER AS QUICK AS I COULD AND SHUT OFF THE CAR. I LIVE IN ND AND IT WAS BELOW ZERO AND IT HAS BEEN EXTREMELY COLD. NOT SURE WHAT HAPPENED OR WHY THERE WAS A PILE OF OIL UNDER MY CAR I GOT IT TOWED TO THE SHOP TO FIND OUT MY REAR MAIN SEAL BLEW OUT. THE TECHNICIAN TOLD ME THAT THERE WERE ICE CRYSTALS AROUND THE MAIN SEAL AND THERE WAS NOTHING THAT COULD HAVE PREVENTED IT FROM HAPPENING. I PAID $1,700 TO GET IT FIXED AND THE SHOP SAID THAT THE ENGINE WAS STILL GOOD. WELL I PICKED IT UP FROM THE SHOP AND DROVE HOME (I LIVE 40 MILES OUT OF TOWN) AND IT SEEMED FINE. UNFORTUNATELY WHEN I WAS DRIVING TO WORK THE NEXT DAY, MIND YOU IT WAS STILL WELL BELOW ZERO DEGREES OUTSIDE, THE ENGINE STARTED KNOCKING AND I SHUT OF THE CAR AS FAST AS I COULD; I GOT STRANDED ALONG THE INTERSTATE AGAIN BUT THIS TIME WITH MY 6 MONTH OLD SON' SITTING IN THE FREEZING COLD WAITING FOR A RIDE' I AM STILL FURIOUS!! I GOT THE EQUINOX TOWED TO THE SHOP AGAIN TO FIND OUT THAT MY ENGINE IS NOW WRECKED. THERE IS ONLY 84,000 MILES ON THE VEHICLE AND IT NEEDS A NEW ENGINE. THIS IS RIDICULOUS; HOPEFULLY CHEVROLET WILL KEEP ME AS A CUSTOMER AND PAY FOR THE ENGINE THAT GOT WRECKED BECAUSE OF THEIR FAULTY REAR MAIN SEAL THAT CAN'T PERFORM IN COLD WEATHER.
TL* THE CONTACT OWNS A 2012 CHEVROLET EQUINOX. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A RAPID OIL CONSUMPTION FAILURE. ALSO, THE ENGINE SHOOK AND VIBRATED WHILE IDLING. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (MEDBEV CHEVROLET, 11001 W. I-70 FRONTAGE ROAD N, WHEAT RIDGE, CO) WHERE IT WAS DIAGNOSED THAT THE TIMING BELT…
Read full complaint
TL* THE CONTACT OWNS A 2012 CHEVROLET EQUINOX. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A RAPID OIL CONSUMPTION FAILURE. ALSO, THE ENGINE SHOOK AND VIBRATED WHILE IDLING. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (MEDBEV CHEVROLET, 11001 W. I-70 FRONTAGE ROAD N, WHEAT RIDGE, CO) WHERE IT WAS DIAGNOSED THAT THE TIMING BELT HAD STRETCHED AND NEEDED TO BE REPLACED. WHILE REPAIRING THE TIMING BELT, THE MECHANIC DETERMINED THAT THE ENGINE WAS ALSO DAMAGED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 70,000.
Official recalls
316V502000 · Electrical System:ignition; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Jul 5, 2016
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Additional source detail variants (2)
Electrical System:ignition
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
14V447000 · Seats:front Assembly:power Adjust
Jul 23, 2014
General Motors LLC (GM) is recalling certain model year 2011-2012 Buick LaCrosse, Regal and Chevrolet Camaro, as well as certain 2010-2012 Cadillac SRX, Chevrolet Equinox and GMC Terrain vehicles, equipped with power height adjustable driver and passenger seats. In the affected vehicles, the bolt that secures the driver's and passenger's power front seat height adjuster may fall out causing the seat to drop suddenly to the lowest vertical position.
Consequence & remedy
Consequence: If the driver's seat unexpectedly drops, the distraction and altered seat position may affect the drivers' control of the vehicle, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the height adjuster shoulder bolts, free of charge. The manufacturer distributed interim letters to owners on September 11, 2014. The recall began on December 26, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-8006 (Cadillac), 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14271.
11V511000 · Tires:pressure Monitoring And Regulating Systems
Oct 19, 2011
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2012 CHEVROLET EQUINOX AND GMC TERRAIN VEHICLES, MANUFACTURED FROM JULY 18, 2011, THROUGH SEPTEMBER 6, 2011, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 138, "TIRE PRESSURE MONITORING SYSTEM" (TPMS). THE TIRE PRESSURE MONITORING SYSTEM IS DESIGNED TO ILLUMINATE THE TIRE PRESSURE WARNING LIGHT WHEN THE PRESSURE IN A TIRE IS 25% BELOW THE RECOMMENDED COLD TIRE PRESSURE. ON THESE VEHICLES, THE LIGHT WILL NOT ILLUMINATE UNTIL THE TIRE PRESSURE IS MORE THAN 25% BELOW THE RECOMMENDED COLD TIRE PRESSURE.
Consequence & remedy
Consequence: UNDERINFLATED TIRES CAN RESULT IN TIRE OVERLOADING AND OVERHEATING, WHICH COULD LEAD TO A BLOWOUT AND POSSIBLE CRASH. THE RESULTING CRASH COULD CAUSE SERIOUS INJURY. UNDERINFLATED TIRES CAN ALSO RESULT IN PREMATURE OR IRREGULAR WEAR, POOR HANDLING, AND POOR FUEL ECONOMY.
Remedy: GM DEALERS WILL UPDATE THE BODY CONTROL MODULE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 9, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE20009 · Momentary Increased Steering Effort
Opened Jun 1, 2020 · Closed Jun 3, 2022
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
Additional source detail variants (2)
Steering:electric Power Assist System
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
Steering
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
EA19005 · Front Wiper Transmission Inoperative
Opened Dec 13, 2019 · Closed Nov 28, 2022
Status: closed (inferred from source dates) · Visibility; Visibility/wiper; Visibility:windshield Wiper/washer:linkages
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Additional source detail variants (3)
Visibility
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Visibility:windshield Wiper/washer:linkages
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Visibility/wiper
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
RQ18002 · Windshield Wiper Transmission Failure
Opened Nov 2, 2018 · Closed Dec 19, 2019
Status: closed (inferred from source dates) · Visibility; Visibility/wiper; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages; Visibility:windshield Wiper/washer:motor
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Additional source detail variants (5)
Visibility
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer:linkages
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer:motor
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility/wiper
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.