IllustrationPCV ORIFICE FROZEN WITH ICE, CAUSED CRANKCASE OVERPRESSURIZATION AND BLEW OUT REAR CRANKSHAFT SEAL, LOST ALL ENGINE OIL. VEHICLE WAS ON HIGHWAY AT 65 MPH.
2011 Chevrolet Equinox
Owner reports · Recalls · Investigations
More warning signs than most Equinox years
Owner complaints for the 2011 Chevrolet Equinox are substantially higher than the model-year median of 382.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Equinox years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1030–25K
6725–50K
11650–75K
12775–100K
181100–150K
38150K+
632 reports with mileage · 150 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 386 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 145 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 74 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
30 crash reports3 fire reports26 injury reports
Engine complaints
386 reportsI JUST HAD TO REPLACE THE EXHAUST MANIFOLD FOR THE SECOND TIME IN 2 YEARS ON MY 2011 CHEVY EQUINOX DUE TO VERY LARGE CRACKS. THE CAR HAS AROUND 90,000 MILES ON IT AND I REALOZE IT'S 7 YEARS OLD, BUT I TALE PRETTY GOOD CARE OF IT AND GET REGULAR MAINTENCE USUALLY AT AN ACTUAL CHEVY DEALERSHIP. THE FIRST TIME I EXPRESSED MY SUPRIS…
Read full complaint
I JUST HAD TO REPLACE THE EXHAUST MANIFOLD FOR THE SECOND TIME IN 2 YEARS ON MY 2011 CHEVY EQUINOX DUE TO VERY LARGE CRACKS. THE CAR HAS AROUND 90,000 MILES ON IT AND I REALOZE IT'S 7 YEARS OLD, BUT I TALE PRETTY GOOD CARE OF IT AND GET REGULAR MAINTENCE USUALLY AT AN ACTUAL CHEVY DEALERSHIP. THE FIRST TIME I EXPRESSED MY SUPRISE TO THE MECHANIC WHEN HE YOLD ME THERE WAS A VERY LARGE CRACK IN THE EXHAUST MANIFOLD. HIS RESPONSE WAS THAT CHEVY EQUINOXES ARE WIDELY KNOWN TO GO THROUGH MANIFOLDS QUICKLY AND FREQUENTLY, AGAIN THIS WAS AT AN ACTUAL CHEVY SERVICE STATION AT A CHEVY DEALERSHIP. THE SECOND TIME LESS THAN 2 YEARS LATER WHEN THE CHECK ENGINE LIGHT CAME ON AGAIN I TOOK MY VEHICLE TO TH AAA CERTIFIED CARE CARE CENTER AND AGAIN SAME THING, MANIFOLD LARGE CRACK MUST BE REPLACED AND AAA TECH TOLD ME SAME STORY, CHEVY EQUINOX MANIFOLD ARE WIDELY KNOWN NOT TO LAST. ONLY THIS TIME IN ADDITION TO THE MANIFOLD, THE CRACKED MANIFOLD HAD SOMEHOW CAUSED DAMAGE TO THE CATALYTIC CONVERTER WHICH IS NOW BROKEN AND MUST BE REPLACED. SO MY QUESTION IS, IF THESE ARE WIDELY KNOWN DEFECTS AMONG 2010-2011 CHEVY EQUINOXES, WHY HASNT CHEVY ISSUED RECALLS FOR MANIFOLDS AND CARALYTIC CONVERTERS?
EVER SINCE I HAVE BOUGHT THIS VEHICLE IT IS A LEMON. I HAVE ALL THE RECEIPTS AS WELL AS RESEARCH THAT GM NEEDS TO RECALL THIS VEHICLE DUE TO SAFETY ISSUES AND EVERYONE HAS THE SAME PROBLEM AS MYSELF. FROM THE OIL CONSUMPTION AND STILL HAVING PROBLEMS AND EVEN SMELLS LIKE BURNING CAUSING ODOR WHICH IS VERY STRONG, STALLING ISSUES…
Read full complaint
EVER SINCE I HAVE BOUGHT THIS VEHICLE IT IS A LEMON. I HAVE ALL THE RECEIPTS AS WELL AS RESEARCH THAT GM NEEDS TO RECALL THIS VEHICLE DUE TO SAFETY ISSUES AND EVERYONE HAS THE SAME PROBLEM AS MYSELF. FROM THE OIL CONSUMPTION AND STILL HAVING PROBLEMS AND EVEN SMELLS LIKE BURNING CAUSING ODOR WHICH IS VERY STRONG, STALLING ISSUES WHERE MY CAR HAS EVEN STOPPED IN THE MIDDLE OF THE HIGHWAY AFTER A NEW ENGINE WAS PUT IN, THE ENGINE TICKING STILL DOES AND STALLING EVEN WITH NEW ENGINE PUT IN HAVE VIDEO OF THE SOUNDS IT MAKES THAT THEY CAN'T SEEM TO FIGURE OUT WHAT'S GOING ON AFTER ALL THIS TIME AND THE CLATTERING NOISE WHEN THE CAR IS STARTED. I HAVE CONTACTED GM NUMEROUS TIMES BECAUSE I DO NOT FEEL SAFE WITH ME NOR MY CHILDREN IN THIS CAR. WITH ALL THE COMPLAINTS ONLINE AND THEY STILL WON'T RECALL THE VEHICLE AND BE CONCERNED FOR THE SAFETY OF THE CUSTOMER. I HAVE ALL MY RECEIPTS AS WELL AS ALL THE RESEARCH I HAVE DONE AND EVEN THE DEALER KEEPS GIVING ME THE RUN AROUND WITH EVERYTHING WRONG WITH IT AND SAYS IT'S SOMETHING DIFFERENT ALL THE TIME JUST TO TRY AND GET MORE MONEY AND STILL HAVING TO TAKE IT IN THE SHOP BUT THIS TIME WAS TOLD OH IT'S NOT SAFE TO DRIVE BUT YET TRIED TO SAY IT WAS THE TIRES THIS TIME WHICH IT WASN'T BECAUSE THERE IS BRAND NEW TIRES ON IT. SO I HATE DRIVING THIS CAR EVEN TO WORK LET ALONE WITH MY CHILDREN BECAUSE I DON'T KNOW WHEN IT WILL STOP AGAIN AND CAUSE ME TO WRECK OR GET HIT OR EVEN THE FUMES CAUSING PROBLEMS WHICH THEY DON'T NEED TO INHALE. GM NEEDS TO RECALL THIS VEHICLE BECAUSE OF ALL THE ISSUES I HAVE HAD AND STILL CONTINUE TO HAVE AND PROVIDE ME WITH A SAFER VEHICLE. I HAVE ALREADY FILED WITH THE BBB AND WILL BE SPEAKING WITH STATE ATTORNEY GENERAL AS WELL. IF NEED PROOF OF RECEIPTS I CAN FAX THOSE.
I OWN A 2011 CHEVROLET EQUINOX LS AWD WITH ROUGHLY 86,000 MILES. WHILE DRIVING BACK AN APPOINTMENT THIS MORNING, THE VEHICLE BEGAN TO SPUTTER AND THE "ENGINE REDUCED POWER"/"SERVICE STABILITRAK SYSTEM" LIGHTS TURNED ON. I WAS ON THE INTERSTATE WITH MORNING TRAFFIC THAT WAS GOING 70MPH (THE SPEED LIMIT) AND HIGHER. THE VEHICLE'S …
Read full complaint
I OWN A 2011 CHEVROLET EQUINOX LS AWD WITH ROUGHLY 86,000 MILES. WHILE DRIVING BACK AN APPOINTMENT THIS MORNING, THE VEHICLE BEGAN TO SPUTTER AND THE "ENGINE REDUCED POWER"/"SERVICE STABILITRAK SYSTEM" LIGHTS TURNED ON. I WAS ON THE INTERSTATE WITH MORNING TRAFFIC THAT WAS GOING 70MPH (THE SPEED LIMIT) AND HIGHER. THE VEHICLE'S RPM REDUCED SUDDENLY AND DRASTICALLY, AND I WAS ONLY ABLE TO SUSTAIN 40MPH. I WAS ALONE. I COASTED OFF THE HIGHWAY AS QUICKLY AS I COULD, STOPPED AT THE MULTI-LANE INTERSECTION, AND THE VEHICLE COMPLETELY SHUT OFF. I COULD NOT RESTART IT. IT WAS 9 DEGREES OUTSIDE WITH SNOW ON THE GROUND, AND THE HEAT STOPPED WORKING IN THE VEHICLE, TOO. THE POWER STEERING SHUT DOWN. I HAD TO WAIT OUTSIDE TO DIRECT TRAFFIC SO THAT I WOULD NOT GET HIT. IT WAS A FRIGHTENING EXPERIENCE. AFTER THE TOW TO THE DEALERSHIP, THE MECHANIC NOTIFIED ME THAT THE ENTIRE ENGINE NEEDS TO BE REPLACED, QUOTING ME BETWEEN $2300 FOR A USED ENGINE AND $6500 FOR A NEW ONE. CORPORATE HAS ONLY OFFERED 10% COST SHARE FOR A NEW ENGINE. THIS IS UNACCEPTABLE AND A KNOWN ISSUE BASED ON CONSUMER COMPLAINTS I HAVE READ. THE COMPLAINTS ARE CONSISTENT AND POINT TO ENGINE FAILURE WITH TOTAL REPLACEMENT IN THE RANGE I WAS QUOTED. I DO NOT HAVE THE MONEY TO REPLACE THE ENGINE, AND IT IS A SHAME THAT A VEHICLE WITH SO FEW MILES AND YEARS NEEDS THIS TYPE OF REPAIR! FURTHERMORE, I COULD HAVE BEEN SEVERELY INJURED OR WORSE, AS HAS HAPPENED TO MANY OTHERS! THIS VEHICLE HAS HAD NO COLLISIONS, NO MAJOR DAMAGES, AND I HAVE KEPT UP WITH ALL RECOMMENDED MAINTENANCE. NOW I HAVE NO VEHICLE, NO POSSIBILITY TO RECOVER ITS VALUE, AND I AM DEVASTATED ABOUT THE FINANCIAL BLOW.
ENGINE FAILED DUE TO EXCESSIVE OIL CONSUMPTION. I WAS IN THE PROCESS OF WORKING THROUGH AN OIL CONSUMPTION TEST WITH THE DEALERSHIP BUT WAS UNABLE TO FINISH. MY CAR FAILED THANKFULLY WHILE IT WAS STATIONARY IN MY DRIVEWAY. IT IS MY UNDERSTANDING THAT THIS FAILURE COULD HAVE HAPPENED AT ANY TIME EVEN WITH MY KIDS IN THE CAR OR ON…
Read full complaint
ENGINE FAILED DUE TO EXCESSIVE OIL CONSUMPTION. I WAS IN THE PROCESS OF WORKING THROUGH AN OIL CONSUMPTION TEST WITH THE DEALERSHIP BUT WAS UNABLE TO FINISH. MY CAR FAILED THANKFULLY WHILE IT WAS STATIONARY IN MY DRIVEWAY. IT IS MY UNDERSTANDING THAT THIS FAILURE COULD HAVE HAPPENED AT ANY TIME EVEN WITH MY KIDS IN THE CAR OR ON THE HIGHWAY. I'VE BEEN TOLD THAT DUE TO THE VEHICLE CONSUMING EXCESSIVE OIL BETWEEN REGULAR OIL CHANGES IT RESULTS IN ISSUES WITH THE TIMING CHAIN WHICH EVENTUALLY LEAD TO ENGINE ISSUES AND ULTIMATELY FAILURE. THERE IS CURRENTLY A TECHNICAL SERVICE BULLETIN RELEASED BY GM FOR THE KNOWN ISSUE BUT NO INFORMATION WAS EVEN SENT TO ME ABOUT THE ISSUE SO THAT I COULD BE MADE AWARE OF IT AND MONITOR THE PROBLEM.
"TAKATA RECALL" MY VEHICLE IS HAVE PROBLEM WITH OIL CONSUMPTION, EXHAUST FUMES COMING OUT OF THE HEATER AND A RATTLING NOISE. I TOOK IT INTO THE SHOP IN THE CAR MECHANIC INFORMED ME THAT THAT THE PROBLEM IS NOT WORTH FIXING BECAUSE THE YEAR MAKE AND MODEL KEEPS GIVING PROBLEMS. HE SAID HE WORKED ON THE SAME TYPE OF VEHICLE MULTI…
Read full complaint
"TAKATA RECALL" MY VEHICLE IS HAVE PROBLEM WITH OIL CONSUMPTION, EXHAUST FUMES COMING OUT OF THE HEATER AND A RATTLING NOISE. I TOOK IT INTO THE SHOP IN THE CAR MECHANIC INFORMED ME THAT THAT THE PROBLEM IS NOT WORTH FIXING BECAUSE THE YEAR MAKE AND MODEL KEEPS GIVING PROBLEMS. HE SAID HE WORKED ON THE SAME TYPE OF VEHICLE MULTIPLE TIMES IN EVERY 2011 CHEVY EQUINOX HAS HAD THE SAME PROBLEMS. HE SAID IT'S NOT WORTH PUTTING THE MONEY INTO AND THAT THAT YEAR WAS A FAULTY CAR AND TO FIND OUT IF THERE WAS A RECALL BECAUSE OF THE NEGATIVE REPORTS. I LOOKED ONLINE NO RECALL SO I'M WONDERING WHY MULTIPLE VEHICLES ARE HAVING THE SAME SITUATION. HE SAID HE SPOKE WITH MY CAR DEALERSHIP AND THEY SAID THAT THIS PROBLEM IS VERY COMMON. AND JUST TODAY MY VEHICLE ENGINE STARTED SMOKING. I'M WORKING ON GETTING A PROBLEM.
MY 2011 CHEVROLET EQUINOX HAS A REALLY BAD TICKING COMING FROM THE TIMING BELT AREA. THIS CAR HAS BEEN IDLING ROUGH AND ITS VERY LOUD DO TO THE TICKING COMING FROM SIDE OF ENGINE. IT SOUND LIKE A 30 YEAR OLD CAR AND ITS BEEN DOING IT SINCE 66,000 MILES
STABILITRAK LIGHT COMES ON THEN ENGINE POWER REDUCED AND VEHICLE DROPPED FROM 65 TO 25 MPH INSTANTLY DRIVING ON HIGHWAY
IN 2014 FAILED OIL CONSUMPTION TEST GOT WORK DONE ON ENGINE REPLACING PISTON AND ETC NOW I HAD (1/2018 ) VEHICLE SHUTTING OFF AT STOP SIGNS OR LIGHTS .TOOK VECHICLE TO PERSONAL MECHANIC IT WAS DOWN A QUART OR OIL BUT WASN'T DUE FOR ANOTHER OIL CHANGE TILL 109.000 MILES .CAR WAS AT 106,000 MILES AT THIS TIME. WAS TOLD THA…
Read full complaint
IN 2014 FAILED OIL CONSUMPTION TEST GOT WORK DONE ON ENGINE REPLACING PISTON AND ETC NOW I HAD (1/2018 ) VEHICLE SHUTTING OFF AT STOP SIGNS OR LIGHTS .TOOK VECHICLE TO PERSONAL MECHANIC IT WAS DOWN A QUART OR OIL BUT WASN'T DUE FOR ANOTHER OIL CHANGE TILL 109.000 MILES .CAR WAS AT 106,000 MILES AT THIS TIME. WAS TOLD THAT I NEEDED AN UPPER FUEL PUMP,CAM SHAFT , TIMING CHAIN SET.AND PLUGS MISFIRED. AFTER CALLING GMC I WAS TOLD THAT I HAD NO WARRANTIES LEFT. SO I CALLED THE CHEVY CERTIFIED DEALER WHO PERFORM THE ENGINE WORK IN 2014 . I WAS TOLD THAT THEIR WARRANTY ONLY LAST FOR A YEAR AND THAT I HAVE SPECIAL COVERAGE STILL LEFT THAT MAY APLLY BUT WOULD HAVE TO BE INSPECTED BY THEIR SPECIALIST AND $100 FEE.NOW MIND YOU MY CAR WAS ALREADY BEING WORKED ON AT MY PRIVATE MECHANIC .AFTER PAYING $1375.00 FOR ALL THE ISSUES LISTED ABOVE MY CATALYST CONVERTER IS BAD. I BEEN HAVING ONGOING ENGINE ISSUES WITH THIS VECHICLE.
WITHOUT WARNING MY CHECK OIL PRESSURE LIGHT ILLUMINATED. I HAD LESS THAN A BLOCK TO GET TO THE SIDE OF THE HIGHWAY BEFORE MY ENGINE FAILED. AFTER HAVING IT INSPECTED BY 3 DIFFERENT INSPECTORS, IT WAS DETERMINED THAT MY PCV VALVE FROZE AND CAUSED MY REAR MAIN SEAL TO LEAK ALL MY OIL VERY RAPIDLY. THIS IN TURN CAUSED MY ENGINE TO …
Read full complaint
WITHOUT WARNING MY CHECK OIL PRESSURE LIGHT ILLUMINATED. I HAD LESS THAN A BLOCK TO GET TO THE SIDE OF THE HIGHWAY BEFORE MY ENGINE FAILED. AFTER HAVING IT INSPECTED BY 3 DIFFERENT INSPECTORS, IT WAS DETERMINED THAT MY PCV VALVE FROZE AND CAUSED MY REAR MAIN SEAL TO LEAK ALL MY OIL VERY RAPIDLY. THIS IN TURN CAUSED MY ENGINE TO SEIZE. THIS PVC ISSUE IS A KNOWN ISSUE AND NO RECALL HAS BEEN ISSUED. THIS IS SOMETHING GM NEEDS TO TAKE OWERSHIP OF AND CORRECT! THIS IS AN EXTREME SAFETY HAZARD!
Official recalls
316V502000 · Electrical System:ignition; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Jul 5, 2016
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Additional source detail variants (2)
Electrical System:ignition
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
14V447000 · Seats:front Assembly:power Adjust
Jul 23, 2014
General Motors LLC (GM) is recalling certain model year 2011-2012 Buick LaCrosse, Regal and Chevrolet Camaro, as well as certain 2010-2012 Cadillac SRX, Chevrolet Equinox and GMC Terrain vehicles, equipped with power height adjustable driver and passenger seats. In the affected vehicles, the bolt that secures the driver's and passenger's power front seat height adjuster may fall out causing the seat to drop suddenly to the lowest vertical position.
Consequence & remedy
Consequence: If the driver's seat unexpectedly drops, the distraction and altered seat position may affect the drivers' control of the vehicle, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the height adjuster shoulder bolts, free of charge. The manufacturer distributed interim letters to owners on September 11, 2014. The recall began on December 26, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-8006 (Cadillac), 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14271.
10V623000 · Seat Belts:front:buckle Assembly
Dec 15, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2011 CADILLAC SRX, CHEVROLET EQUINOX AND GMC TERRAIN VEHICLES. THE DRIVER AND /OR FRONT PASSENGER SAFETY BELT BUCKLE ANCHOR MAY FRACTURE AND SEPARATE NEAR THE SEAT ATTACHMENT IN A VEHICLE CRASH.
Consequence & remedy
Consequence: THE SAFETY BELT SYSTEM MAY NOT RESTRAIN THE OCCUPANT(S) AS DESIGNED AND COULD INCREASE THE RISK OF INJURY.
Remedy: DEALERS WILL MODIFY THE PASSENGER AND/OR THE DRIVER SAFETY BELT BUCKLES AS NECESSARY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 18, 2011. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 AND AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE20009 · Momentary Increased Steering Effort
Opened Jun 1, 2020 · Closed Jun 3, 2022
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
Additional source detail variants (2)
Steering:electric Power Assist System
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
Steering
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
EA19005 · Front Wiper Transmission Inoperative
Opened Dec 13, 2019 · Closed Nov 28, 2022
Status: closed (inferred from source dates) · Visibility; Visibility/wiper; Visibility:windshield Wiper/washer:linkages
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Additional source detail variants (3)
Visibility
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Visibility:windshield Wiper/washer:linkages
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Visibility/wiper
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
RQ18002 · Windshield Wiper Transmission Failure
Opened Nov 2, 2018 · Closed Dec 19, 2019
Status: closed (inferred from source dates) · Visibility; Visibility/wiper; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages; Visibility:windshield Wiper/washer:motor
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Additional source detail variants (5)
Visibility
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer:linkages
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer:motor
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility/wiper
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.