NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
182 reportsClear category filter79,800 miles · Apr 20, 2017
EnginePower TrainVehicle Speed Control
WHILE DRIVING ON CITY STREETS, MY GAS PEDAL BECAME UNRESPONSIVE. THE CAR BEGAN TO SLOW DOWN. UNABLE TO KEEP MY SPEED, I WAS UNABLE TO MAKE A STOPLIGHT AND HAD TO STOP. WHILE MY FOOT WAS ON THE BRAKES, THE RPM FOR MY VEHICLE WERE STEADILY AT 6-7000. AS THE LIGHT TURNED GREEN, I PUT MY FOOT ON THE GAS PEDAL, RECEIVED A JOLT AS IF …
Read full complaint
WHILE DRIVING ON CITY STREETS, MY GAS PEDAL BECAME UNRESPONSIVE. THE CAR BEGAN TO SLOW DOWN. UNABLE TO KEEP MY SPEED, I WAS UNABLE TO MAKE A STOPLIGHT AND HAD TO STOP. WHILE MY FOOT WAS ON THE BRAKES, THE RPM FOR MY VEHICLE WERE STEADILY AT 6-7000. AS THE LIGHT TURNED GREEN, I PUT MY FOOT ON THE GAS PEDAL, RECEIVED A JOLT AS IF THE CAR WAS ACCELERATING, BUT WAS SLOWLY MAKING MY WAY UP TO 20 MPH. AS THE TIME TOOK NEAR 30 SECONDS TO MAKE THE CLIMB ON A FLAT ROAD TO 20 MPH, I DECIDED FOR MY SAFETY TO HIT MY EMERGENCY FLASHERS. AROUND THAT TIME, THE CHECK ENGINE LIGHT CAME ON. I PULLED TO A SIDE STREET AND HIT 'ONSTAR'. THEY WERE ABLE TO GIVE ME TWO CODES THAT APPEARED. P0776 AND P0700. WHILE TALKING TO ONSTAR, MY CAR WAS IN PARK AND AGAIN THE ENGINE WAS PUSHING 7000 RPMS. I WAS BARELY ABLE TO MAKE IT TO MY HOUSE AS THE CAR WAS BARELY ABLE TO MAINTAIN IT'S SPEED. THE NEXT MORNING I WAS CURIOUS IF I WAS ABLE GET THE CAR OUT OF MY DRIVEWAY OR IF IT COULD MOVE IN A FORWARD MOTION. I WAS FORCED TO PUSH MY CAR OUT OF MY DRIVEWAY AS I COULD NOT GO IN REVERSE AT ALL AND AGAIN I NOTICED THAT THE CAR COULD BARELY MOVE FORWARD. AFTER HAVING MY CAR RETURNED FROM SPECIALIST IN TRANSMISSIONS, THEY GAVE ME PICTURES OF WHAT THEY FOUND. WHICH I INCLUDED FIVE WITH THE COMPLAINT. THE ISSUE AFTER TALKING TO THE DEALERSHIP IS A VERY COMMON PROBLEM AND BY READING THOSE TWO CODES WERE ABLE TO INSTRUCT ME THE PARTS THAT BROKE INSIDE THE TRANSMISSION WITHOUT OPENING IT UP OR CHECKING THE TRANSMISSION FLUID.
NHTSA ODI #10979593
79,300 miles · Mar 31, 2017
EnginePower TrainService Brakes
TL* THE CONTACT OWNS A 2010 CHEVROLET EQUINOX. WHILE DRIVING APPROXIMATELY 35 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE ACCELERATOR PEDAL WAS DEPRESSED AND THE VEHICLE STARTED TO DECELERATE WITH THE ENGINE RPMS AT 6,000 WHEN THE CONTACT REMOVED HIS FOOT FROM THE ACCELERATOR PEDAL. IN ADDITION, THE VEHICLE FAILED T…
Read full complaint
TL* THE CONTACT OWNS A 2010 CHEVROLET EQUINOX. WHILE DRIVING APPROXIMATELY 35 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE ACCELERATOR PEDAL WAS DEPRESSED AND THE VEHICLE STARTED TO DECELERATE WITH THE ENGINE RPMS AT 6,000 WHEN THE CONTACT REMOVED HIS FOOT FROM THE ACCELERATOR PEDAL. IN ADDITION, THE VEHICLE FAILED TO REVERSE AND THE "D" ON THE INSTRUMENT PANEL WAS BLINKING. THE VEHICLE WAS TAKEN TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT ALSO STATED THAT ONSTAR PRODUCED CODES P0776 AND P0700. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 79,300. ..UPDATED 08/30/17 *BF *CN
NHTSA ODI #10969705
60,000 miles · Mar 29, 2017
Power Train
TL* THE CONTACT OWNS A 2010 CHEVROLET EQUINOX. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE JERKED AND A WARNING INDICATOR ILLUMINATED. THE VEHICLE LATER SHUT DOWN IN THE MIDDLE OF THE ROAD AND WAS TOWED TO A DEALER. THE DEALER DIAGNOSED AND REPLACED THE TRANSMISSION. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED …
Read full complaint
TL* THE CONTACT OWNS A 2010 CHEVROLET EQUINOX. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE JERKED AND A WARNING INDICATOR ILLUMINATED. THE VEHICLE LATER SHUT DOWN IN THE MIDDLE OF THE ROAD AND WAS TOWED TO A DEALER. THE DEALER DIAGNOSED AND REPLACED THE TRANSMISSION. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000. UPDATED 06/07/17*LJ UPDATED 06/09/17 *JS
NHTSA ODI #10969390
120,000 miles · Mar 27, 2017
Power Train
I OWN A 2010 CHEVY EQUINOX. I WAS HAVING SOME ISSUES WITH MY STABILITRAK, ABS BREAKS AND MY ALL WHEEL DRIVE. I TOOK IT TO THE DEALERSHIP AND THEY HOOKED IT UP TO THE COMPUTER. THEY TOLD ME I NEEDED A NEW RIGHT FRONT HUB AND MY CATALYTIC CONVERTER REPLACED. SO I MADE AN APPOINTMENT TO HAVE THE CATALYTIC CONVERTER TAKEN CARE OF AS…
Read full complaint
I OWN A 2010 CHEVY EQUINOX. I WAS HAVING SOME ISSUES WITH MY STABILITRAK, ABS BREAKS AND MY ALL WHEEL DRIVE. I TOOK IT TO THE DEALERSHIP AND THEY HOOKED IT UP TO THE COMPUTER. THEY TOLD ME I NEEDED A NEW RIGHT FRONT HUB AND MY CATALYTIC CONVERTER REPLACED. SO I MADE AN APPOINTMENT TO HAVE THE CATALYTIC CONVERTER TAKEN CARE OF AS IT IS A PROBLEM CHEVY PAYS FOR. THE NEXT DAY I WAS DRIVING TO WORK AND I NOTICED MY CAR WASN'T SHIFTING. I STOPPED AND HAD A TOW TO THE DEALERSHIP. THEY FIXED THE CONVERTER AND PUT A SPEED SENSOR IN MY TRANSMISSION BECAUSE MY CAR SIMPLY WOULDN'T MOVE. I PICKED UP MY CAR AFTER THEM HAVING IT FOR TWO WEEKS. THAT DAY I NOTICED IT WAS SHIFTING EXTREMELY HARD GOING FROM 3RD TO 4TH GEAR. I PURCHASED A NEW HUB AND A NEW WHEEL SPEED SENSOR AND HAD THEM INSTALLED. WHILE LEAVING THE GARAGE THAT INSTALLED THESE NEW PARTS I STOPPED AT A RED LIGHT. WHEN IT TURNED GREEN I PUSHED THE GAS PEDDLE AND MY CAR JUST SAT THERE AND REVVED. I TURNED OFF AND BACK ON AND WAS ABLE TO GET IT BACK TO THE GARAGE AND THERE IT SAT, REFUSING TO DO ANYTHING BUT REVV. SINCE THIS HAS STARTED I HAVE DONE SOME RESEARCH AND FOUND MANY COMPLAINTS OF THE EXACT SAME PROBLEM FOR THE SAME MAKE AND MODEL. IF THIS IS A COMMON PROBLEM WITHIN THIS SPECIFIC TRANSMISSION I THINK IT NEEDS TO BE LOOKED INTO.
NHTSA ODI #10968857
Mileage unknown · Mar 8, 2017
Air BagsEnginePower Train
MULTIPLE TRIPS TO THE DEALER. SOLENOID PROBLEM, AIR BAG, ENGINE LIGHT ON, BROKEN CHAIN, FUEL PUMP INJECTOR, LEAKING SUN ROOF, AS OF 3/6/2017 I NEED A TRANSMISSION. MY CAR WAS PURCHASED IN 2010, I ONLY HAVE 31,000 MILES ON IT. IV'E VISITED THE DEALER JAN, FEB, AND MARCH OF 2017. I FEEL I SHOULD BE COMPENSATED WITH A NEW CAR!!!!…
Read full complaint
MULTIPLE TRIPS TO THE DEALER. SOLENOID PROBLEM, AIR BAG, ENGINE LIGHT ON, BROKEN CHAIN, FUEL PUMP INJECTOR, LEAKING SUN ROOF, AS OF 3/6/2017 I NEED A TRANSMISSION. MY CAR WAS PURCHASED IN 2010, I ONLY HAVE 31,000 MILES ON IT. IV'E VISITED THE DEALER JAN, FEB, AND MARCH OF 2017. I FEEL I SHOULD BE COMPENSATED WITH A NEW CAR!!!! JAN, F CAR
NHTSA ODI #10959504
63,000 miles · Mar 1, 2017
Power Train
TL* THE CONTACT OWNS A 2010 CHEVROLET EQUINOX. WHILE DRIVING 65 MPH, THE VEHICLE STALLED AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WA…
Read full complaint
TL* THE CONTACT OWNS A 2010 CHEVROLET EQUINOX. WHILE DRIVING 65 MPH, THE VEHICLE STALLED AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 63,000.
NHTSA ODI #10957839
88,889 miles · Feb 27, 2017
Power Train
TL* THE CONTACT OWNS A 2010 CHEVROLET EQUINOX. WHILE DRIVING 10 MPH, WHILE THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE FAILED TO ACCELERATE WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE REVERSE SNAP RING FAILED AND THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE M…
Read full complaint
TL* THE CONTACT OWNS A 2010 CHEVROLET EQUINOX. WHILE DRIVING 10 MPH, WHILE THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE FAILED TO ACCELERATE WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE REVERSE SNAP RING FAILED AND THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 88,889.
NHTSA ODI #10957302
98,000 miles · Feb 21, 2017
Power Train
TL* THE CONTACT OWNS A 2010 CHEVROLET EQUINOX. WHILE DRIVING 65 MPH, THE VEHICLE DOWNSHIFTED WITHOUT WARNING. IN ADDITION, THE VEHICLE WOULD NOT SHIFT INTO REVERSE WHEN PROMPTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 98,000.
NHTSA ODI #10956067
130,000 miles · Feb 13, 2017
EnginePower TrainVisibility/wiper
TL* THE CONTACT OWNS A 2010 CHEVROLET EQUINOX. WHILE DRIVING 40 MPH, THE TRANSMISSION FAILED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE CONTACT ALSO STATED THAT THERE WAS EXCESSIVE OIL CONSUMPTION WITH NO SAFETY DEFECT. THE CONTACT STATED THAT THERE WAS AN ABNORMA…
Read full complaint
TL* THE CONTACT OWNS A 2010 CHEVROLET EQUINOX. WHILE DRIVING 40 MPH, THE TRANSMISSION FAILED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE CONTACT ALSO STATED THAT THERE WAS EXCESSIVE OIL CONSUMPTION WITH NO SAFETY DEFECT. THE CONTACT STATED THAT THERE WAS AN ABNORMAL GRINDING NOISE EMITTED FROM THE ENGINE. THE CONTACT ALSO STATED THAT THE AIR CONDITIONING UNIT AND WINDSHIELD DEFROSTER FAILED TO OPERATE AS INTENDED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT WAS INFORMED THAT THE AIR CONDITIONING EVAPORATOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.
NHTSA ODI #10954251
55,000 miles · Feb 7, 2017
Power Train
I BOUGHT A 2010 EQUINOX NEW, AT 49,000 MILES THE TRANSFER CASE WENT OUT OF IT AND NOW 6 MONTHS LATER AT 55,000 MILES THE TRANSMISSION WENT OUT IT WAS THE 3-5 REVERVSE WAVE PLATE WE WERE TOLD THAT SHATTERED. AND SINCE IT WAS OUT OF WARRANTY OF COURSE GM WOULD NOT HONOR TO GET THIS PLATE FIXED EVEN THOUGH IT ONLY HAD 55,000 MILES …
Read full complaint
I BOUGHT A 2010 EQUINOX NEW, AT 49,000 MILES THE TRANSFER CASE WENT OUT OF IT AND NOW 6 MONTHS LATER AT 55,000 MILES THE TRANSMISSION WENT OUT IT WAS THE 3-5 REVERVSE WAVE PLATE WE WERE TOLD THAT SHATTERED. AND SINCE IT WAS OUT OF WARRANTY OF COURSE GM WOULD NOT HONOR TO GET THIS PLATE FIXED EVEN THOUGH IT ONLY HAD 55,000 MILES ON IT. WE WERE TOLD THESE PLATES WHEN THEY WERE HARDEN THEY WERE HARDEN TO HARD AND SO THEY SHATTER. THIS IS DEFIANTLY A GM ISSUE AND THEY SHOULD REPAIR THESE AT NO COST BUT THEY WON'T ADMIT THERE IS A PROBLEM. THIS TRANSMISSION JUST HAPPENED ALL AT ONCE I PUT IT IN GEAR AND THERE IT WENT OUT. IF GM IS GOING TO BUILD A THROW AWAY CAR AT 50,000 MILES THEN THEY SHOULD SELL IT AS A THROW AWAY CAR. THEY KNOW THEY HAVE TRANSMISSION PROBLEMS BUT THEY KEEP SOCKING THE CONSUMER FOR COSTLY REPAIRS BECAUSE ALL THEY CAN SAY IS IT'S OUT OF WARRANTY. YOU WOULD THINK YOUR CAR WOULD LAST MORE THAN 55,000 MILES.
NHTSA ODI #10950054
Official recalls
3Jul 5, 2016
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Additional source detail variants (2)
Electrical System:ignition
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Jul 23, 2014
General Motors LLC (GM) is recalling certain model year 2011-2012 Buick LaCrosse, Regal and Chevrolet Camaro, as well as certain 2010-2012 Cadillac SRX, Chevrolet Equinox and GMC Terrain vehicles, equipped with power height adjustable driver and passenger seats. In the affected vehicles, the bolt that secures the driver's and passenger's power front seat height adjuster may fall out causing the seat to drop suddenly to the lowest vertical position.
Consequence & remedy
Consequence: If the driver's seat unexpectedly drops, the distraction and altered seat position may affect the drivers' control of the vehicle, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the height adjuster shoulder bolts, free of charge. The manufacturer distributed interim letters to owners on September 11, 2014. The recall began on December 26, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-8006 (Cadillac), 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14271.
Dec 23, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2010 CHEVROLET EQUINOX AND GMC TERRAIN VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 103, "WINDSHIELD DEFROSTING AND DEFOGGING SYSTEMS AND WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 101, CONTROLS AND DISPLAYS". THE SOFTWARE IN THE CENTER INSTRUMENT PANEL CAN CAUSE THE HEATING, AIR CONDITIONING, DEFROST, AND RADIO CONTROLS, AS WELL AS THE PANEL ILLUMINATION TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: DRIVING WITHOUT A FUNCTIONING DEFROST SYSTEM CAN DECREASE YOUR VISIBILITY UNDER CERTAIN DRIVING CONDITIONS AND COULD RESULT IN A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPLACE THE COMPUTER MODULE IN THE CENTER INSTRUMENT PANEL FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JANUARY 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463 OR AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE20009 · Momentary Increased Steering Effort
Opened Jun 1, 2020 · Closed Jun 3, 2022
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
Additional source detail variants (2)
Steering:electric Power Assist System
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
Steering
On June 1, 2020, the Office of Defects Investigations (ODI) opened PE20-009 to investigate instances of a momentary increase in steering effort after the vehicle is driven in a straight line for a period of time due to an issue with the steering gear in model year (MY) 2010 through 2012 Chevrolet Equinox and GMC Terrain SUVs.If the electric power steering system fails to operate as intended, the driver will experience momentary increased effort when attempting to turn the steering wheel from the straight-ahead position. For this condition to occur, the driver would need to have traveled in a straight line at a sustained high speed, without turning the steering wheel, for approximately 30 minutes or longer. The steering gear contains a servo unit that includes a worm gear with a worm and a worm wheel. General Motors (GM) stated that the primary root cause of the increased steering effort is the supplier's inconsistent application of grease in the interface between the worm and the worm wheel. The grease may have been applied in a location on the worm wheel that didn't interface with the worm, depriving the worm gear of proper lubrication.On November 1, 2014, GM issued Special Coverage 14232 to address the power steering stick-slip issue in MY 2010-2014 Chevrolet Equinox and GMC Terrain; MY 2011-2014 Chevrolet Cruze and Volt; MY 2012-2014 Buick Verano; and MY 2013-2014 Chevrolet Malibu vehicles. GM notified consumers via mail.The Special Coverage repair includes the replacement of the steering gear with an improved internal worm gear greasing process for MY 2010-2012 vehicles. For the MY 2013-2014 vehicles, the Special Coverage repair includes a reprogramming of the steering gear control module. The new software has an anti-stick feature which senses and reduces the friction between the worm and worm wheel by oscillating the worm gear. GM stated that the difference in remedy is due to the inability of the MY 2010-2012 steering gear control module to accept the new software.The remedy implemented in GM Special Coverage 14232 appears to be sufficient in addressing the safety-related concerns of this issue. Considering the low complaint and warranty rates of steering rack replacement as well as the field exposure time for the subject vehicles, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. ODI has not identified a safety defect or defect-related failure trend in the subject vehicles. In view of the Special Coverage, low rate of failure, and low potential hazard to drivers, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers:11424633,11421725,11229647,11101375,10919921,10689932,10671557,10664687,10663350, 10593429,10592065,10585476,10585365,10576237,10575693,10532766,10490295,10434128, 10417845,10412535,10403168,10395532,10395171,10391948,10384211,10375515,10366297, 10360999,10360599,10345626,10319530,10305569,10304769,10299745
EA19005 · Front Wiper Transmission Inoperative
Opened Dec 13, 2019 · Closed Nov 28, 2022
Status: closed (inferred from source dates) · Visibility; Visibility/wiper; Visibility:windshield Wiper/washer:linkages
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Additional source detail variants (3)
Visibility
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Visibility:windshield Wiper/washer:linkages
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
Visibility/wiper
On December 13, 2019, the Office of Defects Investigation (ODI) upgraded RQ18-002 to an Engineering Analysis (EA19-005) to further assess the MY2010-2016 Chevrolet Equinox and GMC Terrain windshield wiper failures. Due to a prior recall, 16V-582, addressing this issue in the MY2013 subject vehicles, MY2013 was not included in the analysis. To date, ODI had received 998 complaints with allegations of the front windshield wiper failing in adverse whether conditions, while the vehicle was in motion.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intruding into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint resulting in loss of windshield wiper function. ODI?s review focused on 2010-2012 and 2014-2016 Equinox and Terrain vehicles. Owners were reporting a high rate of failures of the windshield wiper system. These failures were the same as that addressed by recall 16V-582. ODI's review of data supplied by GM as well as its own confirmed a high failure rate in model years 2014 and 2015. On March 17, 2022, GM filed a defect information report recalling all MY2014-2015 Chevrolet Equinox and GMC Terrain vehicles to remedy the potential failure of the front windshield wiper transmission assembly.General Motors is also conducting a special coverage program, N192266181, for MY2010-2012 and MY2016-2017 Chevrolet Equinox and GMC Terrain vehicles. The special coverage is for a period of 15 years or 200,000 miles, whichever comes first.Both the recall, 22V-165, and the special coverage program, N192266181, address windshield wiper system failures on the subject vehicles. The dealership will inspect the front wiper assembly for ball joint wear. Depending on the degree of wear, the wiper links will be replaced, and a water shield installed or the entire module will be replaced.In view of the recall and special coverage, ODI is closing this Engineering Analysis (EA). NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers in a separate attachment.
RQ18002 · Windshield Wiper Transmission Failure
Opened Nov 2, 2018 · Closed Dec 19, 2019
Status: closed (inferred from source dates) · Visibility; Visibility/wiper; Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages; Visibility:windshield Wiper/washer:motor
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Additional source detail variants (5)
Visibility
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer:linkages
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility:windshield Wiper/washer:motor
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Visibility/wiper
On November 2, 2018, the Office of Defects Investigation (ODI) opened a Recall Query (RQ18-002) to assess the scope of Recall 16V-582.General Motors (GM) initiated Safety Recall 16V-582 on August 3, 2016 to address windshield wiper failure in the Model Year (MY) 2013 Chevrolet Equinox and GMC Terrain. Failures were attributed to water and debris intrusion into the windshield wiper assembly ball joints, leading to excessive wear and eventual detachment of the affected ball joint with an attendant loss of windshield wiper function. The recall remedy addressed these conditions with the installation of an improved windshield wiper motor/transmission assembly and the relocation of a drain hole on the Air Inlet Panel at the base of the windshield.RQ18-002 was opened to assess windshield wiper failure rates in the MY 2010-2012 and MY 2014 - 2016 Equinox and Terrain (subject vehicles).During the course of the investigation, ODI received additional consumer complaint traffic bringing its total to 602 concerning the alleged defect in the subject vehicles. In their December 20, 2018 response to ODI's Information Request (IR) Letter, GM reported 1,303 complaints related to the alleged defect in the subject vehicles. Together, these bodies of data correspond to 1,905 unique Vehicle Identification Numbers (VIN).GM stated the recalled vehicles exhibited double the warranty rate and five times the complaint rate of the subject vehicles and that continuing complaint traffic concerning the alleged defect in the subject vehicles stemmed from publicity surrounding Recall 16V-582.ODI's review of GM's data confirms the stated difference in failure rates between the recalled and subject vehicles. However, ODI believes that the subject vehicle failure rates are nevertheless elevated and that publicity alone cannot account for the continued consumer complaint traffic concerning the alleged defect in the subject vehicles. ODI is upgrading to RQ18-002 to an Engineering Analysis to compare subject vehicle failure rates and engineering practices to those in peer vehicles.The 602 ODI complaints cited can be viewed in a separate attachment.
Illustration