NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
44 reportsClear category filter80,000 miles · Jan 26, 2022
Engine And Engine Cooling
The contact owns a 2012 Chevrolet Cruze. The contact stated that coolant was leaking from the vehicle. The temperature gauge increased to high and then decreased. There were no warning lights illuminated. The vehicle was taken to the local dealer on several occasions and was diagnosed that the thermostat housing and thermostat n…
Read full complaint
The contact owns a 2012 Chevrolet Cruze. The contact stated that coolant was leaking from the vehicle. The temperature gauge increased to high and then decreased. There were no warning lights illuminated. The vehicle was taken to the local dealer on several occasions and was diagnosed that the thermostat housing and thermostat needed to be replaced. The vehicle was repaired however, the failure recurred. The manufacturer was not contacted. The approximate failure mileage was 80,000.
NHTSA ODI #11448963
209,000 miles · Jan 24, 2022
Engine And Engine Cooling
The contact owns a 2012 Chevrolet Cruze. The contact stated while driving at various speeds, the vehicle overheated. The contact stated that the check engine warning light was illuminated. The vehicle was towed to a local mechanic where it was diagnosed with needing the head gasket replaced. The vehicle was not repaired. The veh…
Read full complaint
The contact owns a 2012 Chevrolet Cruze. The contact stated while driving at various speeds, the vehicle overheated. The contact stated that the check engine warning light was illuminated. The vehicle was towed to a local mechanic where it was diagnosed with needing the head gasket replaced. The vehicle was not repaired. The vehicle was towed to a local dealer where it was diagnosed with needing the engine repaired however, the vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 209,000.
NHTSA ODI #11448703
89,000 miles · Nov 16, 2021
Engine And Engine Cooling
The contact owns a 2012 Chevrolet Cruze. The contact stated that since purchasing the vehicle, multiple oil and coolant repairs have been performed on the vehicle due to leakage. The contact stated that while in stop-and-go traffic, a cloud of white smoke began to emit from the vehicle as a warning message stating "turn off the …
Read full complaint
The contact owns a 2012 Chevrolet Cruze. The contact stated that since purchasing the vehicle, multiple oil and coolant repairs have been performed on the vehicle due to leakage. The contact stated that while in stop-and-go traffic, a cloud of white smoke began to emit from the vehicle as a warning message stating "turn off the heater, high engine heat" appeared on the instrument panel. The contact pulled the vehicle over and upon inspection discovered that there was no coolant in the reservoir. A service vehicle pulled over to help. The service attendant reattached an unknown hose that had disconnected and added coolant. Soon after restarting of the vehicle, the white smoke and the warning message returned; the contact had the vehicle towed to her daughter's home. Neither the dealer nor the manufacturer was notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 89,000.
NHTSA ODI #11440706
100,000 miles · Sep 10, 2021
EngineEngine And Engine Cooling
The contact owns a 2012 Chevrolet Cruze. The contact stated while driving 30 MPH, the check engine warning light illuminated, and the temperature gauge was fluctuating on the instrument panel. The contact pulled over to the side of the road and turned off the vehicle for several minutes while waiting for the vehicle engine to co…
Read full complaint
The contact owns a 2012 Chevrolet Cruze. The contact stated while driving 30 MPH, the check engine warning light illuminated, and the temperature gauge was fluctuating on the instrument panel. The contact pulled over to the side of the road and turned off the vehicle for several minutes while waiting for the vehicle engine to cool down before restarting the vehicle and continuing to drive to his residence. The next day the contact took the vehicle to be diagnosed by an independent mechanic. The contact was informed that the head gasket needed to be replaced. Additionally, the mechanic performed temporary repairs on the thermostat housing and replaced the manifold and oil gasket however, the failure persisted. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000.
NHTSA ODI #11432521
64,000 miles · Aug 14, 2018
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2012 CHEVROLET CRUZE. THE CONTACT STATED THAT THE TEMPERATURE WARNING INDICATOR ILLUMINATED. THE CONTACT ALSO NOTICED AN ABNORMAL ODOR COMING FROM THE VEHICLE. UPON INSPECTION, THE CONTACT FOUND AN ANTIFREEZE LEAK. THE VEHICLE WAS TAKEN TO CAMPBELL CHEVROLET (2151 SCOTTSVILLE RD, BOWLING GREEN, KY) WHERE I…
Read full complaint
TL* THE CONTACT OWNS A 2012 CHEVROLET CRUZE. THE CONTACT STATED THAT THE TEMPERATURE WARNING INDICATOR ILLUMINATED. THE CONTACT ALSO NOTICED AN ABNORMAL ODOR COMING FROM THE VEHICLE. UPON INSPECTION, THE CONTACT FOUND AN ANTIFREEZE LEAK. THE VEHICLE WAS TAKEN TO CAMPBELL CHEVROLET (2151 SCOTTSVILLE RD, BOWLING GREEN, KY) WHERE IT WAS DIAGNOSED THAT THE WATER PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED A YEAR LATER. THE SAME DEALER DIAGNOSED THAT THERE WAS A CRACK IN THE COOLANT OUTLET FLANGE AND RECOMMENDED IT BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 64,000.
NHTSA ODI #11119824
Mileage unknown · Oct 20, 2016
Engine And Engine CoolingVisibility
IN 2014 MY CAR HAD AN ISSUE WHERE IT STARTED OVER HEATING. THE CAR WAS PREVIOUSLY PART OF A RECALL FOR THE WATER PUMP BREAKING. THIS CAUSED MY CAR HEATING AND COOLING SYSTEM NOT TO WORK PROPERLY. THIS CAN BE DANGEROUS IF DRIVING AND IT HAPPENED WHILE I WAS DRIVING. I JUST HAD THE SAME ISSUE ON OCTOBER 20 OF 2016. *TR
NHTSA ODI #10917469
5,000 miles · Jul 13, 2015
Electrical SystemEngine And Engine CoolingExterior Lighting
SINCE MARCH 30, 2015, I HAVE BEEN EXPERIENCING ISSUES WITH AND I HAVE VIDEO EVIDENCE WHILE IN FAILURE MODE, OF WHAT I BELIEVE TO BE FAILURES OF THE BODY COMPUTER(S) IN THIS VEHICLE. THE DASHBOARD DISPLAYS HAVE BEEN GOING ON AND OFF UNDER A WIDE VARIETY OF DRIVING SITUATIONS, AND WHILE SITTING AT IDLE. THEY FAULT WHEN THE VEHIC…
Read full complaint
SINCE MARCH 30, 2015, I HAVE BEEN EXPERIENCING ISSUES WITH AND I HAVE VIDEO EVIDENCE WHILE IN FAILURE MODE, OF WHAT I BELIEVE TO BE FAILURES OF THE BODY COMPUTER(S) IN THIS VEHICLE. THE DASHBOARD DISPLAYS HAVE BEEN GOING ON AND OFF UNDER A WIDE VARIETY OF DRIVING SITUATIONS, AND WHILE SITTING AT IDLE. THEY FAULT WHEN THE VEHICLE IS SIMPLY DRIVING DOWN THE HIGHWAY. DURING THESE FAULTS, THE CENTER INFORMATION DISPLAY FOR THE HVAC AND ENTERTAINMENT WILL FREQUENTLY TURN OFF. THIS KILLS THE RADIO. IT AT TIMES KILLS THE HVAC SYSTEMS AND THE TURN SIGNALS (AT LEAST THE NOISE FOR THE TURN SIGNAL INDICATORS). AT TIMES, THE CENTER DISPLAY ABOVE THE STEERING COLUMN WILL GO BLACK AND THEN DISPLAY A MESSAGE ABOUT THE STABILITRAK HAVING FAILED AND REQUIRING IT TO BE CHECKED. THEN IT RETURNS TO NORMAL MODE. THIS IS LESS FREQUENT AN OCCURRENCE. WHILE DRIVING ON THE HIGHWAY UNDER CRUISE CONTROL, THE VEHICLE EXPERIENCED ONE INCIDENT OF UNINTENDED ACCELERATION WHILE THE DISPLAYS WERE IN FAULT MODES. THIS OCCURRED ON APRIL 1, 2015 I BELIEVE. THE DRIVER'S FEET WERE ON THE FLOORBOARDS. NOT TOUCHING ANY PEDALS AT ALL. THE INCIDENT WAS STOPPED BY THE DRIVER FIRMLY PRESSING DOWN ON THE BRAKE PEDAL. WHEN SUFFICIENT VIDEO EVIDENCE IS ACCUMULATED ON THESE FAILURES THE VEHICLE WILL BE TAKEN INTO THE DEALERSHIP. LACKING ACTUAL DEMONSTRATIVE EVIDENCE OF THE FAILURES, THE DEALERSHIP WILL NOT BE ABLE TO KNOW WHAT TO REPAIR OR REPLACE. THE CAR HAS A HISTORY OF DASH DISPLAY ISSUES. THE OWNER, A RETIRED LIBRARIAN/RESEARCHER FROM GENERAL MOTORS ADVANCED ENGINEERING STAFF AND THE R&D CENTER, HAS WORKED ON UNINTENDED ACCELERATION LEGAL CASES FOR THE COMPANY, AND HAS SUPPORTED LITIGATION DEFENSE WORK ON SUCH ISSUES WHILE AT THE COMPANY. HE IS STILL GATHERING EVIDENCE BUT FEELS THE NEED TO DOCUMENT THIS INCIDENT AS SOON AS POSSIBLE FOR NHTSA SHOULD AN ACCIDENT OCCUR TO HIM DUE TO THIS. IS A VERY HIGH RISK
NHTSA ODI #10734176
10,000 miles · Jan 23, 2015
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2012 CHEVROLET CRUZE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, OIL AND COOLANT FUMES EMITTED INSIDE THE VEHICLE. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER, WHERE IT WAS DIAGNOSED THAT THE OIL AND COOLANT NEEDED TO BE CHANGED. THE VEHICLE WAS NOT REPAIRED. THE M…
Read full complaint
TL*THE CONTACT OWNS A 2012 CHEVROLET CRUZE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, OIL AND COOLANT FUMES EMITTED INSIDE THE VEHICLE. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER, WHERE IT WAS DIAGNOSED THAT THE OIL AND COOLANT NEEDED TO BE CHANGED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 10,000.
NHTSA ODI #10678498
57,000 miles · Dec 15, 2014
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2012 CHEVROLET CRUZE. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE CHECK ENGINE WARNING LIGHT ILLUMINATED AND AN ABNORMAL NOISE WAS HEARD COMING FROM THE ENGINE COOLING FAN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE MECHANIC DIAGNOSED THAT THE THERMOSTAT SENSOR FAILED. THE VEH…
Read full complaint
TL* THE CONTACT OWNS A 2012 CHEVROLET CRUZE. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE CHECK ENGINE WARNING LIGHT ILLUMINATED AND AN ABNORMAL NOISE WAS HEARD COMING FROM THE ENGINE COOLING FAN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE MECHANIC DIAGNOSED THAT THE THERMOSTAT SENSOR FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 57,000. UPDATED 02/24/15*LJ UPDATED 10/7/2015*JS
NHTSA ODI #10664357
64,000 miles · Nov 18, 2014
Engine And Engine Cooling
BAD ANTIFREEZE SMELL ENTERING CAR WITH HEAT ON AND ENGINE AT FULL OPERATING TEMPERATURE, BUT NO ANTIFREEZE LOSS. *TR
NHTSA ODI #10659130
Official recalls
7Jul 5, 2016
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Additional source detail variants (2)
Electrical System:ignition
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Jun 6, 2014
General Motors LLC (GM) is recalling certain model year 2012 Buick Verano vehicles manufactured December 2, 2011 to July, 16, 2012, Chevrolet Cruze vehicles manufactured December 7, 2011 to July 25, 2012, Chevrolet Sonic vehicles manufactured December 5, 2011 to August 2, 2012, and Chevrolet Camaro vehicles manufactured December 1, 2011 to June 11, 2012. The driver side frontal air bag has a shorting bar which may intermittently contact the air bag terminals.
Consequence & remedy
Consequence: If the bar and terminals are contacting each other at the time of a crash necessitating deployment of the driver's frontal air bag, that air bag will not deploy, increasing the driver's risk of injury.
Remedy: GM will notify owners, and dealers will replace the steering wheel air bag coil, free of charge. The recall began on July 25, 2014. Chevrolet owners may contact GM at 1-800-222-1020. Buick owners may contact GM at 1-800-521-7300. Note: This is an expansion of recalls 12V-522 and 13V-023.
Aug 15, 2013
General Motors (GM) is recalling certain model year 2011-2012 Chevrolet Cruze vehicles equipped with 1.4L DOHC gasoline turbo engines and 6T40 front wheel drive automatic transmissions and equipped with an electric vacuum pump to provide supplemental vacuum for brake assist, when needed. In the affected vehicles, the pump may not activate, resulting in an intermittent reduction or loss of brake assist.
Consequence & remedy
Consequence: A loss of braking assistance will require extra pedal force and/or distance to bring the vehicle to a stop, increasing the risk of a crash.
Remedy: General Motors will notify owners, and dealers will replace a microswitch in the power brake vacuum pipe assembly, free of charge. The recall began on October 7, 2013. Owners may contact Chevrolet at 1-800-222-1020. GM's recall number is 12213.
Jan 24, 2013
General Motors LLC (GM) is recalling certain model year 2012 Chevrolet Camaro, Cruze and Sonic, and model year 2012 Buick Verano vehicles. The driver side frontal air bag has a shorting bar which may intermittently contact the air bag terminals.
Consequence & remedy
Consequence: If the bar and terminals are contacting each other at the time of a crash necessitating deployment of the driver's frontal air bag, that air bag will not deploy, increasing the driver's risk of injury.
Remedy: GM will notify owners, and dealers will replace the steering wheel air bag coil, free of charge. The safety recall began on February 13, 2013. Owners may contact General Motors at 1-800-521-7300.
Oct 31, 2012
General Motors is recalling certain model year 2012 Buick Verano, Chevrolet Cruze, and Chevrolet Sonic vehicles. The driver side frontal air bag has a shorting bar which may intermittently contact the air bag terminals.
Consequence & remedy
Consequence: If the bar and terminals are contacting each other at the time of a crash necessitating deployment of the driver's frontal airbag, that airbag will not deploy, increasing the driver's risk of injury.
Remedy: General Motors will notify owners, and dealers will replace the steering wheel airbag coil, free of charge. The safety recall began on January 11, 2013. Owners may contact General Motors at 1-800-521-7300.
Jun 22, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 CHEVROLET CRUZE VEHICLES MANUFACTURED FROM OCTOBER 2, 2009, THROUGH MAY 31, 2012. SPILLED OR DRIPPING OIL (SUCH AS AFTER AN OIL CHANGE) MAY COLLECT IN THE ENGINE SHIELD (BELLYPAN) NEAR HOT ENGINE OR EXHAUST SYSTEM SURFACES. AS A RESULT, THE OIL AND THE ENGINE SHIELD MAY IGNITE AND BURN.
Consequence & remedy
Consequence: EITHER CONDITION COULD RESULT IN AN ENGINE COMPARTMENT FIRE, POSSIBLY CAUSING INJURY OR DEATH.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL MODIFY THE ENGINE SHIELD TO PREVENT FLUID FROM CONTACTING THE SHIELD. ALSO, ON VEHICLES WITH A MANUAL TRANSMISSION, DEALERS WILL APPLY A PROTECTIVE TAPE TO THE ELECTRONIC POWER STEERING WIRE HARNESS. REPAIRS WILL BE PERFORMED FREE OF CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON JULY 10, 2012. OWNERS MAY CONTACT THE CHEVROLET OWNER CENTER AT 1-866-694-6546.
Jun 22, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 CHEVROLET CRUZE VEHICLES MANUFACTURED FROM OCTOBER 2, 2009, THROUGH MAY 14, 2012. ATTACHMENT WELDS FOR THE FUEL TANK STRAP SECONDARY BRACKETS MAY HAVE BEEN OMITTED.
Consequence & remedy
Consequence: THE FUEL TANK COULD COME LOOSE IN A CRASH, POSSIBLY ALLOWING FUEL TO LEAK FROM THE TANK. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE VEHICLE FOR MISSING WELDS. IF THE VEHICLE IS MISSING WELDS, DEALERS WILL SECURE THE BRACKET ATTACHMENTS WITH FASTENERS. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 9, 2012. OWNERS MAY CONTACT THE CHEVROLET OWNER CENTER AT 1-866-694-6546.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ13002 · Air Bag Non-deployment
Opened May 31, 2013 · Closed Jul 9, 2014
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Side:inflator Module
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Additional source detail variants (6)
Air Bags:frontal:driver Side:inflator Module
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags:frontal:driver Side:inflator Module
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags:frontal
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags:frontal
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
AQ12002 · Chapman Chevrolet / Cruze Engine Recall
Opened Oct 15, 2012 · Closed Oct 20, 2014
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine:gasoline
NHTSA opened AQ12-002 to determine whether Chapman Chevrolet of Philadelphia, Pennsylvania complied with the requirements of the National Traffic and Motor Vehicle Safety Act, 49 U.S.C.Chapter 301 (Safety Act) and its implementing regulations.The Safety Act requires, among other things, that a manufacturer notify its dealers of defects related to motor vehicle safety and non-compliances with Federal Motor Vehicle Safety Standards and, in turn, that a dealer not sell a new vehicle subject to a recall unless the recall remedy has been performed (49 U.S.C. ? 30120(i)). NHTSA issued an information request (IR) letter to Chapman Chevrolet on October 16, 2012.Chapman Chevrolet responded to this request on November 8, 2012.To gather additional information, NHTSA mailed an IR letter to General Motors LLC (GM) on February 25, 2013.GM responded to this request on April 1, 2013.NHTSA then issued a second IR letter to Chapman Chevrolet on July 2, 2013.Chapman Chevrolet supplied their response on July 30, 2013. NHTSA?s investigation indicated that Chapman Chevrolet sold and delivered 23 recalled vehicles that did not have the recall remedy completed at the time the vehicles were delivered to the customers.NHTSA therefore concluded that Chapman Chevrolet was liable for civil penalties for violations of the Safety Act, pursuant to 49 U.S.C. ? 30165.Under a Settlement Agreement dated October 1, 2014, Chapman Chevrolet paid compromised civil penalties in the amount of $50,000.This Audit Query is closed.
PE12010 · Engine Compartment Fire
Opened Mar 28, 2012 · Closed Jul 19, 2012
Status: closed (inferred from source dates) · Engine
In a June 21, 2012 letter to NHTSA, General Motors LLC. (GM) submitted a Defect Information Report (DIR) identifying a defect in approximately 413,148 model year (MY) 2011 through 2012 Chevrolet Cruze vehicles manufactured from October 2, 2009 through May 31, 2012 (Recall 12V-288). According to GM, engine oil change procedures can result in spilling or dripping of oil on the engine shield.Also, manual transmission vehicles with a completely worn clutch may cause hydraulic fluid to be expelled from the clutch housing vent hole.If oil, debris or the burning hydraulic fluid contacts hot engine or exhaust system surfaces, and the engine shield, the shield may ignite and burn, leading to a possible engine compartment or vehicle fire.GM and its engine shield supplier, Hanwha, modified the engine shield to address factors that may contribute to engine compartment fire. The redesigned shields were completely implemented in production vehicles by June 2012.The Office of Defects Investigation (ODI) analyzed complaint data provided by GM as well as complaints submitted to ODI from consumers. In total, there were 25 unique Chevrolet Cruze reports indicating hot surface ignition due to engine oil or hydraulic fluid contacting hot manifold, exhaust surfaces and the engine shield.Four additional fires were identified that resulted from other or unknown causes, including 1 attributed to a missing oil filler cap.Three fires of unknown cause all involved vehicles equipped with 1.4L L4 turbocharged engines.ODI will continue to monitor field experience in Cruze vehicles equipped with that engine.Owners of the recalled vehicles are notified to take their vehicle to a GM dealer, who will modify the engine shield to prevent oil fluids from contacting the shield.Also, on vehicles with a manual transmission, dealers are to apply a protective tape to the electronic power steering wire harness to prevent any incidents related to this issue. This preliminary evaluation is closed.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers (ODI Nos.): 10456338, 10453754, 10450556, 10446718.
Illustration