NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
268 reportsClear category filter95,000 miles · Dec 12, 2022
EngineEngine And Engine Cooling
The contact owns a 2012 Chevrolet Cruze. The contact stated while driving 35 MPH, he smelled a burning odor and saw smoke coming from underneath the hood of the vehicle. The contact then drove the vehicle to a local dealer where it was diagnosed that the front valve cover gasket and oil pan were leaking. The front valve cover ga…
Read full complaint
The contact owns a 2012 Chevrolet Cruze. The contact stated while driving 35 MPH, he smelled a burning odor and saw smoke coming from underneath the hood of the vehicle. The contact then drove the vehicle to a local dealer where it was diagnosed that the front valve cover gasket and oil pan were leaking. The front valve cover gasket and seals were replaced; however, the failure reoccurred. Additionally, the contact stated that while driving at an undisclosed speed, the message "Low Power" was displayed, and the vehicle lost motive power. The contact veered to the side of the road. The vehicle was taken back to the dealer where the front valve cover gasket and seals were replaced. Additionally, the dealer diagnosed that the thermostat had overheated and had melted the coolant hoses. The thermostat and coolant hoses were replaced; however, the failure persisted. The vehicle was towed back to the dealer where the front valve cover gasket and seals, the thermostat, five coolant hoses and coolant reservoir were replaced; however, the oil leak persisted. The vehicle was taken to a second dealer, Curry Center Auto Center, Inc. Chevrolet (2906 E Buick Cadillac Blvd, Bloomington, IN 47401) where the coolant sealant hoses, the front crank seal, the oil cooler, and other unknown repairs were completed; however, the failure persisted. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle model had been discontinued. The manufacturer referred the contact to the NHTSA hotline. The failure mileage was approximately 95,000.
NHTSA ODI #11497120
Mileage unknown · Sep 15, 2022
EngineFuel/propulsion SystemPower Train
The cars turbo system fails. This causes a loss of power when accelerating. Pulling out into traffic or merging onto the freeway are all unsafe now as the car suddenly doesn't accelerate. This can cause crashes. I have pulled out and assumed I was at a very safe distance only to have the car not pick up as it usually does. I…
Read full complaint
The cars turbo system fails. This causes a loss of power when accelerating. Pulling out into traffic or merging onto the freeway are all unsafe now as the car suddenly doesn't accelerate. This can cause crashes. I have pulled out and assumed I was at a very safe distance only to have the car not pick up as it usually does. I feel very unsafe.
NHTSA ODI #11484649
Mileage unknown · Aug 31, 2022
Electrical SystemEngineVehicle Speed Control
The car began to shake uncontrollably on the freeway at 55/MPH . The car then marked "Engine Power is Reduced", causing the car to no longer accelerate more than 5-7/MPH. This is a very dangerous situation because it can cause a terrible accident on the road since it's a random inconvenience. I have heard that many of these type…
Read full complaint
The car began to shake uncontrollably on the freeway at 55/MPH . The car then marked "Engine Power is Reduced", causing the car to no longer accelerate more than 5-7/MPH. This is a very dangerous situation because it can cause a terrible accident on the road since it's a random inconvenience. I have heard that many of these types of cars "Chevy Cruze" seem to experience the same type of problem. With that being said it's safe to say that as an owner this situation is far out of my control and it's definitely a collective problem with the type of car and make that it is. I ask for this to be immediately looked into.
NHTSA ODI #11482259
100,000 miles · Jun 10, 2022
EngineEngine And Engine Cooling
The contact owns a 2012 Chevrolet Cruze. The contact stated while driving 40-45 MPH, the check engine warning light illuminated and the vehicle stalled. The contact veered to the side of the road. The contact was able to restart the vehicle; however, the vehicle started overheating while driving. The vehicle was taken to an inde…
Read full complaint
The contact owns a 2012 Chevrolet Cruze. The contact stated while driving 40-45 MPH, the check engine warning light illuminated and the vehicle stalled. The contact veered to the side of the road. The contact was able to restart the vehicle; however, the vehicle started overheating while driving. The vehicle was taken to an independent mechanic where it was diagnosed that the knock control system, the knock sensor, the camshaft, the positive crankcase ventilation system, and the engine intake manifold gasket had failed. The contact received an unknown recall notification from the manufacturer associated with the failure at the beginning of the pandemic. The contact contacted several unknown dealers to schedule an appointment however, the dealers informed the contact that there was no availability to complete the recall repair on the vehicle. The manufacturer was later notified of the failure and assisted the contact in scheduling an appointment with the dealer for repair. The vehicle was towed to the local dealer who informed the contact that the vehicle could not be repaired under the unknown recall as the recall had expired. The vehicle was not repaired. The vehicle was towed back to the contact's residence. The failure mileage was approximately 100,000.
NHTSA ODI #11468626
Mileage unknown · Mar 11, 2022
Electrical SystemEngineUnknown Or Other
The temperature gauge never shows the hand even get to half on the hot cold fail however the car could have no coolant and be 400 degrees the sail will Or reflect so. This has caused many probable s bc I can’t tell when it over hears it’s mezwwzs the comupeter
NHTSA ODI #11456379
Mileage unknown · Oct 30, 2021
EngineUnknown Or OtherInjury
The vehicle will start to smoke, filling the cab with smoke with a strong smell of antifreeze causing occupants to become sick to the stomach and dizzy. This will occur unrelated to speed and operating temperature, and has happened multiple times.
NHTSA ODI #11438762
100,000 miles · Sep 10, 2021
EngineEngine And Engine Cooling
The contact owns a 2012 Chevrolet Cruze. The contact stated while driving 30 MPH, the check engine warning light illuminated, and the temperature gauge was fluctuating on the instrument panel. The contact pulled over to the side of the road and turned off the vehicle for several minutes while waiting for the vehicle engine to co…
Read full complaint
The contact owns a 2012 Chevrolet Cruze. The contact stated while driving 30 MPH, the check engine warning light illuminated, and the temperature gauge was fluctuating on the instrument panel. The contact pulled over to the side of the road and turned off the vehicle for several minutes while waiting for the vehicle engine to cool down before restarting the vehicle and continuing to drive to his residence. The next day the contact took the vehicle to be diagnosed by an independent mechanic. The contact was informed that the head gasket needed to be replaced. Additionally, the mechanic performed temporary repairs on the thermostat housing and replaced the manifold and oil gasket however, the failure persisted. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000.
NHTSA ODI #11432521
Mileage unknown · Sep 3, 2021
EngineFuel/propulsion System
I had no heat for a long time, as well as the engine light constantly being on and never knowing why. There was a lag to accelerate. Also it would suddenly overheat and say turn off ac due to overheating, as well as suddenly fluctuate to cold and back to normal. I change the throttle body inlet heater hose to see if that would g…
Read full complaint
I had no heat for a long time, as well as the engine light constantly being on and never knowing why. There was a lag to accelerate. Also it would suddenly overheat and say turn off ac due to overheating, as well as suddenly fluctuate to cold and back to normal. I change the throttle body inlet heater hose to see if that would get it working. It did for a day. Then all over a sudden the same issues started happening. From what I can tell it is an extremely common issue that has not been address yet or had a recall yet....the thermostat. That is the only thing it could be at this point. I am going to try and bleed out the coolant for air again. But other than that it is the thermostat, it is the only thing that covers every symptom and it is an extremely, well documented problem with these types of cars.
NHTSA ODI #11431594
Mileage unknown · Aug 6, 2021
EngineFuel/propulsion SystemPower Train
I have filed a complaint 2 other times on my car from the power train to the electrical and now my radiator. Because of the date of my car, which is one week off, my car doesn't fall under all the recalls that have been made. Everything wrong with my car is a recall including the head gasket! I have paid to fix my car out of poc…
Read full complaint
I have filed a complaint 2 other times on my car from the power train to the electrical and now my radiator. Because of the date of my car, which is one week off, my car doesn't fall under all the recalls that have been made. Everything wrong with my car is a recall including the head gasket! I have paid to fix my car out of pocket every time and now the repair isn't worth fixing because i never know whats going to happen next! Just like every other government agency NHTSA is controlled by the big corporations while the little guy gets screwed over! Times are hard as is now throw in this plandemic and car problems life becomes unmanageable at times.
NHTSA ODI #11428042
Mileage unknown · Aug 5, 2021
EngineFuel/propulsion SystemSteeringCrash
I've had this car for less than 2 months I've already spent $3,500 I've had to replace the thermostat the resvoir tank most oxygen sensors lower stream and upper stream now has a blown head gasket and a possible fuel pump
NHTSA ODI #11427813
Official recalls
7Jul 5, 2016
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Additional source detail variants (2)
Electrical System:ignition
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.
Jun 6, 2014
General Motors LLC (GM) is recalling certain model year 2012 Buick Verano vehicles manufactured December 2, 2011 to July, 16, 2012, Chevrolet Cruze vehicles manufactured December 7, 2011 to July 25, 2012, Chevrolet Sonic vehicles manufactured December 5, 2011 to August 2, 2012, and Chevrolet Camaro vehicles manufactured December 1, 2011 to June 11, 2012. The driver side frontal air bag has a shorting bar which may intermittently contact the air bag terminals.
Consequence & remedy
Consequence: If the bar and terminals are contacting each other at the time of a crash necessitating deployment of the driver's frontal air bag, that air bag will not deploy, increasing the driver's risk of injury.
Remedy: GM will notify owners, and dealers will replace the steering wheel air bag coil, free of charge. The recall began on July 25, 2014. Chevrolet owners may contact GM at 1-800-222-1020. Buick owners may contact GM at 1-800-521-7300. Note: This is an expansion of recalls 12V-522 and 13V-023.
Aug 15, 2013
General Motors (GM) is recalling certain model year 2011-2012 Chevrolet Cruze vehicles equipped with 1.4L DOHC gasoline turbo engines and 6T40 front wheel drive automatic transmissions and equipped with an electric vacuum pump to provide supplemental vacuum for brake assist, when needed. In the affected vehicles, the pump may not activate, resulting in an intermittent reduction or loss of brake assist.
Consequence & remedy
Consequence: A loss of braking assistance will require extra pedal force and/or distance to bring the vehicle to a stop, increasing the risk of a crash.
Remedy: General Motors will notify owners, and dealers will replace a microswitch in the power brake vacuum pipe assembly, free of charge. The recall began on October 7, 2013. Owners may contact Chevrolet at 1-800-222-1020. GM's recall number is 12213.
Jan 24, 2013
General Motors LLC (GM) is recalling certain model year 2012 Chevrolet Camaro, Cruze and Sonic, and model year 2012 Buick Verano vehicles. The driver side frontal air bag has a shorting bar which may intermittently contact the air bag terminals.
Consequence & remedy
Consequence: If the bar and terminals are contacting each other at the time of a crash necessitating deployment of the driver's frontal air bag, that air bag will not deploy, increasing the driver's risk of injury.
Remedy: GM will notify owners, and dealers will replace the steering wheel air bag coil, free of charge. The safety recall began on February 13, 2013. Owners may contact General Motors at 1-800-521-7300.
Oct 31, 2012
General Motors is recalling certain model year 2012 Buick Verano, Chevrolet Cruze, and Chevrolet Sonic vehicles. The driver side frontal air bag has a shorting bar which may intermittently contact the air bag terminals.
Consequence & remedy
Consequence: If the bar and terminals are contacting each other at the time of a crash necessitating deployment of the driver's frontal airbag, that airbag will not deploy, increasing the driver's risk of injury.
Remedy: General Motors will notify owners, and dealers will replace the steering wheel airbag coil, free of charge. The safety recall began on January 11, 2013. Owners may contact General Motors at 1-800-521-7300.
Jun 22, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 CHEVROLET CRUZE VEHICLES MANUFACTURED FROM OCTOBER 2, 2009, THROUGH MAY 31, 2012. SPILLED OR DRIPPING OIL (SUCH AS AFTER AN OIL CHANGE) MAY COLLECT IN THE ENGINE SHIELD (BELLYPAN) NEAR HOT ENGINE OR EXHAUST SYSTEM SURFACES. AS A RESULT, THE OIL AND THE ENGINE SHIELD MAY IGNITE AND BURN.
Consequence & remedy
Consequence: EITHER CONDITION COULD RESULT IN AN ENGINE COMPARTMENT FIRE, POSSIBLY CAUSING INJURY OR DEATH.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL MODIFY THE ENGINE SHIELD TO PREVENT FLUID FROM CONTACTING THE SHIELD. ALSO, ON VEHICLES WITH A MANUAL TRANSMISSION, DEALERS WILL APPLY A PROTECTIVE TAPE TO THE ELECTRONIC POWER STEERING WIRE HARNESS. REPAIRS WILL BE PERFORMED FREE OF CHARGE TO THE OWNER. THE SAFETY RECALL BEGAN ON JULY 10, 2012. OWNERS MAY CONTACT THE CHEVROLET OWNER CENTER AT 1-866-694-6546.
Jun 22, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 CHEVROLET CRUZE VEHICLES MANUFACTURED FROM OCTOBER 2, 2009, THROUGH MAY 14, 2012. ATTACHMENT WELDS FOR THE FUEL TANK STRAP SECONDARY BRACKETS MAY HAVE BEEN OMITTED.
Consequence & remedy
Consequence: THE FUEL TANK COULD COME LOOSE IN A CRASH, POSSIBLY ALLOWING FUEL TO LEAK FROM THE TANK. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE VEHICLE FOR MISSING WELDS. IF THE VEHICLE IS MISSING WELDS, DEALERS WILL SECURE THE BRACKET ATTACHMENTS WITH FASTENERS. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 9, 2012. OWNERS MAY CONTACT THE CHEVROLET OWNER CENTER AT 1-866-694-6546.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ13002 · Air Bag Non-deployment
Opened May 31, 2013 · Closed Jul 9, 2014
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Side:inflator Module
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Additional source detail variants (6)
Air Bags:frontal:driver Side:inflator Module
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags:frontal:driver Side:inflator Module
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags:frontal
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags:frontal
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
Air Bags
General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.
AQ12002 · Chapman Chevrolet / Cruze Engine Recall
Opened Oct 15, 2012 · Closed Oct 20, 2014
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine:gasoline
NHTSA opened AQ12-002 to determine whether Chapman Chevrolet of Philadelphia, Pennsylvania complied with the requirements of the National Traffic and Motor Vehicle Safety Act, 49 U.S.C.Chapter 301 (Safety Act) and its implementing regulations.The Safety Act requires, among other things, that a manufacturer notify its dealers of defects related to motor vehicle safety and non-compliances with Federal Motor Vehicle Safety Standards and, in turn, that a dealer not sell a new vehicle subject to a recall unless the recall remedy has been performed (49 U.S.C. ? 30120(i)). NHTSA issued an information request (IR) letter to Chapman Chevrolet on October 16, 2012.Chapman Chevrolet responded to this request on November 8, 2012.To gather additional information, NHTSA mailed an IR letter to General Motors LLC (GM) on February 25, 2013.GM responded to this request on April 1, 2013.NHTSA then issued a second IR letter to Chapman Chevrolet on July 2, 2013.Chapman Chevrolet supplied their response on July 30, 2013. NHTSA?s investigation indicated that Chapman Chevrolet sold and delivered 23 recalled vehicles that did not have the recall remedy completed at the time the vehicles were delivered to the customers.NHTSA therefore concluded that Chapman Chevrolet was liable for civil penalties for violations of the Safety Act, pursuant to 49 U.S.C. ? 30165.Under a Settlement Agreement dated October 1, 2014, Chapman Chevrolet paid compromised civil penalties in the amount of $50,000.This Audit Query is closed.
PE12010 · Engine Compartment Fire
Opened Mar 28, 2012 · Closed Jul 19, 2012
Status: closed (inferred from source dates) · Engine
In a June 21, 2012 letter to NHTSA, General Motors LLC. (GM) submitted a Defect Information Report (DIR) identifying a defect in approximately 413,148 model year (MY) 2011 through 2012 Chevrolet Cruze vehicles manufactured from October 2, 2009 through May 31, 2012 (Recall 12V-288). According to GM, engine oil change procedures can result in spilling or dripping of oil on the engine shield.Also, manual transmission vehicles with a completely worn clutch may cause hydraulic fluid to be expelled from the clutch housing vent hole.If oil, debris or the burning hydraulic fluid contacts hot engine or exhaust system surfaces, and the engine shield, the shield may ignite and burn, leading to a possible engine compartment or vehicle fire.GM and its engine shield supplier, Hanwha, modified the engine shield to address factors that may contribute to engine compartment fire. The redesigned shields were completely implemented in production vehicles by June 2012.The Office of Defects Investigation (ODI) analyzed complaint data provided by GM as well as complaints submitted to ODI from consumers. In total, there were 25 unique Chevrolet Cruze reports indicating hot surface ignition due to engine oil or hydraulic fluid contacting hot manifold, exhaust surfaces and the engine shield.Four additional fires were identified that resulted from other or unknown causes, including 1 attributed to a missing oil filler cap.Three fires of unknown cause all involved vehicles equipped with 1.4L L4 turbocharged engines.ODI will continue to monitor field experience in Cruze vehicles equipped with that engine.Owners of the recalled vehicles are notified to take their vehicle to a GM dealer, who will modify the engine shield to prevent oil fluids from contacting the shield.Also, on vehicles with a manual transmission, dealers are to apply a protective tape to the electronic power steering wire harness to prevent any incidents related to this issue. This preliminary evaluation is closed.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers (ODI Nos.): 10456338, 10453754, 10450556, 10446718.
Illustration