IllustrationFUEL TANK LEAKS (DRIVER'S SIDE) OUT OF THE TOP WHEN FILLED. GM SPECIAL COVERAGE ADJUSTMENT 15682 SHOULD COVER PAST WHEN VEHICLE WAS 'PLACED IN SERVICE' AND INSTEAD SHOULD INSTEAD READ '10 YEARS OR 120,000 MILES' - THIS FUEL LEAK IS A SERIOUS SAFETY ISSUE AND SHOULD BE COVERED.
2007 Chevrolet Corvette
Owner reports · Recalls · Investigations
More warning signs than most Corvette years
Owner complaints for the 2007 Chevrolet Corvette are substantially higher than the model-year median of 29.
About this comparison →How this year compares
Owner complaints by model year
Compare all Corvette years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
690–25K
8425–50K
6350–75K
3375–100K
16100–150K
4150K+
269 reports with mileage · 72 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 102 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports4 fire reports2 injury reports
Fuel/propulsion System complaints
102 reportsI RECEIVED A NOTICE IN JANUARY 2017 THAT THERE WAS A FUEL SYSTEM PROBLEM (SPECIAL NOTICE 15682) AND CHEVROLET (GM) WAS GOING TO EXTEND THE WARRANTY FOR 10 YEARS FOR MY 2007 CORVETTE. I GOT THE NOTICE 10 YEARS AFTER GM ACKNOWLEDGED THE PROBLEM SO THEIR REMEDY DOESN'T EXIST! THE FUEL SMELL IS SO EXCESSIVE THAT I AM AFRAID TO KE…
Read full complaint
I RECEIVED A NOTICE IN JANUARY 2017 THAT THERE WAS A FUEL SYSTEM PROBLEM (SPECIAL NOTICE 15682) AND CHEVROLET (GM) WAS GOING TO EXTEND THE WARRANTY FOR 10 YEARS FOR MY 2007 CORVETTE. I GOT THE NOTICE 10 YEARS AFTER GM ACKNOWLEDGED THE PROBLEM SO THEIR REMEDY DOESN'T EXIST! THE FUEL SMELL IS SO EXCESSIVE THAT I AM AFRAID TO KEEP THE CAR IN THE GARAGE SO I TOOK IT TO THE DEALER. I WAS TOLD THAT SINCE THE CAR IS 10 YEARS OLD GM WILL NOT HONOR THE NOTICE. THIS IS THE SECOND GM VEHICLE THAT I HAVE HAD THIS SAME PROBLEM WITH (HAD IT WITH A 2004 SUV) AND GM REFUSED TO HONOR THE RECALL BECAUSE THE SERIAL NUMBER WAS NOT IN THE RAGE OF THEIR SPECIAL NOTICE EVEN THOUGH IT HAD EXCESSIVE FUEL ODORS. THAT ONE COST ME $3200. GM HAS A TRACK RECORD OF SENDING NOTICES (LIKELY TO AVOID LEGAL ACTION OR BEING FORCED INTO A RECALL) AND NOT HONORING THEM. THIS IS HIGHLY UNSAFE AND COULD CAUSE FIRE/EXPLOSION. AT THIS POINT IT IS MY HOPE THAT YOUR AGENCY WILL FORCE GM TO RECALL ALL CORVETTES WITH THIS PROBLEM AND COVER THE ASSOCIATED COSTS . THIS NOTICE SAYS, IN BOLD AND UNDERLINING, DO NOT TAKE YOUR VEHICLE TO THE CHEVROLET DEALER AS A RESULT OF THIS LATTE UNLESS YOU BELIEVE THAT YOUR VEHICLE HAS THE CONDITION DESCRIBED ABOVE. I HAD INQUIRED ABOUT THIS RECALL ON 3/8/2017 AT THE DEALER. SINCE THE SMELL OF FUEL WAS NOT PRESENT I WAS TOLD THAT IT MAY NOT HAVE BEEN AN AFFECTED VEHICLE
RECENTLY AFTER I PARK MY CAR IN THE GARAGE I GET A STRONG ODOR OF GAS FUMES.IT HAS GOTTEN WORSE EACH TIME AFTER DRIVING.THE FUMES ARE VERY STRONG.THE CAR ONLY HAS 30, 000 MILES.TODAY I DISCOVERED A GAS STAIN ON THE GARAGE FLOOR BELOW THE GAS TANK.THE TANK IS LESS THAN 1/2 FULL.I HAVE A GAS WATER HEATER IN GARAGE THAT COULD CAUSE…
Read full complaint
RECENTLY AFTER I PARK MY CAR IN THE GARAGE I GET A STRONG ODOR OF GAS FUMES.IT HAS GOTTEN WORSE EACH TIME AFTER DRIVING.THE FUMES ARE VERY STRONG.THE CAR ONLY HAS 30, 000 MILES.TODAY I DISCOVERED A GAS STAIN ON THE GARAGE FLOOR BELOW THE GAS TANK.THE TANK IS LESS THAN 1/2 FULL.I HAVE A GAS WATER HEATER IN GARAGE THAT COULD CAUSE A FIRE. AFTER CHECKING ABOUT THIS PROBLEM I FOUND THAT MANY CORVETTE OWNERS HAVE THE SAME PROBLEM.GM BETTER RESOLVE THIS VERY SERIOUS SITUTION BEFORE SOMEONE IS KILLED.THESE GAS TANKS ARE DEFECTIVE AND MUST BE RECALLED!
TL* THE CONTACT OWNS A 2007 CHEVROLET CORVETTE. WHILE THE VEHICLE WAS STATIONARY AND WHILE DRIVING VARIOUS SPEEDS, A STRONG ODOR OF FUEL ENTERED INTO THE CABIN OF THE VEHICLE. A DEALER AND THE MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 83,200.
TL* THE CONTACT OWNS A 2007 CHEVROLET CORVETTE. THE CONTACT STATED THAT FUEL LEAKED FROM THE FUEL TANK WHILE THE VEHICLE WAS BEING REFUELED. WHILE DRIVING VARIOUS SPEEDS, THE ODOR OF FUMES EMITTED INTO THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER STATED THAT TH…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET CORVETTE. THE CONTACT STATED THAT FUEL LEAKED FROM THE FUEL TANK WHILE THE VEHICLE WAS BEING REFUELED. WHILE DRIVING VARIOUS SPEEDS, THE ODOR OF FUMES EMITTED INTO THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER STATED THAT THE EXTENDED WARRANTY HAD EXPIRED. THE APPROXIMATE FAILURE MILEAGE WAS 98,000.
BAD FUEL SMELL AFTER FILLING UP VEHICLE. DID NOT OVERFLOW OR TOP OFF. SMELL FUEL IN CABIN WHILE CAR IS IN MOTION AND STOPPED.
RECEIVED AN EXTENDED WARRANTY LETTER FROM CHEV IN MID FEB 2017 STATING MY VEHICLE MAY EXPERIENCE FUEL LEAK AND IF LEAK IS SUSPECTED TO HAVE VEHICLE INSPECTED AT CHEV DEALER AND IF VEHICLE HAS BEEN IN SERVICE FOR LESS THAN 10 YRS AND HAS LESS THAN 120,000 MILES, CHEV WILL REPAIR AT NO CHARGE. VEHICLE WAS INSPECTED AT DEALER (DUE …
Read full complaint
RECEIVED AN EXTENDED WARRANTY LETTER FROM CHEV IN MID FEB 2017 STATING MY VEHICLE MAY EXPERIENCE FUEL LEAK AND IF LEAK IS SUSPECTED TO HAVE VEHICLE INSPECTED AT CHEV DEALER AND IF VEHICLE HAS BEEN IN SERVICE FOR LESS THAN 10 YRS AND HAS LESS THAN 120,000 MILES, CHEV WILL REPAIR AT NO CHARGE. VEHICLE WAS INSPECTED AT DEALER (DUE TO FUEL ODER) AND CONDITION WAS CONFIRMED. DEALER WILL NOT HONOR REPAIR AND QUOTED COST AT $1338. CHEV CUSTOMER SERVICE STATED THAT VEHICLE WAS IN SERVICE SINCE NOV 2006 AND EXTENDED WARRANTY WAS NO LONGER VALID BECAUSE IT HAD EXCEEDED THE 10 YR PARAMETER BY 3 MO WHEN ISSUE WAS REPORTED. MILEAGE WAS AT 55,552. I BELIEVE THE ISSUE WAS PRESENT BEFORE NOV 2006 BUT THE FUEL ODOR WAS NOT DETECTED UNTIL THE LETTER WAS RECEIVED AND UNTIL I CHECKED THE VEHICLE (BOTH STATIONARY AND IN MOTION). THIS VEHICLE IS GENERALLY NOT DRIVEN IN WINTER MONTHS. I ALSO BELIEVE THAT ANY FUEL LEAKAGE IS A SAFETY HAZARD AND THAT THE LEAKAGE IS CAUSED BY A DESIGN DEFICIENCY AND AFFECTED VEHICLES SHOULD BE RECALLED AND REPAIRED FREE OF CHARGE BY THE MANUFACTURER REGARDLESS OF DELIVERY DATE (DUE TO DESIGN DEFICIENCY). I WILL SEND A COPY OF THIS HAZARD REPORT TO CHEVROLET. THEIR CASE # IS 8-2782315093. THANK YOU FOR YOUR ASSISTANCE.
HAVE GAS FUMES IN THE CAR AFTER FILLING THE TANK. WILL DISSIPATE AFTER 100 MILES WILL SMELL THE FUMES WHEN MOVING, TURNING CORNERS, AND STATIONARY AFTER USING THE CAR
I FOUND THE FOLLOWING DESCRIPTION ON THE CORVETTE FORUM. IT DESCRIBES THE SYMPTOMS OF MY CAR EXACTLY. FUEL LEAKS OUT THE TOP OF THE TANKS, AND WILL THEN DRIP DOWN THE BACK SIDE ONTO THE HOT EXHAUST. IF IGNORED THIS COULD RESULT IN A FIRE AND POSSIBLE DEATH. IF PARKED OVERNIGHT IN A GARAGE, THE VAPOR WILL FILL THE GARAGE A…
Read full complaint
I FOUND THE FOLLOWING DESCRIPTION ON THE CORVETTE FORUM. IT DESCRIBES THE SYMPTOMS OF MY CAR EXACTLY. FUEL LEAKS OUT THE TOP OF THE TANKS, AND WILL THEN DRIP DOWN THE BACK SIDE ONTO THE HOT EXHAUST. IF IGNORED THIS COULD RESULT IN A FIRE AND POSSIBLE DEATH. IF PARKED OVERNIGHT IN A GARAGE, THE VAPOR WILL FILL THE GARAGE AND COULD EASILY BE TRIGGERED INTO AN EXPLOSION AND FIRE FROM A GAS WATER HEATER OR OTHER IGNITION SOURCE.
STRONG FUEL ODOR WHEN TANK IS ABOVE HALF FULL. THE CAR WAS PARKED IN GARAGE NEXT TO GAS WATER HEATER. WOKE TO HOUSE WITH STRONG GASOLINE ODOR. CAN ONLY PUT 6 GALLONS OF GAS IN CAR. CAR IS A FIRE HAZARD
Official recalls
214V251000 · Electrical System:wiring; Exterior Lighting:headlights
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2005-2007 Chevrolet Corvette vehicles manufactured March 29, 2004, through June 22, 2007. In the affected vehicles, the underhood bussed electrical center (UBEC) housing can expand and cause the headlamp low beam relay control circuit wire to bend. If the wire is repeatedly bent, it may fracture causing a loss of low beam headlamp illumination.
Consequence & remedy
Consequence: The loss of low beam headlamp illumination will decrease the driver's visibility, as well as the vehicle's conspicuity to other motorists, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will install a jumper wire to correct this condition, free of charge. The recall began January 2, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 13146. Note: Model year 2008-2013 Chevrolet Corvettes will be covered under customer satisfaction program number 14203 for the same issue.
Additional source detail variants (2)
Exterior Lighting:headlights
General Motors LLC (GM) is recalling certain model year 2005-2007 Chevrolet Corvette vehicles manufactured March 29, 2004, through June 22, 2007. In the affected vehicles, the underhood bussed electrical center (UBEC) housing can expand and cause the headlamp low beam relay control circuit wire to bend. If the wire is repeatedly bent, it may fracture causing a loss of low beam headlamp illumination.
Consequence: The loss of low beam headlamp illumination will decrease the driver's visibility, as well as the vehicle's conspicuity to other motorists, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will install a jumper wire to correct this condition, free of charge. The recall began January 2, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 13146. Note: Model year 2008-2013 Chevrolet Corvettes will be covered under customer satisfaction program number 14203 for the same issue.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2005-2007 Chevrolet Corvette vehicles manufactured March 29, 2004, through June 22, 2007. In the affected vehicles, the underhood bussed electrical center (UBEC) housing can expand and cause the headlamp low beam relay control circuit wire to bend. If the wire is repeatedly bent, it may fracture causing a loss of low beam headlamp illumination.
Consequence: The loss of low beam headlamp illumination will decrease the driver's visibility, as well as the vehicle's conspicuity to other motorists, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will install a jumper wire to correct this condition, free of charge. The recall began January 2, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 13146. Note: Model year 2008-2013 Chevrolet Corvettes will be covered under customer satisfaction program number 14203 for the same issue.
09V491000 · Structure:body:roof And Pillars
Dec 23, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2007 CORVETTE VEHICLES EQUIPPED WITH A REMOVABLE ROOF AND MODEL YEAR 2006 AND 2007 CORVETTE Z06 VEHICLES. THE ADHESIVE BETWEEN THE ROOF PANEL AND THE FRAME MAY SEPARATE. IF THERE IS A PARTIAL SEPARATION, THE DRIVER MAY NOTICE ONE OR MORE SYMPTOMS, SUCH AS A SNAPPING NOISE WHEN DRIVING OVER BUMPS, WIND NOISE, POOR ROOF PANEL FIT, ROOF PANEL MOVEMENT/BOUNCE WHEN A DOOR OR HATCH IS CLOSED, OR A WATER LEAK IN THE HEADLINER.
Consequence & remedy
Consequence: IF THERE IS A COMPLETE SEPARATION, THE ROOF PANEL MAY DETACH FROM THE VEHICLE. IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS BEING DRIVEN, IT COULD STRIKE A FOLLOWING VEHICLE AND CAUSE INJURY AND/OR PROPERTY DAMAGE.
Remedy: DEALERS WILL INSTALL A NEW DESIGN ROOF PANEL FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING APRIL 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA13007 · Simultaneous Loss Of Low-Beam Headlights
Opened Aug 23, 2013 · Closed Jun 24, 2014
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights
On May 14, 2014, General Motors (GM) submitted a Part 573 defect information report initiating NHTSA Safety Recall 14V-251 to remedy the subject vehicles.GM will remedy a defect condition in the underhood bussed electrical center (UBEC) by modifying the vehicle's electrical harnessing.GM also announced a customer satisfaction bulletin to address this issue on model year (MY) 2008-2013 Chevrolet Corvettes.Both programs will be conducted free of charge.According to GM, when the engine heats up and cools down (from normal use), the plastic material in the UBEC housing expands at a different rate than an electrical conductor routed within it.The difference in expansion rates results in bending of the conductor, a control circuit for the low beam headlights.After multiple thermal cycles, often taking several years of use, the conductor fractures resulting in an open circuit.When this occurs the low-beam headlights will not illuminate.After the engine is turned off and the UBEC cools, the conductor may temporarily reconnect and restore low-beam function, although subsequent failures will occur.This condition does not affect high-beam headlights, marker lamps, turn signals or fog lamps.Simultaneous loss of low-beam headlights could reduce the driver's visibility, increasing the risk of a crash. The ODI report counts noted above, involving the loss of low beam headlights, represents those received at the time of GM's recall filing; however NHTSA has since received additional complaints.GM submitted similar complaints in response to the agency's information request.Among the complaints reported to NHTSA, five alleged minor crashes in which the vehicle ran off the road or into roadside objects due to the sudden loss of headlights.Two of these complaints alleged minor injuries and three alleged property damage.Several other reports to NHTSA alleged close calls due to the loss of lighting.GM states that it has received no reports of crashes, injuries or fatalities as a result of this condition. GM's recall action appears to adequately address the safety risks in the subject vehicles of concern to ODI.Accordingly, the investigation is closed.In addition to recalling the subject vehicles, GM is covering MY 2008-2013 Corvettes, which contain essentially the same UBEC, under a customer satisfaction campaign.ODI notes that these vehicles exhibit a lower likelihood of failure due to their comparatively shorter service life. The VOQs cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10400308, 10415603, 10415867, 10416531, 10421639, 10424391, 10424543, 10445971, 10451733, 10454919, 10460674, 10460750, 10463546, 10466342, 10466857, 10468128, 10469057, 10470616, 10471595, 10474350, 10474368, 10475257, 10486597, 10491670, 10496592, 10496788, 10498100, 10502059, 10505606, 10508507, 10510052, 10511467, 10511517, 10511576, 10511696, 10511699, 10511789, 10511837, 10511994, 10512072, 10512093, 10512154, 10512292, 10512341, 10512856, 10513422, 10514576, 10514802, 10514978, 10515162, 10515311, 10515821, 10519426, 10519879, 10520155, 10521036, 10521585, 10522260, 10523059, 10523064, 10523190, 10525646, 10531602, 10531631, 10532221, 10532439, 10533227, 10533251, 10533339, 10536835, 10537561, 10537612, 10538184, 10541749, 10542468, 10542540, 10542576, 10542708, 10542726, 10543187, 10543970, 10544083, 10544810, 10545441, 10545516, 10547343, 10547561, 10547600, 10548492, 10548588, 10548687, 10548982, 10549272, 10549487, 10550079, 10550260, 10551233, 10551867, 10551926, 10551978, 10552019, 10553258, 10554456, 10554573, 10556002, 10556433, 10556844, 10556984, 1
Additional source detail variants (2)
Exterior Lighting
On May 14, 2014, General Motors (GM) submitted a Part 573 defect information report initiating NHTSA Safety Recall 14V-251 to remedy the subject vehicles.GM will remedy a defect condition in the underhood bussed electrical center (UBEC) by modifying the vehicle's electrical harnessing.GM also announced a customer satisfaction bulletin to address this issue on model year (MY) 2008-2013 Chevrolet Corvettes.Both programs will be conducted free of charge.According to GM, when the engine heats up and cools down (from normal use), the plastic material in the UBEC housing expands at a different rate than an electrical conductor routed within it.The difference in expansion rates results in bending of the conductor, a control circuit for the low beam headlights.After multiple thermal cycles, often taking several years of use, the conductor fractures resulting in an open circuit.When this occurs the low-beam headlights will not illuminate.After the engine is turned off and the UBEC cools, the conductor may temporarily reconnect and restore low-beam function, although subsequent failures will occur.This condition does not affect high-beam headlights, marker lamps, turn signals or fog lamps.Simultaneous loss of low-beam headlights could reduce the driver's visibility, increasing the risk of a crash. The ODI report counts noted above, involving the loss of low beam headlights, represents those received at the time of GM's recall filing; however NHTSA has since received additional complaints.GM submitted similar complaints in response to the agency's information request.Among the complaints reported to NHTSA, five alleged minor crashes in which the vehicle ran off the road or into roadside objects due to the sudden loss of headlights.Two of these complaints alleged minor injuries and three alleged property damage.Several other reports to NHTSA alleged close calls due to the loss of lighting.GM states that it has received no reports of crashes, injuries or fatalities as a result of this condition. GM's recall action appears to adequately address the safety risks in the subject vehicles of concern to ODI.Accordingly, the investigation is closed.In addition to recalling the subject vehicles, GM is covering MY 2008-2013 Corvettes, which contain essentially the same UBEC, under a customer satisfaction campaign.ODI notes that these vehicles exhibit a lower likelihood of failure due to their comparatively shorter service life. The VOQs cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10400308, 10415603, 10415867, 10416531, 10421639, 10424391, 10424543, 10445971, 10451733, 10454919, 10460674, 10460750, 10463546, 10466342, 10466857, 10468128, 10469057, 10470616, 10471595, 10474350, 10474368, 10475257, 10486597, 10491670, 10496592, 10496788, 10498100, 10502059, 10505606, 10508507, 10510052, 10511467, 10511517, 10511576, 10511696, 10511699, 10511789, 10511837, 10511994, 10512072, 10512093, 10512154, 10512292, 10512341, 10512856, 10513422, 10514576, 10514802, 10514978, 10515162, 10515311, 10515821, 10519426, 10519879, 10520155, 10521036, 10521585, 10522260, 10523059, 10523064, 10523190, 10525646, 10531602, 10531631, 10532221, 10532439, 10533227, 10533251, 10533339, 10536835, 10537561, 10537612, 10538184, 10541749, 10542468, 10542540, 10542576, 10542708, 10542726, 10543187, 10543970, 10544083, 10544810, 10545441, 10545516, 10547343, 10547561, 10547600, 10548492, 10548588, 10548687, 10548982, 10549272, 10549487, 10550079, 10550260, 10551233, 10551867, 10551926, 10551978, 10552019, 10553258, 10554456, 10554573, 10556002, 10556433, 10556844, 10556984, 1
Exterior Lighting:headlights
On May 14, 2014, General Motors (GM) submitted a Part 573 defect information report initiating NHTSA Safety Recall 14V-251 to remedy the subject vehicles.GM will remedy a defect condition in the underhood bussed electrical center (UBEC) by modifying the vehicle's electrical harnessing.GM also announced a customer satisfaction bulletin to address this issue on model year (MY) 2008-2013 Chevrolet Corvettes.Both programs will be conducted free of charge.According to GM, when the engine heats up and cools down (from normal use), the plastic material in the UBEC housing expands at a different rate than an electrical conductor routed within it.The difference in expansion rates results in bending of the conductor, a control circuit for the low beam headlights.After multiple thermal cycles, often taking several years of use, the conductor fractures resulting in an open circuit.When this occurs the low-beam headlights will not illuminate.After the engine is turned off and the UBEC cools, the conductor may temporarily reconnect and restore low-beam function, although subsequent failures will occur.This condition does not affect high-beam headlights, marker lamps, turn signals or fog lamps.Simultaneous loss of low-beam headlights could reduce the driver's visibility, increasing the risk of a crash. The ODI report counts noted above, involving the loss of low beam headlights, represents those received at the time of GM's recall filing; however NHTSA has since received additional complaints.GM submitted similar complaints in response to the agency's information request.Among the complaints reported to NHTSA, five alleged minor crashes in which the vehicle ran off the road or into roadside objects due to the sudden loss of headlights.Two of these complaints alleged minor injuries and three alleged property damage.Several other reports to NHTSA alleged close calls due to the loss of lighting.GM states that it has received no reports of crashes, injuries or fatalities as a result of this condition. GM's recall action appears to adequately address the safety risks in the subject vehicles of concern to ODI.Accordingly, the investigation is closed.In addition to recalling the subject vehicles, GM is covering MY 2008-2013 Corvettes, which contain essentially the same UBEC, under a customer satisfaction campaign.ODI notes that these vehicles exhibit a lower likelihood of failure due to their comparatively shorter service life. The VOQs cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10400308, 10415603, 10415867, 10416531, 10421639, 10424391, 10424543, 10445971, 10451733, 10454919, 10460674, 10460750, 10463546, 10466342, 10466857, 10468128, 10469057, 10470616, 10471595, 10474350, 10474368, 10475257, 10486597, 10491670, 10496592, 10496788, 10498100, 10502059, 10505606, 10508507, 10510052, 10511467, 10511517, 10511576, 10511696, 10511699, 10511789, 10511837, 10511994, 10512072, 10512093, 10512154, 10512292, 10512341, 10512856, 10513422, 10514576, 10514802, 10514978, 10515162, 10515311, 10515821, 10519426, 10519879, 10520155, 10521036, 10521585, 10522260, 10523059, 10523064, 10523190, 10525646, 10531602, 10531631, 10532221, 10532439, 10533227, 10533251, 10533339, 10536835, 10537561, 10537612, 10538184, 10541749, 10542468, 10542540, 10542576, 10542708, 10542726, 10543187, 10543970, 10544083, 10544810, 10545441, 10545516, 10547343, 10547561, 10547600, 10548492, 10548588, 10548687, 10548982, 10549272, 10549487, 10550079, 10550260, 10551233, 10551867, 10551926, 10551978, 10552019, 10553258, 10554456, 10554573, 10556002, 10556433, 10556844, 10556984, 1
PE13013 · Loss Of Low Beam Headlights
Opened May 6, 2013 · Closed Aug 26, 2013
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights
The Office of Defects Investigation (ODI) opened this investigation based on 30 reports from consumers alleging that, after driving for a short time (5 to 30 minutes), both low beam headlights stopped working simultaneously and without warning. The low beam headlights remained inoperative for the remainder of the drive cycle, however no other lighting is affected.General Motors (GM) provided information in response to ODI's information request letter explaining that the loss of headlights is caused by a fractured low beam circuit wire in the underhood bussed electrical center (UBEC), a device that is similar to a fuse box. The UBEC is located in a high heat area near the engine, and the low beam circuit wire routing within the UBEC makes it susceptible to cyclical stress caused by thermal expansion.The investigation covers model years 2005-2007 Corvettes however ODI also has received four VOQs alleging the same condition in model year 2008 Corvettes. ODI is upgrading the investigation to an Engineering Analysis to further examine the consequences, frequency and scope of this problem. The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers.For MY 2005-2007: 10400308, 10415603, 10415867, 10416531, 10421639, 10424391, 10424543, 10445971, 10451733, 10454919, 10460674, 10460750, 10463546, 10466342, 10466857, 10468128, 10469057, 10470616, 10471595, 10474350, 10474368, 10475257, 10486597, 10491670, 10496592, 10496788, 10498100, 10502059, 10505606, 10508507, 10510052, 10511467, 10511517, 10511576, 10511696, 10511699, 10511789, 10511837, 10511994, 10512072, 10512093, 10512154, 10512292, 10512341, 10513422, 10514802, 10514978, 10515162, 10515311, 10515821, 10519426, 10519879, 10520155, 10521036, 10521585, 10522260, 10523064, 10523190, 10525646, 10531602, 10531631, 10532439, 10533227, 10533251, 10533339For MY 2008: 10512856, 10514576, 10523059, 10532221
Additional source detail variants (2)
Exterior Lighting
The Office of Defects Investigation (ODI) opened this investigation based on 30 reports from consumers alleging that, after driving for a short time (5 to 30 minutes), both low beam headlights stopped working simultaneously and without warning. The low beam headlights remained inoperative for the remainder of the drive cycle, however no other lighting is affected.General Motors (GM) provided information in response to ODI's information request letter explaining that the loss of headlights is caused by a fractured low beam circuit wire in the underhood bussed electrical center (UBEC), a device that is similar to a fuse box. The UBEC is located in a high heat area near the engine, and the low beam circuit wire routing within the UBEC makes it susceptible to cyclical stress caused by thermal expansion.The investigation covers model years 2005-2007 Corvettes however ODI also has received four VOQs alleging the same condition in model year 2008 Corvettes. ODI is upgrading the investigation to an Engineering Analysis to further examine the consequences, frequency and scope of this problem. The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers.For MY 2005-2007: 10400308, 10415603, 10415867, 10416531, 10421639, 10424391, 10424543, 10445971, 10451733, 10454919, 10460674, 10460750, 10463546, 10466342, 10466857, 10468128, 10469057, 10470616, 10471595, 10474350, 10474368, 10475257, 10486597, 10491670, 10496592, 10496788, 10498100, 10502059, 10505606, 10508507, 10510052, 10511467, 10511517, 10511576, 10511696, 10511699, 10511789, 10511837, 10511994, 10512072, 10512093, 10512154, 10512292, 10512341, 10513422, 10514802, 10514978, 10515162, 10515311, 10515821, 10519426, 10519879, 10520155, 10521036, 10521585, 10522260, 10523064, 10523190, 10525646, 10531602, 10531631, 10532439, 10533227, 10533251, 10533339For MY 2008: 10512856, 10514576, 10523059, 10532221
Exterior Lighting:headlights
The Office of Defects Investigation (ODI) opened this investigation based on 30 reports from consumers alleging that, after driving for a short time (5 to 30 minutes), both low beam headlights stopped working simultaneously and without warning. The low beam headlights remained inoperative for the remainder of the drive cycle, however no other lighting is affected.General Motors (GM) provided information in response to ODI's information request letter explaining that the loss of headlights is caused by a fractured low beam circuit wire in the underhood bussed electrical center (UBEC), a device that is similar to a fuse box. The UBEC is located in a high heat area near the engine, and the low beam circuit wire routing within the UBEC makes it susceptible to cyclical stress caused by thermal expansion.The investigation covers model years 2005-2007 Corvettes however ODI also has received four VOQs alleging the same condition in model year 2008 Corvettes. ODI is upgrading the investigation to an Engineering Analysis to further examine the consequences, frequency and scope of this problem. The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers.For MY 2005-2007: 10400308, 10415603, 10415867, 10416531, 10421639, 10424391, 10424543, 10445971, 10451733, 10454919, 10460674, 10460750, 10463546, 10466342, 10466857, 10468128, 10469057, 10470616, 10471595, 10474350, 10474368, 10475257, 10486597, 10491670, 10496592, 10496788, 10498100, 10502059, 10505606, 10508507, 10510052, 10511467, 10511517, 10511576, 10511696, 10511699, 10511789, 10511837, 10511994, 10512072, 10512093, 10512154, 10512292, 10512341, 10513422, 10514802, 10514978, 10515162, 10515311, 10515821, 10519426, 10519879, 10520155, 10521036, 10521585, 10522260, 10523064, 10523190, 10525646, 10531602, 10531631, 10532439, 10533227, 10533251, 10533339For MY 2008: 10512856, 10514576, 10523059, 10532221