IllustrationWHEN I START MY CAR THE GAS LEAKS OUT OF THE REAR DRIVER SIDE ONTO THE GROUND BELOW THE CAR.
2000 Chevrolet Corvette
Owner reports · Recalls · Investigations
More warning signs than most Corvette years
Owner complaints for the 2000 Chevrolet Corvette are substantially higher than the model-year median of 29.
About this comparison →How this year compares
Owner complaints by model year
Compare all Corvette years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
490–25K
5925–50K
3450–75K
1175–100K
16100–150K
4150K+
173 reports with mileage · 104 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 168 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
15 crash reports0 fire reports8 injury reports
What owners actually said
277 reportsTHE STEERING COLUMN OF MY CAR LOCKED AND I HAD TO TOW THE CAR TO THE NEAREST DEALERSHIP. I KNOW THERE WAS A RECALL FOR THIS PROBLEM IN 2004. THE RECALL WAS NEVER FIXED ON MY CAR. THE DEALERSHIP CLAIMS THAT THERE A 0 OPEN RECALLS ON MY CAR AND WANTS TO CHARGE ME $1500 FOR THE REPAIR. I AM THE FIRST AND ONLY OWNER OF THE CAR AND A…
Read full complaint
THE STEERING COLUMN OF MY CAR LOCKED AND I HAD TO TOW THE CAR TO THE NEAREST DEALERSHIP. I KNOW THERE WAS A RECALL FOR THIS PROBLEM IN 2004. THE RECALL WAS NEVER FIXED ON MY CAR. THE DEALERSHIP CLAIMS THAT THERE A 0 OPEN RECALLS ON MY CAR AND WANTS TO CHARGE ME $1500 FOR THE REPAIR. I AM THE FIRST AND ONLY OWNER OF THE CAR AND AM VERY SURE THAT THE RECALL WAS NOT FIXED BECAUSE I'VE NEVER TAKEN THE CAR TO ANY DEALERSHIP FOR ANY REASON. I ASKED FOR RECORDS OF THE REPAIR AND WAS TOLD THAT THEY DON'T HAVE RECORDS. PLEASE HELP!!!!!
MY 2000 CHEVROLET CORVETTE HAS APPROXIMATELY 57,500 ORIGINAL MILES ON IT. RECALL #04006 WAS COMPLETED ON MY VEHICLE BY DEALER CODE 20385 BACK IN 2004. I DID SEE THEY RELEASED RECALL'S #04006B AND 04006C AS WELL. I STARTED MY CAR ON 7/30/2019 AND I WAS SITTING IN THE GARAGE WHEN I SAW THE "STEERING COLUMN LOCK" MESSAGE ON THE DAS…
Read full complaint
MY 2000 CHEVROLET CORVETTE HAS APPROXIMATELY 57,500 ORIGINAL MILES ON IT. RECALL #04006 WAS COMPLETED ON MY VEHICLE BY DEALER CODE 20385 BACK IN 2004. I DID SEE THEY RELEASED RECALL'S #04006B AND 04006C AS WELL. I STARTED MY CAR ON 7/30/2019 AND I WAS SITTING IN THE GARAGE WHEN I SAW THE "STEERING COLUMN LOCK" MESSAGE ON THE DASHBOARD. THE CAR WAS STARTED AND NOW THE STEERING WHEEL IS LOCKED AND CAN NOT BE TURNED. I REACHED OUT TO TWO LOCAL SAN DIEGO CHEVROLET DEALERSHIPS; BOB STALL CHEVROLET AND JIMMIE JOHNSON CHEVROLET, CORPORATE GM, CORPORATE CHEVROLET AND THE NTSB. THEY ALL TOLD ME THE RECALL WAS COMPLETED AND THERE IS NOTHING THEY CAN DO, THEY SAID I WILL HAVE TO REPAIR THE ISSUE. THIS IS UNSATISFACTORY! I COULD HAVE TAKEN THE CAR OUT FOR A DRIVE AND HAD THE STEERING WHEEL LOCK UP AS IM DRIVING. DOING RESEARCH ONLINE AND READING THE RECALL BULLETIN IS IT POSSIBLE THE REPAIR WAS NOT DONE PROPERLY? I DON'T KNOW, I DID NOT OWN THE CAR WHEN THE RECALL WAS PERFORMED. I WAS GIVEN A CASE # OF [XXX] WHEN I CALLED 1-800-630-2438. PLEASE SEE THE ATTACHED PICTURES. CONTACT HAS NOT BEEN ABLE TO DRIVE THE CAR FOR 10 MONTHS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TT *LN*JB *LN*JB
I HAVE A FUEL LEAK COMING FROM RIGHT BEHIND THE FUEL FILTER TOWARDS THE TOP OF THE PASSENGER FUEL TANK. THIS IS CREATING A FUEL VAPOR SMELL AND A SAFETY HAZARD .
I HAVE A MESSAGE ON MY DASHBOARD STATING "SERVICE STEERING COLUMN LOCK". THIS MESSAGE TRIGGERS A FUEL SHUTOFF AT 2 MPH. LUCKILY THIS HAPPENED TO ME AS I WAS PULLING OUT OF MY DRIVEWAY. I DREAD TO IMAGINE THE CONSEQUENCES OF THIS HAPPENING IF I HAD BEEN DRIVING AT SPEED ON A HIGHWAY OR BUSY STREET.
WHILE GETTING IN MY VEHICLE, THE SEATS HAVE AN AUTO ADJUST MEMORY FUNCTION. HOWEVER, WHILE DRIVING DOWN THE ROAD, AFTER PULLING OUT OF MY DRIVEWAY, ON AT LEAST 5 OCCASIONS, MY SEATS BEGAN TO MOVE BACKWARDS AWAY FROM THE PEDALS AND STEERING WHEEL AND I'M A RATHER SHORT LADY. THIS SCARED ME TO DEATH!
TL* THE CONTACT OWNS A 2000 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING); HOWEVER, THE OEM REPLACEMENT PART FAILED. THE VEHICLE WAS TOWED BACK TO THE DEALER (RICK HENDRICK CITY CHEVROLET, 5101 E INDEPENDENCE BLVD, CHARLOTTE, NC 28212, (980) 242-5621) WITHIN …
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING); HOWEVER, THE OEM REPLACEMENT PART FAILED. THE VEHICLE WAS TOWED BACK TO THE DEALER (RICK HENDRICK CITY CHEVROLET, 5101 E INDEPENDENCE BLVD, CHARLOTTE, NC 28212, (980) 242-5621) WITHIN MONTHS DUE TO THE IGNITION LOCKING AND THE SECURITY ALARM RANDOMLY ACTIVATING, WHICH CAUSED THE VEHICLE TO COMPLETELY SHUT DOWN. THE VEHICLE WAS TOWED TO A SECOND DEALER (FRED CALDWELL CHEVROLET, 974 BETHEL ST, CLOVER, SC 29710, 1-888-692-6546 AND 1-803-222-4581). THE MANUFACTURER WAS CONTACTED SEVERAL TIMES OVER THE YEARS AND WAS AWARE THAT VARIOUS FIFTH EDITION VEHICLES WERE AFFECTED. THE MANUFACTURER HAD NOT DEVELOPED A NEWLY DESIGNED OEM PART AND EXPECTED THE CONTACT TO HAVE THE PART REPLACED A THIRD TIME. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA ACTION NUMBERS: EA02031 (STEERING) AND PE02054 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS NOT AVAILABLE.
TL* THE CONTACT OWNS A 2000 CHEVROLET CORVETTE. MONTHS AFTER THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING), THE STEERING WHEEL SEIZED, THE VEHICLE STALLED, AND AN ERROR MESSAGE INDICATED TO REMOVE THE KEY. THE VEHICLE WAS ABLE TO RESTART AND WAS TOWED TO PARKS CHEVROLET (103 ROBERT SMALLS PKWY, BEAUFOR…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET CORVETTE. MONTHS AFTER THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING), THE STEERING WHEEL SEIZED, THE VEHICLE STALLED, AND AN ERROR MESSAGE INDICATED TO REMOVE THE KEY. THE VEHICLE WAS ABLE TO RESTART AND WAS TOWED TO PARKS CHEVROLET (103 ROBERT SMALLS PKWY, BEAUFORT, SC 29906, (843) 525-4100) WHERE IT WAS DIAGNOSED THAT THE STEERING WHEEL SECURITY SYSTEM WAS DEFECTIVE. THE VEHICLE WAS REPAIRED, BUT THE FAILURE PERSISTED. THE VEHICLE WAS TOWED TO FRED CALDWELL CHEVROLET (974 BETHEL ST, CLOVER, SC 29710, (803) 810-0089) WHERE IT WAS DIAGNOSED THAT THE STEERING WHEEL SECURITY SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE AND VIN WERE NOT PROVIDED.
THE ABS LIGHT AND TRACTION CONTROL ARE NON-FUNCTIONING. CHEVROLET DEALER ADVISED THE PROBLEM IS THE ELECTRONIC BRAKE CONTROL MODULE. CHEVROLET DISCONTINUED THE PART AND NO PARTS ARE AVAILABLE. I WAS ADVISED THEY CAN NOT FIX THIS ISSUE AND MY CAR WILL SIMPLY NOT HAVE ABS OR TRACTION CONTROL FUNCTIONALITY ANYMORE. HARD FOR ME TO B…
Read full complaint
THE ABS LIGHT AND TRACTION CONTROL ARE NON-FUNCTIONING. CHEVROLET DEALER ADVISED THE PROBLEM IS THE ELECTRONIC BRAKE CONTROL MODULE. CHEVROLET DISCONTINUED THE PART AND NO PARTS ARE AVAILABLE. I WAS ADVISED THEY CAN NOT FIX THIS ISSUE AND MY CAR WILL SIMPLY NOT HAVE ABS OR TRACTION CONTROL FUNCTIONALITY ANYMORE. HARD FOR ME TO BELIEVE CHEVROLET CANT BE HELD RESPONSIBLE TO PROVIDE PARTS TO REPAIR THEIR OWN CARS FOR A FEATURE SUCH AS ABS SYSTEMS.
THIS VEHICLE HAS 30,000 MI. JUST STARTED NOTICING FUEL SMELL COMING FROM RIGHT REAR SIDE AFTER PARKING INSIDE MY GARAGE. CAN'T SEE ANY LEAKS ON THE FLOOR, YET CONCERNING !
Official recalls
204V060000 · Steering:column LOCKING:ANTI-THEFT Device
Feb 9, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ELECTRONIC COLUMN LOCK SYSTEMS (ECL), WHEN THE IGNITION SWITCH IS TURNED TO "LOCK," THE ECL SYSTEM PREVENTS TURNING OF THE STEERING SYSTEM. WHEN THE VEHICLE IS STARTED, THE ECL UNLOCKS THE STEERING SYSTEM. THE VEHICLE IS DESIGNED SO THAT IF THE COLUMN FAILS TO UNLOCK WHEN THE VEHICLE IS STARTED AND THE CUSTOMER TRIES TO DRIVE, THE FUEL SUPPLY WILL BE SHUT OFF SO THAT THE VEHICLE CANNOT MOVE WHEN THE VEHICLE CANNOT BE STEERED. IF VOLTAGE AT THE POWERTRAIN CONTROL MODULE IS LOW OR INTERRUPTED, HOWEVER, THE FUEL SHUT OFF MAY NOT OCCUR AND THE VEHICLE CAN BE ACCELERATED WHILE THE STEERING SYSTEM IS LOCKED. ALSO WHEN THE CONTROL SYSTEM SHOWS THAT THE ECL IS UNLOCKED AND THE VEHICLE IS BEING DRIVEN, THE LOCK PIN LOCATION CAN VARY. DEPENDING ON THE LOCATION OF THE LOCK PLATE RELATIVE TO THE SWITCH TRANSITION POINT, THERE COULD THEN BE CONTACT BETWEEN THE LOCK PLATE AND PIN CAUSING THE STEERING TO LOCK WHILE DRIVING .
Consequence & remedy
Consequence: IF THIS OCCURS, A CRASH COULD OCCUR WITHOUT WARNING.
Remedy: ON VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE DEALER WILL DISABLE THE STEERING COLUMN LOCK BY REMOVING THE COLUMN LOCK PLATE. WHEN THE IGNITION KEY IS REMOVED, THE TRANSMISSION SHIFTER WILL LOCK BUT THE STEERING COLUMN WILL NOT LOCK. ON VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION, THE DEALER WILL REPROGRAM THE POWERTRAIN CONTROL MODULE, PERFORM A DIMENSIONAL CHECK OF THE COLUMN LOCK AND, IF NECESSARY, REPLACE THE LOCK PLATE. THE STEERING COLUMN ON THESE VEHICLES WILL CONTINUE TO LOCK WHEN THE KEY IS REMOVED. OWNER NOTIFICATION TO OWNERS OF 1997 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS BEGAN ON APRIL 26, 2004. OWNERS OF 1998 THROUGH 2004 VEHICLES (EXCEPT 1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED BEGINNING ON AUGUST 2, 2004. THE REMAINING OWNERS (1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED LATER IN 2004, WHEN PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
00V111000 · Seat Belts:front
Apr 17, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE LAP BELT WEBBING CAN TWIST ALLOWING THE WEBBING TO BECOME JAMMED IN THE RETRACTOR.
Consequence & remedy
Consequence: WHEN THE BELT WEBBING BECOMES JAMMED IN THE RETRACTOR, THE SEAT BELT MAY BE UNUSABLE.
Remedy: DEALERS WILL INSTALL INSERTS TO THE BELT WEB GUIDE OF EACH LAP BELT RETRACTOR.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02031 · Steering Column Lockup
Opened Nov 15, 2002 · Closed Mar 11, 2004
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (3)
Steering:column
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
PE02054 · Steering Column Lockup
Opened Jul 1, 2002 · Closed Nov 15, 2002
Status: closed (inferred from source dates) · Steering
SEE RESUME IN REPOSITORY.
EA00009 · Front Lap Belt Malfunction
Opened Mar 16, 2000 · Closed Apr 18, 2000
Status: closed (inferred from source dates) · Seat Belts
ODI OPENED THIS EA00-009 ON MARCH 16, 2000, TO CONTINUE ANALYSES BEGUN UNDER PRELIMINARY EVALUATION PE99-076.THE ALLEGED DEFECT: LAP BELT WEBBING IN BOTH SEATING POSITIONS TENDS TO FOLD OVER WHILE ENTERING THE RETRACTOR OPENING.THESE FOLDS FREQUENTLY IMPEDE PROPER WEBBING RETRACTION.IF THE RETRACTOR HAS BEEN INADVERTENTLY TOGGLED INTO AUTOMATIC LOCK RETRACTOR (ALR) MODE BY BEING EXTENDED TO ITS FULL LENGTH, IT MAY FAIL TO RESET ITSELF TO THE NORMAL EMERGENCY LOCK RETRACTOR (ELR) MODE.SUCH A CONDITION HAS BEEN SHOWN TO RENDER THE ACTIVE RESTRAINT UNUSABLE.CONCLUSION: GM WILL REMEDY THE ALLEGED DEFECT IN 71,569 SUBJECT VEHICLES BUILT PRIOR TO AUGUST 1999 BY ADDING WEBBING GUIDE INSERTS TO THE LAP RETRACTOR OPENINGS OF BOTH SEATING POSITIONS TO PREVENT THE ADMISSION OF FOLDED WEBBING ONTO THE RETRACTOR SPOOL.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.