NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
277 reports16,000 miles · Jan 20, 2005
Electrical System
1. FUEL GAUGE DROPS TO EMPTY WHEN I HAVE AROUND 1/2 A TANK, LOW FUEL LIGHT COMES ON. HAVE TO PUT GAS IN TO MAKE LIGHT GO OUT. I HAVE TO USE ODOMETER TO KEEP TRACK OF HOW FUEL I HAVE USED AND HOW FAR CAN I GO, BECAUSE THIS WILL HAPPEN AT ANY TIME. THIS HAPPENS ALL THE TIME, EVERY TIME. 2. TURN SIGNALS QUIT WORKING AT ANY TIME …
Read full complaint
1. FUEL GAUGE DROPS TO EMPTY WHEN I HAVE AROUND 1/2 A TANK, LOW FUEL LIGHT COMES ON. HAVE TO PUT GAS IN TO MAKE LIGHT GO OUT. I HAVE TO USE ODOMETER TO KEEP TRACK OF HOW FUEL I HAVE USED AND HOW FAR CAN I GO, BECAUSE THIS WILL HAPPEN AT ANY TIME. THIS HAPPENS ALL THE TIME, EVERY TIME. 2. TURN SIGNALS QUIT WORKING AT ANY TIME THEY PLEASE. I HAVE TO PUT THE 4-WAYS ON FOR ABOUT 5 SECONDS AND THEN OFF TO MAKE THE SIGNALS WORK AGAIN. *JB
NHTSA ODI #10107611
29,300 miles · Jan 10, 2005
Electrical System
ERATIC FUEL READINGS, RIGHT REAR TIRE SENSOR KEEPS GOING OUT THIS WAS REPLACED ONCE ALREADY. ENGINE HAS KNOCKING NOISE INJECTORS WERE CLEANED DID NOT HELP. WIND NOISE FROM LEFT WINDOW. FRONT RIGHT HEADLAMP MOTOR STOPPED WORKING HAD TO REPLACE. HUD GOES OUT ON HOT DAYS. CAR HAS ON 2 OCCASSIONS HAS STOPPED ACCELERATING CAR HAS TO …
Read full complaint
ERATIC FUEL READINGS, RIGHT REAR TIRE SENSOR KEEPS GOING OUT THIS WAS REPLACED ONCE ALREADY. ENGINE HAS KNOCKING NOISE INJECTORS WERE CLEANED DID NOT HELP. WIND NOISE FROM LEFT WINDOW. FRONT RIGHT HEADLAMP MOTOR STOPPED WORKING HAD TO REPLACE. HUD GOES OUT ON HOT DAYS. CAR HAS ON 2 OCCASSIONS HAS STOPPED ACCELERATING CAR HAS TO BE CUT OFF AND RESTARTED TO SOLVE PROBLEM. THIS VEHICLE HAS HAD MANY PROBLEMS MAINLY ELECTRICAL. *AK
NHTSA ODI #10106038
20,810 miles · Dec 14, 2004
Steering
C5 CORVETTES HAVE A PROBLEM WITH THE STEERING COLUMN LOCK MALFUNCTIONING AND LEAVING OWNERS STRANDED OR LOCKING THE STEERING WHEEL WHILE DRIVING. I AM ONE OF SEVERAL OWNERS AFFECTED BY THESE PROBLEMS. I'VE HAD THE STEERING COLUMN LOCK WHILE MAKING A SLOW TURN IN A RESIDENTIAL AREA, FORTUNATELY NOT RESULTING IN AN ACCIDENT, AN…
Read full complaint
C5 CORVETTES HAVE A PROBLEM WITH THE STEERING COLUMN LOCK MALFUNCTIONING AND LEAVING OWNERS STRANDED OR LOCKING THE STEERING WHEEL WHILE DRIVING. I AM ONE OF SEVERAL OWNERS AFFECTED BY THESE PROBLEMS. I'VE HAD THE STEERING COLUMN LOCK WHILE MAKING A SLOW TURN IN A RESIDENTIAL AREA, FORTUNATELY NOT RESULTING IN AN ACCIDENT, AND WAS LEFT STRANDED WHEN THE CAR REFUSED TO START BECAUSE OF A COLUMN LOCK MALFUNCTION. GM ISSUED A RECALL TO FIX THE PROBLEM AND I HAD THE RECALL PERFORMED ON MY CAR. HOWEVER, I CONTINUE TO EXPERIENCE STEERING COLUMN MALUFUNCTIONS. MOST RECENTLY THIS WEEK, MY CAR FAILED TO START AFTER DISPLAYING ERROR MESSAGES ON THE SAME STEERING LOCK MALFUNCTION. WAS ABLE TO GET THE CAR TO THE SAME DEALERSHIP WHICH PERFORMED THE RECALL, BUT THEY WERE UNABLE TO FIND A PROBLEM AFTER RUNNING THE DIAGNOSTICS. A SECOND DEALERSHIP ENCOUNTERED THE SAME RESULT. HOWEVER, I CONTINUE TO HAVE INTERMITTENT PROBLEMS.*AK
NHTSA ODI #10102968
21,911 miles · Nov 27, 2004
Engine And Engine CoolingSteering
STEERING COLUMN LOCKED WHILE CAR WAS IN MOTION AT APPROX 15 MPH. THE PROBLEM TURNED OUT TO BE A KNOWN ISSUE AND WAS REPAIRED BY GM UNDER RECALL BY COLONIAL CHEVROLET-BUICK, INC. OF TALLADEGA ALABAMA. DAYS LATER THE SAME THING HAPPENED AGAIN, COLUMN LOCKING WHILE IN MOTION, EVEN THOUGH GM SAID THE RECALL WOULD PREVENT THIS DANGER…
Read full complaint
STEERING COLUMN LOCKED WHILE CAR WAS IN MOTION AT APPROX 15 MPH. THE PROBLEM TURNED OUT TO BE A KNOWN ISSUE AND WAS REPAIRED BY GM UNDER RECALL BY COLONIAL CHEVROLET-BUICK, INC. OF TALLADEGA ALABAMA. DAYS LATER THE SAME THING HAPPENED AGAIN, COLUMN LOCKING WHILE IN MOTION, EVEN THOUGH GM SAID THE RECALL WOULD PREVENT THIS DANGEROUS MALFUNCTION FROM HAPPENING AGAIN. FURTHERMORE IN THE PROCESS OF PERFORMING THE RECALL SERVICE, COLONIAL CHEVROLET-BUICK, INC. DAMAGED AND REPLACED THE CAR'S RADIATOR. UPON FURTHER INSPECTION I FOUND THAT THE RADIATOR WAS NOT REINSTALLED PROPERLY AND ITS HOUSING IS BROKEN. I AM UNAWARE OF WHAT POSSIBLE DANGERS MAY BE PRESENT DUE TO THE IMPROPERLY POSITIONED RADIATOR, AND HAVE DISCONTINUED USE OF THE VEHICLE PENDING FURTHER INVESTIGATION IN THIS MATTER AND THE COLUMN LOCKING AGAIN. FOLLOWING SERVICE, THE CAR WAS DRIVEN TO A TIRE SHOP AT COLONIAL'S RECOMMENDATION AND THEN STRAIGHT HOME. THE CAR HAS NOT LEFT THE HOUSE SINCE AS THE SECOND INSTANCE OF THE COLUMN LOCKING AT SPEED OCCURED ON MY HOME'S DRIVEWAY.*AK
NHTSA ODI #10100614
Mileage unknown · Nov 4, 2004
Air BagsSteeringCrashInjury
CONSUMER WAS TRAVELING 75 MPH ON THE HIGHWAY AND THE STEERING WHEEL LOCKED UP. CONSUMER WAS UNABLE TO MAINTAIN CONTROL OF THE VEHICLE, AND IT CRASHED INTO GUARD RAIL AND FLIPPED THREE TIMES, LANDING IN A DITCH. UPON IMPACT, BOTH FRONTAL AIR BAGS DID NOT DEPLOY. DRIVER SUSTAINED HEAD AND NECK INJURIES, AND WAS TRANSPORTED T…
Read full complaint
CONSUMER WAS TRAVELING 75 MPH ON THE HIGHWAY AND THE STEERING WHEEL LOCKED UP. CONSUMER WAS UNABLE TO MAINTAIN CONTROL OF THE VEHICLE, AND IT CRASHED INTO GUARD RAIL AND FLIPPED THREE TIMES, LANDING IN A DITCH. UPON IMPACT, BOTH FRONTAL AIR BAGS DID NOT DEPLOY. DRIVER SUSTAINED HEAD AND NECK INJURIES, AND WAS TRANSPORTED TO A HOSPITAL. VEHICLE WAS TOWED AND TOTALED. *AK
NHTSA ODI #10099452
28,000 miles · Nov 3, 2004
Power TrainSteering
THE CONSUMER FELT THAT THE REMEDY FOR THE AUTOMATIC TRANSMISSION ELECTRONIC COLUMN LOCK 04V060000 RECALL IS MAKING IT EASIER FOR THE VEHICLE TO BE STOLEN. WHEN THE COLUMN LOCK PLATE IS REMOVED ONLY THE TRANSMISSION SHIFTER IS LOCKED. THE SHIFTER CAN BE EASILY UNLOCKED, AND WITHOUT THE ASSISTANCE OF THE STEERING LOCK, THE VE…
Read full complaint
THE CONSUMER FELT THAT THE REMEDY FOR THE AUTOMATIC TRANSMISSION ELECTRONIC COLUMN LOCK 04V060000 RECALL IS MAKING IT EASIER FOR THE VEHICLE TO BE STOLEN. WHEN THE COLUMN LOCK PLATE IS REMOVED ONLY THE TRANSMISSION SHIFTER IS LOCKED. THE SHIFTER CAN BE EASILY UNLOCKED, AND WITHOUT THE ASSISTANCE OF THE STEERING LOCK, THE VEHICLE WASN'T SECURED FROM THEFT. THE VEHICLE WOULD LIKE A NEW REMEDY FOUND TO CORRECT THIS FAILURE WITHOUT DEACTIVATING THE ELECTRONIC COLUMN LOCK SYSTEM. *AK *SC
NHTSA ODI #10094600
47,575 miles · Nov 1, 2004
Steering
04 V 060 000/ELECTRONIC COLUMN LOCK: VEHICLE WAS TAKEN TO THE DEALER ON THREE SEPARATE OCCASIONS BECAUSE OF A PROBLEM WITH THE STEERING COLUMN LOCKING UP WHILE STARTING THE VEHICLE. PLEASE PROVIDE DEALER INFORMATION.
NHTSA ODI #10099150
60,890 miles · Nov 1, 2004
Steering
HAVE 2000 CORVETTE W/ MANUAL TRANSMISSION SUBJECT TO RECALL 04V060000. HAD 04V060000 RECALL DONE AT MAROONE CHEVROLET IN 8/04. ELECTRONIC STEERING COLUMN LOCK LOCKED UP 10/29/2004 WHILE GOING ABOUT 5 MILES AN HOUR IN REVERSE AFTER HAVING THE RECALL PERFORMED THAT WAS SUPPOSED TO REMEDY THE PROBLEM. CAR HAD A PREVIOUS RECALL PER…
Read full complaint
HAVE 2000 CORVETTE W/ MANUAL TRANSMISSION SUBJECT TO RECALL 04V060000. HAD 04V060000 RECALL DONE AT MAROONE CHEVROLET IN 8/04. ELECTRONIC STEERING COLUMN LOCK LOCKED UP 10/29/2004 WHILE GOING ABOUT 5 MILES AN HOUR IN REVERSE AFTER HAVING THE RECALL PERFORMED THAT WAS SUPPOSED TO REMEDY THE PROBLEM. CAR HAD A PREVIOUS RECALL PERFORMED 3X IN 2002 FOR THE EXACT SAME PROBLEM WHICH NEVER REMEDIED THE SAFETY ISSUE BECAUSE IT KEPT HAPPENING. THE STEERING WHEEL OBVIOUSLY CAN LOCK UP WHILE THE VEHICLE IS IN MOTION RENDERING A HAZARDOUS CONDITION WHICH GM HAS FAILED TO ADEQUATELY ADDRESS IN EITHER OF THEIR RECALL ATTEMPTS. THEY NEED TO BE COMPELLED TO PROVIDE AN ADEQUATE FIX THAT ACTUALLY SOLVES THE PROBLEM!*AK *JB
NHTSA ODI #10098133
Mileage unknown · Oct 13, 2004
Seats
I HAVE 22,000 MILES ON MY 200 CORVETTE. THE PASSENGER SIDE SEAT IS LOOSE AND MOVES WHEN I DRIVE. THE DEALER IS SAYING THAT I HAVHE TO REPLACE THE ENTIRE ADJUSTER FOR AROUND $1000.*AK
NHTSA ODI #10095698
5,000 miles · Oct 4, 2004
Fuel System, Other
WHEN DRIVING FOR ABOUT AN HOUR THE ALARM WENT OFF, AND FUEL GAUGE DROPPED TO ZERO, AS IF THE VEHICLE DID NOT HAVE GAS IN IT. IT HAPPENED INTERMITTENTLY. HOWEVER, CONSUMER CONSULTED WITH CHRYSLER. THEY STATED THAT IT WAS NOT A SAFETY DEFECT, AND THAT NOTHING WOULD BE DONE ABOUT IT. HOWEVER, THE PROBLEM CONTINUED. *AK
NHTSA ODI #10094965
NHTSA investigations
3EA02031 · Steering Column Lockup
Opened Nov 15, 2002 · Closed Mar 11, 2004
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (3)
Steering:column
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
PE02054 · Steering Column Lockup
Opened Jul 1, 2002 · Closed Nov 15, 2002
Status: closed (inferred from source dates) · Steering
SEE RESUME IN REPOSITORY.
EA00009 · Front Lap Belt Malfunction
Opened Mar 16, 2000 · Closed Apr 18, 2000
Status: closed (inferred from source dates) · Seat Belts
ODI OPENED THIS EA00-009 ON MARCH 16, 2000, TO CONTINUE ANALYSES BEGUN UNDER PRELIMINARY EVALUATION PE99-076.THE ALLEGED DEFECT: LAP BELT WEBBING IN BOTH SEATING POSITIONS TENDS TO FOLD OVER WHILE ENTERING THE RETRACTOR OPENING.THESE FOLDS FREQUENTLY IMPEDE PROPER WEBBING RETRACTION.IF THE RETRACTOR HAS BEEN INADVERTENTLY TOGGLED INTO AUTOMATIC LOCK RETRACTOR (ALR) MODE BY BEING EXTENDED TO ITS FULL LENGTH, IT MAY FAIL TO RESET ITSELF TO THE NORMAL EMERGENCY LOCK RETRACTOR (ELR) MODE.SUCH A CONDITION HAS BEEN SHOWN TO RENDER THE ACTIVE RESTRAINT UNUSABLE.CONCLUSION: GM WILL REMEDY THE ALLEGED DEFECT IN 71,569 SUBJECT VEHICLES BUILT PRIOR TO AUGUST 1999 BY ADDING WEBBING GUIDE INSERTS TO THE LAP RETRACTOR OPENINGS OF BOTH SEATING POSITIONS TO PREVENT THE ADMISSION OF FOLDED WEBBING ONTO THE RETRACTOR SPOOL.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
Illustration