2005 Chevrolet Colorado

TRAVELLING I-270 IN DUBLIN, OHIO AROUND 2PM AT APPROXIMATELY 70MPH WHEN TRUCK ENGINE DIED. THE EMERGENCY FLASHERS AND RADIO WERE STILL OPERATIONAL. PULLED TO RIGHT SIDE OF HIGHWAY AND ATTEMPTED TO STOP. THE BRAKES WERE LOSING POWER, BUT THERE WAS ENOUGH TO SLOW AND THEN STOP. DASH INDICATED 'REDUCED POWER'. UPON PULLING OFF ROAD, WIFE CONTACTED AAA, WHILE I LOOKED UNDER HOOD FOR ANYTHING OBVIOUS SUCH AS BATTERY TERMINALS LOOSE OR ANY PLUGS BEING UNPLUGGED. NOTHING APPEARED OUT OF ORDER, I GOT BACK INTO TRUCK AND IT STARTED. I TOLD WIFE TO TELL AAA WE WOULD ATTEMPT TO MAKE IT HOME, APPROXIMATELY 2 HOURS AWAY. THROUGH THIS ALL, THE TRUCK HAD STOPPED RUNNING 6 MORE TIMES BEFORE WE GOT HOME. IT RESTARTED AFTER SITTING A FEW MINUTES EACH TIME.TRUCK WAS TOWED TO LOCAL CHEVY DEALERSHIP. AFTER A FEW DAYS, RECEIVED CALL TRUCK WAS REPAIRED. THE PCM (POWER CONTROL MODULE) WAS REPLACED. WHEN I GOT INTO VEHICLE THERE WAS A SHEET OF PAPER ON TRANSMISSION HUMP EXPLAINING WHAT A REFURBISHED PART IS (NHTSA DOC#2). I GLANCED AT IT AND THOUGHT IT WAS MISTAKE SINCE I WAS CHARGED $500 FOR THE PART ALONE. TOTAL COST WAS $772.36 (NHTSA DOC#1). WHEN I GOT HOME I REVIEWED THE PAPERWORK, SAW THEY HAD INSTALLED A USED PART AND IMMEDIATELY CALLED. THEY SAID A NEW PART WAS NOT AVAILABLE. I CONTACTED GENERAL MOTORS (NHTSA DOC#4 & NHTSA DOC#5) AND THEY WERE NO HELP. I ALSO CONTACTED AC DELCO AND THEY CONFIRMED THE PART WAS NOT AVAILABLE AS NEW. I THOUGHT MANUFACTURERS WERE REQUIRED TO MAKE PARTS AVAILABLE FOR VEHICLES 10 YEARS AFTER PRODUCTION STOPPED. THE TRUCK IS 10 YEARS OLD, BUT PRODUCTION OF THAT GENERATION STOPPED IN 2012.

TL* THE CONTACT OWNS A 2005 CHEVROLET COLORADO. THE CONTACT STATED THAT WHILE DRIVING AT 50 MPH, THE VEHICLE VEERED OFF THE ROAD AND CRASHED INTO A DITCH. THE ENTIRE FRONT END OF THE VEHICLE WAS DAMAGED. THE AIR BAGS FAILED TO DEPLOY. AS A RESULT, TO THE AIR BAGS NOT DEPLOYING THE CONTACT SUSTAINED NOSE AND LEGS INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 200,000.

TL* THE CONTACT OWNS A 2005 CHEVROLET COLORADO. WHILE DRIVING 70 MPH, THE AIR BAG WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE REAR AIR BAG SENSOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

IN FEBRUARY 2015 MY CHECK ENGINE LIGHT CAME ON. AFTER SEVERAL REPAIRS WITH MY LOCAL MECHANIC HE WAS UNABLE TO FIND THE PROBLEM. I WENT TO GREENWOOD CHEVROLET IN HUBBARD, OH, AND THEY RESET MY COMPUTER. HOWEVER, BEFORE I GOT OUT OF THE AUTO LOT, THE CHECK ENGINE LIGHT REAPPEARED. I RETURNED TO THE SERVICE DEPARTMENT AND THEY THEN DIAGNOSED A BAD CYLINDER HEAD AND VALVES. THE SERVICE MANAGER REPORTED THIS HAS BEEN A PROBLEM WITH THIS PARTICULAR ENGINE AND MY ONLINE RESEARCH REVEALED THAT CHEVROLET RECOGNIZED THIS PROBLEM AND EXTENDED THE WARRANTY COVERAGE TO 7 YEARS AND 100,000 MILES. MY VEHICLE ONLY HAD 87335 MILES, BUT HAD BEEN IN SERVICE FOR 9 YEARS, 7 MONTHS. I FELT CHEVROLET SHOULD HAVE COVERED MY REPAIRS UNDER THE 100,000 MILES EXTENSION EVEN THOUGH I WAS OVER THE 7 YEARS. MY REASONING IS THAT CHEVROLET WAS AWARE OF THIS PROBLEM WITH THIS PARTICULAR ENGINE AS EVIDENCED BY CHEVROLET'S SERVICE BULLETIN #07123A. I CONTACTED THE PRESIDENT AND CEO OF GENERAL MOTORS AND PROVIDED THEM WITH ALL MY SERVICE RECORDS TO OFFER PROOF OF MAINTENANCE DURING MY OWNERSHIP. I HEARD NOTHING FROM THEM. I AM FILING THIS COMPLAINT BECAUSE I FELT GM SHOULD HAVE COVERED THE REPAIRS BECAUSE OF THE MILEAGE OF MY VEHICLE AND THE CARE I HAD DONE TO IT. IT COST ME OVER $2000 TO HAVE THIS VEHICLE REPAIRED.

SEPT OF 2014 OUR CHEVROLET COLORADO HAD ISSUES WITH NOT STARTING. THE DEALER DIAGNOSED IT AS "CODE ISSUES" AND REPLACED A SAFETY SENSOR. THE ISSUE WAS NEVER RESOLVED AS CHECK ENGINE LIGHT STAYED ON. OCT OF 2015 WHILE DRIVING, THE AIRBAG LIGHT CAME ON AND NEVER WENT OFF. ALSO OCT 2015, ABOUT THE TIME THE AIRBAG LIGHT CAME ON, WE RECEIVED A LETTER STATING THAT A WIRE HARNESS IN THIS MAKE, MODEL AND YEAR OF VEHICLE COULD CAUSE CODE PROBLEMS AND OR THE AIRBAG LIGHT TO ILLUMINATE, AND THAT GM WOULD FIX IT AT NO COST TO US, IF THE VEHICLE WAS WITHIN 10 YRS OLD OR HAD 120,000 OR LESS MILES. LAST YEAR WHEN THIS STARTED OUR VEHICLE WAS 9 YRS OLD, YET GM WILL NOT PAY FOR IT SAYING IT'S NOT A SAFETY HAZARD. I COMPLETELY DISAGREE AS THE LIGHT STAYS ON ALL THE TIME, HOW AM I SUPPOSE TO KNOW IF IT'S REALLY NOT AIRBAG FAILURE AS OPPOSED TO THE FAULTY WIRE AND HARNESS? THIS LETTER WAS DATED OCT 2015 YET GM IS SAYING THE OFFER ON THIS EXPIRED OCT 29 2014 YET WE DIDN'T RECEIVE A LETTER UNTIL 2015

TL* THE CONTACT OWNS A 2005 CHEVROLET COLORADO. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH, THE AIR BAG WARNING LIGHT ILLUMINATED. THE FAILURE OCCURRED CONSTANTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE CAMSHAFT SENSOR AND THE CRANKSHAFT SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.

THE BLOWER MOTOR RESISTOR AND THE WIRING IS BROKEN FOR THE THIRD TIME. THIS TIME THERE WERE BURN MARKS ON THE WIRES WHICH WORRIES ME ABOUT A POSSIBLE FIRE IN MY DASHBOARD. THIS OCCURS WHILE THE VEHICLE IS ON. THIS OVERHEATING/BURNING OF THE RESISTOR AND WIRES CAUSES THE BLOWER MOTOR TO NOT BLOW AIR WHICH IN PHOENIX, AZ IS A MUST DUE TO SEVERE HOT WEATHER.

A/C & HEATER CONTROLS NOT WORKING. 1ST TIME TOOK PICK-UP IN AND WAS FIXED UNDER WARRANTY AT HUDIBURG CHEVEROLET IN OKLAHOMA CITY, OK. THE SAME THING WAS HAPPENING AGAIN AROUND 1 1/2 YEARS LATER TOOK BACK TO HUDIBURGS AGAIN AND THEY REFUSED TO FIX IT BECAUSE IT WAS OUT OF WARRANTY. A COUPLE OF WEEKS LATER IT BEGAN TO WORK FOR A LITTLE WHILE THEN STOPPED WORKING ALTOGETHER.

THIS TRUCK HAS A RECURRING PROBLEM WHERE THE REAR BRAKES FREEZE INTO POSITION WHEN THE EMERGENCY (PARKING) BRAKE IS APPLIED. HAS BEEN HAPPENING FOR 10 YEARS SINCE I BOUGHT THE TRUCK NEW. IF THE EMERGENCY BRAKE IS SET, THE REAR BRAKES WILL NOT RELEASE WHEN THE LEVER IS RELEASED BY THE DRIVER. I AM STUCK WHERE I PARKED WITH A SET OF FROZEN REAR BRAKES. IN ORDER TO GET HOME I AM FORCED TO DRIVE WITH THE REAR BRAKES ENGAGED CAUSING A SEVERE OVERHEATING CONDITION IN THE REAR WHEELS AND POTENTIAL FOR A BRAKE FIRE NEAR THE GAS TANK. GM SAID THERE WAS NOT A PROBLEM AND REFUSED TO FIX THIS PROBLEM UNDER WARRANTY. IT IS STILL A PROBLEM AND GM STILL REFUSES TO FIX THIS PROLEM EVEN THOUGH THERE ARE THOUSANDS OF DRIVERS WITH THIS "FREEZING REAR BRAKES" ISSUE. MY WORK AROUND? I DON'T USE THE PARKING BRAKE. I HAVE A STICK SHIFT AND THE ENGINE COMPRESSION ALONE WILL NOT HOLD THE TRUCK IN PLACE ON A SLOPED DRIVEWAY, SO I HAVE TO CARRY A BLOCK OF WOOD TO PLACE BEHIND THE WHEELS AS MY "PARKING BRAKE". GM NEEDS TO RECALL CHEVY COLORADO TRUCKS FOR THIS SYSTEMIC FAILURE IN THE REAR BRAKE SYSTEMS.

THE AC FAN ONLY WORKS ON HIGH (4). THE AC FAN SWITCH HAS A KNOWN DEFECT IN THE RESISTOR SWITCH FOR THE FAN. THIS CAN CAUSE THE WIRING TO OVERHEAT AND START A FIRE. GM HAS ALREADY RECALLED THE HUMMER H3 FOR THE SAME PROBLEM. THE RECALL SHOULD BE EXTENDED TO THE 1ST GENERATION CHEVY COLORADO BECAUSE IT HAS THE SAME FAN SWITCH RESISTOR.