IllustrationVehicle taillights failed to function when lights come on at night. I became aware of this when another motorist stopped beside me to tell me. Fuse and lightbulbs work when tested.
2005 Chevrolet Colorado
Owner reports · Recalls · Investigations
More warning signs than most Colorado years
Owner complaints for the 2005 Chevrolet Colorado are substantially higher than the model-year median of 84.
About this comparison →How this year compares
Owner complaints by model year
Compare all Colorado years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
760–25K
6425–50K
5550–75K
4575–100K
26100–150K
22150K+
288 reports with mileage · 68 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 69 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
27 crash reports11 fire reports16 injury reports
Electrical System complaints
69 reportsAIR BAG LIGHT COMES ON MAKING IT UNCLEAR IF OCCUPANTS ARE PROTECTED OR IF AIR BAG WILL JUST GO OFF ON ITS OWN. PROBLEM IS WIRES IN BACK DOOR JAMB BECOME FATIGUED AND BREAK CAUSING FAILURE OF AIR BAGS. VEHICLE IS ALSO CONSIDERED AN INSPECTION FAILURE AS WELL IN MASSACHUSETTS.
I'VE TRIED TO HAVE A GARAGE REPAIR/FIX MY HEATER/FAN MOTOR THREE TIMES TO NO AVAIL. HEATER WORKS ON HIGH ONLY...AND NOT ON ANY OTHER SPEEDS.
IGNITINION SWITCH TRIGGERS ANTI-THEFT SECURE ON TRUCK SO IT WOULD NOT START I WAIT FOR 10 MINUTES THEN IT STARTS, DEALERSHIP COULD NOT TELL ME A FEW YEARS AGO WHEN I TOOK IT, AND MECHANICS TELL ME ITS A DEFECTED IGNITION SWITCH BUT ONLY DEALER CAN FIX IT, ITS A RECALL THING FROM WHAT MECHANICS ARE TELLING ME. ITS A SHAME MECHANI…
Read full complaint
IGNITINION SWITCH TRIGGERS ANTI-THEFT SECURE ON TRUCK SO IT WOULD NOT START I WAIT FOR 10 MINUTES THEN IT STARTS, DEALERSHIP COULD NOT TELL ME A FEW YEARS AGO WHEN I TOOK IT, AND MECHANICS TELL ME ITS A DEFECTED IGNITION SWITCH BUT ONLY DEALER CAN FIX IT, ITS A RECALL THING FROM WHAT MECHANICS ARE TELLING ME. ITS A SHAME MECHANICS OUTSIDE THE DEALERSHIP KNOW MORE THEN DEALERSHIP ON WHAT IT IS BEEN RECALL.
WIRING FOR TURNSIGNALS MELTS DOWN. THERE IS A WIRE HARNESS WITH A CONNECTOR AT THE TURN FRONT SIGNALS, THE WIRE GAUGE IS IN ADEQAUTE AND CAUSEA EXCESSIVE HEAT BUILD-UP THIS CAUSES THE WIRES AND CONNECTORS TO THE FRONT TURN SIGNALS TO MELT DOWN AND THE TURN SIGNALS BECOME INOPERABLE. I HAVE REPLACED THESE COMPONENTS TWICE DUE TO …
Read full complaint
WIRING FOR TURNSIGNALS MELTS DOWN. THERE IS A WIRE HARNESS WITH A CONNECTOR AT THE TURN FRONT SIGNALS, THE WIRE GAUGE IS IN ADEQAUTE AND CAUSEA EXCESSIVE HEAT BUILD-UP THIS CAUSES THE WIRES AND CONNECTORS TO THE FRONT TURN SIGNALS TO MELT DOWN AND THE TURN SIGNALS BECOME INOPERABLE. I HAVE REPLACED THESE COMPONENTS TWICE DUE TO THIA ISSUE. THE RESISTOR PACK FOR AIR CONDITIONING BLOWER FAN SPEED CONTROL MELTS AND CATCHES FIRE. I HAVE REPLACED THIS PART TWICE AND ULTIMATELY HAVE BYPASSED THE RESISTOR PACK LEAVING THE AC BLOWER WITH ONLY THE CHOICE OF HIGH SPEED OR OFF.
I AM EXPERIENCING AN INTERMITTENT ISSUE WHERE THE PASSLOCK SYSTEM FAILS WHEN ATTEMPTING TO START THE VEHICLE AND I HAVE TO WAIT 15 MINUTES FOR IT TO TIME OUT. THERE ARE FORUMS WITH THIS MODEL OF TRUCK THAT STATE THIS IS A COMMON PROBLEM BUT I HAVE FOUND NO RECALL ON IT. I HAVE FOUND THAT THE IGNITION AND BODY CONTROL MODULES …
Read full complaint
I AM EXPERIENCING AN INTERMITTENT ISSUE WHERE THE PASSLOCK SYSTEM FAILS WHEN ATTEMPTING TO START THE VEHICLE AND I HAVE TO WAIT 15 MINUTES FOR IT TO TIME OUT. THERE ARE FORUMS WITH THIS MODEL OF TRUCK THAT STATE THIS IS A COMMON PROBLEM BUT I HAVE FOUND NO RECALL ON IT. I HAVE FOUND THAT THE IGNITION AND BODY CONTROL MODULES WERE TO BLAME AND CURRENTLY DEALERS ARE CHARGING UPWARD OF $1100 TO REPAIR. THIS SHOULD BE A RECALL ISSUE DUE TO THE WIDESPREAD PROBLEM AND THAT IT IS A KNOWN DEFECT SPECIFIC TO THIS MODEL OF TRUCK.
HELLO, I JUST PURCHASED A USED VEHICLE AND IT HAS THE SAME PASSCODE PROBLEM THAT MY 2000 EXPRESS VAN HAS. THIS IS A SUBSTANTIAL PROBLEM AND GM IS NOT OWNING UP TO THE PROBLEM AND SHOULD HAVE A FIX FOR IT. HOW LONG ARE YOU GOING TO IGNORE THAT ''TIS IS A SERIOUS PROBLEM AND IN AN EMERGENCY SITUATION HAVING TO WAIT 10 MIN. COULD…
Read full complaint
HELLO, I JUST PURCHASED A USED VEHICLE AND IT HAS THE SAME PASSCODE PROBLEM THAT MY 2000 EXPRESS VAN HAS. THIS IS A SUBSTANTIAL PROBLEM AND GM IS NOT OWNING UP TO THE PROBLEM AND SHOULD HAVE A FIX FOR IT. HOW LONG ARE YOU GOING TO IGNORE THAT ''TIS IS A SERIOUS PROBLEM AND IN AN EMERGENCY SITUATION HAVING TO WAIT 10 MIN. COULD BE LIFE THREATENING. ALL I WANT IS THE 05 COLORADO TO WORK, I'LL BE SELLING THE VAN AND PASSING THE PROBLEM TO SOMEONE ELSE. TIME TO STAND BEHIND YOUR VEHICLES, THIS WILL BE MY LAST GM VEHICLE IF YOU WON'T FIX IT. AFTER 30 YEARS OF LOYALTY YOU SHOULD HAVE MY BACK
MY CRUISE CONTROL STOPPED WORKING AND THEN MY BREAK LIGHTS. PUT IN NEW BREAK BULBS AND THEY STILL DO NOT WORK! I WAS DRI ING WHEN CRUISE CONTROL WENT OUT AND MY HUSBAND NOTICED MY BREAKS WHILE I WAS DRIVING.
AT DIFFERENT TIMES TURN SIGNALS, BRIGHTS, BRAKE LIGHTS WILL QUIT WORKING AND DASH LIGHT INDICATOR THAT AIR BAG IS NOT WORKING WILL ILLUMINATE. THIS CAN HAPPEN WHILE DRIVING OR WHEN FIRST STARTING UP. AT TIMES YOU CAN PUSH STALK UP FOR A RIGHT HAND TURN AND LEFT TURN SIGNAL INDICATOR WILL LIGHT UP AND BLINK. IF YOU PUSH THE STALK…
Read full complaint
AT DIFFERENT TIMES TURN SIGNALS, BRIGHTS, BRAKE LIGHTS WILL QUIT WORKING AND DASH LIGHT INDICATOR THAT AIR BAG IS NOT WORKING WILL ILLUMINATE. THIS CAN HAPPEN WHILE DRIVING OR WHEN FIRST STARTING UP. AT TIMES YOU CAN PUSH STALK UP FOR A RIGHT HAND TURN AND LEFT TURN SIGNAL INDICATOR WILL LIGHT UP AND BLINK. IF YOU PUSH THE STALK DOWN FOR A LEFT TURN SIGNAL NOTHING WILL HAPPEN.
THE BLOWER MOTOR RESISTOR AND THE WIRING IS BROKEN FOR THE THIRD TIME. THIS TIME THERE WERE BURN MARKS ON THE WIRES WHICH WORRIES ME ABOUT A POSSIBLE FIRE IN MY DASHBOARD. THIS OCCURS WHILE THE VEHICLE IS ON. THIS OVERHEATING/BURNING OF THE RESISTOR AND WIRES CAUSES THE BLOWER MOTOR TO NOT BLOW AIR WHICH IN PHOENIX, AZ IS A MUST…
Read full complaint
THE BLOWER MOTOR RESISTOR AND THE WIRING IS BROKEN FOR THE THIRD TIME. THIS TIME THERE WERE BURN MARKS ON THE WIRES WHICH WORRIES ME ABOUT A POSSIBLE FIRE IN MY DASHBOARD. THIS OCCURS WHILE THE VEHICLE IS ON. THIS OVERHEATING/BURNING OF THE RESISTOR AND WIRES CAUSES THE BLOWER MOTOR TO NOT BLOW AIR WHICH IN PHOENIX, AZ IS A MUST DUE TO SEVERE HOT WEATHER.
Official recalls
310V575000 · Child Seat
Nov 18, 2010
GM IS RECALLING CERTAIN MODEL YEAR 2004-2011, CHEVROLET COLORADO, GMC CANYON, MODEL YEAR 2006, ISUZU I-280/I-350, AND MODEL YEAR 2007-2008, I-290/I-370, REGULAR CAB VEHICLES AND EXTENDED CAB VEHICLES WITHOUT A REAR SEAT AND EQUIPPED WITH A FRONT 60/40 SPLIT BENCH SEAT. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT IS NOT ACCESSIBLE AND THE OWNER MANUAL DOES NOT INCLUDE INSTRUCTIONS REGARDING HOW TO USE THE TOP TETHER.
Consequence & remedy
Consequence: BOTH NHTSA AND GM DISCOURAGE PLACEMENT OF A CHILD IN A FRONT SEAT. NEVERTHELESS, THERE ARE INDIVIDUAL CIRCUMSTANCES THAT MAY REQUIRE PLACEMENT OF A CHILD IN A RESTRAINT IN THE FRONT CENTER SEATING POSITION OF THIS VEHICLE THAT DOES NOT OFFER A REAR SEAT. LACK OF ACCESS TO THE TOP TETHER ANCHOR AND A LACK OF INSTRUCTIONS AS TO HOW TO USE IT, MAY RESULT IN IMPROPER INSTALLATION OF A CHILD RESTRAINT. IMPROPER INSTALLATION OF A CHILD RESTRAINT CAN RESULT IN A REDUCTION IN THE RESTRAINT'S PERFORMANCE IN THE EVENT OF A CRASH AND AN INCREASED RISK OF INJURY OR DEATH TO THE CHILD SEATED IN THE RESTRAINT.
Remedy: DEALERS WILL CUT A HOLE INTO THE BACK PANEL TRIM COVER TO ALLOW ACCESS TO THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT POSITION AND WILL PROVIDE SUPPLEMENTAL INFORMATION AS TO USE IN THE OWNER'S MANUAL. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR VISIT GM'S WEBSITE AT WWW.GMOWNERCENTER.COM.
09V310000 · Exterior Lighting:brake Lights:switch
Jul 29, 2009
GM IS RECALLING 185,903 MODEL YEAR 2004-2009 COLORADO, GMC MODEL YEAR 2009-2004 CANYON, MODEL YEAR 2006 I-280, I-350, MODEL YEAR 2007-2008 I-290, AND I-370, PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALABAMA, ARIZONA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, PUERTO RICO, SOUTH CAROLINA, TEXAS, U.S. VIRGIN ISLANDS AND UTAH. SOME OF THESE VEHICLES HAVE A BRAKE LAMP SWITCH THAT MAY NOT WORK AS DESIGNED DUE TO CONTAMINATION IN THE SWITCH.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE THE SIMULTANEOUS LOSS OF ALL BRAKE LAMPS OR CAUSE ALL OF THE BRAKE LAMPS TO STAY ON CONTINUOUSLY. BOTH OF THESE CONDITIONS COULD FAIL TO WARN OTHERS OF THE DRIVER'S INTENTIONS AND COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS AS SPECIFIED IN THE RECALL BULLETIN FREE OF CHARGE. GM ANTICIPATES THAT PARTS WILL BE AVAILABLE BY JUNE 2010. A SPECIAL COVERAGE FOR VEHICLES REGISTERED IN ALL OTHER STATES WILL BE IMPLEMENTED IN THE SAME TIME FRAME. IN THE INTERIM, OWNERS WHO EXPERIENCE THE FAILURE CAN OBTAIN A FREE REPAIR, HOWEVER THEY WILL BE REQUIRED TO RETURN WHEN THE NEW DESIGN PART BECOMES AVAILABLE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR AT WWW.GMOWNERCENTER.COM.
06V139000 · Exterior Lighting:brake Lights:switch
Apr 27, 2006
CERTAIN PICKUP TRUCKS MAY EXPERIENCE THE PERMANENT LOSS OF BRAKE LAMP FUNCTION OR BRAKE LAMPS THAT ARE ILLUMINATED AT ALL TIMES. THE CENTER HIGH-MOUNTED STOP LAMP (CHMSL) IS AFFECTED IN BOTH INSTANCES. ALSO, IF EQUIPPED, THE CRUISE CONTROL WILL BECOME INOPERATIVE. ANY TRAILER BRAKE LAMPS WHICH ARE CONNECTED TO THE VEHICLE'S BRAKE LAMP WIRING WILL MIMIC THE VEHICLE'S BRAKE LAMPS WHEN EITHER CONDITION OCCURS.
Consequence & remedy
Consequence: A FOLLOWING DRIVER MAY NOT KNOW WHEN THE BRAKES HAVE BEEN APPLIED, AND A REAR-END CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE BRAKE LAMP SWITCH ASSEMBLY. THE RECALL BEGAN ON DECEMBER 5, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463 OR ISUZU AT 1-800-255-6727.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ09001 · Brake Lamp Switch Malfunction
Opened Feb 25, 2009 · Closed Jul 30, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights:switch
ON JULY 28,2009, GM INITIATED A REGIONAL RECALL CAMPAIGN ON CERTAIN MODEL YEAR (MY) 2004-2009 CHEVROLET COLORADO AND GMC CANYON VEHICLES AND MY2006-2008 ISUZU I-SERIES VEHICLES.THE STATES AND U.S. TERRITORIES INVOLVED ARE AL, AZ, FL, GA, HI, LA, MS, NV, NM, PR, SC, TX, VI AND UT.A TOTAL OF 185,903 VEHICLES WILL BE RECALLED WITH 92,272 VEHICLES WITHIN THE SCOPE OF THIS INVESTIGATION.IN ADDITION, A SPECIAL COVERAGE/EXTENDED WARRANTY PROGRAM WILL BE INITIATED FORVEHICLES REGISTERED IN ALL OTHER STATES. GM DETERMINED THAT BRAKE LAMP SWITCH FAILURES ARE MORE LIKELY TO OCCUR IN VEHICLES IN WHICH CUSTOMERS USED INTERIOR CLEANERS CONTAINING SILICON AND THAT RESIDE IN HOT GEOGRAPHICAL LOCATIONS.BRAKE LAMP SWITCH CONTAMINATION FAILURE CAN CAUSE LOSS OF THE BRAKE LAMPS OR THE BRAKE LAMPS TO STAY ON CONTINUOUSLY, INCREASING THE RISK OF REAR-END CRASHES.GM HAS REPORTED NO CRASHES OR INJURIES DUE TO THE FAILURE OF THE BRAKE LAMP SWITCH.ODI INITIALLY REPORTED ONE CRASH INCIDENT, BUT LATER DOWNGRADED THE REPORT DUE TO THE ABSENCE OF ACTUAL PROPERTY DAMAGE OR COST INCURRED WHEN THE VEHICLE WAS LIGHTLY TAPPED FROM BEHIND AT LOW SPEED.THIS INVESTIGATION IS CLOSED (SEE RECALL CAMPAIGN 09V0310).
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
ON JULY 28,2009, GM INITIATED A REGIONAL RECALL CAMPAIGN ON CERTAIN MODEL YEAR (MY) 2004-2009 CHEVROLET COLORADO AND GMC CANYON VEHICLES AND MY2006-2008 ISUZU I-SERIES VEHICLES.THE STATES AND U.S. TERRITORIES INVOLVED ARE AL, AZ, FL, GA, HI, LA, MS, NV, NM, PR, SC, TX, VI AND UT.A TOTAL OF 185,903 VEHICLES WILL BE RECALLED WITH 92,272 VEHICLES WITHIN THE SCOPE OF THIS INVESTIGATION.IN ADDITION, A SPECIAL COVERAGE/EXTENDED WARRANTY PROGRAM WILL BE INITIATED FORVEHICLES REGISTERED IN ALL OTHER STATES. GM DETERMINED THAT BRAKE LAMP SWITCH FAILURES ARE MORE LIKELY TO OCCUR IN VEHICLES IN WHICH CUSTOMERS USED INTERIOR CLEANERS CONTAINING SILICON AND THAT RESIDE IN HOT GEOGRAPHICAL LOCATIONS.BRAKE LAMP SWITCH CONTAMINATION FAILURE CAN CAUSE LOSS OF THE BRAKE LAMPS OR THE BRAKE LAMPS TO STAY ON CONTINUOUSLY, INCREASING THE RISK OF REAR-END CRASHES.GM HAS REPORTED NO CRASHES OR INJURIES DUE TO THE FAILURE OF THE BRAKE LAMP SWITCH.ODI INITIALLY REPORTED ONE CRASH INCIDENT, BUT LATER DOWNGRADED THE REPORT DUE TO THE ABSENCE OF ACTUAL PROPERTY DAMAGE OR COST INCURRED WHEN THE VEHICLE WAS LIGHTLY TAPPED FROM BEHIND AT LOW SPEED.THIS INVESTIGATION IS CLOSED (SEE RECALL CAMPAIGN 09V0310).
Exterior Lighting
ON JULY 28,2009, GM INITIATED A REGIONAL RECALL CAMPAIGN ON CERTAIN MODEL YEAR (MY) 2004-2009 CHEVROLET COLORADO AND GMC CANYON VEHICLES AND MY2006-2008 ISUZU I-SERIES VEHICLES.THE STATES AND U.S. TERRITORIES INVOLVED ARE AL, AZ, FL, GA, HI, LA, MS, NV, NM, PR, SC, TX, VI AND UT.A TOTAL OF 185,903 VEHICLES WILL BE RECALLED WITH 92,272 VEHICLES WITHIN THE SCOPE OF THIS INVESTIGATION.IN ADDITION, A SPECIAL COVERAGE/EXTENDED WARRANTY PROGRAM WILL BE INITIATED FORVEHICLES REGISTERED IN ALL OTHER STATES. GM DETERMINED THAT BRAKE LAMP SWITCH FAILURES ARE MORE LIKELY TO OCCUR IN VEHICLES IN WHICH CUSTOMERS USED INTERIOR CLEANERS CONTAINING SILICON AND THAT RESIDE IN HOT GEOGRAPHICAL LOCATIONS.BRAKE LAMP SWITCH CONTAMINATION FAILURE CAN CAUSE LOSS OF THE BRAKE LAMPS OR THE BRAKE LAMPS TO STAY ON CONTINUOUSLY, INCREASING THE RISK OF REAR-END CRASHES.GM HAS REPORTED NO CRASHES OR INJURIES DUE TO THE FAILURE OF THE BRAKE LAMP SWITCH.ODI INITIALLY REPORTED ONE CRASH INCIDENT, BUT LATER DOWNGRADED THE REPORT DUE TO THE ABSENCE OF ACTUAL PROPERTY DAMAGE OR COST INCURRED WHEN THE VEHICLE WAS LIGHTLY TAPPED FROM BEHIND AT LOW SPEED.THIS INVESTIGATION IS CLOSED (SEE RECALL CAMPAIGN 09V0310).
PE05065 · Brake Lamp Switch Failure
Opened Dec 2, 2005 · Closed May 1, 2006
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch
BY LETTER DATED APRIL 26, 2006, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO. 06V139) INVOLVING CERTAIN MODEL YEAR (MY) 2004-06 CHEVROLET COLORADO, GMC CANYON AND 2006 MY ISUZU I280/I350 VEHICLES.GM'S RECALL COVERS 404,733 VEHICLES.GM REPORTS THAT LOSS OF BRAKE LAMP ILLUMINATION WAS CAUSED BY INSUFFICIENT PLATING ON THE STATIONARY CONTACT IN THE BRAKE LAMP SWITCH.GM WILL REPLACE THE BRAKE LAMP SWITCH ASSEMBLY ON ALL INVOLVED VEHICLES WITH THE NEW SWITCH THAT HAS THE INCREASED PLATING ON THE STATIONARY CONTACT.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.