NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
845 reports56,000 miles · Oct 3, 2011
StructureSuspensionInjury
TL* THE CONTACT OWNS A 2008 CHEVROLET COBALT. THE CONTACT STATED THAT HE CUT HIS HAND ON THE FRONT DRIVER SIDE INTERIOR DOOR HANDLE. THE CONTACT NOTICED THAT THE CHROME WAS PEELING OFF FROM BOTH DOOR HANDLES ON THE DRIVER'S SIDE. THE VEHICLE WAS TAKEN TO THE DEALER TO HAVE THE FAILURE REPAIRED. THE CONTACT ALSO STATED THAT THE F…
Read full complaint
TL* THE CONTACT OWNS A 2008 CHEVROLET COBALT. THE CONTACT STATED THAT HE CUT HIS HAND ON THE FRONT DRIVER SIDE INTERIOR DOOR HANDLE. THE CONTACT NOTICED THAT THE CHROME WAS PEELING OFF FROM BOTH DOOR HANDLES ON THE DRIVER'S SIDE. THE VEHICLE WAS TAKEN TO THE DEALER TO HAVE THE FAILURE REPAIRED. THE CONTACT ALSO STATED THAT THE FRONT SWAY BAR END WAS LOOSE BECAUSE IT WAS WORN. THE FAILURE MILEAGE WAS 56,000. UPDATED 11/17/11 *BF UPDATED 11/30/11
NHTSA ODI #10428306
83,000 miles · Sep 25, 2011
Electrical System
MY 2008 CHEVY COBALT LT WON'T TURN OFF THE KEY IS IN THE IGNITION AND WON'T COME OUT OR TURN OFF. I WENT TO THE DEALER SHIP AND THEY SAID THAT THIS IS A COMMON PROBLEM WITH COBALTS PRIOR TO THIS AND IT'S THE CYLINDER IGNITION. THEY SAID THAT IT IS NOT COVERED BY WARRANTY AND IT HASN'T BEEN RECALLED, BUT IF IT HAPPENS SO MUCH WH…
Read full complaint
MY 2008 CHEVY COBALT LT WON'T TURN OFF THE KEY IS IN THE IGNITION AND WON'T COME OUT OR TURN OFF. I WENT TO THE DEALER SHIP AND THEY SAID THAT THIS IS A COMMON PROBLEM WITH COBALTS PRIOR TO THIS AND IT'S THE CYLINDER IGNITION. THEY SAID THAT IT IS NOT COVERED BY WARRANTY AND IT HASN'T BEEN RECALLED, BUT IF IT HAPPENS SO MUCH WHY HAVEN'T THEY DONE ANYTHING ABOUT IT YET. IF PEOPLE ARE HAVING PROBLEMS THEN WHY ISN'T THIS TAKING CARE OF? I DO NOT HAVE 300 PLUS DOLLARS TO PUT INTO MY CAR. TO FIX IT. THEY TOLD ME I COULD DRIVE IT LIKE THAT TIL I COULD FIX IT ALL I HAD TO DO WAS DISCONNECT THE BATTERY TERMINAL UNTIL I WAS READY TO USE THE CAR. WHEN I DID THAT AND WENT TO TURN THE CAR BACK ON BY BATTERY IT SAID ENERGY POWER REDUCED AND MY CAR WON'T EVEN START NOW. WHEN I CALLED TO THEM THIS THEY SAID OH YOUR THROTTLE BODY WENT BAD. BUT THEY WERE THE ONES WHO TOLD ME I COULD DO THIS. NOW I HAVE NO CAR TO DRIVE AND THEY SAID IT WOULD BE 300 PLUS TO FIX THIS PROBLEM AS WELL. SO NOW IM LOOKING AT OVER 600 DOLLARS TO FIX MY CAR WHICH I DO NOT HAVE. *TR
NHTSA ODI #10427083
47,800 miles · Sep 19, 2011
Fuel System, Gasoline
NOTICED A FAINT SMELL OF GAS WHILE DRIVING MY COBALT ON THURSDAY SEPTEMBER 15TH, 2011. GAS SMELL GREW STRONGER LATER IN THE DAY AND, ON FRIDAY, WAS SO STRONG THAT IT WAS OVERPOWERING, EVEN WITH THE WINDOWS ROLLED DOWN. UPON TAKING MY CAR TO THE MECHANIC, THEY FOUND THAT A PLASTIC SUPPLY PORT ON THE MODULAR RESERVOIR OF MY FUEL…
Read full complaint
NOTICED A FAINT SMELL OF GAS WHILE DRIVING MY COBALT ON THURSDAY SEPTEMBER 15TH, 2011. GAS SMELL GREW STRONGER LATER IN THE DAY AND, ON FRIDAY, WAS SO STRONG THAT IT WAS OVERPOWERING, EVEN WITH THE WINDOWS ROLLED DOWN. UPON TAKING MY CAR TO THE MECHANIC, THEY FOUND THAT A PLASTIC SUPPLY PORT ON THE MODULAR RESERVOIR OF MY FUEL PUMP HAD CRACKED AND IT WAS CREATING A SEVERE FUEL LEAK. I HAD TO REPLACE THE FUEL PUMP IN ORDER TO FIX THIS SITUATION, BUT, THREE DAYS LATER, MY CAR STILL HAS AN EXISTING GAS SMELL TO IT. ON FRIDAY WHEN THE INCIDENT OCCURRED, I FELT LIKE I HAD INGESTED GASOLINE ALL DAY, AND IT TOOK A WHILE FOR THAT FEELING TO GO AWAY. IN ADDITION, I KNOW THAT GAS LEAKS ARE POTENTIALLY VERY HAZARDOUS AND CAN START FIRES. IN CONDUCTING RESEARCH, IT SEEMS THAT THIS PROBLEM IS CONSISTENT WITH RECALL ID # 09V419000 DATED 10/29/2009 IN WHICH 2006 AND 2007 YEAR CHEVROLET COBALTS WERE RECALLED FOR THE SAME PROBLEM IN SOME STATES INCLUDING ARIZONA, WHERE MY CAR WAS PURCHASED AND REGISTERED. SERVICE MEMBERS AT A CHEVROLET DEALERSHIP HAVE STATED THAT THIS ISSUE HAS BECOME COMMON WITH MY YEAR COBALTS, SO PERHAPS THE 2008 COBALTS SHOULD BE RECALLED AS WELL? THIS IS A HAZARDOUS PROBLEM THAT HAS TURNED IN TO QUITE AN EXPENSIVE FIX FOR ME, AND I BELIEVE THAT IT NEEDS TO BE TAKEN CARE OF IMMEDIATELY. *KB
NHTSA ODI #10426264
48,000 miles · Sep 9, 2011
Air BagsElectrical SystemEngine And Engine Cooling
MY AIRCONDITION QUITS BLOWING COOL AIR OFF AND ON THE BUTTONS ARE WRONG. ENGINE LIGHT COMES ON AND OFF. THE AIRBAG LIGHT COMES ON AND OFF. *TR
NHTSA ODI #10424419
63,000 miles · Sep 7, 2011
Fuel System, Gasoline
NOTICE A STRONG FUEL SMELL WHEN THE VEHICLE IS TOPPED OFF WITH FUEL. FUEL MILEAGE IS DEGRADED AND FUEL SMELL GOES AWAY WHEN TANK IS BELOW 1/2. CLASS 1 LEAK APPEARS TO COME FROM WHERE FUEL FILLER HOSE ATTACHES TO THE TANK. IT MAY ALSO BE COMING FROM THE FUEL PUMP AND DRIPPING ONTO THAT AREA. *TR
NHTSA ODI #10424163
42,000 miles · Sep 5, 2011
Steering
STEERING COLUMN RATTLES, DEALER INSTALLED RECALLED POWER STEERING UNIT AND GREASED INTERMEDIATE SHAFT. NOISE QUIT FOR 10,0000 MILES AND STARTED AGAIN. DEALER SAID NEW SHAFTS ONLY LAST 20,0000. *TR
NHTSA ODI #10423798
21,000 miles · Aug 15, 2011
Electrical System
MILEAGE, ABOUT 21,000 MILES, OUT OF WARRANTY. IGNITION LOCK SEIZED WHILE DRIVING. COULD NOT TURN OFF. WENT TO DEALER, WHO PERFORMED A "COURTESY" REPAIR. IF THIS HAD HAPPENED AT NIGHT OR OVER THE WEEKEND, WOULD HAVE HAD A MAJOR PROBLEM. *TR
NHTSA ODI #10419453
33,324 miles · Aug 10, 2011
Electrical SystemEquipment
THIS IS A 3 YEAR OLD 2008 GM COBALT WITH LESS THAN 35,000 MILE. I WAS OUT RUNNING ERRANDS 7/18/11. I DROVE IN TO PARKING SPOT AND ATTEMPTED TO TURN MY CAR OFF. THE KEY DID NOT TURN TO TURN THE CAR OFF NOR COULD I REMOVE THE KEY FROM THE IGNITION. I DROVE MY CAR TO GM DEALER AND WAS TOLD THE IGNITION CYLINDER NEEDED REPLACEM…
Read full complaint
THIS IS A 3 YEAR OLD 2008 GM COBALT WITH LESS THAN 35,000 MILE. I WAS OUT RUNNING ERRANDS 7/18/11. I DROVE IN TO PARKING SPOT AND ATTEMPTED TO TURN MY CAR OFF. THE KEY DID NOT TURN TO TURN THE CAR OFF NOR COULD I REMOVE THE KEY FROM THE IGNITION. I DROVE MY CAR TO GM DEALER AND WAS TOLD THE IGNITION CYLINDER NEEDED REPLACEMENT. I WAS SURPRISED BECAUSE THE CAR IS ONLY 3 YEARS OLD AND I HAD NO OTHER PROBLEM. I HAVE OWNED TWO OTHER CARS, ONE FOR 10 YRS AND ONE FOR 11 YRS NEVER AT ANY TIME DID I HAVE ANY PROBLEM WITH GETTING THE KEY FROM THE IGNITION OR PROBLEMS TURNING MY CAR OFF. I BELIEVE THAT THE IGNITION CYLINDER WAS DEFECTIVE AND SO I SHOULD NOT BE RESPONSIBLE FOR PAYING FOR A DEFECTIVE PART TO BE REPLACED. THANK YOU FOR THE OPPORTUNITY TO ENTER MY COMPLAINT. *TR
NHTSA ODI #10418441
67,500 miles · Jul 29, 2011
Steering
TL* THE CONTACT OWNS A 2008 CHEVROLET COBALT. THE CONTACT STATED WHILE DRIVING 45 MPH, THE POWER STEERING LAMP ILLUMINATED. THE POWER STEERING FAILED MAKING IT IMPOSSIBLE TO MAKE ANY TURNS OR CHANGE LANES. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. T…
Read full complaint
TL* THE CONTACT OWNS A 2008 CHEVROLET COBALT. THE CONTACT STATED WHILE DRIVING 45 MPH, THE POWER STEERING LAMP ILLUMINATED. THE POWER STEERING FAILED MAKING IT IMPOSSIBLE TO MAKE ANY TURNS OR CHANGE LANES. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 67,500. UPDATED 09/01/2011 *LN *TR
NHTSA ODI #10416256
65,925 miles · Jul 9, 2011
Electrical SystemEquipment
IGNITION KEY WOULD NOT TURN OFF. HAD TO HAVE IGNITION SWITCH REPLACED. *TR
NHTSA ODI #10411592
Official recalls
4Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Sep 19, 2012
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE20011 · Fuel Line Leak
Opened Jul 5, 2020 · Closed Aug 17, 2023
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:delivery:hoses, Lines/piping, And Fittings; Fuel/propulsion System
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
Additional source detail variants (3)
Fuel/propulsion System
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
Fuel System, Gasoline
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal fuel lines are corroding and leaking fuel in the area between the front and rear wheels on the driver's side of the vehicle before the muffler. Most consumers allege a fuel odor and/or an observable fuel leak that alerts them to the condition.The subject metal fuel lines have a protective AGE coating and, in the vicinity of the left rear wheel, are further wrapped in a foil heat shield. The AGE coating consists of an annealed zinc aluminum alloy metal coating with extended corrosion protection paint. Under certain conditions, water and corrosive road deicing agents may enter a crevice between the heat shield and the AGE coating. With extended environmental exposure in high corrosive environments, the AGE coating can degrade. If it degrades enough, the base metal lines may begin to corrode beneath the heat shield.Corrosion to the fuel lines may eventually cause a perforation to develop in the line, allowing fuel vapors to escape from between the line and the heat shield, emitting a fuel odor that will be detectable to the vehicle operator. If the corrosion progresses, fuel may begin to weep from the line. Further metal degradation due to corrosion could create a drip or a mist of fuel. If this occurs, vehicle owners may see drips, spots, or puddles on the ground near the rear portion of the vehicle, primarily along the driver's side rear wheel.The majority of allegations (85%) were reported for vehicles that are operated in the salt belt region of the United States. This area includes states in the Northeast, mid-Atlantic, and Midwest regions. Additionally, the average failure mileage in the subject vehicles is approximately 111,000 across all data sources.Considering the low manufacturer complaint/warranty rates of fuel line replacement, the fact that the majority of failures are concentrated in salt belt states, high failure mileages, as well as the field exposure time for the subject vehicles, and the highly detectable and progressive nature of this failure over time, the potential safety consequences of this issue are very low. To date, there have been no reported crashes, injuries, or fatalities related to this issue. There are two reported fires in ODI data and no reported fires in GM data. Both ODI reported fires were minor, occurred after the vehicle was parked, and were extinguished utilizing fire extinguishers.In view of the progressive failure occurring at high mileages, the age of the subject vehicles, the high detectability of the leak, and the majority of failures occurred in salt belt states, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the attached identification numbers.
PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.
Illustration