IllustrationNOISY BROKEN STABILIZER LINKS, CONTROL ARM BUSHING BROKEN. QUICK INTERNET SEARCH SHOWS THIS TO BE A WISE SPREAD PROBLEM. *TR
2007 Chevrolet Cobalt
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cobalt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1340–25K
30525–50K
28850–75K
20775–100K
253100–150K
89150K+
1,276 reports with mileage · 288 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 689 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 283 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 281 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
116 crash reports16 fire reports72 injury reports
What owners actually said
1,564 reportsTL THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING APPROXIMATELY 30 MPH THE IGNITION SWITCH FAILED AND THE VEHICLE STALLED CAUSING THE STEERING WHEEL TO LOCK. THE CONTACT HAD A DIFFICULT TIME REMOVING THE KEY FROM THE IGNITION AND WAS UNABLE TO GET THE KEY BACK INTO THE IGNITION. THE VEHICLE WAS TOWED TO THE DEALER WHO …
Read full complaint
TL THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING APPROXIMATELY 30 MPH THE IGNITION SWITCH FAILED AND THE VEHICLE STALLED CAUSING THE STEERING WHEEL TO LOCK. THE CONTACT HAD A DIFFICULT TIME REMOVING THE KEY FROM THE IGNITION AND WAS UNABLE TO GET THE KEY BACK INTO THE IGNITION. THE VEHICLE WAS TOWED TO THE DEALER WHO STATED THE IGNITION SWITCH WAS FAULTY AND IT WAS REPLACED AT THE OWNERS EXPENSE. THE FAILURE OCCURRED ON MARCH 2, 2014. THE MANUFACTURER ADVISED HER THAT THE RECALL WAS NOT AVAILABLE UNTIL APRIL OF 2014 AND THERE WAS NOTHING THEY COULD DO TO ASSIST HER. THE CONTACT WAS CONCERNED THAT THE FAILURE COULD RECUR AND RESULT IN A FATAL CRASH. THE APPROXIMATE FAILURE MILEAGE WAS 179,000. RK UPDATED 04/22/14 MA THE CONSUMER STATED THE STEERING WHEEL LOCKED UP AND THERE WAS A VIBRATION IN THE STEERING WHEEL. UPDATED 04/24/14
MY DOOR LOCKS ARE ELECTRIC LOCKS AND THEY LOCK ON THEIR OWN AND WHEN I AM DRIVING THEY TEND TO GO UP AND DOWN ON THEIR OWN. THIS HAS BEEN GOING FOR THREE WEEKS. ALSO THE SOUND FOR MY SIGNAL AND SEAT BELT WARNING IS NOT CLICKING NOR CHIMING, THE LEFT SPEAKING WENT OUT AT THE SAME TIME THE SOUND STOPPED. *TR
I WAS TRAVELING ON THE FREEWAY WHEN I WAS CLIPPED BY A DIESEL TRUCK ON MY DRIVERS LEFT REAR. I SPUN COUNTER CLOCKWISE IN FRONT OF DIESEL AND WENT STRAIGHT TOWARDS CENTER DIVIDER, UPON OBSERVING A VEHICLE IN THE SAME LANE MY VEHICLE WAS HEAD TOWARDS. BOTH VEHICLES MADE CONTACT HITTING ME ON MY DRIVERS FRONT PANEL AND THE COBALT …
Read full complaint
I WAS TRAVELING ON THE FREEWAY WHEN I WAS CLIPPED BY A DIESEL TRUCK ON MY DRIVERS LEFT REAR. I SPUN COUNTER CLOCKWISE IN FRONT OF DIESEL AND WENT STRAIGHT TOWARDS CENTER DIVIDER, UPON OBSERVING A VEHICLE IN THE SAME LANE MY VEHICLE WAS HEAD TOWARDS. BOTH VEHICLES MADE CONTACT HITTING ME ON MY DRIVERS FRONT PANEL AND THE COBALT HITTING STRAIGHT INTO CENTER DIVIDER NO AIR BAGS WERE DEPLOYED. INJURIES WERE SUSTAINED, CAR WAS A TOTAL LOSS. THIS VEHICLE HAS NOTHING BUT PROBLEM TWICE IN 2013 THE KEY WOULD BREAK OFF IN THE IGNITION AND WERE NOT FITTING CORRECTLY CAUSING REPLACEMENT. *TR
ON JULY 15, 2010 I WAS HIT HEAD-ON BY ANOTHER DRIVER. PICTURES OF MY CHEVY COBALT CLEARLY SHOW THE DRIVER SIDE AIRBAG DIDN'T DEPLOY CORRECTLY ON THE RIDE SIDE OF THE STEERING WHEEL. AS A RESULT, I SUFFERED MULTIPLE INJURIES, MOST OF THE INJURIES ARE ON THE RIGHT SIDE OF MY BODY. DISLOCATED AND SHATTERED RIGHT FOOT, RIGHT WRIST F…
Read full complaint
ON JULY 15, 2010 I WAS HIT HEAD-ON BY ANOTHER DRIVER. PICTURES OF MY CHEVY COBALT CLEARLY SHOW THE DRIVER SIDE AIRBAG DIDN'T DEPLOY CORRECTLY ON THE RIDE SIDE OF THE STEERING WHEEL. AS A RESULT, I SUFFERED MULTIPLE INJURIES, MOST OF THE INJURIES ARE ON THE RIGHT SIDE OF MY BODY. DISLOCATED AND SHATTERED RIGHT FOOT, RIGHT WRIST FRACTURE, CUT IN RIGHT KNEE, DISFIGURED STOMACH, NEED LEFT HIP REPLACED, ALSO HAVE DEPRESSION, PTSD, ANXIETY, LONG AND SHORT TERM MEMORY LOSS, CHRONIC PAIN, DEGENERATIVE DISK DISEASE, BOTH KNEES AND ARMS WEAK. TOTALLY DISABLED, UNABLE TO WORK. HOW DO I SUE GM? *TR
ON JULY 15, 2010 I WAS HIT HEAD-ON BY ANOTHER DRIVING AT HIGH SPEED NEAR WARRENTON, OREGON. FOUR VEHICLES IN ALL WERE INVOLVED. I'M AM TOTALLY DISABLED. SUFFERED MULTIPLE INJURIES, MOST ON THE RIGHT SIDE OF MY BODY. AM UNABLE TO WORK. PICTURES OF MY CHEVY COBALT STEERING WHEEL CLEARLY SHOWS THE AIRBAG DIDN'T DEPLOY CORRECTLY. TH…
Read full complaint
ON JULY 15, 2010 I WAS HIT HEAD-ON BY ANOTHER DRIVING AT HIGH SPEED NEAR WARRENTON, OREGON. FOUR VEHICLES IN ALL WERE INVOLVED. I'M AM TOTALLY DISABLED. SUFFERED MULTIPLE INJURIES, MOST ON THE RIGHT SIDE OF MY BODY. AM UNABLE TO WORK. PICTURES OF MY CHEVY COBALT STEERING WHEEL CLEARLY SHOWS THE AIRBAG DIDN'T DEPLOY CORRECTLY. THUS LEAVING ME WITH ONGOING PAIN. DISLOCATED MY RIGHT FOOT, SIX SURGERIES IN ALL. FRACTURED MY RIGHT WRIST, KEY WENT INTO MY RIGHT KNEE, BRUISED RIGHT BREAST AND TISSUE DAMAGE, BOTH KNEES AND ARMS WEAK, BRUISING FROM SEAT BELT AND DISFIGURED RIGHT FOOT, STOMACH, AND RIGHT HIP. SUFFER ALSO FROM PTSD, LONG AND SHORT TERM MEMORY, DEPRESSION, AGITATION, DEGENERATIVE DISK DISEASE, MIGRAINES, AND MORE. PICTURES CLEARLY SHOW THE AIRBAG DID NOT DEPLOY CORRECTLY ON THE RIGHT SIDE OF THE STEER WHEEL. HOW DO I SUE GM. *TR
THE ENGINE TURNED OFF ALL BY ITSELF WHILE I WAS DRIVING AROUND A CORNER, CAUSING THE CAR TO GO OFF THE ROAD. I WAS GOING ABOUT 35 MPH, AND APPLIED THE BRAKES AS FAST AS I COULD, BUT THE CAR WENT UP AND OVER THE CURB, ACROSS THE SIDEWALK, AND BOTH FRONT TIRES WENT DOWN OFF THE STEEP EDGE OF THE SIDEWALK'S FAR SIDE INTO THE MUD. …
Read full complaint
THE ENGINE TURNED OFF ALL BY ITSELF WHILE I WAS DRIVING AROUND A CORNER, CAUSING THE CAR TO GO OFF THE ROAD. I WAS GOING ABOUT 35 MPH, AND APPLIED THE BRAKES AS FAST AS I COULD, BUT THE CAR WENT UP AND OVER THE CURB, ACROSS THE SIDEWALK, AND BOTH FRONT TIRES WENT DOWN OFF THE STEEP EDGE OF THE SIDEWALK'S FAR SIDE INTO THE MUD. THE PART OF THE CAR BODY IMMEDIATELY BEHIND THE FRONT TIRES WAS ALMOST TOUCHING (WAY LESS THAN 1 INCH ABOVE) THE EDGE OF THE TOP / EDGE OF THE SIDEWALK. I COULDN'T REVERSE BACK UP AND OVER THE SIDEWALK EDGE. A TOW TRUCK WAS CALLED, AND PULLED THE CAR STRAIGHT BACK AND UP/OVER THE EDGE OF THE SIDEWALK AND ONTO THE ROAD. SOME SORT OF DUST COVER THING FROM UP INSIDE THE PASSENGER-SIDE WHEEL WELL HAD BEEN TORN LOOSE DURING THE CRASH OFF THE SIDEWALK EDGE AND WAS STILL LAYING IN THE MUD. AFTER I RESTARTED THE CAR AND DROVE HOME, THE STEERING / SUSPENSION (I CANNOT TELL WHICH) MADE A CREAKING AND GRINDING SORT OF NOISE WHEN TURNING, AND I COULD TELL FROM THE EXTENSIVE BOUNCING AT EVEN LITTLE BUMPS IN THE ROAD THAT BOTH FRONT STRUTS HAD BEEN DAMAGED. *TR
WHILE BACKING OUT OF A PARKING SPACE AND SHIFTING INTO DRIVE, MY 2007 COBALT LOST POWER STEERING. A CHIME SOUNDED AND THE DASH LIT UP WITH AN ERROR MESSAGE ABOUT POWER STEERING FAILURE. I'VE PREVIOUSLY TAKEN ADVANTAGE OF THE RECALL FOR THE ASSISTED POWER STEERING REBUILD IN 2010, YET THE COMPONENT HAS FAILED AGAIN! GM WANTS ME T…
Read full complaint
WHILE BACKING OUT OF A PARKING SPACE AND SHIFTING INTO DRIVE, MY 2007 COBALT LOST POWER STEERING. A CHIME SOUNDED AND THE DASH LIT UP WITH AN ERROR MESSAGE ABOUT POWER STEERING FAILURE. I'VE PREVIOUSLY TAKEN ADVANTAGE OF THE RECALL FOR THE ASSISTED POWER STEERING REBUILD IN 2010, YET THE COMPONENT HAS FAILED AGAIN! GM WANTS ME TO PAY FOR A TOW TO THE DEALERSHIP AND PAY FOR A DIAGNOSTIC. I WILL PAY FOR A TOW, BUT I WILL NOT PAY FOR THEM TO TELL ME THAT THE ASSISTED POWER STEERING HAS AGAIN FAILED. IF I TAKE IT TO THE DEALERSHIP, AND THEY FIND AN ERROR CODE INDICATING THAT THE ASSISTED POWER STEERING HAS FAILED, I BELIEVE THEY SHOULD NOT CHARGE ME AT ALL. FURTHERMORE, THEY SHOULD REPLACE - NOT REBUILD - THIS FAULTY, ILL CONCEIVED DEVICE THAT HAS SUCH POOR DESIGN. *TR
MY DAUGHTERS CAR CAUGHT FIRE. NO ONE SEEMS INTERESTED BECAUSE SHE MADE IT OUT ALIVE. I AM HAVING ISSUES WITH FINDING OUT WHO IS AT FAULT. I AM REQUESTING SOME ANSWERS. *TR
THERE ARE A LOT OF RECALLS ON THESE VEHICLES RIGHT NOW, EVERYTIME I CALL TO SEE IF MINE IS RECALLED FOR IGNITION TROUBLE THEY SAY NO. I WANT MINE REPLACED, AT GM'S EXPENSE. WE JUST HAD THE BLINKER SWITCH REPLACED AND THERE ARE TIMES THE IGNITION SEEMS STUCK. HOW CAN WE KNOW IF THERE IS A RECALL WHEN WE PURCHASED USED? *TR
Official recalls
514V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
12V459000 · Fuel System, Gasoline:delivery:fuel Pump
Sep 19, 2012
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
10V073000 · Steering:electric Power Assist System
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
09V419000 · Fuel System, Gasoline:delivery:fuel Pump
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.