NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,564 reports142,000 miles · May 12, 2014
Air BagsElectrical SystemPower Train
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT STATED THAT THERE WAS AN ABNORMAL NOISE BEING EMITTED FROM THE IGNITION WHEN THE KEY WAS REMOVED. THE VEHICLE WAS REPAIRED BY THE DEALER UNDER NHTSA CAMPAIGN ID NUMBER 14V047000 (AIR BAGS, ELECTRICAL SYSTEM), HOWEVER THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIF…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT STATED THAT THERE WAS AN ABNORMAL NOISE BEING EMITTED FROM THE IGNITION WHEN THE KEY WAS REMOVED. THE VEHICLE WAS REPAIRED BY THE DEALER UNDER NHTSA CAMPAIGN ID NUMBER 14V047000 (AIR BAGS, ELECTRICAL SYSTEM), HOWEVER THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 142,000. KMJ UPDATED 7/16/14*CN THE CONSUMER STATED THE VEHICLE STALLED THREE YEARS AGO. AT THE TIME, SHE WAS INFORMED THE VEHICLE NEEDED A NEW TRANSMISSION. THE CONSUMER BELIEVED IT WAS THE IGNITION ALL ALONG.
NHTSA ODI #10587742
Mileage unknown · May 9, 2014
Electrical System
I OWN A 2007 CHEVY COBALT INCLUDED IN THE NATIONWIDE RECALL. I HAVE BEEN TRYING FOR MONTHS TO HAVE THIS CAR' IGNITION SWITCH REPLACED IN ACCORDANCE WITH THE RECALL, HOWEVER BOTH CHEVY AND THE LOCAL DEALER, ED MORSE CHEVROLET HAVE BEEN UNCOOPERATIVE IN REPLACING THE IGNITION SWITCH, PROVIDING A DATE THE PART WILL BE AVAILABLE OR…
Read full complaint
I OWN A 2007 CHEVY COBALT INCLUDED IN THE NATIONWIDE RECALL. I HAVE BEEN TRYING FOR MONTHS TO HAVE THIS CAR' IGNITION SWITCH REPLACED IN ACCORDANCE WITH THE RECALL, HOWEVER BOTH CHEVY AND THE LOCAL DEALER, ED MORSE CHEVROLET HAVE BEEN UNCOOPERATIVE IN REPLACING THE IGNITION SWITCH, PROVIDING A DATE THE PART WILL BE AVAILABLE OR PROVIDE A LOANER VEHICLE. I HAVE CALLED AND SPOKE WITH BOTH GM AND ED MORSE NUMEROUS TIMES, HOWEVER EACH TIME MET WITH THE SAME OLD, STOCK ANSWER - THAT IT'S "OK TO DRIVE AS LONG AS ALL OTHER KEYS/FOBS ARE REMOVED". THIS ANSWER IS NOT SUFFICIENT FOR ME NOR WILL I ACCEPT DRIVING THE CAR "AS SAFE". THE CAR, OVER THE YEARS WAS DRIVEN WITH UP TO 15 KEYS ON THE RING, SO WHATEVER DAMAGE TO THE IGNITION SWITCH OCCURRED, IS STILL PRESENT AND POSES RISK AT CURRENT. I AM ASKING YOUR AGENCY TO INTERVENE IN THIS MATTER. I HAVE PUT EXCESS MILES AND WEAR AND TEAR ON MY PRIMARY CAR AND WILL INCUR AN ADDITIONAL FINANCIAL BURDEN SINCE THIS 2007 COBALT IS SITTING IDLE. NEITHER GM OR ED MORSE CHEVROLET HAS OR WILL STEP UP TO THE PLATE AND ASSIST IN THIS MATTER. I TRUST YOUR DEPARTMENT WILL ASSIST IN MY ISSUE. THANK YOU. *TR
NHTSA ODI #10587474
Mileage unknown · May 8, 2014
Structure
PERIODICALLY, THE DRIVER SIDE DOOR HANDLE WOULD NOT WORK. IT COULD BE PULLED, BUT THE DOOR WOULD NOT OPEN. THIS HAS HAPPENED SEVERAL TIMES OVER THE PAST FEW YEARS. IT CANNOT BE OPENED FROM THE INSIDE EITHER. TODAY, IT HAPPENED AGAIN, AND THIS TIME, THE OUTSIDE DOOR HANDLE CAME OFF IN MY HAND. *TR
NHTSA ODI #10587291
68,000 miles · May 8, 2014
Fuel/propulsion System
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT STATED THAT UPON INSPECTION, IT WAS FOUND THAT THERE WAS A FUEL LEAK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 12V459000 (FUEL SYSTEM, GASOLINE). THE FAILU…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT STATED THAT UPON INSPECTION, IT WAS FOUND THAT THERE WAS A FUEL LEAK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 12V459000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS 68,000.
NHTSA ODI #10587227
Mileage unknown · May 7, 2014
Air BagsElectrical System
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA RECALL CAMPAIGN ID NUMBER 14V047000 (AIR BAGS , ELECTRICAL SYSTEM) AND THE PART NEEDED WAS CURRENTLY UNAVAILABLE TO REPAIR THE VEHICLE. THE DEALER WAS UNABLE TO PROVIDE AN EXPECTED DATE FOR THE REMEDY PART TO BE AVAILABLE. THE MANUFACTURE…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA RECALL CAMPAIGN ID NUMBER 14V047000 (AIR BAGS , ELECTRICAL SYSTEM) AND THE PART NEEDED WAS CURRENTLY UNAVAILABLE TO REPAIR THE VEHICLE. THE DEALER WAS UNABLE TO PROVIDE AN EXPECTED DATE FOR THE REMEDY PART TO BE AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THERE ARE NO FAILURES AT THIS TIME. RK
NHTSA ODI #10586923
77,000 miles · May 5, 2014
Exterior Lighting
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT STATED THAT AFTER DEACTIVATING THE HIGH BEAMS, THE HEADLIGHTS FAILED. THE CONTACT MENTIONED THAT THE HIGH BEAMS STILL FUNCTIONED. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE BODY COMPUTER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT STATED THAT AFTER DEACTIVATING THE HIGH BEAMS, THE HEADLIGHTS FAILED. THE CONTACT MENTIONED THAT THE HIGH BEAMS STILL FUNCTIONED. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE BODY COMPUTER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 77,000 AND THE CURRENT MILEAGE WAS 78,530. UPDATED 06/27/14*LJ
NHTSA ODI #10586590
Mileage unknown · May 5, 2014
Air BagsElectrical System
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT RECEIVED A NOTICE FOR NHTSA CAMPAIGN NUMBER 14V047000 (AIR BAGS, ELECTRICAL SYSTEM) BUT WAS INFORMED THAT THE PARTS WERE NOT AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE MANUFACTURER WAS NOT CONTACTED.
NHTSA ODI #10586542
Mileage unknown · May 5, 2014
Air BagsElectrical System
2007 CHEVY COBALT. CONSUMER WRITES IN REGARDS TO MANUFACTURERS HANDLING OF RECENT RECALL. *SMD THE CONSUMER STATED A MONTH WAS TOO LONG, FOR A KNOWN AND DANGEROUS ISSUE TO GO UNATTENDED. *JB
NHTSA ODI #10584872
70,000 miles · May 4, 2014
EngineService BrakesVehicle Speed ControlCrash
THE FIRST INCIDENT HAPPEN IN 2012 AND CAUSED A CRASH. I WAS DRIVING DOWN THE STREET AND NEEDED TO STOP AT A RED LIGHT AND PUT MY FOOT TO THE FLOOR ON THE BRAKES AND IT DID NOT STOP ME. I COULD NOT MOVE THE STEERING WHEEL EITHER SO I COULD NOT AVOID HITTING THE LADY IN FRONT OF ME. LUCKILY, I WAS NOT GOING VERY FAST AND EVERYONE …
Read full complaint
THE FIRST INCIDENT HAPPEN IN 2012 AND CAUSED A CRASH. I WAS DRIVING DOWN THE STREET AND NEEDED TO STOP AT A RED LIGHT AND PUT MY FOOT TO THE FLOOR ON THE BRAKES AND IT DID NOT STOP ME. I COULD NOT MOVE THE STEERING WHEEL EITHER SO I COULD NOT AVOID HITTING THE LADY IN FRONT OF ME. LUCKILY, I WAS NOT GOING VERY FAST AND EVERYONE WAS OKAY. WHILE EXCHANGING INSURANCE INFORMATION, I NOTICED MY KEYS WERE IN THE FLOOR BOARD OF MY VEHICLE. I DIDN'T THINK ANYTHING OF IT, BECAUSE WHEN IT CAME OUT OF THE SHOP IT SEEMED JUST FINE. THEN, I WAS ON THE FREEWAY ON MY WAY TO WORK IN 2013 AND MY KNEE BUMPED MY KEY RING AND THEY FELL TO THE FLOOR. I COULD NOT SLOW DOWN OR SWITCH LANES. I GOT A SPEEDING TICKET. THEN IN NOVEMBER, 2013, THE SAME THING HAPPENED AS THE FIRST TIME WHICH CAUSED A WRECK. I COULD NOT STOP AT A RED LIGHT AND REAR ENDED A VEHICLE IN FRONT OF ME. I WAS BARELY MOVING WHATSOEVER THOUGH, SO I GOT LUCKY AGAIN. RECENTLY, MY CHECK ENGINE LIGHT CAME ON AND I TOOK IT TO THE AUTOVBODY SHOP IN TOWN AND HAD TO PAY 800 DOLLARS TO GET THE TIMING CHAIN REPLACED. I HAVE HAD NOTHING BUT ISSUES WITH THAT CAR AND NOW I FIND OUT THAT MANY RECALLS HAVE BEEN ISSUED ON THE VEHICLE AND I HAVE NOT BEEN NOTIFIED OF A SINGLE ONE. APPARENTLY GM WAS SUPPOSED TO NOTIFY OWNERS WITH THEIR REGISTRATION INFORMATION. MY REGISTRATION JUST CAME UP FOR RENEWAL AS OF MAY 1ST AND I HAVE NOT BEEN NOTIFIED OR INSTRUCTED WHAT TO DO. IT HAS GOTTEN TO THE POINT NOW WHERE I DUCT TAPE MY KEY SO THAT IT WILL NOT COME OUT WHILE I AM DRIVING. I LIMIT MY DRIVING TO NECESSITY TRAVEL BECAUSE I AM TOO AFRAID THAT SOMETHING ELSE, POSSIBLY WORSE, THAN WHAT HAS ALREADY HAPPENED THUS FAR. *TR
NHTSA ODI #10586472
78,000 miles · May 4, 2014
Air BagsCrash
ON MARCH 27, 2014, MY WIFE WAS IN AN ACCIDENT AT AN INTERSECTION WITH ANOTHER VEHICLE. THE 2007 CHEVROLET - COBALT RECEIVED MAJOR DAMAGE TO THE FRONT OF THE VEHICLE. THE AIR BAGS DID NOT DEPLOY. LUCKILY, MY WIFE WAS NOT INJURED BUT COULD HAVE BEEN FATALITY #14 OR #304 DEPENDING ON THE REPORT YOU READ REGARDING THE AIRBAG DEPL…
Read full complaint
ON MARCH 27, 2014, MY WIFE WAS IN AN ACCIDENT AT AN INTERSECTION WITH ANOTHER VEHICLE. THE 2007 CHEVROLET - COBALT RECEIVED MAJOR DAMAGE TO THE FRONT OF THE VEHICLE. THE AIR BAGS DID NOT DEPLOY. LUCKILY, MY WIFE WAS NOT INJURED BUT COULD HAVE BEEN FATALITY #14 OR #304 DEPENDING ON THE REPORT YOU READ REGARDING THE AIRBAG DEPLOYMENT FAILURES AND IGNITION PROBLEMS OF THE COBALT. THE INSURANCE "TOTALED" THE CAR. I WANT TO FILE THE POLICE REPORT, INSURANCE REPORT AND PHOTOS TO THE N.H.T.S.A.. SAFETY DEVICES PLACED IN VEHICLES SHOULD WORK OR DON'T ADVERTISE SAFETY OF THE VEHICLE AND CHARGE THE CONSUMER FOR PRODUCTS THAT DON'T WORK. PLEASE EMAIL ME YOUR CLAIMS DEPARTMENT ADDRESS. THANK YOU.
NHTSA ODI #10586420
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Sep 19, 2012
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration