Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1340–25K
30525–50K
28850–75K
20775–100K
253100–150K
89150K+
1,276 reports with mileage · 288 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Steering. Review the 689 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel/propulsion System. Review the 283 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 281 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
116 crash reports16 fire reports72 injury reports
What owners actually said
1,564 reports
52,000 miles · Apr 13, 2015
Fuel/propulsion System
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. AFTER HAVING THE VEHICLE REPAIRED UNDER AN UNKNOWN MANUFACTURER RECALL, FUEL STARTED LEAKING FROM THE FUEL TANK. THE FAILURE OCCURRED CONTINUOUSLY. THE VEHICLE WAS NOT TAKEN TO A DEALER OR DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT INCLUDED IN NHTS…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. AFTER HAVING THE VEHICLE REPAIRED UNDER AN UNKNOWN MANUFACTURER RECALL, FUEL STARTED LEAKING FROM THE FUEL TANK. THE FAILURE OCCURRED CONTINUOUSLY. THE VEHICLE WAS NOT TAKEN TO A DEALER OR DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V459000 (FUEL SYSTEM, GASOLINE). THE APPROXIMATE FAILURE MILEAGE WAS 52,000. ....UPDATED 07/22/15 *BF UPDATED 10/05/2017*CN
NHTSA ODI #10705461
Mileage unknown · Apr 13, 2015
Steering
POWER STEERING FAILED TO WORK. HAVE NOT BEEN ABLE TO DRIVE VEHICLE. I DID NOT OWN VEHICLE WHEN ORIGINAL RECALL WAS SENT OUT. *TR
NHTSA ODI #10705374
105,371 miles · Apr 9, 2015
Electrical SystemSteering
I WAS BACKING UP OUT OF MY DRIVEWAY TO LET ANOTHER CAR OUT AND AS SOON AS I PUT THE CAR IN REVERSE THE CAR MADE THE CHIME NOISE AS IF IT WAS TELLING ME TO PUT ON MY SEATBELT SECONDS LATER POWER STEERING WAS FLASHING ON THE DASHBOARD THE RPM GAUGE WAS JUMPING, THE FUEL GAUGE WAS JUMPING BACK AND FORTH, LOW FUEL BLINKING ON DASHBO…
Read full complaint
I WAS BACKING UP OUT OF MY DRIVEWAY TO LET ANOTHER CAR OUT AND AS SOON AS I PUT THE CAR IN REVERSE THE CAR MADE THE CHIME NOISE AS IF IT WAS TELLING ME TO PUT ON MY SEATBELT SECONDS LATER POWER STEERING WAS FLASHING ON THE DASHBOARD THE RPM GAUGE WAS JUMPING, THE FUEL GAUGE WAS JUMPING BACK AND FORTH, LOW FUEL BLINKING ON DASHBOARD WITH FULL TANK OF GAS, STEERING WHEEL VERY HARD TO TURN, CHECK ENGINE LIGHT IS ON, SECURITY LOCK LIGHT IS ON, TRANSMISSION CLICKS WHEN SHIFTING. CALLED THE DEALER I FINANCED THE CAR FROM HE TOLD ME TO TAKE IT TO A SHOP CALLED PRECISION AUTO SERVICES HE COULDN'T FIGURE OUT PROBLEM SAID MOST LIKELY IT WAS A COMPUTER ISSUE SO I CALLED GM CUSTOMER SERVICE TO INFORM WHAT WAS GOING ON THEY HAD THE CAR TOWED TO BOB JOHNSON CHEVROLET AND THEY DID A RECALL ON THE IGNITION SWITCH ALSO SAID THERE WAS A BROKEN SHIFT CABLE INSTALLED A NEW CABLE, THEY ALSO HAD TO REPLACE SERPENTINE BELT. AFTER ALL THAT I PICK UP CAR AND MAKE PAYMENT A WEEK AND A HALF LATER CAR DOES THE SAME THING. I CALL AND EXPLAIN TO SERVICE ASSISTANT MANAGER HE SAYS THAT HE DIDN'T CHECK FOR POWER STEERING AFTER I EXPLAINED WAS THE WHOLE PURPOSE OF HAVING THE CAR LOOKED AT LONG STORY SHORT HE GAVE ME THE RUN AROUND SO I THOUGHT TO LOOK ELSEWHERE I TOOK IT TO ANOTHER SHOP WHERE IT WAS DIAGNOSED FREE OF CHARGE HE SAID THAT THERE WERE LOTS OF CODES ON MY CAR. BUT THE CAR WAS BACK TO NORMAL AFTER DIAGNOSIS THEN ABOUT 3 WEEKS LATER SAME PROBLEM TOOK IT BACK HE EXPLAINED TO ME THAT WHOEVER DISCONNECTED A REMOTE STARTER ON MY CAR DIDN'T DO IT PROPERLY CAUSING THE MODULES IN THE CAR TO NOT COMMUNICATE. I PAID TO HAVE THAT REPAIRED 2 WEEKS LATER SAME PROBLEM NOW MECHANIC TELLS ME ITS TRANSMISSION CONTROL MODULE WHICH COSTS ALMOST $500 WHICH IS OVER MY BUDGET. I'M MAKING PAYMENTS ON SOMETHING THAT I SHOULD BE ABLE TO DRIVE TO AND FROM WORK SAFE AND COMFORTABLY. PLEASE HELP! *TR
NHTSA ODI #10704738
123,000 miles · Apr 3, 2015
Fuel/propulsion System
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT STATED THAT THERE WAS A FUEL LEAK NEAR THE FRONT OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER. THE TECHNICIAN DIAGNOSED THAT THERE WAS A FRACTURE ON THE FILLER ASSOCIATED WITH THE FUEL TANK AND, AS A RESULT, THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICL…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT STATED THAT THERE WAS A FUEL LEAK NEAR THE FRONT OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER. THE TECHNICIAN DIAGNOSED THAT THERE WAS A FRACTURE ON THE FILLER ASSOCIATED WITH THE FUEL TANK AND, AS A RESULT, THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V419000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 123,000.
NHTSA ODI #10703574
154,000 miles · Apr 2, 2015
Seat Belts
SEATBELT WILL NOT BUCKLE. HUSBAND HAD TO SLIDE OUT UNDER THE SEATBELT AND WE CANNOT GET IT UNSTUCK. *TR
NHTSA ODI #10703428
60,300 miles · Apr 2, 2015
Electrical SystemSteering
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT STATED THAT AFTER TURNING THE VEHICLE ON, THE ENTIRE INSTRUMENT PANEL ILLUMINATED. ALSO, THE CONTACT STATED THAT THE STEERING WHEEL SEIZED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT STATED THAT AFTER TURNING THE VEHICLE ON, THE ENTIRE INSTRUMENT PANEL ILLUMINATED. ALSO, THE CONTACT STATED THAT THE STEERING WHEEL SEIZED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,300.
NHTSA ODI #10703311
78,251 miles · Apr 1, 2015
Fuel/propulsion System
I NOTICED A STRONG GAS ODOR. WHEN I LOOKED UNDER THE CAR, IT WAS DRIPPING GASOLINE ONTO THE MUFFLER HEAT SHIELD AND ONTO THE PAVEMENT. I LOOKED ON THE NHTSA WEBSITE AND SEE THAT CERTAIN CHEVY COBALTS ARE UNDER RECALL FOR A PROBLEM WITH THE FUEL PUMP CRACKING AND LEAKING. MY CAR IS EXPERIENCING THE SAME PROBLEM AS THE ONES UND…
Read full complaint
I NOTICED A STRONG GAS ODOR. WHEN I LOOKED UNDER THE CAR, IT WAS DRIPPING GASOLINE ONTO THE MUFFLER HEAT SHIELD AND ONTO THE PAVEMENT. I LOOKED ON THE NHTSA WEBSITE AND SEE THAT CERTAIN CHEVY COBALTS ARE UNDER RECALL FOR A PROBLEM WITH THE FUEL PUMP CRACKING AND LEAKING. MY CAR IS EXPERIENCING THE SAME PROBLEM AS THE ONES UNDER RECALL, THE FUEL PUMP CRACKED CAUSING THE LEAK. WHEN I CONTACTED GENERAL MOTORS, I WAS TOLD SORRY YOUR VIN # IS NOT UNDER RECALL. I AM NOT HAPPY THAT MY CAR HAS THE SAME PROBLEM AS THE RECALLED CARS BUT I AM STUCK PAYING THE BILL FOR A NEW FUEL PUMP. THIS VEHICLE SHOULD BE RECALLED ALONG WITH THE REST. *TR
NHTSA ODI #10703103
100,279 miles · Mar 31, 2015
Air BagsSeat Belts
THE AIRBAG MAINTENANCE LIGHT CAME ON IN THE CAR, TOOK CAR TO GM DEALER AND STATED THAT THERE WAS BROKEN WIRE IN THE PASSENGER SIDE SEATBELT RETRACTOR. DEALER HAD TO REPLACE RETRACTOR AND CLEAR CODE. HAVING HARD TIME UNDERSTANDING HOW THIS IS NOT SAFETY RELATED AND WHY I AM HAVING TO PAY OUT OF POCKET TO FIX THIS. THIS PART DO…
Read full complaint
THE AIRBAG MAINTENANCE LIGHT CAME ON IN THE CAR, TOOK CAR TO GM DEALER AND STATED THAT THERE WAS BROKEN WIRE IN THE PASSENGER SIDE SEATBELT RETRACTOR. DEALER HAD TO REPLACE RETRACTOR AND CLEAR CODE. HAVING HARD TIME UNDERSTANDING HOW THIS IS NOT SAFETY RELATED AND WHY I AM HAVING TO PAY OUT OF POCKET TO FIX THIS. THIS PART DOES NOT HARDLY MOVE AND SHOULD BE DESIGNED TO MOVE SO MANY REVOLUTIONS. MY OPINION THIS IS A FLAW IN THE DESIGN AND SHOULD BE COVERED BY GM. *TR
NHTSA ODI #10702773
138,000 miles · Mar 25, 2015
Electrical System
THE KEY IS STUCK ON THE ON POSITION AN STUCK IN THE IGNITION {CAN NOT GET THE KEY OUT OF THE IGNITION }. *TR
NHTSA ODI #10701812
150,589 miles · Mar 17, 2015
Electrical System
COBALT WILL RANDOMLY DISPLAY CAR LOCK SYMBOL AND CHECK ENGINE LIGHT ON THE DASH. THE GAUGES ON THE DASH (SPEEDOMETER, GAS, ETC.) BEGIN TO FLASH BACK AND FORTH, AND ERROR MESSAGES COME UP SAYING "NO FUEL", "POWER STEERING" AND ROTATE BETWEEN THE TWO. WHILE THE CAR IS DOING THIS, IT BECOMES HARD TO ACCELERATE AND THE CAR SURGES RA…
Read full complaint
COBALT WILL RANDOMLY DISPLAY CAR LOCK SYMBOL AND CHECK ENGINE LIGHT ON THE DASH. THE GAUGES ON THE DASH (SPEEDOMETER, GAS, ETC.) BEGIN TO FLASH BACK AND FORTH, AND ERROR MESSAGES COME UP SAYING "NO FUEL", "POWER STEERING" AND ROTATE BETWEEN THE TWO. WHILE THE CAR IS DOING THIS, IT BECOMES HARD TO ACCELERATE AND THE CAR SURGES RANDOMLY. IT'S HAPPENED FREQUENTLY, AND WE HAVE TAKEN THE CAR IN TO SEVERAL DIFFERENT MECHANICS, ALL WHO CANNOT FIGURE OUT WHAT IS CAUSING THE ISSUE. WE HAVE REPLACED THE MAIN COMPUTER, AND STILL ARE HAVING THE SAME ISSUES. IT IS NOT SAFE TO DRIVE AS I CANNOT SEE HOW FAST I AM GOING WHEN THE GAUGES START TO GO CRAZY, AND THE CAR WILL BEGIN TO THINK IT'S OUT OF GAS, EVEN ON A FULL TANK. WE HAVE HAD SO MANY ISSUES WITH CHEVROLET CARS OVER THE PAST FEW YEARS THAT WE NO LONGER WISH TO PURCHASE FROM THEM. *TR
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.
2007 Chevrolet Cobalt Problems, Complaints & Recalls | Skip That Year
Illustration