IllustrationTHE BOTH FRONT SPEAKER QUIT WORKING. THAT THE TURN SIGNAL CHIME DID NOT WORK EITHER THIS AFTER TAKE MI CAR TO THE DEALERSHIP CAUSE SOMETHING ABOUT POWER STEERING RECALL
2007 Chevrolet Cobalt
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cobalt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1340–25K
30525–50K
28850–75K
20775–100K
253100–150K
89150K+
1,276 reports with mileage · 288 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 689 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 283 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 281 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
116 crash reports16 fire reports72 injury reports
Steering complaints
689 reportsIN 2010 THERE WAS A GENERAL MOTORS RECALL RE THE ELECTRIC ASSISTED POWER STEERING ON THE 2007 CHEVROLET COBALT. I HAD NO PROBLEM UP TO THAT TIME. TERRY CULLEN CHEVROLET REPAIRED THE CAR ACCORDING TO THEM. HOWEVER, ON WED., OCTOBER 28, 2015 AT AROUND 1:30 PM THE POWER STEERING FAILED. MY CAR SUDDENLY APPEARED TO STOP; THEN I TRIE…
Read full complaint
IN 2010 THERE WAS A GENERAL MOTORS RECALL RE THE ELECTRIC ASSISTED POWER STEERING ON THE 2007 CHEVROLET COBALT. I HAD NO PROBLEM UP TO THAT TIME. TERRY CULLEN CHEVROLET REPAIRED THE CAR ACCORDING TO THEM. HOWEVER, ON WED., OCTOBER 28, 2015 AT AROUND 1:30 PM THE POWER STEERING FAILED. MY CAR SUDDENLY APPEARED TO STOP; THEN I TRIED TO DRIVE AND COULD BARELY MOVE THE CAR. THE WORDS "POWER STEERING" LIT UP ON MY DASHBOARD. FORTUNATELY, I WAS IN A PARKING LOT AND WAS ABLE TO TURN THE STEERING WHEEL AND MOVE INTO A PARKING SPOT WITH GREAT DIFFICULTY. I HAVE SPOKEN SEVERAL TIMES TO A GM CSR OVER THE PHONE WHO STATED THAT SHE WOULD REACH OUT TO THE DEALER TERRY CULLEN WHO HAD "REPAIRED" THE CAR. I ALSO SPOKE TO LEE POWELL, THE SERVICE MANAGER (770-968-4444) WHO STATED THAT TO REPAIR THE CAR IT WOULD COST. THE CSR, STACY, (1-790-5600, EXT 5913487) AT GM TELEPHONED ME AND STATED THAT LEE POWELL, SERVICE MANAGER TOLD HER THAT THEY WOULD REPAIR MY AUTO FOR $95.00. I BELIEVE THAT GENERAL MOTORS SHOULD REPAIR MY CAR FOR FREE SINCE THE PROBLEM IS ONE OF THE SEVEN RECALLS THAT ARE ON THE 2007 CHEVROLET COBALT AND EVEN THOUGH THE ASSISTED POWER STEERING WAS SUPPOSED TO HAVE BEEN REPAIRED, THE POWER STEERING FAILED ON OCTOBER 28, 2015. I AM 80 YEARS OLD, ON A VERY LOW FIXED INCOME OF SOCIAL SECURITY, AND DO NOT HAVE ANY FUNDS FOR THIS REPAIR. SINCE LEE POWELL, SERVICE MANAGER AT TERRY CULLEN CHEVROLET AT 1250 BATTLECREEK RD., JONESBORO, GA 30236 CLAIMED TO HAVE REPAIRED THE ELECTRIC POWER ASSIST SYSTEM AND IT FAILED ON OCTOBER 28, 2015, OBVIOUSLY THERE IS STILL A FLAW IN THE SYSTEM. I BELIEVE THAT THE ELECTRIC POWER ASSIST SYSTEM IN THE 2007 CHEVROLET COBALT HAS AN INHERENT FLAW. THAT MODEL OF CAR SHOULD HAVE ANOTHER RECALL FOR THIS SERIOUS, POTENTIALLY FATAL FLAW. I REQUEST THAT GENERAL MOTORS ISSUE ANOTHER RECALL ON THAT PROBLEM, AND REPAIR MY CAR FREE; NO CHARGE TO ME.
I BOUGHT A USED 07 COBALT TWO WEEKS AGO. IT WAS RUNNING FINE UNTIL JUST LAST NIGHT (10/23/15) POWER STEERING LIGHT CAME ON AND POWER STEERING WAS GONE. I WAS PARKING MY CAR AND ALL OF A SUDDEN THE WHEEL BECAME EXTREMELY HARD TO MOVE.
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING AT APPROXIMATELY 55 MPH, THE STEERING WHEEL SEIZED AND AN UNKNOWN WARNING LIGHT ILLUMINATED. THE VIN WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 10V073000 (STEERING), BUT THE FAILURE RECURRED TWICE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIF…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING AT APPROXIMATELY 55 MPH, THE STEERING WHEEL SEIZED AND AN UNKNOWN WARNING LIGHT ILLUMINATED. THE VIN WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 10V073000 (STEERING), BUT THE FAILURE RECURRED TWICE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT PROVIDED. THE APPROXIMATE FAILURE MILEAGE WAS 29,930.
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING APPROXIMATELY 35 MPH, THE STEERING WHEEL LOCKED AND WOULD NOT STEER IN EITHER DIRECTION. THE VEHICLE WAS SHUT OFF AND RESTARTED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE …
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING APPROXIMATELY 35 MPH, THE STEERING WHEEL LOCKED AND WOULD NOT STEER IN EITHER DIRECTION. THE VEHICLE WAS SHUT OFF AND RESTARTED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 113,210.
I WAS ATTEMPTING TO EXIT MY DRIVEWAY TO THE RIGHT WHEN SUDDENLY I COULD NOT STEER THE CAR. MY STREET CURVES, AND AS I WAS LEAVING THE DRIVEWAY A CAR WAS COMING AROUND THE CURVE AND I JUST MISSED HITTING IT. THE DRIVER WAS NICE ENOUGH TO STOP AND GOT MY CAR BACK IN THE DRIVEWAY. HE TOLD ME TO LOOK ON THE DASHBOARD, AND I SAW T…
Read full complaint
I WAS ATTEMPTING TO EXIT MY DRIVEWAY TO THE RIGHT WHEN SUDDENLY I COULD NOT STEER THE CAR. MY STREET CURVES, AND AS I WAS LEAVING THE DRIVEWAY A CAR WAS COMING AROUND THE CURVE AND I JUST MISSED HITTING IT. THE DRIVER WAS NICE ENOUGH TO STOP AND GOT MY CAR BACK IN THE DRIVEWAY. HE TOLD ME TO LOOK ON THE DASHBOARD, AND I SAW THE 'POWER STEERING' LIGHT LIT. I WAS EXTREMELY SHAKEN UP BY THIS INCIDENT AND CALLED MY DEALER, LOU BACHRODT CHEVROLET IN POMPANO BEACH. THIS WAS A SUNDAY AND THE SERVICE DEPT. WAS CLOSED. I SPOKE WITH A SALESMAN, ALEX, WHO LEFT A MESSAGE FOR JEREMY IN THE SERVICE DEPT. I SPOKE WITH JEREMY EARLY MONDAY MORNING AND EXPLAINED TO HIM WHAT HAPPENED. I TOLD HIM MY HUSBAND DROVE THE CAR WHEN HE CAME HOME FROM WORK AND THE LIGHT WAS NOT ON AND THERE WAS NO PROBLEM WITH THE STEERING. JEREMY SAID IT'S BECOMING A COMMON PROBLEM CALLED INTERMITTENT POWER STEERING FAILURE. HE CHECKED MY VIN NUMBER AND SAID THERE WAS NO RECALL. I AM VERY AFRAID TO DRIVE THE CAR SINCE JEREMY SAID THERE'S A VERY GOOD CHANCE THIS WILL HAPPEN AGAIN. HE SAID IT'S A MOTOR PROBLEM AND HAS TO BE REPAIRED. I AM NOT PAYING FOR YET ANOTHER CHEVY PROBLEM. I HAD THE IGNITION SWITCH REPLACED LAST YEAR. THIS CAR IS MY TRANSPORTATION FOR WORK. GM NEEDS TO STEP UP AND DO THE RIGHT THING AND RECALL ALL COBALTS FOR THIS PROBLEM. THAT DAY I SENT AN EMAIL TO GM, BUT HAVE HEARD NOTHING.
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING 25 MPH, THE POWER STEERING WARNING INDICATOR SUDDENLY ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING. THE DEALER STATED THAT THE POWER STEERING MODULE CRACKED AND NEEDED TO BE REPLACED. THE MANUFACTURER STATED THAT THE VE…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING 25 MPH, THE POWER STEERING WARNING INDICATOR SUDDENLY ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING. THE DEALER STATED THAT THE POWER STEERING MODULE CRACKED AND NEEDED TO BE REPLACED. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V073000 (STEERING). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 47,000.
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AND THE POWER STEERING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 180,000. THE VIN WAS NOT AVAILABLE.
I WAS ON THE LODGE FREEWAY, HIGHWAY 10, HEADING EAST WHEN I LOSS CONTROL BY 7 ME RD, SKINNED OUT, HIT THE WALL ON THE REAR LEFT FENDER AND BUMPER.
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE DRIVING 45 MPH, THE STEERING WHEEL SEIZED AND THE POWER STEERING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 93,000.
Official recalls
514V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
12V459000 · Fuel System, Gasoline:delivery:fuel Pump
Sep 19, 2012
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
10V073000 · Steering:electric Power Assist System
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
09V419000 · Fuel System, Gasoline:delivery:fuel Pump
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.