NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
150 reportsClear category filter32,600 miles · Sep 27, 2010
Fuel System, Gasoline
TL* THE CONTACT OWNED A 2007 CHEVROLET COBALT. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING FUEL ABNORMALLY. THE CONTACT INSPECTED THE VEHICLE AND DISCOVERED THAT FUEL WAS LEAKING FROM UNDER THE FUEL TANK. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE FUEL MODULE WAS REPLACED. THE CONTACT INQUIRED ABOUT NHTSA CAMPAIGN…
Read full complaint
TL* THE CONTACT OWNED A 2007 CHEVROLET COBALT. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING FUEL ABNORMALLY. THE CONTACT INSPECTED THE VEHICLE AND DISCOVERED THAT FUEL WAS LEAKING FROM UNDER THE FUEL TANK. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE FUEL MODULE WAS REPLACED. THE CONTACT INQUIRED ABOUT NHTSA CAMPAIGN ID NUMBER: 09V419000 (FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP) AND WAS TOLD THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL BASED ON THE VIN. THE CONTACT CALLED THE MANUFACTURER WHO VERIFIED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL AND PROVIDED NO FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 32,600 AND THE CURRENT MILEAGE WAS 32,917.
NHTSA ODI #10357833
44,587 miles · Sep 14, 2010
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH, THERE WAS AN EXTREMELY STRONG ODOR OF FUEL EMITTING INSIDE OF THE VEHICLE. THE FAILURE WOULD OCCUR ANYTIME AFTER STARTING THE IGNITION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY DETECTED A FUEL PUMP LEAK. THE FUEL …
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH, THERE WAS AN EXTREMELY STRONG ODOR OF FUEL EMITTING INSIDE OF THE VEHICLE. THE FAILURE WOULD OCCUR ANYTIME AFTER STARTING THE IGNITION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY DETECTED A FUEL PUMP LEAK. THE FUEL PUMP WAS REPLACED AT THE CONTACTS EXPENSE. THE FAILURE MILEAGE WAS 44,587. UPDATED 12/14/2011 *CN UPDATED 04/25/11*JB
NHTSA ODI #10355495
165,527 miles · Sep 14, 2010
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT WAS DRIVING APPROXIMATELY 60-65 MPH WHEN HE NOTICED AN UNUSUAL GASOLINE FUEL ODOR. THE CONTACT INSPECTED THE VEHICLE BUT DID NOT LOCATE A FUEL LEAK. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS ADVISED THAT HIS VEHICLE WAS OVER THE MILEAGE LIMITATIO…
Read full complaint
TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT WAS DRIVING APPROXIMATELY 60-65 MPH WHEN HE NOTICED AN UNUSUAL GASOLINE FUEL ODOR. THE CONTACT INSPECTED THE VEHICLE BUT DID NOT LOCATE A FUEL LEAK. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS ADVISED THAT HIS VEHICLE WAS OVER THE MILEAGE LIMITATIONS FOR NHTSA CAMPAIGN ID NUMBER: 09V419000 (FUEL SYSTEM, GASOLINE: DELIVERY: FUEL PUMP). THE CONTACT THEN TOOK THE VEHICLE TO A LOCAL MECHANIC WHERE IT WAS REPAIRED. THE LOCAL MECHANIC ADVISED HIM THAT THE FUEL HAD SETTLED ON THE FUEL TANK AND WAS LEAKING. THE FAILURE MILEAGE WAS 165,527 AND THE CURRENT MILEAGE WAS 168,303.
NHTSA ODI #10355465
51,000 miles · Aug 23, 2010
Fuel System, GasolineFire
WHILE DRIVING 07 CHEVROLET COBALT ON HIGHWAY IN NEVADA WHEN SMOKE EMITTED FILLING THE VEHICLE, ROLLED DOWN WINDOWS TO SEE AND PULLED OVER 2 LANES TO GET OFF THE HIGHWAY AND JUST GOT OUT OF THE VEHICLE AS IT WAS ENGULFED IN FLAMES. TIRES POPPED THEN VEHICLE EXPLODED. *TR
NHTSA ODI #10351316
25,000 miles · Aug 20, 2010
Fuel System, Gasoline
I OWN A 2007 CHEVROLET COBALT (VIN NUMBER [XXX]) WHICH WAS PURCHASED AND LICENSED IN THE STATE OF TEXAS. THERE IS A CURRENT RECALL FOR SOME 2007 CHEVY COBALTS (NHTSA CAMPAIGN ID NUMBER: 09V419000). THE DEALER I CONTACTED INDICATED THAT MY AUTO WAS NOT PART OF THE RECALL AND I NEVER RECEIVED A RECALL NOTICE. HOWEVER, MY CAR I…
Read full complaint
I OWN A 2007 CHEVROLET COBALT (VIN NUMBER [XXX]) WHICH WAS PURCHASED AND LICENSED IN THE STATE OF TEXAS. THERE IS A CURRENT RECALL FOR SOME 2007 CHEVY COBALTS (NHTSA CAMPAIGN ID NUMBER: 09V419000). THE DEALER I CONTACTED INDICATED THAT MY AUTO WAS NOT PART OF THE RECALL AND I NEVER RECEIVED A RECALL NOTICE. HOWEVER, MY CAR IS EXPERIENCING THE SAME SYMPTIONS AS CARS THAT HAVE BEEN RECALLED FOR THIS ISSUE. THE SYMPTIONS ARE: (1) GAS SMALL (2) NOTICABLE REDUCTION IN FUEL MILEAGE (FROM 27 MPG TO 18 MPG) (3) DIFFICULT STARTING I BELIEVE MY CAR SHOULD HAVE BEEN INCLUDED IN THIS RECALL AS WELL. IS THERE ANY WAY TO ADDRESS THIS ISSUE? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*TR
NHTSA ODI #10350763
38,754 miles · Aug 16, 2010
Fuel System, Gasoline
I CURRENTLY OWN A 2007 CHEVROLET COBALT LT. ON JULY 19, MY HUSBAND AND I NOTICED A STRONG SMELL OF GASOLINE INSIDE THE VEHICLE. A WEEK LATER, OUR CAR WAS IN THE SHOP FOR REPAIRS (NOT RELATING TO THE GASOLINE ODOR), AND I WAS INFORMED THAT THE FUEL PUMP MODULAR ASSEMBLY WAS CRACKED, AND LEAKING GASOLINE. THE MECHANIC INFORMED ME …
Read full complaint
I CURRENTLY OWN A 2007 CHEVROLET COBALT LT. ON JULY 19, MY HUSBAND AND I NOTICED A STRONG SMELL OF GASOLINE INSIDE THE VEHICLE. A WEEK LATER, OUR CAR WAS IN THE SHOP FOR REPAIRS (NOT RELATING TO THE GASOLINE ODOR), AND I WAS INFORMED THAT THE FUEL PUMP MODULAR ASSEMBLY WAS CRACKED, AND LEAKING GASOLINE. THE MECHANIC INFORMED ME THAT IT COULD CATCH FIRE IF IT WAS NOT REPLACED. THE WARRANTY ON THE FUEL PUMP HAD EXPIRED TWO MONTHS PREVIOUS, AND WAS ON RECALL, BUT NOT IN THE STATE WE RESIDE IN. IT HAD TO BE REPLACED IMMEDIATELY, AND THE COST CAME OUT OF POCKET. *TR
NHTSA ODI #10349587
53,700 miles · Aug 11, 2010
Fuel System, Gasoline
TL*THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING SHE SMELLED GASOLINE. WHEN SHE LOOKED UNDERNEATH THE VEHICLE SHE FUEL LEAKING OUT OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC AND THE FUEL PUMP WAS REPLACED ALONG WITH THE FUEL TANK. THE REPAIR SEEMED TO HAVE REMEDIED THE FAILURE. TH…
Read full complaint
TL*THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING SHE SMELLED GASOLINE. WHEN SHE LOOKED UNDERNEATH THE VEHICLE SHE FUEL LEAKING OUT OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC AND THE FUEL PUMP WAS REPLACED ALONG WITH THE FUEL TANK. THE REPAIR SEEMED TO HAVE REMEDIED THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 53,700. THE VIN WAS UNKNOWN.
NHTSA ODI #10348839
77,109 miles · Aug 10, 2010
Fuel System, Gasoline
2007 CHEVY COBALT SMELL STRONG GAS SMELL. POOR STARTING. FOUND OUT THERE WAS A RECALL ISSUED ON FUEL PUMPS BUT ONLY ISSUED IN CERTAIN STATES. CAR IS REGISTERED IN MISSOURI WHICH IS NOT ON LIST BUT WAS ORIGINALLY PURCHASED IN GEORGIA WHICH IS ON LIST. VIN NUMBER FALLS WITHIN RANGE LISTED ON THIS WEB SITE ON DOCUMENT 2410373 L…
Read full complaint
2007 CHEVY COBALT SMELL STRONG GAS SMELL. POOR STARTING. FOUND OUT THERE WAS A RECALL ISSUED ON FUEL PUMPS BUT ONLY ISSUED IN CERTAIN STATES. CAR IS REGISTERED IN MISSOURI WHICH IS NOT ON LIST BUT WAS ORIGINALLY PURCHASED IN GEORGIA WHICH IS ON LIST. VIN NUMBER FALLS WITHIN RANGE LISTED ON THIS WEB SITE ON DOCUMENT 2410373 LISTED ON THIS SITE BY GM DIRECTOR SCOTT LAWSON. CONTACTED CHEVY AND THEY ACTED LIKE THEY NEVER HEARD OF SUCH A PROBLEM. NO HELP OR CONCERN ABOUT SITUATION. THIS IS DANGEROUS ,MANY INCIDENTS OUT THERE LIKE THIS ON THIS YEAR OF VEHICLE. *TR
NHTSA ODI #10348583
83,600 miles · Jul 22, 2010
Fuel System, Gasoline
TL*THE CONTACT OWNS 2007 CHEVROLET COBALT. THE CONTACT STATED THAT THE FUEL PUMP ASSEMBLY WAS CRACKED. WHILE DRIVING, THERE WAS A FUEL ODOR AND FUEL SPILL LEAK IN THE VEHICLE. HE TOOK THE VEHICLE TO A MECHANIC WHO STATED THAT THE FUEL TANK DROPPED AND THE FUEL PUMP ASSEMBLY WAS CRACKED. THE VEHICLE WAS REPAIRED BY THE MECHANIC…
Read full complaint
TL*THE CONTACT OWNS 2007 CHEVROLET COBALT. THE CONTACT STATED THAT THE FUEL PUMP ASSEMBLY WAS CRACKED. WHILE DRIVING, THERE WAS A FUEL ODOR AND FUEL SPILL LEAK IN THE VEHICLE. HE TOOK THE VEHICLE TO A MECHANIC WHO STATED THAT THE FUEL TANK DROPPED AND THE FUEL PUMP ASSEMBLY WAS CRACKED. THE VEHICLE WAS REPAIRED BY THE MECHANIC AT THE CONTACTS EXPENSE. THE MANUFACTURER WAS CONTACTED AND INFORMED HIM THAT SINCE HIS VEHICLE WAS MANUFACTURED IN OHIO IT WAS NOT INCLUDED IN THE RECALL. THE FAILURE AND CURRENT MILEAGES WERE 83,600. UPDATED 10/25/10 *BF UPDATED 10/27/10*JB
NHTSA ODI #10344756
49,000 miles · Jun 30, 2010
Fuel System, Gasoline
2007 CHEVROLET COBALT VIN# [XXX] . FUEL LEAK COMING FROM FUEL PUMP MODULE. EXISTING RECALL FOR SAME PROBLEM, THAT GM SAYS DOES NOT APPLY TO THIS VEHICLE. CAR IS CURRENTLY REGISTERED IN SOUTH CAROLINA, WAS PREVIOUSLY REGISTERED IN ALABAMA, AND NEW MEXICO. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), …
Read full complaint
2007 CHEVROLET COBALT VIN# [XXX] . FUEL LEAK COMING FROM FUEL PUMP MODULE. EXISTING RECALL FOR SAME PROBLEM, THAT GM SAYS DOES NOT APPLY TO THIS VEHICLE. CAR IS CURRENTLY REGISTERED IN SOUTH CAROLINA, WAS PREVIOUSLY REGISTERED IN ALABAMA, AND NEW MEXICO. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10340730
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Sep 19, 2012
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration