← New search

2007 Chevrolet Cobalt

Owner reports · Recalls · Investigations

Limited comparison data

There is not enough comparable history to draw a useful model-year comparison.

About this comparison →

When problems were reported

Mileage at the reported incident

1,276 reports with mileage · 288 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Steering. Review the 689 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 283 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 281 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

116 crash reports16 fire reports72 injury reports

Fuel System, Gasoline complaints

150 reports
Clear category filter
55,000 miles · Jan 13, 2011
Fuel System, Gasoline

TL*THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT STATED THAT WHEN DRIVING OR WHILE THE VEHICLE WAS PARKED SHE WOULD SMELL A GASOLINE ODOR AND THERE WAS ALSO A FUEL LEAK. THE VEHICLE WAS INSPECTED BY A DEALER WHO INFORMED THE CONTACT THAT SHE NEEDED TO REPLACE THE RETURN PORTS FOR THE FUEL SYSTEM DUE TO IT BEING FRACTURE…

Read full complaint

TL*THE CONTACT OWNS A 2007 CHEVROLET COBALT. THE CONTACT STATED THAT WHEN DRIVING OR WHILE THE VEHICLE WAS PARKED SHE WOULD SMELL A GASOLINE ODOR AND THERE WAS ALSO A FUEL LEAK. THE VEHICLE WAS INSPECTED BY A DEALER WHO INFORMED THE CONTACT THAT SHE NEEDED TO REPLACE THE RETURN PORTS FOR THE FUEL SYSTEM DUE TO IT BEING FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 55,000. UPDATED 04/15/11*LJ UPDATED 12/19/2011 *LN

NHTSA ODI #10376503

54,000 miles · Dec 29, 2010
Fuel System, Gasoline

CONNECTION TO THE FUEL PUMP BROKE. STRONG SMELL OF GASOLINE IN THE CAB ALERTED THE DRIVER TO THE PROBLEM. GASOLINE WAS FOUND LEAKING FROM THE CAR. NO ACCIDENT, BUMP, OR OTHER EVENT LEADING UP TO THE FAILURE NOTICED. VERY UNSAFE. PART WAS IMMEDIATELY REPLACED. FUEL TANK HAD TO BE TAKEN OFF TO GET AT THE PART, WHICH WAS TIME IN…

Read full complaint

CONNECTION TO THE FUEL PUMP BROKE. STRONG SMELL OF GASOLINE IN THE CAB ALERTED THE DRIVER TO THE PROBLEM. GASOLINE WAS FOUND LEAKING FROM THE CAR. NO ACCIDENT, BUMP, OR OTHER EVENT LEADING UP TO THE FAILURE NOTICED. VERY UNSAFE. PART WAS IMMEDIATELY REPLACED. FUEL TANK HAD TO BE TAKEN OFF TO GET AT THE PART, WHICH WAS TIME INTENSIVE, AND PART WAS EXPENSIVE. *TR

NHTSA ODI #10373243

38,000 miles · Nov 5, 2010
Fuel System, Gasoline

TL*THE CONTACT OWNS 2007 CHEVROLET COBALT. WHILE DRIVING AT VARIOUS SPEEDS, THE CONTACT SMELLED A STRONG ODOR OF FUEL INSIDE AND OUTSIDE OF THE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY DIAGNOSED THAT THE FUEL PUMP MODULE EXHIBITED A CRACK. THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NU…

Read full complaint

TL*THE CONTACT OWNS 2007 CHEVROLET COBALT. WHILE DRIVING AT VARIOUS SPEEDS, THE CONTACT SMELLED A STRONG ODOR OF FUEL INSIDE AND OUTSIDE OF THE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY DIAGNOSED THAT THE FUEL PUMP MODULE EXHIBITED A CRACK. THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 09V419000 (FUEL SYSTEM, GASOLINE: DELIVERY: FUEL PUMP). THE VEHICLE WAS NOT INCLUDED IN THE RECALL DEFECT DUE TO THE VEHICLE NOT BEING ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE REQUIRED STATES MENTIONED IN THE RECALL. THE VEHICLE WAS NOT BEING DRIVEN. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 38,000.

NHTSA ODI #10364116

160,000 miles · Oct 30, 2010
Fuel System, Gasoline

MY 2007 CHEVY COBALT HAS A LEAK IN THE GAS TANK, WHICH IS COMING FROM THE FUEL PUMP. THERE WAS A RECALL ON 2006 AND 2007 BUT SINCE MY CAR WAS PURCHASED IN FLORIDA 2007 I AM NOT COVERED.THIS IS A HAZARDOUS CAR AND CAN CATCH ON FIRE. WHEN THE CAR IS ON A FLAT SURFACE IT LEAKS LIKE A FAUCET. WHEN IN A ANGLE IT DOES NOT LEAK BECAUSE…

Read full complaint

MY 2007 CHEVY COBALT HAS A LEAK IN THE GAS TANK, WHICH IS COMING FROM THE FUEL PUMP. THERE WAS A RECALL ON 2006 AND 2007 BUT SINCE MY CAR WAS PURCHASED IN FLORIDA 2007 I AM NOT COVERED.THIS IS A HAZARDOUS CAR AND CAN CATCH ON FIRE. WHEN THE CAR IS ON A FLAT SURFACE IT LEAKS LIKE A FAUCET. WHEN IN A ANGLE IT DOES NOT LEAK BECAUSE OF THE POSITION OF THE FUEL PUMP. I CALL GM AND THEY SAID SINCE MY CAR WAS PURCHASED IN FLORIDA 2007 I WAS NOT COVERED. THAT IS NOT MY FAULT. THEY ALSO STATED SINCE I HAD HIGH MILES THEY PROBABLY COULD NOT DO NOTHING ANYWAY. I AM STILL PAYING FOR THIS CAR, AND THIS REPAIR IS GOING TO BE EXPENSIVE. THEY SHOULD BE HELD LIABLE FOR THEIR DEFECTED CARS THEY SEND OUT. THEY ARE LUCKY THAT WHEN ME AND MY DAUGHTER WAS DRIVING IN IT DID NOT BLOW UP, THIS WOULD HAVE COST THEM MORE MONEY THAN JUST TO REPAIR IT. FOR THIS VERY REASON, THAT IS WHY AMERICANS BUY FOREIGN CARS DUE TO RELIABILITY. ITS SAD. I AM A LOYAL CUSTOMER TO GM AND I ONLY BUY THEIR CARS, BUT IF I AM CONSIDERED A LOYAL CUSTOMER, THEN WHERE IS THEIR LOYALTY TO ME. SIGNED VERY DISAPPOINTED GM LOYAL CUSTOMER! *TR

NHTSA ODI #10362985

28,250 miles · Oct 22, 2010
Fuel System, Gasoline

SMELL OF FUEL ODOR ON PASSENGER REAR OF VEHICLE. INSPECTION REVEALED FUEL LEAK AT THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY. *TR

NHTSA ODI #10361823

110,000 miles · Oct 18, 2010
Fuel System, Gasoline

TL*THE CONTACT OWNS A 2007 CHEVROLET COBALT. HE SMELLED AN ODOR OF GASOLINE WHILE STANDING NEXT TO THE VEHICLE. WHILE HAVING THE VEHICLE SERVICED BY AN INDEPENDENT REPAIR SHOP HE WAS INFORMED THAT THE FUEL TANK WAS LEAKING. THE MANUFACTURER WAS NOTIFIED AND STATED THAT HIS VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH…

Read full complaint

TL*THE CONTACT OWNS A 2007 CHEVROLET COBALT. HE SMELLED AN ODOR OF GASOLINE WHILE STANDING NEXT TO THE VEHICLE. WHILE HAVING THE VEHICLE SERVICED BY AN INDEPENDENT REPAIR SHOP HE WAS INFORMED THAT THE FUEL TANK WAS LEAKING. THE MANUFACTURER WAS NOTIFIED AND STATED THAT HIS VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 09V419000, FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP. THE FAILURE AND CURRENT MILEAGES WERE 110,000.

NHTSA ODI #10361039

62,500 miles · Oct 15, 2010
Fuel System, Gasoline

SMELL GASOLINE COMING FROM THE REAR OF THE VEHICLE. LOOKED UNDER REAR OF VEHICLE AND CAN SEE GAS DRIPPING FROM THE TOP OF THE GAS TANKS FUEL MODULE. RECALL ONLY COVERS CERTAIN VEHICLES WITH THE SAME PROBLEM! FUMES COULD IGNITE ANYTIME. DEALESHIP WILL NOT REPAIR ON RECALL DUE TO VIN NOT FALLING BETWEEN THE NUMBERS. *TR

NHTSA ODI #10360656

84,000 miles · Oct 12, 2010
Fuel System, Gasoline

TL*THE CONTACT OWNS A 2007 CHEVROLET COBALT. WHILE THE VEHICLE WAS PARKED, THE CONTACT SMELLED GASOLINE. THE CONTACT ALSO NOTICED FUEL LEAKING FROM THE BOTTOM OF THE FUEL TANK. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE FUEL PUMP WAS REPLACED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 84,000.

NHTSA ODI #10360141

50,000 miles · Oct 4, 2010
Fuel System, Gasoline

TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. AFTER PARKING, THE CONTACT NOTICED THAT THERE WAS A PUDDLE OF GASOLINE UNDERNEATH THE VEHICLE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE FUEL PUMP WOULD NEED TO BE REPLACED. THE CONTACT CALLED THE MANUFACTURER WHERE THE CONTACT WAS INFORMED THA…

Read full complaint

TL* THE CONTACT OWNS A 2007 CHEVROLET COBALT. AFTER PARKING, THE CONTACT NOTICED THAT THERE WAS A PUDDLE OF GASOLINE UNDERNEATH THE VEHICLE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE FUEL PUMP WOULD NEED TO BE REPLACED. THE CONTACT CALLED THE MANUFACTURER WHERE THE CONTACT WAS INFORMED THAT NHTSA CAMPAIGN ID NUMBER: 09V419000 (FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP) DID NOT APPLY TO HIS VIN. THE VEHICLE WAS NOT REPAIRED AND THERE WERE NO PRIOR WARNINGS OF THE FAILURE. THE CURRENT AND FAILURE MILEAGE WAS 50,000.

NHTSA ODI #10359051

39,000 miles · Sep 27, 2010
Fuel System, Gasoline

TL* THE CONTACT OWNS 2007 CHEVROLET COBALT. THE CONTACT STATED THERE WAS A STRONG FUEL ODOR COMING FROM THE VEHICLE. WHILE THE CONTACT WAS REFUELING THE VEHICLE, HE NOTICED THERE WAS GASOLINE ON THE GROUND UNDER THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL LINE WAS LEAKING INTO THE EXHAUS…

Read full complaint

TL* THE CONTACT OWNS 2007 CHEVROLET COBALT. THE CONTACT STATED THERE WAS A STRONG FUEL ODOR COMING FROM THE VEHICLE. WHILE THE CONTACT WAS REFUELING THE VEHICLE, HE NOTICED THERE WAS GASOLINE ON THE GROUND UNDER THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL LINE WAS LEAKING INTO THE EXHAUST PIPE. THE DEALER REPLACED THE FUEL PUMP ASSEMBLY. THE MANUFACTURER ADVISED THAT THE CONTACTS VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 09V419000 (FUEL SYSTEM, GASOLINE: DELIVERY: FUEL PUMP) THEREFORE THEY WOULD NOT ASSIST WITH THE REPAIR. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 39,000.

NHTSA ODI #10357908

Official recalls

5

14V171000 · Electrical System:ignition

Apr 10, 2014

General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.

Consequence & remedy

Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.

Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.

14V047000 · Air Bags; Electrical System:ignition:switch

Feb 10, 2014

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence & remedy

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Additional source detail variants (2)

Air Bags

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Electrical System:ignition:switch

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

12V459000 · Fuel System, Gasoline:delivery:fuel Pump

Sep 19, 2012

General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.

Consequence & remedy

Consequence: Fuel leakage in the presence of an ignition source may result in a fire.

Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.

10V073000 · Steering:electric Power Assist System

Mar 3, 2010

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.

Consequence & remedy

Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

09V419000 · Fuel System, Gasoline:delivery:fuel Pump

Oct 29, 2009

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.

Consequence & remedy

Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

PE10005 · Electric Power Steering Failure

Opened Jan 27, 2010 · Closed Jul 19, 2010

Status: closed (inferred from source dates) · Steering:electric Power Assist System

In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.