NHTSA owner reports · September 18, 2026 snapshot.
Suspension complaints
51 reportsClear category filter76,000 miles · Aug 16, 2010
Service Brakes, HydraulicSuspension
EXPERIENCED ISSUES WITH STOPPING DISTANCE AND STEERING IN 2006 CHEVROLET COBALT LT. HAD BRAKES, SHOCKS, AND STRUTS REPLACED...CONTINUED TO EXPERIENCE ISSUE WITH STOPPING DISTANCE AND STEERING...TOOK IN TO DEALER AND WAS ADVISED THE CONTROL ARMS WERE "DRY ROTTED'...IT SEEMS TO ME THAT THIS WAS THE MOST LIKELY CONTRIBUTING ISSUE …
Read full complaint
EXPERIENCED ISSUES WITH STOPPING DISTANCE AND STEERING IN 2006 CHEVROLET COBALT LT. HAD BRAKES, SHOCKS, AND STRUTS REPLACED...CONTINUED TO EXPERIENCE ISSUE WITH STOPPING DISTANCE AND STEERING...TOOK IN TO DEALER AND WAS ADVISED THE CONTROL ARMS WERE "DRY ROTTED'...IT SEEMS TO ME THAT THIS WAS THE MOST LIKELY CONTRIBUTING ISSUE TO THE PROBLEM WITH BRAKES SHOCKS AND STRUTS. IN ADDITION DUE TO ISSUE WITH THE CONTROL RODS THE U-JOINT IN THE STEERING COLUMN HAS BEEN BENT CAUSING PROBLEMS WITH STEERING. *TR
NHTSA ODI #10349626
18,807 miles · Aug 11, 2010
Suspension
TL*THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE THE DEALER WAS REPAIRING NHTSA RECALL CAMPAIGN ID NUMBER 10V073000, STEERING ELECTRIC POWER ASSIST SYSTEM, SHE INFORMED THEM THAT SHE HEARD A NOISE WHENEVER SHE DROVE OVER A BUMP. THE DEALER STATED THAT THE LOWER CONTROL ARM BUSHINGS NEEDED CAUSED THE NOISE AND NEEDED TO BE RE…
Read full complaint
TL*THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE THE DEALER WAS REPAIRING NHTSA RECALL CAMPAIGN ID NUMBER 10V073000, STEERING ELECTRIC POWER ASSIST SYSTEM, SHE INFORMED THEM THAT SHE HEARD A NOISE WHENEVER SHE DROVE OVER A BUMP. THE DEALER STATED THAT THE LOWER CONTROL ARM BUSHINGS NEEDED CAUSED THE NOISE AND NEEDED TO BE REPAIRED AND THAT IT WAS A COMMON ISSUE AMONG HER YEAR, MAKE AND MODEL VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 18,807.
NHTSA ODI #10348747
36,000 miles · Aug 3, 2010
SteeringSuspension
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED WHEN DRIVING AT ANY SPEED AND TURNING THE STEERING WHEEL TO THE RIGHT, THERE WAS AN UNUSUAL CRACKING NOISE COMING FROM THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE POWER ASSIST MOTOR WAS REPLACED YET THE FAILURE PERSISTED. THE FAILURE MILEAGE W…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED WHEN DRIVING AT ANY SPEED AND TURNING THE STEERING WHEEL TO THE RIGHT, THERE WAS AN UNUSUAL CRACKING NOISE COMING FROM THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE POWER ASSIST MOTOR WAS REPLACED YET THE FAILURE PERSISTED. THE FAILURE MILEAGE WAS 36,000 AND THE CURRENT MILEAGE WAS 51,000. UPDATED 10/26/10. *LJ THE LEFT FRONT STRUT WAS LEAKING OIL AND THE STEERING COLUMN WAS REPLACED. UPDATED 10/26/10*JB
NHTSA ODI #10347039
26,000 miles · Jul 8, 2010
Suspension
TL*THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 40 MPH THE BRAKES WERE ENGAGED. SUDDENLY, THERE WAS A LOUD BANGING NOISE COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE BEGAN TO SHAKE AND VIBRATE EXCESSIVELY. THE CONTACT REDUCED THE SPEED BEING TRAVELED AND CONTINUED WITH EXTREME CAUTION…
Read full complaint
TL*THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 40 MPH THE BRAKES WERE ENGAGED. SUDDENLY, THERE WAS A LOUD BANGING NOISE COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE BEGAN TO SHAKE AND VIBRATE EXCESSIVELY. THE CONTACT REDUCED THE SPEED BEING TRAVELED AND CONTINUED WITH EXTREME CAUTION. THE FAILURE WAS CONTRIBUTED TO THE LOWER CONTROL ARM REAR BUSHING. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED BY THE CONTACT WHEN THE COMPLAINT WAS FILED. THE IDENTICAL FAILURE OCCURRED TWICE. THE FAILURE MILEAGE WAS 26,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10341979
Mileage unknown · Mar 12, 2010
Electrical SystemPower TrainSteering
2006 CHEVROLET COBALT. CONSUMER STATES STEERING AND FRONT END PROBLEMS. *TGW THE CONSUMER STATED THE VEHICLE HAS BEEN TO THE REPAIR SHOP 3 TIMES FOR FRONT END PROBLEMS. THE COIL PACK AND MODULE HAD TO BE REPLACED. THE SHIFT LEVER FAILED AND WOULD NOT RELEASE THE KEY WHEN THE ENGINE WAS TURNED OFF.
NHTSA ODI #10318619
67,000 miles · Dec 4, 2009
SteeringSuspension
I HAVE A2006 COBALT LTZAND THE POWER STEERING KEEPS GOING OUT WHEN I DRIVE DOWN THE ROAD, ALSO I HAVE A VERY BAD SHAKING PROBLEM WITH IT, ALSO I HAVE NOISE COMING FROM BACK OF THE CAR.............PLEASE HELP, I HAVE WENT TO THE DEALERSHIP, AND THEY WANT TO CHARGE ME A OUTRAGEOUS PRICE TO FIX IT.....THIS IS A VERY DANGEROUS PROB…
Read full complaint
I HAVE A2006 COBALT LTZAND THE POWER STEERING KEEPS GOING OUT WHEN I DRIVE DOWN THE ROAD, ALSO I HAVE A VERY BAD SHAKING PROBLEM WITH IT, ALSO I HAVE NOISE COMING FROM BACK OF THE CAR.............PLEASE HELP, I HAVE WENT TO THE DEALERSHIP, AND THEY WANT TO CHARGE ME A OUTRAGEOUS PRICE TO FIX IT.....THIS IS A VERY DANGEROUS PROBLEM..................EUGENE OFFENBERGER......... *TR
NHTSA ODI #10294510
65,001 miles · Nov 28, 2009
SteeringSuspension
I WAS MAKING A U TURN THE FIRST TIME MY POWER STEERING WENT OUT, I THOUGHT I WAS OUT OF GAS OR SOMETHING SO I TURNED THE KEY TO OFF AND RESTARTED THE CAR,IT WAS FINE FOR A WHILE MAYBE 20 MIN. AND THEN IT WENT OUT ON ME AGAIN GOING AROUND A CORNER THEN I REALIZED IT WAS MY POWER STEERING THAT'S WHEN I FOUND OUT IT WAS COMPLETELY …
Read full complaint
I WAS MAKING A U TURN THE FIRST TIME MY POWER STEERING WENT OUT, I THOUGHT I WAS OUT OF GAS OR SOMETHING SO I TURNED THE KEY TO OFF AND RESTARTED THE CAR,IT WAS FINE FOR A WHILE MAYBE 20 MIN. AND THEN IT WENT OUT ON ME AGAIN GOING AROUND A CORNER THEN I REALIZED IT WAS MY POWER STEERING THAT'S WHEN I FOUND OUT IT WAS COMPLETELY ELECTRONIC .IT COMES AND GOES AS IT PLEASES NOW!!!!! (THIS IS A 2006 CHEVY COBALT !!!!!!!!!!!! ) *TR
NHTSA ODI #10293797
12,000 miles · Sep 8, 2009
SteeringSuspension
WHILE TURNING OR SLOXWNG DOWN MY CAR SHAKES VIOLENTLY AND PULLS TO THE LEFT. I RECENTLY PUT NEW TIRES, ALIGNMENT AND ROTATION THINKING THIS WOULD SOLVE THE PROBLEM AND IT HAS NOT. IT FEELS AS THOUGH MY STEERING WHEEL IS GOING TO SHAKE OFF. THE DEALERSHIP SUGGESTED THE NEW TIRES AND IT HAS NOT HELPED. THIS IS A HUGE SAFETY CONCER…
Read full complaint
WHILE TURNING OR SLOXWNG DOWN MY CAR SHAKES VIOLENTLY AND PULLS TO THE LEFT. I RECENTLY PUT NEW TIRES, ALIGNMENT AND ROTATION THINKING THIS WOULD SOLVE THE PROBLEM AND IT HAS NOT. IT FEELS AS THOUGH MY STEERING WHEEL IS GOING TO SHAKE OFF. THE DEALERSHIP SUGGESTED THE NEW TIRES AND IT HAS NOT HELPED. THIS IS A HUGE SAFETY CONCERN AND SOMETHING NEEDS TO BE DONE. *TR
NHTSA ODI #10283304
35,000 miles · Jul 31, 2009
Suspension
2006 CHEVY COBALT 2.2 ECOTECH FE1 SUSPENSION CONTROL ARM BUSHINGS BAD AT 42000 MILES. BUSHING ARE NOW AVAILABLE UNDER A DIFFERENT PART #. *TR
NHTSA ODI #10278875
63,000 miles · Apr 18, 2009
Suspension
I HAVE NOTICED LOOKING ON LINE TO CONSUMER COMPLAINTS, THERE ARE ALOT OF PEOPLE COMPLAINING ABOUT THE LOWER CONTROL ARMS GOING OUT ON THE CARS. I HAVE A 2006 CHEVY COBALT. MY NIECE HAS A 2007 CHEVY COBALT AND HAD THE SAME PROBLEM. I THINK THIS NEEDS TO BE A RECALL ON THESE CARS. I'M A SINGLE MOTHER JUST BACK AT WORK AFTER DAUGHT…
Read full complaint
I HAVE NOTICED LOOKING ON LINE TO CONSUMER COMPLAINTS, THERE ARE ALOT OF PEOPLE COMPLAINING ABOUT THE LOWER CONTROL ARMS GOING OUT ON THE CARS. I HAVE A 2006 CHEVY COBALT. MY NIECE HAS A 2007 CHEVY COBALT AND HAD THE SAME PROBLEM. I THINK THIS NEEDS TO BE A RECALL ON THESE CARS. I'M A SINGLE MOTHER JUST BACK AT WORK AFTER DAUGHTER HAD A TRANSPLANT. I DIDN'T WORK FOR 4 YEARS TAKING CARE OF MY DAUGHTER. *TR
NHTSA ODI #10265970
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration