NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
255 reportsClear category filter68,110 miles · Feb 12, 2015
Electronic Stability Control (esc)Fuel/propulsion System
I LIVE IN BUFFALO, NY SO THIS IS MORE OF A PROBLEM THAN NOT. DURING THE COLD MONTHS WENT HE TEMPERATURE GOES BELOW 20 DEGREES THE CAR FAILS TO START. I HAVE REPLACED THE FUEL PUMP, SPARK PLUGS, INTAKE, MASS AIR FLOW SENSOR, AND BATTERY. I WILL BE TRYING THE CRANKSHAFT POSITION SENSOR NEXT. THE CAR WILL CRANK STRONG, AND CONTINUE…
Read full complaint
I LIVE IN BUFFALO, NY SO THIS IS MORE OF A PROBLEM THAN NOT. DURING THE COLD MONTHS WENT HE TEMPERATURE GOES BELOW 20 DEGREES THE CAR FAILS TO START. I HAVE REPLACED THE FUEL PUMP, SPARK PLUGS, INTAKE, MASS AIR FLOW SENSOR, AND BATTERY. I WILL BE TRYING THE CRANKSHAFT POSITION SENSOR NEXT. THE CAR WILL CRANK STRONG, AND CONTINUE TO CRANK FOR SEVERAL MINUTES. IT WILL THEN STOP, AND BEGIN TO CRANK AGAIN WHEN THE KEY IS AGAIN TURNED. HOWEVER THE CAR NEVER TURNS OVER. THE ONLY THING I CAN IMAGINE IS THAT SOMETHING IS COMMUNICATING WITH THE ECM OR ECU, NOT TO START. THIS ONLY OCCURS WHEN IT IS VERY COLD OUT AS I PURCHASED THE CAR IN LATE SEPTEMBER, THEREFORE I HAVE TO EXPERIENCE WITH THE VEHICLE IN WARM TEMPERATURES. *TR
NHTSA ODI #10682992
Mileage unknown · Feb 12, 2015
Fuel/propulsion System
FUEL PUMP IS LEAKING FUEL LOOKING UP RECALL ON MY 2006 CHEVY COBALT AND FOUND THEY ACCEPT RECALLS FOR THE FUEL PUMP MODULAR LEAKING FUEL BUT NOT ACCEPTED IN MY STATE OF KS MY VIN NUMBER FALLS INBETWEEN THE NUMBERS ARE BEING RECALLED THE SMELL OF FUEL IS OVERWHELMING AND I CANNOT AFFORD TO FIX THIS ISSUE. *TR
NHTSA ODI #10682933
Mileage unknown · Jan 19, 2015
Fuel/propulsion System
I HAVE BEEN HAVING AN ISSUE WITH A STRONG FUEL SMELL AND WITNESSED A LARGE PUDDLE OF GAS LEAKING UNDER THE CAR. LOOKING UNDER THE CAR I FOUND CORRODED FUEL LINES ON A PLASTIC CHASSIS BRACKET. SINCE THE LINES COME FROM THE PUMP RUNNING FORWARD UNDER THE PASSENGER SIDE, THIS IS A REAL FIRE HAZARD. THE FUEL LINES ARE ONLY A FEW I…
Read full complaint
I HAVE BEEN HAVING AN ISSUE WITH A STRONG FUEL SMELL AND WITNESSED A LARGE PUDDLE OF GAS LEAKING UNDER THE CAR. LOOKING UNDER THE CAR I FOUND CORRODED FUEL LINES ON A PLASTIC CHASSIS BRACKET. SINCE THE LINES COME FROM THE PUMP RUNNING FORWARD UNDER THE PASSENGER SIDE, THIS IS A REAL FIRE HAZARD. THE FUEL LINES ARE ONLY A FEW INCHES FROM THE EXHAUST PIPE. UPON IGNITION THIS COULD IGNITE A FIRE. SEVERAL ONLINE COMPLAINTS HAVE BEEN MADE TO RECALL FORUMS MENTIONING THE SAME ISSUE WITH THE COBALT MODEL.IN THE PASSED THEIR HAS BEEN A RECALL, BUT ONLY FOR THE FUEL PUMP,NOT INCLUDING THE FUEL LINES. ALSO, MANY INCLUDING MYSELF HAVE WENT TO THE CHEVROLET DEAL TO GET THIS PROBLEM SOLVED. THE PROBLEM IS THAT THEY REFUSE TO FIX ANY UNLESS I PAY $600 OR MORE FOR THE FUEL LINES.THE FUEL LINES ARE NOT EVEN INCLUDED INTO ANY WARRANTY, YET THE FUEL PUMP IS. SINCE THERE HAS BEEN A MAJOR ISSUE WITH THIS LIFE THREATENING ISSUE, THE MATERIALS ARE OBVIOUSLY PROBLEMATIC AND NEED TO BE RECALLED OR REVISED. *TR
NHTSA ODI #10676475
173,000 miles · Jan 16, 2015
Fuel/propulsion System
I HAVE A SERIOUS LEAK IN MY FUEL TANK. THE LOCATION OF THIS LEAK IS ON THE PASSENGER SIDE NEAR THE REAR TIRE. THE FUMES ARE SO STRONG IT CAN BE SMELLED OVER 50FT AWAY FROM THE VEHICLE. I HAVE LITERALLY HAD GAS LEAK ONTO A FRIENDS HAND WHEN THEY LEANED DOWN TO CHECK FOR A LEAK. I MYSELF AM A 24 YEAR OLD FEMALE, MY PASSENGERS ON A…
Read full complaint
I HAVE A SERIOUS LEAK IN MY FUEL TANK. THE LOCATION OF THIS LEAK IS ON THE PASSENGER SIDE NEAR THE REAR TIRE. THE FUMES ARE SO STRONG IT CAN BE SMELLED OVER 50FT AWAY FROM THE VEHICLE. I HAVE LITERALLY HAD GAS LEAK ONTO A FRIENDS HAND WHEN THEY LEANED DOWN TO CHECK FOR A LEAK. I MYSELF AM A 24 YEAR OLD FEMALE, MY PASSENGERS ON A DAILY BASIS INCLUDE A 24 YEAR OLD MALE, AND TWO CHILDREN ONE OF WHICH IS MY FOUR YEAR OLD SON AND A FIVE YEAR OLD GIRL! THIS IS EXTREMELY DANGEROUS AND MEMBERS OF OUR FAMILIES AS WELL AS FRIENDS ARE EXTREMELY CONCERNED FOR OUR SAFETY! I AM EXTREMELY CONCERNED FOR OUR SAFETY AS WELL! YOU HAVE A PREVIOUS RECALL FOR THE YEAR MAKE AND MODEL OF MY VEHICLE BUT ONLY LIMITED TO A FEW SPECIFIC STATES! THIS IS A SERIOUS PROBLEM, I HAVE READ REPORTS OF MANY OTHERS HAVING THE SAME ISSUES AS ME WITH THIS CAR. SOMETHING NEEDS TO BE DONE AND IT NEEDS TO HAPPEN BEFORE SOMETHING HORRIFIC HAPPENS TO SOMEONE WHO IS EITHER IN OR NEAR THESE VEHICLES! *TR
NHTSA ODI #10673057
127,000 miles · Jan 12, 2015
Fuel/propulsion System
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE DRIVING 25 MPH, FUEL FUMES WERE PRESENT IN AND AROUND THE VEHICLE. AFTER INSPECTING THE VEHICLE, THE CONTACT OBSERVED A FUEL LEAKAGE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 127,000.
NHTSA ODI #10671729
132,525 miles · Dec 29, 2014
Fuel/propulsion System
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE DRIVING THE VEHICLE, THE CONTACT DETECTED A STRONG FUEL ODOR. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THAT THE VIN WAS NOT INCLUDED IN A MANUFACTURER RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 132,525.
NHTSA ODI #10668679
Mileage unknown · Nov 19, 2014
EngineFuel/propulsion System
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE DRIVING APPROXIMATELY 55 MPH, AN ALARM SOUND WAS HEARD, THE CHECK ENGINE INDICATOR ILLUMINATED, AND THE FUEL GAUGE LEVER MOVED TO EMPTY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10659325
Mileage unknown · Nov 16, 2014
Electrical SystemFuel/propulsion SystemFireInjury
OUR 2006 CHEVY COBALT VIN WAS TOOK IN FOR REPAIR IN NOV 2013, WE WERE TOLD WE NEEDED A STARTER BUT NEVER WHY, IT WAS BECAUSE THERE WAS A GAS LEAK,WE FOUND OUT IN AUG 2014 WHEN IT CAUGHT ON FIRE. AGAIN OCT 2014 THE AUTO DID THE SAME THING WE WERE TOLD THE REST OF THE RECALL PARTS WERE IN AND TO BRING IT IN, ALL THE TIME WE WER…
Read full complaint
OUR 2006 CHEVY COBALT VIN WAS TOOK IN FOR REPAIR IN NOV 2013, WE WERE TOLD WE NEEDED A STARTER BUT NEVER WHY, IT WAS BECAUSE THERE WAS A GAS LEAK,WE FOUND OUT IN AUG 2014 WHEN IT CAUGHT ON FIRE. AGAIN OCT 2014 THE AUTO DID THE SAME THING WE WERE TOLD THE REST OF THE RECALL PARTS WERE IN AND TO BRING IT IN, ALL THE TIME WE WERE DRIVING A UNSAFE CAR ND WAS NEVER TOLD. WE TOOK THE CAR IN NOV 2014 WITH ONLY THE BATTERY LIGHT ON A NEW BATTERY (LESS THAN 48 HRS OLD AND THE 3RD ONE IN A YEAR). WHEN GOT THE CAR BACK THE ENGINE LIGHT WAS ON, THE POWER STEERING LIGHT WAS ON AND THE T/C LIGHTS WERE ON THE SPEED ODOMETER NOR GAS HAND WORKS, NOR A/C AND HEAT, BUT THEY REPLACED THE FUSE WHEN WE TOOK IT BACK. THE CAR WILL NOT CHANGE GEARS AND IS REALLY LOUD. THEY HAS US TO BRING IT BACK AND DID NOT AGAIN DO A DIAGNOSTIC TEST JUST SAY IN HIS OPINION THE AUTO NEEDS A NEW POWER STEERING MONITOR (POWER STEERING AFTER RECALL REPLACEMENT WENT OUT, DRIVES SLUGGISH LIKE IT IS GOING TO STOP IN TRAFFIC LIKE IT DID BEFORE THE RECALLS BUT WORSE. IT IS AS LOUD AS A 5TH WHEELER TRUCK, THEREFORE IT IS HARD TO HEARD EMERGENCY VEHICLES. NONE OF THESE SAFETY MATTER OR ISSUES WERE OCCURRING BEFORE THE RECALL PARTS WERE PUT ON. THE CAR WOULD STOP BUT WOULD START UP AND DRIVE HOWEVER IT HAD NONE OF THE PROBLEMS. THE AUTO WE ARE TOLD IF WE DRIVE LESS THAN 15 MPH WILL BE UNCONTROLLABLE. WE CANNOT CONTROL THE SPEED NOW THEREFORE IT NOW DRIVES AT THE SLUGGISH GEAR. WE ARE SENIORS AND ARE AFRAID OF THE CAR. WE DID NOT KNOW THE DANGER OF RECALL BECAUSE THE CARDS ONLY STATED THE NAME OF THE PART. THE CAR AS I PREVIOUSLY STATED WOULD DRIVE BUT IN NO WAY HAS THESE PROBLEMS. THE STARTER PUT ON LAST YEAR IS AM EXAMPLE OF THE SAFETY ISSUES THAT ARE HIDDEN FROM US THEY REPLACED THE STARTER WE PAID FOR IT AND NEVER TOLD US IT WAS CAUSE BY A RECALL GAS LEAK UNTIL IT HAPPEN AGAIN IN AUG 2013. I SUBMITTED A COMPLAINT THIS TIME AND THE LAST TIME AND THEY ARE NOT INTERESTED IN RECALL ISSUES. *TR
NHTSA ODI #10655277
192,000 miles · Oct 30, 2014
Fuel/propulsion SystemVehicle Speed Control
THE VEHICLE STARTED TO EMIT AN ODOR OF FUEL WHEN PARKED, NOT RUNNING. A FEW DAYS LATER A VISIBLE PUDDLE OF FUEL WAS UNDER THE BODY OF THE CAR. THIS HAS BEEN RECURRING EVERY DAY SINCE THE FIRST OCCURRENCE. NOW A VISIBLE LEAK FROM ABOVE THE FUEL TANK CAN BE SEEN DRIPPING FUEL AT AN ACCELERATED RATE. *TR
NHTSA ODI #10651273
49,000 miles · Oct 19, 2014
Electrical SystemExterior LightingFuel/propulsion System
MY CAR HAS BEEN MILDLY HAVING PROBLEMS WHEN YOU WOULD STOP AT A LIGHT OR PULL INTO A PARKING SPOT IT ACTS LIKE IT WANTS TO CUTOFF. I GOT THE LETTER ON THE RECALL AND IT DEFINITELY GAVE ME ANXIETY DRIVING THE CAR ESPECIALLY SINCE I HAVE TO TRAVEL 180 MILES QUITE OFTEN FOR MY KIDS. I HAD THE RECALL FIXED AND YET STILL HAD THE MI…
Read full complaint
MY CAR HAS BEEN MILDLY HAVING PROBLEMS WHEN YOU WOULD STOP AT A LIGHT OR PULL INTO A PARKING SPOT IT ACTS LIKE IT WANTS TO CUTOFF. I GOT THE LETTER ON THE RECALL AND IT DEFINITELY GAVE ME ANXIETY DRIVING THE CAR ESPECIALLY SINCE I HAVE TO TRAVEL 180 MILES QUITE OFTEN FOR MY KIDS. I HAD THE RECALL FIXED AND YET STILL HAD THE MINOR PROBLEM. I SAY MINOR ONLY BECAUSE IT DID NOT CAUSE ANYTHING BAD TO HAPPEN AT THAT TIME. ALSO NOTICED THAT MY CAR WAS NOT ACTING RIGHT WITH THE TWO KEYS THEY GAVE ME SOMETIMES IT WOULD START AND SOMETIMES IT LOCKED UP. BUT NOT EVERY TIME. ABOUT TWO MONTHS AFTER THAT I WENT TO LUNCH AND MY KEY GOT LOCKED IN THE IGNITION AND THE CAR WOULD NOT START. FIGURING I TRUST BE THE BATTERY I WENT BOUGHT A NEW BATTERY BUT THE CAR STILL WOULDN'T START. I HAD IT TOWED TO GM DEALERSHIP AND THEY TOLD ME IT CODED FOR THE IGNITION SWITCH AND THE FUSE BOX. BUT THEN CALLED ME BACK AND SAID IT WAS THE FUSE BOX AND THE BODY CONTROL MODULE AND THE FUEL PRESSURE CENSOR. I TRIED TO TRADE IT IN AND THE VALUE OF A CAR I BOUGHT JUST A YEAR AND A HALF AGO FOR 11,999 IS NOW ONLY WORTH 3000.00 EVEN TO THE MAKER OF THE CAR I WOULD BE STUCK PAYING ON A CAR THAT IS UNSAFE STILL AND MAKES IT TO WHERE I CANNOT GET A NEW CAR BECAUSE OF THE AMOUNT I STILL OWE ON THE VEHICLE. *TR
NHTSA ODI #10648705
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration