IllustrationWHILE DRIVING TODAY DOOR LOCKS UNLOCK AND LOCK AGAIN RANDOMLY. IT WAS SCARY. I WAS DRIVING IN TOWN. ALSO TRACTION CONTROL LIGHT AND ENGINE LIGHT CAME ON. BEGAN RUNNING ROUGH AND LUNGING. I AM AFRAID TO DRIVE MY OWN CAR.
2006 Chevrolet Cobalt
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cobalt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1540–25K
42125–50K
55750–75K
34575–100K
331100–150K
142150K+
1,950 reports with mileage · 380 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 1,299 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 412 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 255 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
164 crash reports14 fire reports81 injury reports
Engine complaints
93 reportsTL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 09V419000 (FUEL SYSTEM, GASOLINE). THE CONTACT STATED THAT THERE WAS AN ABNORMAL FUEL ODOR EMERGING FROM THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STA…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 09V419000 (FUEL SYSTEM, GASOLINE). THE CONTACT STATED THAT THERE WAS AN ABNORMAL FUEL ODOR EMERGING FROM THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FUEL PUMP MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS CONTACTED AND STATED THAT THE VEHICLE SHOULD HAVE BEEN REPAIRED BY THE DEALER. THE MANUFACTURER DECLINED REIMBURSEMENT OF THE REPAIR FEES. THE FAILURE MILEAGE WAS 28,000. *BF*JB
'TAKATA RECALL' MY MOTHER'S COBALT HAS STALLED ON HER MANY TIMES AT STOPLIGHTS AND ALMOST CAUSED ACCIDENTS BECAUSE WHEN THE CAR MAKES A STOP AT A STOPLIGHT THE CHECK ENGINE LIGHT COMES ON AND POWER STEERING AND EVERYTHING GOES OUT AND THE KEY WON'T TURN. THIS IS A VERY DANGEROUS CAR TO DRIVE IN PLEASE PUT A RECALL ON THIS VEHICL…
Read full complaint
'TAKATA RECALL' MY MOTHER'S COBALT HAS STALLED ON HER MANY TIMES AT STOPLIGHTS AND ALMOST CAUSED ACCIDENTS BECAUSE WHEN THE CAR MAKES A STOP AT A STOPLIGHT THE CHECK ENGINE LIGHT COMES ON AND POWER STEERING AND EVERYTHING GOES OUT AND THE KEY WON'T TURN. THIS IS A VERY DANGEROUS CAR TO DRIVE IN PLEASE PUT A RECALL ON THIS VEHICLE, SHE IS AN OLDER WOMAN AND IT ISN'T SAFE FOR ANYONE TO DRIVE AT THIS POINT. ONE OF THE ALMOST ACCIDENT HAPPENED ON A CITY STREET AND SHE ALMOST WAS REAR ENDED SINCE SHE COULDN'T MOVE IN TIME AND THE CAR GOES OUT AT ANY MOMENT IT WANTS TO.
CAR STOPPED 01/2019, REPAIRED ($400) 2/11/2019: STILL NOT WORKING: CHECK ENGINE LIGHT ON, POWER STEERING LIGHT ON, KEY GETS STUCK IN IGNITION, ALTERNATOR REPLACED, BATTERY REPLACED, CODES: ISO 9141, LWP2000, LINK ERROR. I NEED THIS CAR FOR WORK AND CHEVY DEALER SAYS MY VIN NOT ATTACHED TO RECALL NOTICES. PLEASE ATTACH RECALLS TO…
Read full complaint
CAR STOPPED 01/2019, REPAIRED ($400) 2/11/2019: STILL NOT WORKING: CHECK ENGINE LIGHT ON, POWER STEERING LIGHT ON, KEY GETS STUCK IN IGNITION, ALTERNATOR REPLACED, BATTERY REPLACED, CODES: ISO 9141, LWP2000, LINK ERROR. I NEED THIS CAR FOR WORK AND CHEVY DEALER SAYS MY VIN NOT ATTACHED TO RECALL NOTICES. PLEASE ATTACH RECALLS TO THIS VIN
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. AFTER THE VEHICLE WAS STARTED, IT SHUDDERED AND VIBRATED WHILE IDLING. THE VEHICLE STALLED AND THE AIR BAG WARNING INDICATOR ILLUMINATED. THE CONTACT MENTIONED THAT THE KEY SWITCHED BACK TO THE ACCESSORY POSITION. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAG…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. AFTER THE VEHICLE WAS STARTED, IT SHUDDERED AND VIBRATED WHILE IDLING. THE VEHICLE STALLED AND THE AIR BAG WARNING INDICATOR ILLUMINATED. THE CONTACT MENTIONED THAT THE KEY SWITCHED BACK TO THE ACCESSORY POSITION. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 18,071.
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE PARKING THE VEHICLE IN THE DRIVEWAY, THE CONTACT FORGOT TO PLACE THE SHIFTER INTO PARK AND REMOVED THE KEY FROM THE IGNITION SWITCH. THE CONTACT ATTEMPTED TO RESTART THE VEHICLE WHILE IN GEAR, BUT IT FAILED TO START. THE CONTACT NOTICED THE VEHICLE WAS STILL IN GEAR AND PLACED …
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE PARKING THE VEHICLE IN THE DRIVEWAY, THE CONTACT FORGOT TO PLACE THE SHIFTER INTO PARK AND REMOVED THE KEY FROM THE IGNITION SWITCH. THE CONTACT ATTEMPTED TO RESTART THE VEHICLE WHILE IN GEAR, BUT IT FAILED TO START. THE CONTACT NOTICED THE VEHICLE WAS STILL IN GEAR AND PLACED THE GEAR SHIFTER INTO PARK. THE CONTACT ATTEMPTED TO DRIVE THE VEHICLE, BUT IT FAILED TO START. ALL THE WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TOWED TO ESTLE CHEVROLET (LOCATED AT 1515 N CLINTON ST, DEFIANCE, OH 43512, (419) 785-8015), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.
I WAS DRIVING ON THE HIGHWAY AND MY TRACTION CONTROL CAME ON. I LOST STEERING CONTROL AND MY CAR STARTED SHIFTING ROUGH AND EVENTUALLY MY POWER DEMINISHED. NOW COMES ON PERIODICALLY FOR A COUPLE DAYS THEN WILL GO OFF AND DRIVE FINE. ALSO MY AIRBAG LIGHT STAYS ON FOR PASSENGER AND SHOWS IT TO BE OFF. HAS DONE THIS SINCE I BOUGHT …
Read full complaint
I WAS DRIVING ON THE HIGHWAY AND MY TRACTION CONTROL CAME ON. I LOST STEERING CONTROL AND MY CAR STARTED SHIFTING ROUGH AND EVENTUALLY MY POWER DEMINISHED. NOW COMES ON PERIODICALLY FOR A COUPLE DAYS THEN WILL GO OFF AND DRIVE FINE. ALSO MY AIRBAG LIGHT STAYS ON FOR PASSENGER AND SHOWS IT TO BE OFF. HAS DONE THIS SINCE I BOUGHT IT.
POWER STEERING FAILURE AND ENGINE LIGHT CAME ON DASHBOARD. CAR IS DRIVABLE BUT POWER STEERING FAILS OFTEN AT TIMES WHEN DRIVING. WAS ALMOST IN BAD CAR ACCIDENT IF I HAD NOT PULLED OFF THE HIGHWAY.
THE VEHICLE CAN MESS UP FROM EITHER DRIVING DOWN THE HIGHWAY OR TRYING TO ACCELERATE THE VEHICLE ON CITY STREET OR HIGHWAY THAT THE ENGINE STALLS AND SAYS "ENGINE POWER REDUCED" THE CHECK ENGINE LIGHT ALONG WITH THE T/C LIGHT COMES ON. IT HAPPENS MULTIPLE TIMES IN JUST 30 MINUTES OF DRIVING, MORE FOR LONGER TRIPS. IT WILL EVEN …
Read full complaint
THE VEHICLE CAN MESS UP FROM EITHER DRIVING DOWN THE HIGHWAY OR TRYING TO ACCELERATE THE VEHICLE ON CITY STREET OR HIGHWAY THAT THE ENGINE STALLS AND SAYS "ENGINE POWER REDUCED" THE CHECK ENGINE LIGHT ALONG WITH THE T/C LIGHT COMES ON. IT HAPPENS MULTIPLE TIMES IN JUST 30 MINUTES OF DRIVING, MORE FOR LONGER TRIPS. IT WILL EVEN DO IT IN 10 MINUTES OF DRIVING. YOU HAVE TO PULL OVER AND TURN VEHICLE OFF FOR A FEW MINUTES AND THEN IT DRIVES FINE FOR MAYBE A MILE DOWN THE ROAD BEFORE IT DOES IT AGAIN, OR, YOU CAN CONTINUE DRIVING IT WITH THE PEDAL ALL THE WAY TO THE FLOOR BOARD TRYING TO GET SPEED WHICH IF YOU DO THE CAR SHIFTS GEAR VERY BADLY AND RIDES ROUGH BUT WHEN YOU'RE TRYING TO GET TO WORK ON TIME YOU DO WHAT YOU HAVE TOO. I HAVE TAKEN THE VEHICLE TO A MECHANIC 3 TIMES OVER THIS. THROTTLE BODY WAS CHANGED (TWICE), THEY REPLACED THE COMPUTER AND CLEANED THE WIRES. ONE MECHANIC WAS THE CHEVROLET DEALERSHIP AND THEY TOLD ME THEY NEEDED IT THERE WHEN IT HAPPENED TO BETTER DIAGNOSE THE SITUATION. I DO NOT HAVE THE ABILITY TO LET THEM JUST KEEP MY VEHICLE. I HAVE HAD THIS VEHICLE FOR A LITTLE OVER A YEAR. I BOUGHT IT USED. I HAVE A LOAN ON THE VEHICLE AND I AM SCARED TO DRIVE THIS ANY FURTHER THAN I HAVE TO BECAUSE I KNOW THE VEHICLE WILL MESS UP. I HAVE TWO CHILDREN THAT I HAVE TO PUT IN THIS VEHICLE TO TAKE PLACES. THIS VEHICLE IS EXTREMELY UNSAFE!!!!!!!!!!!!!!!!! I WANT HELP WITH THIS SITUATION!! THIS FIRST HAPPENED IN NOVEMBER OF 2016. I DO NOT KNOW THE DAY SPECIFICALLY. I DO REMEMBER IT DID NOT FALL UNDER THE DEALERSHIPS WARRANTY THAT I GOT IT FROM.
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE DRIVING UNKNOWN SPEEDS, THERE WAS AN ABNORMAL FUEL ODOR AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THERE WAS A FUEL LEAK. THE CONTACT CALLED THE LOCAL DEALER (MUNDAY CHEVROLET, 17800 NORTH FWY HOUSTON…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. WHILE DRIVING UNKNOWN SPEEDS, THERE WAS AN ABNORMAL FUEL ODOR AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THERE WAS A FUEL LEAK. THE CONTACT CALLED THE LOCAL DEALER (MUNDAY CHEVROLET, 17800 NORTH FWY HOUSTON, TX 77090) AND WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS 81,744.
Official recalls
514V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
10V073000 · Steering:electric Power Assist System
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
09V419000 · Fuel System, Gasoline:delivery:fuel Pump
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
07V014000 · Structure
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.