Illustration2006 CHEVROLET COBALT. CONSUMER STATES STEERING AND FRONT END PROBLEMS. *TGW THE CONSUMER STATED THE VEHICLE HAS BEEN TO THE REPAIR SHOP 3 TIMES FOR FRONT END PROBLEMS. THE COIL PACK AND MODULE HAD TO BE REPLACED. THE SHIFT LEVER FAILED AND WOULD NOT RELEASE THE KEY WHEN THE ENGINE WAS TURNED OFF.
2006 Chevrolet Cobalt
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cobalt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1540–25K
42125–50K
55750–75K
34575–100K
331100–150K
142150K+
1,950 reports with mileage · 380 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 1,299 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 412 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 255 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
164 crash reports14 fire reports81 injury reports
Electrical System complaints
412 reportsFEB. 28, 2010 2006 CHEVY COBALT LS SEDAN 4 CYLINDER 4 DOOR AUTOMATIC TRANSMISSION I PURCHASED THE 2006 CHEVY COBALT BRAND NEW FROM A CHEVY DEALER. I FULLY MAINTAINED AND SERVICED THE VEHICLE AS REQUIRED AND WHEN NECESSARY. ON OCTOBER 25, 2008 I WAS DRIVING THE 2006 CHEVY COBALT AND I WAS DRIVING ONTO THE CROSS COUNTY PARKW…
Read full complaint
FEB. 28, 2010 2006 CHEVY COBALT LS SEDAN 4 CYLINDER 4 DOOR AUTOMATIC TRANSMISSION I PURCHASED THE 2006 CHEVY COBALT BRAND NEW FROM A CHEVY DEALER. I FULLY MAINTAINED AND SERVICED THE VEHICLE AS REQUIRED AND WHEN NECESSARY. ON OCTOBER 25, 2008 I WAS DRIVING THE 2006 CHEVY COBALT AND I WAS DRIVING ONTO THE CROSS COUNTY PARKWAY HEADING EASTBOUND WHEN THE VEHICLES STEERING SYSTEM FAILED THUS CAUSING ME TO LOSE CONTROL OF THE VEHICLE THUS CRASHING THE VEHICLE ONTO THE PARKWAYS GUARDRAIL. I WAS VERY SHAKEN, THE VEHICLE SUSTAINED SERIOUS DAMAGE, AND THE COUNTY POLICE WAS CALLED TO THE SCENE. A POLICE REPORT WAS FILED SOON THEREAFTER. THE 2006 CHEVY COBALT HAD TO BE TOWED OFF THE PARKWAY AND BACK TO MY HOME. GM SHOULD REALLY INVESTIGATE THE CHEVY COBALT FOR STEERING SYSTEM FAILURE. *TR
1. THE INSTRUMENT PANEL GAUGES CONTINUE TO MOVE AFTER VEHICLE IS SHUT OFF. OCCURS DAILY AND HAS DONE SO SINCE PURCHASE OF VEHICLE 2/2006. DEALERSHIP REPLACED ENGINE COMPUTER TWICE WHILE VEHICLE UNDER WARRANTY BUT ONLY AFTER I PERSONALLY CONTACTED GM. 2. WHILE DRIVING CAR THE STEERING WHEEL AND CAR PULLS TO THE LEFT. DEALERS…
Read full complaint
1. THE INSTRUMENT PANEL GAUGES CONTINUE TO MOVE AFTER VEHICLE IS SHUT OFF. OCCURS DAILY AND HAS DONE SO SINCE PURCHASE OF VEHICLE 2/2006. DEALERSHIP REPLACED ENGINE COMPUTER TWICE WHILE VEHICLE UNDER WARRANTY BUT ONLY AFTER I PERSONALLY CONTACTED GM. 2. WHILE DRIVING CAR THE STEERING WHEEL AND CAR PULLS TO THE LEFT. DEALERSHIP STATES THEY CAN NOT REPRODUCE THIS CONDITION YET OTHER FAMILY MEMBERS WHO HAVE DRIVEN THE CAR HAVE HAD THIS HAPPEN TO THEM. SAW ON NEWS BROADCAST A POSSIBLE RECALL FOR THIS. 3. IGNITION IN STEERING COLUMN WILL NOT TURN ON. IGNITION REPLACED 4-5 TIMES BY DEALERSHIP. 4. GEAR SHIFTER STICKS OR WILL NOT GO INTO GEAR. REPLACED WHILE UNDER WARRANTY AND UNDER SERVICE BULLETIN NUMEROUS TIMES. 5. WHILE TRYING TO START CAR STARTER OR SOMETHING DRAGS. HAS DONE THIS SINCE PURCHASE OF VEHICLE. DEALERSHIP CLAIMS THEY CAN NOT REPRODUCE CONDITION. *TR
TL*THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT WAS DRIVING APPROXIMATELY 25 MPH ON NORMAL ROAD CONDITIONS. SUDDENLY, THE ENGINE AND TRACTION CONTROL WARNING LIGHT INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE WARNING INDICATORS REMAINED ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN …
Read full complaint
TL*THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT WAS DRIVING APPROXIMATELY 25 MPH ON NORMAL ROAD CONDITIONS. SUDDENLY, THE ENGINE AND TRACTION CONTROL WARNING LIGHT INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE WARNING INDICATORS REMAINED ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN WAS UNABLE TO DUPLICATE THE FAILURE. THE FAILURE MILEAGE WAS 56,000.
I WAS DRIVING IN THE FREEWAY AND THE POWER STEERING WAS NOT RESPONDING FOR A MOMENT SO I WAS SO SCARED A THOUGHT I WAS GOING TO CAUSE AN ACCIDENT SO I STOP FOR A WHILE AND IT WAS WORKING AGAIN BUT WHEN I GOT HOME I TRIED TO PARKED MY CAR AND THE SAME PROBLEM HAPPENED I DON'T KNOW WHAT TO DO MY DAD CHECK THE CAR TO PUT SOME FLUID…
Read full complaint
I WAS DRIVING IN THE FREEWAY AND THE POWER STEERING WAS NOT RESPONDING FOR A MOMENT SO I WAS SO SCARED A THOUGHT I WAS GOING TO CAUSE AN ACCIDENT SO I STOP FOR A WHILE AND IT WAS WORKING AGAIN BUT WHEN I GOT HOME I TRIED TO PARKED MY CAR AND THE SAME PROBLEM HAPPENED I DON'T KNOW WHAT TO DO MY DAD CHECK THE CAR TO PUT SOME FLUID ON THE POWER STEERING BUT WE FOUND THAT THE SYSTEM IS ELECTRIC, TODAY COULD BE REALLY DANGEROUS NOT ONLY FOR ME BUT OTHERS THAT WERE DRIVING CLOSE TO ME IN THE FREEWAY. *TR
I WAS DRIVING HOME ON FEBRUARY 05, 2010 WHEN MY STEERING WHEEL LOCKED UP AND I DID NOT HAVE CONTROL OF THE VEHICLE. I WAS COMING TO A STOP FORTUNATELY WHEN THIS HAPPENED. THIS IS THE FIRST TIME I HAVE EXPERIENCED THIS SITUATION. A FRIEND TOLD ME CHEVY COBALT HAVE BEEN RECALLED AND I BEGAN MY SEARCH ONLINE AND HAVE FOUND NUMEROUS…
Read full complaint
I WAS DRIVING HOME ON FEBRUARY 05, 2010 WHEN MY STEERING WHEEL LOCKED UP AND I DID NOT HAVE CONTROL OF THE VEHICLE. I WAS COMING TO A STOP FORTUNATELY WHEN THIS HAPPENED. THIS IS THE FIRST TIME I HAVE EXPERIENCED THIS SITUATION. A FRIEND TOLD ME CHEVY COBALT HAVE BEEN RECALLED AND I BEGAN MY SEARCH ONLINE AND HAVE FOUND NUMEROUS COMPLAINTS REGARDING THIS ISSUE. SEVERAL MONTHS AGO, MY FUEL PUMP MODULE HAD A SMALL CRACK IN IT DISBURSING GASOLINE. THE MECHANIC WHO WORKED ON IT SAID HE HAD NEVER SEEN ANYTHING SUCH AS THIS BEFORE. IM LUCKY I WAS NOT DRIVING AT A HIGH SPEED OR AROUND A CORNER WHEN MY STEERING WHEEL LOCKED UP OR MY CAR DIDN'T EXPLODE INTO FLAMES FROM THE GASOLINE DISBURSING THROUGHOUT MY CAR WHEN I HAD TO REPLACE MY FUEL PUMP. POWER STEERING AND FUEL PUMPS SHOULD NOT REQUIRE REGULAR MAINTENANCE. CHEVY BARELY ACKNOWLEDGES THE PROBLEM AND SAY ITS NOT BIG DEAL, TRY YOUR BEST TO CONTROL YOUR CAR WHEN YOUR POWER STEERING GOES OUT. I'VE HEARD THIS BECOMES A REGULAR OCCURRENCE AFTER THE FIRST TIME. *TR
ELECTRIC POWER STEERING. *TR
I HAVE A 2006 CHEVROLET COBALT WITH 39K MILES. MY STEERING WHEEL SHAKES WHEN DRIVING, IT IS SOMETIMES HARD TO TURN, THE RADIO TURNS ON AND OFF, AND THE CHECK ENGINE LIGHT & AIR BAG LIGHT ARE ON. I TOOK THE CAR TO THE DEALERSHIP AND THEY SAID NOTHING IS WRONG WITH THE CAR. THEY GOT THE LIGHTS TO TURN OFF. MY WARRANTY IS NOW EXPIR…
Read full complaint
I HAVE A 2006 CHEVROLET COBALT WITH 39K MILES. MY STEERING WHEEL SHAKES WHEN DRIVING, IT IS SOMETIMES HARD TO TURN, THE RADIO TURNS ON AND OFF, AND THE CHECK ENGINE LIGHT & AIR BAG LIGHT ARE ON. I TOOK THE CAR TO THE DEALERSHIP AND THEY SAID NOTHING IS WRONG WITH THE CAR. THEY GOT THE LIGHTS TO TURN OFF. MY WARRANTY IS NOW EXPIRED AND THE SAME LIGHTS CAME ON AGAIN. *TR
MY POWER STEERING TENDS TO GO OUT WHILE DRIVING. TRACTION CONTROL LIGHT COMES ON. THE SHIFTER CLICKS. MY SPEEDOMETER AND RMPS GO NUTS. MY ABS AND BRAKE LIGHT FLASH. THE CAR STALLS WHEN I STOP IN TRAFFIC OR AT LIGHTS. THEY REPROGRAMMED THE COMPUTER CHIP THREE TIMES AND REPLACED THE PART ONCE. I NOW AM HAVING THE PROBLEM AGAIN AND…
Read full complaint
MY POWER STEERING TENDS TO GO OUT WHILE DRIVING. TRACTION CONTROL LIGHT COMES ON. THE SHIFTER CLICKS. MY SPEEDOMETER AND RMPS GO NUTS. MY ABS AND BRAKE LIGHT FLASH. THE CAR STALLS WHEN I STOP IN TRAFFIC OR AT LIGHTS. THEY REPROGRAMMED THE COMPUTER CHIP THREE TIMES AND REPLACED THE PART ONCE. I NOW AM HAVING THE PROBLEM AGAIN AND THEY SAID ITS NOT THEIR PROBLEM. *TR
I OWN A 2006 CHEVY COBALT SS. MY KEY OFTEN GETS STUCK IN THE IGNITION, TAKING QUITE SOME TIME TO FIDDLE WITH TO GET OUT. AS WELL, AND A MUCH MORE SERIOUS COMPLAINT, IS THE FAILURE OF MY POWER STEERING. MY POWER STEERING LIGHT HAS COME ON QUITE OFTEN IN THE PAST 2 WEEKS. TURNING THE CAR ON AND OFF TAKES THE LIGHT AWAY. HOWEVER, T…
Read full complaint
I OWN A 2006 CHEVY COBALT SS. MY KEY OFTEN GETS STUCK IN THE IGNITION, TAKING QUITE SOME TIME TO FIDDLE WITH TO GET OUT. AS WELL, AND A MUCH MORE SERIOUS COMPLAINT, IS THE FAILURE OF MY POWER STEERING. MY POWER STEERING LIGHT HAS COME ON QUITE OFTEN IN THE PAST 2 WEEKS. TURNING THE CAR ON AND OFF TAKES THE LIGHT AWAY. HOWEVER, TODAY WHILE TAKING A TURN AT A GREEN LIGHT, MY POWER STEERING LITERALLY FAILED ON ME. THIS IS NOT SAFE, AND AFTER MUCH RESEARCH, I HAVE LEARNED ITS A COMMON DEFECT OF 2005-2009 CHEVY COBALTS. *TR
Official recalls
514V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
10V073000 · Steering:electric Power Assist System
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
09V419000 · Fuel System, Gasoline:delivery:fuel Pump
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
07V014000 · Structure
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.