NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
412 reportsClear category filter46,000 miles · Feb 7, 2013
Electrical System
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT THE CHECK ENGINE AND BATTERY LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE ALTERNATOR WAS REPLACED TWICE. THE CONTACT ALSO STATED THAT THE BATTERY AND RELAY WERE ALSO REPLACED BUT THE FAILURE RECURRED. THE DEALER WAS UNABLE TO DIAGNOSE THE …
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT THE CHECK ENGINE AND BATTERY LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE ALTERNATOR WAS REPLACED TWICE. THE CONTACT ALSO STATED THAT THE BATTERY AND RELAY WERE ALSO REPLACED BUT THE FAILURE RECURRED. THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE. THE FAILURE MILEAGE WAS 46,000 AND THE CURRENT MILEAGE WAS 46,500. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10496760
97,000 miles · Jan 29, 2013
Electrical SystemPower TrainSteering
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE POWER STEERING SEIZED AND THE VEHICLE STALLED. THE CONTACT HAD TO WAIT A FEW SECONDS TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER. AFTER DIAGNOSIS, THE CONTACT WAS ADVISED THAT THE ANTI THEFT MODULE HAD FAILED …
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE POWER STEERING SEIZED AND THE VEHICLE STALLED. THE CONTACT HAD TO WAIT A FEW SECONDS TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER. AFTER DIAGNOSIS, THE CONTACT WAS ADVISED THAT THE ANTI THEFT MODULE HAD FAILED AND WAS LATER REPLACED. IMMEDIATELY AFTER THE REPAIR, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 97,000. THE CURRENT MILEAGE WAS APPROXIMATELY 109,507. UPDATED 03/07/13*LJ THE CONSUMER STATED THE POWER STEERING WILL SHUT OFF, THE TRANSMISSION WILL SHIFT VERY ROUGHLY, THE INSTRUMENT CLUSTER GO ON AND OFF,AND THE CAR WILL DIE AT VARIOUS SPEEDS. WHEN THIS FAILURE OCCURRED THE STEERING WOULD LOCK UP. RECENTLY, 02/13/2013, THE VEHICLE HAD NO POWER STEERING THEN, IT SUDDENLY TURNED ON NEARLY CAUSING THE VEHICLE TO FLY OFF THE ROAD. UPDATED 03/11/2013 *JS
NHTSA ODI #10495040
Mileage unknown · Nov 7, 2012
Electrical SystemEngineFire
I WAS IN THE FOOD FOR LESS MARKET AND MY CAR - BLOW UP OR WHATEVER IT WAS ON FIRE WHEN I CAME OUT AFTER SOMEONE STATE "A CHEVY VOLT WAS ON FIRE, COME TO THE FRONT", THEN HE SAID, "WILL THE PERSON WITH A CHEVY VOLT, COME TO THE FRONT - COLOR PURPLE" THAT'S WHEN I WENT TO SEE WHAT WAS GOING ON. MY CAR WAS ON FIRE AND THE FIRE PEOP…
Read full complaint
I WAS IN THE FOOD FOR LESS MARKET AND MY CAR - BLOW UP OR WHATEVER IT WAS ON FIRE WHEN I CAME OUT AFTER SOMEONE STATE "A CHEVY VOLT WAS ON FIRE, COME TO THE FRONT", THEN HE SAID, "WILL THE PERSON WITH A CHEVY VOLT, COME TO THE FRONT - COLOR PURPLE" THAT'S WHEN I WENT TO SEE WHAT WAS GOING ON. MY CAR WAS ON FIRE AND THE FIRE PEOPLE WAS PUTTING IT OUT. OH, MY GOODNESS!!!!!! *TR
NHTSA ODI #10483662
103,000 miles · Sep 7, 2012
Electrical System
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT THE KEY BECAME STUCK IN THE IGNITION. IN ADDITION, THE GEAR SHIFTER COULD NOT BE SHIFTED OUT FROM PARK. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 103,000. TH…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT THE KEY BECAME STUCK IN THE IGNITION. IN ADDITION, THE GEAR SHIFTER COULD NOT BE SHIFTED OUT FROM PARK. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 103,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10474275
24,000 miles · Sep 6, 2012
Electrical System
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT KEY BECAME LODGED IN THE IGNITION AND SHE WAS UNABLE TO REMOVE IT. THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSE THAT THE IGNITION HOUSING NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILU…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT KEY BECAME LODGED IN THE IGNITION AND SHE WAS UNABLE TO REMOVE IT. THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSE THAT THE IGNITION HOUSING NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 24,000.
NHTSA ODI #10474117
62,000 miles · Aug 27, 2012
Electrical System
KEY GETS STUCK IN IGNITION AND WILL NOT COME OUT OF THE ACTUAL IGNITION WHEN YOU SHUT OFF THE CAR. I HAVE TO REACH INSIDE THE STEELING COLUMN TO PUSH A RELEASE BUTTON EACH TIME TO GET THE KEY TO BE RELEASED. *TR
NHTSA ODI #10472644
155,560 miles · Aug 23, 2012
Electrical SystemExterior LightingSteering
I WAS DRIVING HOME ONE RAINY DAY, ABOUT 45MPH, DASH LIT UP TO SHIFT. I LOOKED AND I WAS ALREADY IN 5TH. NEXT SECOND EVERYTHING ON DASH WENT OUT. NO SPEEDOMETER, NO SHIFT LIGHT, NO MILEAGE OR TRIP METER, NOTHING. ONLY THING ON DASH THAT WORKS IS TACH AND DIGITAL DISPLAY SAYS POWER STEERING. ALREADY HAD AN APPOINTMENT FOR RECALL W…
Read full complaint
I WAS DRIVING HOME ONE RAINY DAY, ABOUT 45MPH, DASH LIT UP TO SHIFT. I LOOKED AND I WAS ALREADY IN 5TH. NEXT SECOND EVERYTHING ON DASH WENT OUT. NO SPEEDOMETER, NO SHIFT LIGHT, NO MILEAGE OR TRIP METER, NOTHING. ONLY THING ON DASH THAT WORKS IS TACH AND DIGITAL DISPLAY SAYS POWER STEERING. ALREADY HAD AN APPOINTMENT FOR RECALL WORK FOR POWER STEERING ASSIST MOTOR, THOUGHT THAT MAYBE THAT WAS WHAT WAS WRONG SO I KEPT APPOINTMENT. WHEN GOT BACK FROM DEALER, THEY TELL ME THEY REPLACED POWER STEERING ASSIST MOTOR AND THEY HAD NOTICED THE DASH DISPLAY AND HAD DONE SCAN AND IT SHOWED THE POWER STEERING MOTOR IS WENT OUT! BOUGHT THIS CAR FOR MY DAUGHTER, TO DRIVE BACK IN FORTH TO SCHOOL, SCARED FOR HER TO DRIVE IT THE 90 MILES A DAY SHE DRIVES TO COLLEGE. THOUGHT THIS WAS JUST AN ISOLATED CASE BUT AFTER CHECKING ONLINE, I SEE THAT THIS IS A MAJOR DEFECT IN THESE CARS. SOMETHING NEEDS DONE BEFORE SOMEONE GETS HURT OR KILLED. *TR
NHTSA ODI #10471968
103,000 miles · Aug 14, 2012
Electrical SystemSteering
WHILE DRIVING MY 2006 CHEVY COBALT WHEN I LOST POWER STEERING WHICH MADE IT DIFFICULT TO CONTROL MY CAR AROUND SHARP TURNS DUE TO THE FACT THAT I WAS NOT EXPECTING THE POWER STEERING TO JUST GO OUT ON ME LIKE THAT. THIS TYPE OF PROBLEM IS VERY DANGEROUS ESPECIALLY WHEN IT HAPPENS WHILE DRIVING. I HAVE ALREADY HAD MY POWER STEER…
Read full complaint
WHILE DRIVING MY 2006 CHEVY COBALT WHEN I LOST POWER STEERING WHICH MADE IT DIFFICULT TO CONTROL MY CAR AROUND SHARP TURNS DUE TO THE FACT THAT I WAS NOT EXPECTING THE POWER STEERING TO JUST GO OUT ON ME LIKE THAT. THIS TYPE OF PROBLEM IS VERY DANGEROUS ESPECIALLY WHEN IT HAPPENS WHILE DRIVING. I HAVE ALREADY HAD MY POWER STEERING FIXED ONCE DUE TO A PAST RECALL AND HERE I AM AGAIN HAVING PROBLEMS WITH THE SAME THING AGAIN! *TR
NHTSA ODI #10470564
50,000 miles · May 20, 2012
Electrical SystemSteering
MY WIFE AND GRANDSON WERE IN THE CAR WHEN POWER STEERING CAME ON THE DASH. IT CAUGHT HER ATTENTION BUT DIDN'T KNOW REALLY WHAT HAD HAPPENED TILL SHE TRIED TO TURN AND ALMOST WENT IN THE DITCH. WE TOOK IT TO THE DEALER AND 700.00 PAID TO HAVE THE PROBLEM CONTINUE TO RECUR. IT COMES AND GOES AND IF IT IS NOT A PROBLEM WHEN WE TAKE…
Read full complaint
MY WIFE AND GRANDSON WERE IN THE CAR WHEN POWER STEERING CAME ON THE DASH. IT CAUGHT HER ATTENTION BUT DIDN'T KNOW REALLY WHAT HAD HAPPENED TILL SHE TRIED TO TURN AND ALMOST WENT IN THE DITCH. WE TOOK IT TO THE DEALER AND 700.00 PAID TO HAVE THE PROBLEM CONTINUE TO RECUR. IT COMES AND GOES AND IF IT IS NOT A PROBLEM WHEN WE TAKE IT TO THE DEALER THEY DON'T KNOW WHAT TO DO. ALL THEY SAY IS IT IS IN THE WIRING ISSUE AND THINK WE SHOULD BUY SOMETHING ELSE. I DIDN'T KNOW ABOUT ALL THESE PROBLEMS TILL IT OCCURRED TO US. WE BOUGHT THE CAR NEW AND HAVE LIKE THE 2006 COBALT BUT THIS IS THE FIRST I HAVE HEARD THEY HAVE A PROBLEM WITH THE POWERSTEERING OR WIRING TO THE ELECTRIC ASSIST TO THE POWER STEERING. I AM TOLD THEY HAD A FIX BACK IN 2010 ARE WE STILL QUALIFIED TO HAVE OUR CAR FIXED UNDER THAT RECALL. MY SON IS GOING IN THE ARMY IN A COUPLE WEEKS WE WANTED TO LET HIM HAVE THIS CAR AFTER HE GETS STATIONED SOMEWHERE BUT WE CAN'T GIVE IT TO HIM WHEN WE ARE NOT TRUSTING ITS SAFETY. *TR
NHTSA ODI #10459035
52,000 miles · May 11, 2012
Electrical SystemSteering
I PURCHASED A BRAND NEW 2006 CHEVY COBALT AND HAVEN'T HAD PROBLEMS UNTIL RECENTLY (2012). MY PROBLEM STARTED IN FEBRUARY 2012 WHEN HEADING TO A DOCTOR'S APPOINTMENT. STARTED THE CAR AND THE POWER STEERING LIGHT CAME ON. STARTED PULLING CAR OFF OF PARKING LOT WHERE I LIVE AND THE CAR HAD A JERKING/BUCKING SENSATION TO IT AND THE…
Read full complaint
I PURCHASED A BRAND NEW 2006 CHEVY COBALT AND HAVEN'T HAD PROBLEMS UNTIL RECENTLY (2012). MY PROBLEM STARTED IN FEBRUARY 2012 WHEN HEADING TO A DOCTOR'S APPOINTMENT. STARTED THE CAR AND THE POWER STEERING LIGHT CAME ON. STARTED PULLING CAR OFF OF PARKING LOT WHERE I LIVE AND THE CAR HAD A JERKING/BUCKING SENSATION TO IT AND THEN SHUT OFF ON ME. HAD CAR TOWED TO CHEVY DEALER AND THE CAR WOULDN'T DUPLICATE THE SAME PROBLEM SO I GOT THE CAR BACK. 9 DAYS LATER I GO OUT AGAIN AND THE CAR STARTS WITH THE SAME PROBLEM - POWER STEERING LIGHT ON; JERKING SENSATION AND THE SPEEDOMETER DROPPED FROM 35 MPH TO 0. CAR WENT BACK TO CHEVY DEALERSHIP. AGAIN, CAR WOULD NOT DUPLICATE PROBLEMS. GOT CAR BACK & SINCE I HAVE BEEN SCARED TO DEATH TO HAVE THIS VEHICLE ON THE ROAD, IT HAS SAT FOR 2 MONTHS. AFTER GETTING GM INVOLVED, TRIED TO TAKE VEHICLE BACK TO DEALER AND ONCE AGAIN - POWER STEERING LIGHT ON; JERKING/BUCKING SENSATION; CLICKING IN GEAR CONSOLE. 3 TIMES NOW I HAVE HAD THIS CAR BACK TO DEALERSHIP AND NOW THEY DECIDE IT'S THE BODY CONTROL MODULE (BCM), YET THEY INDICATED THAT ON MY FIRST TRIP, THAT A STORED CODE SHOWED THEM THE BCM WAS NOT COMMUNICATING. GETTING GM INVOLVED HAS BEEN A WASTE OF TIME BECAUSE NATURALLY SINCE THE WARRANT IS OFF OF THE CAR, THEY DON'T WANT TO DO ANYTHING TO SOAK UP THE COST OF REPLACING THIS MODULE WHICH IS GOING TO COST ME $685.00. *TR
NHTSA ODI #10458118
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration