Illustration2006 CHEVROLET COBALT. CONSUMER WRITES IN REGARDS TO LOANER CAR ISSUE FROM DEALERSHIP. *SMD LOANER VEHICLES, WERE SUPPOSED TO BE ISSUED, UNTIL THE RECALL WAS RECTIFIED. *JB
2006 Chevrolet Cobalt
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cobalt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1540–25K
42125–50K
55750–75K
34575–100K
331100–150K
142150K+
1,950 reports with mileage · 380 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 1,299 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 412 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 255 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
164 crash reports14 fire reports81 injury reports
Electrical System complaints
412 reportsTL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT THE IGNITION FAILED AND THE KEY COULD NOT BE TURNED. THE DEALER INSPECTED THE VEHICLE AND ADVISED THAT THE IGNITION LOCK CYLINDER NEEDED TO BE REPLACED. THE APPROXIMATE FAILURE MILEAGE WAS 44,000 AND THE CURRENT MILEAGE WAS 49,000.
I WAS DRIVING ON THE HIGHWAY, AND MY COBALT SUDDENLY LOST POWER STEERING. I RECEIVED FLASHING WARNING MESSAGES FOR POWER STEERING AND ANOTHER ONE SAYING "SERVICE AIR BAG." I AM WORRIED THAT IF I AM IN AN ACCIDENT, THE AIR BAGS WILL NOT DEPLOY. THESE TWO THINGS HAPPENED SIMULTANEOUSLY. *TR
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE SUDDENLY STALLED. THE CONTACT ALSO MENTIONED THAT THE POWER STEERING OCASSIONALLY FAILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE AND VIN W…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE SUDDENLY STALLED. THE CONTACT ALSO MENTIONED THAT THE POWER STEERING OCASSIONALLY FAILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE AND VIN WAS NOT AVIAILABLE.
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED WHEN SHE ATTEMPTED TO START THE VEHICLE, THE ENGINE WOULD NOT START. THE VEHICLE WAS TOWED TO THE DEALER WHO ADVISED A NEW KEY WAS NEEDED TO START VEHICLE. THE CONTACT PURCHASED A NEW KEY AND THE FAILURE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAIL…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED WHEN SHE ATTEMPTED TO START THE VEHICLE, THE ENGINE WOULD NOT START. THE VEHICLE WAS TOWED TO THE DEALER WHO ADVISED A NEW KEY WAS NEEDED TO START VEHICLE. THE CONTACT PURCHASED A NEW KEY AND THE FAILURE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 31,000. UPDATED 5/28/14*CN *TR
DEAR SIR OR MADAM, WE HAVE RECENTLY RECEIVED THE ABOVE-MENTIONED RECALL NOTICE FOR OUR 2006 CHEVROLET COBALT. IMMEDIATELY WE CONTACTED THE LOCAL CHEVROLET DEALERSHIP, BUT WERE TOLD THAT THE PARTS TO FIX THE PROBLEM WOULD NOT BE AVAILABLE UNTIL SOMETIME IN APRIL 2014. CONSIDERING THAT GM HAS KNOWN ABOUT THIS PROBLEM FOR QU…
Read full complaint
DEAR SIR OR MADAM, WE HAVE RECENTLY RECEIVED THE ABOVE-MENTIONED RECALL NOTICE FOR OUR 2006 CHEVROLET COBALT. IMMEDIATELY WE CONTACTED THE LOCAL CHEVROLET DEALERSHIP, BUT WERE TOLD THAT THE PARTS TO FIX THE PROBLEM WOULD NOT BE AVAILABLE UNTIL SOMETIME IN APRIL 2014. CONSIDERING THAT GM HAS KNOWN ABOUT THIS PROBLEM FOR QUITE SOME TIME, BUT FAILED TO INFORM ITS CUSTOMERS, WE ARE DEFINITELY NOT SATISFIED WITH THE HANDLING OF THE SITUATION. WE ARE A MILITARY FAMILY AND SINCE WE BOUGHT THIS PARTICULAR VEHICLE IN 2005, WE HAVE HAD TO MOVE FIVE TIMES DUE TO MILITARY ORDERS. ALL OF THOSE MOVES WERE ACROSS COUNTRY, FROM WEST COAST TO EAST COAST, BACK TO WEST COAST AND IN THE LAST MOVE FROM WEST COAST TO THE MIDWEST. CONSIDERING ALL THE MILES WE HAVE PUT ON THIS CAR, WITHOUT KNOWING THAT THERE WAS AN ISSUE WITH ITS IGNITION SWITCH/KEY, IT IS VERY WORRISOME, EVEN UPSETTING, TO HAVE BEEN LEFT IN DARK FOR SO LONG BY GM. ADDITIONALLY NOW, WE HAVE BEEN PUT INTO THE SITUATION OF HAVING TO WAIT EVEN LONGER, DUE TO THE PARTS NOT BEING AVAILABLE, WHICH POTENTIALLY PUTS US INTO CONTINUOUS DANGER. TRULY, AS A LONG-TIME CUSTOMER OF GM PRODUCTS, THIS SHOULD NOT BE THE WAY OF HOW ONE GETS TREATED; AND WE HAVE HAD THE STRONG DESIRE TO VOICE OUR DISSATISFACTION. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
TL* THE CONTACT OWNS A 2006 CHEVY COBALT. THE CONTACT BECAME INVOLVED IN A CRASH IN WHICH THE AIR BAGS DID NOT DEPLOY. THE DETAILS OF THE CRASH WERE LIMITED HOWEVER, THE CONTACT WAS TRAVELING 20 MPH WHEN THE CRASH OCCURRED. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED OF THE INCIDENT. THE CONTACT ALSO STATED THAT T…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVY COBALT. THE CONTACT BECAME INVOLVED IN A CRASH IN WHICH THE AIR BAGS DID NOT DEPLOY. THE DETAILS OF THE CRASH WERE LIMITED HOWEVER, THE CONTACT WAS TRAVELING 20 MPH WHEN THE CRASH OCCURRED. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED OF THE INCIDENT. THE CONTACT ALSO STATED THAT THE BRAKES MALFUNCTIONED. ADDITIONALLY, THE IGNITION SWITCH FAILED. THE FAILURE MILEAGE WAS 110,000.
DRIVING DOWN THE ROAD AND ALL ITEMS ON GAUGE CLUSTER DIE AND COME BACK ON OVER AND OVER AGAIN. SECURITY LIGHT POPS ON ABS LIGHT COMES ON AIR BAG LIGHT COMES ON. I LOSE POWER STEERING WHEN THIS HAPPENS AND SOMETIME VEHICLE WONT START AND MY SECURITY LIGHT POPS ON. SOMETIMES NOTHING IN MY GAUGE CLUSTER WONT WORK AND ALL WARNING L…
Read full complaint
DRIVING DOWN THE ROAD AND ALL ITEMS ON GAUGE CLUSTER DIE AND COME BACK ON OVER AND OVER AGAIN. SECURITY LIGHT POPS ON ABS LIGHT COMES ON AIR BAG LIGHT COMES ON. I LOSE POWER STEERING WHEN THIS HAPPENS AND SOMETIME VEHICLE WONT START AND MY SECURITY LIGHT POPS ON. SOMETIMES NOTHING IN MY GAUGE CLUSTER WONT WORK AND ALL WARNING LIGHTS WILL APPEAR WHEN DRIVING DOWN THE ROAD OR AS SOON AS I START MY VEHICLE. *TR
DEAR SIRS, I NO LONGER FEEL SAFE SENDING MY DAUGHTER BACK AND FORTH TO COLLEGE WITH HER CHEVY COBALT. IF SOMETHING DOES HAPPEN WITH HER CAR KNOWING WHAT I KNOW NOW.....I WILL BE THE ONE WHO IS AT BLAME. SHE WENT BACK TO COLLEGE THIS MORNING......DRIVING THE COBALT. I AM SUFFERING TO MUCH ANXIETY OVER THIS. WHY DID I LET HER…
Read full complaint
DEAR SIRS, I NO LONGER FEEL SAFE SENDING MY DAUGHTER BACK AND FORTH TO COLLEGE WITH HER CHEVY COBALT. IF SOMETHING DOES HAPPEN WITH HER CAR KNOWING WHAT I KNOW NOW.....I WILL BE THE ONE WHO IS AT BLAME. SHE WENT BACK TO COLLEGE THIS MORNING......DRIVING THE COBALT. I AM SUFFERING TO MUCH ANXIETY OVER THIS. WHY DID I LET HER GO! COULD YOU PLEASE GIVE HER A SAFER CAR TO DRIVE? ....MAYBE AT LEAST UNTIL HER CAR IS FIXED? *TR
I CALLED TWO LOCAL CHEVY DEALERSHIPS TODAY. ONE SAID THEY ARE WAITING ON INSTRUCTIONS FROM GM TO DECIDE HOW TO RESOLVE THE SITUATION. THE OTHER SAID THEIR SERVICE MANAGER IS OUT UNTIL WEDNESDAY AND ONLY THEN CAN THEY APPLY THROUGH GM FOR A LOANER CAR AND THAT PROCESS TAKES A FEW DAY. I HAVE WATCHED SOMEONE DIE IN A CAR CRASH AN…
Read full complaint
I CALLED TWO LOCAL CHEVY DEALERSHIPS TODAY. ONE SAID THEY ARE WAITING ON INSTRUCTIONS FROM GM TO DECIDE HOW TO RESOLVE THE SITUATION. THE OTHER SAID THEIR SERVICE MANAGER IS OUT UNTIL WEDNESDAY AND ONLY THEN CAN THEY APPLY THROUGH GM FOR A LOANER CAR AND THAT PROCESS TAKES A FEW DAY. I HAVE WATCHED SOMEONE DIE IN A CAR CRASH AND I DIDN'T QUITE UNDERSTAND THE SEVERITY OF THIS ISSUE UNTIL I REALIZED THAT PEOPLE HAVE BEEN KILLED. AS A ONE CAR FAMILY, GETTING TO WORK SO THAT WE CAN KEEP OUR HEAD ABOVE WATER IS ALWAYS MY MAIN PRIORITY. GM IS NOT HELPING ME, I HAVE ALSO SENT THEM THE SAME INFORMATION I AM SENDING YOU. MY HUSBAND CANNOT DRIVE THIS CAR TO WORK UNTIL THE PROBLEM IS FIXED, IT IS NOT SAFE AND WE ARE FINANCIALLY SCREWED. I HAVE DRIVEN HUNDRED OF MY CLIENTS, ALL WITH DEVELOPMENTAL DISABILITIES IN MY COBALT. GM NOT ONLY KNOWINGLY PUT MY FAMILY'S LIVES AT RISK, THEY PUT THE LIVES OF HUNDREDS OF INDIVIDUALS WITH DEVELOPMENTAL DISABILITIES AT RISK ALSO. IF YOU NEED A TEXT BOOK EXAMPLE OF THE IGNITION SWITCH ISSUE ON THE COBALT, BY ALL MEANS, COME GET MINE. IT WILL RELIABLY FAIL. *TR
Official recalls
514V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
10V073000 · Steering:electric Power Assist System
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
09V419000 · Fuel System, Gasoline:delivery:fuel Pump
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
07V014000 · Structure
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.