NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
412 reportsClear category filter106,473 miles · Jul 3, 2014
Electrical System
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT THE KEY BECAME LODGED IN THE IGNITION. THE BATTERY HAD TO BE DISCONNECTED IN ORDER TO PREVENT IT FROM DRAINING. THE DEALER REPAIRED THE VEHICLE ACCORDING TO NHTSA CAMPAIGN NUMBER: 14V171000 (ELECTRICAL SYSTEM); HOWEVER, THE FAILURE RECURRED. AS A RESULT, T…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT THE KEY BECAME LODGED IN THE IGNITION. THE BATTERY HAD TO BE DISCONNECTED IN ORDER TO PREVENT IT FROM DRAINING. THE DEALER REPAIRED THE VEHICLE ACCORDING TO NHTSA CAMPAIGN NUMBER: 14V171000 (ELECTRICAL SYSTEM); HOWEVER, THE FAILURE RECURRED. AS A RESULT, THE SHIFT INTERLOCK ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 106,473. UPDATED 10/09/14*LJ
NHTSA ODI #10607966
Mileage unknown · Jun 30, 2014
Air BagsElectrical SystemService Brakes, Hydraulic
LETTER FROM SENATOR NELSON ON BEHALF OF CONSTITUENT CONCERNING THE CHEVY RECALL ON COBALTS FOR IGNITION KEY RECALLS; HE HANDLING FOR HIS DAUGHTER, THE OWNER OF THE CAR; SEND RESPOND DIRECTLY TO SENATOR OFFICE, PLEASE REF: CONSTITUENT. *SMD THE CONSUMER STATED WHILE DRIVING, HE LOST POWER MOMENTARY. THERE WAS NO STEERING ABILIT…
Read full complaint
LETTER FROM SENATOR NELSON ON BEHALF OF CONSTITUENT CONCERNING THE CHEVY RECALL ON COBALTS FOR IGNITION KEY RECALLS; HE HANDLING FOR HIS DAUGHTER, THE OWNER OF THE CAR; SEND RESPOND DIRECTLY TO SENATOR OFFICE, PLEASE REF: CONSTITUENT. *SMD THE CONSUMER STATED WHILE DRIVING, HE LOST POWER MOMENTARY. THERE WAS NO STEERING ABILITY, AND WHEN HE APPLIED THE BRAKE, ALL THE WARNING LIGHTS ILLUMINATED ON THE DASHBOARD. THE VEHICLE THE CONTINUED AS NORMAL. HOWEVER, THE TRACTION CONTROL LIGHT AND THE BRAKE LIGHT REMAINED ON. THE DEALER INFORMED THE CONSUMER, THE BRAKE WARNING LIGHT AND ABS WERE NOT RELATED TO THE RECALL, HE THEN WENT TO A LOCAL REPAIR SHOP, WHERE THE FOUND THE ABS FUSE WAS BLOWN AND A WIRE WAS TRACED TO A SHORT IN THE IGNITION SWITCH. HOWEVER, THE PARTS WERE NOT AVAILABLE .
NHTSA ODI #10607320
115,000 miles · Jun 27, 2014
Air BagsElectrical System
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THE ENGINE FAILED TO START AFTER NUMEROUS ATTEMPTS. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. AFTER AWAITING FOUR CONSECUTIVE WEEKS THE VEHICLE WAS REPAIRED UNDER THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 14V047000 (AIR BAG, E…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THE ENGINE FAILED TO START AFTER NUMEROUS ATTEMPTS. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. AFTER AWAITING FOUR CONSECUTIVE WEEKS THE VEHICLE WAS REPAIRED UNDER THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 14V047000 (AIR BAG, ELECTRICAL SYSTEM) HOWEVER, THE FAILURE PERSISTED. THE REMEDY FAILED TO CORRECT THE PROBLEM. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 115,000. D
NHTSA ODI #10606530
75,000 miles · Jun 26, 2014
Electrical SystemService BrakesSteering
ON THE FIRST WEEK OF JUNE 2014, MY 2006 CHEVY COBALT WENT IN FOR THE SAFETY RECALL 13454 (REPLACEMENT OF IGNITION SWITCH). (THIS WAS THE SECOND RECALL THIS CAR HAS HAD.) ON JUNE 19TH, 2014 WITH THE NEW IGNITION SWITCH INSTALLED BY THE LOCAL CHEVY DEALERSHIP, WHILE DRIVING THE CAR IN TOWN, AT SPEEDS OF 20 AND 30 MPH THE CAR L…
Read full complaint
ON THE FIRST WEEK OF JUNE 2014, MY 2006 CHEVY COBALT WENT IN FOR THE SAFETY RECALL 13454 (REPLACEMENT OF IGNITION SWITCH). (THIS WAS THE SECOND RECALL THIS CAR HAS HAD.) ON JUNE 19TH, 2014 WITH THE NEW IGNITION SWITCH INSTALLED BY THE LOCAL CHEVY DEALERSHIP, WHILE DRIVING THE CAR IN TOWN, AT SPEEDS OF 20 AND 30 MPH THE CAR LOST POWER TO STEERING, BRAKES WHICH MADE DIFFICULT EVEN TO STOP AND MANEUVER SAFELY OFF THE ROAD. THE CAR LOST MOST OF THE ENGINE PERFORMANCE BUT STAYED RUNNING. THE CAR WAS THEN TURNED OFF AND RESTARTED, WITH DASH LIGHT WARNINGS OF ENGINE LIGHT, TC LIGHT AND A CAR SECURITY EMBLEM LIGHT ON. THE CAR RAN WITH VERY LIMITED POWER AND STRANGE CLICKING NOISE WHICH WAS COMING FROM THE SHIFTER. I HAVE CELL PHONE VIDEO OF THE SHIFTER NOB CLICKING ALONG WITH CELL PICTURE OF THE DASH WARNING LIGHTS THAT ARE ON. CAR HAD TO BE "MAN HANDLED" TO GET IT TO A SAFE DESTINATION. THE BATTERY WAS DISCONNECTED A THEN RECONNECTED, WITH THE THOUGHT OF RESETTING COMPUTER. WHEN BATTERY WAS RECONNECTED THE CAR WAS 100% BACK TO NORMAL. FOR HOW LONG, IS ANYONE GUESS, THIS STRANGE OCCURRENCE HAS HAPPENED MORE THAN ONCE. THE CAR IS SCHEDULED TO GO TO THE CHEVY DEALERSHIP FOR FURTHER DIAGNOSTICS. THEY INFORMED THAT IT WILL BE A WEEK OR SO BECAUSE THEIR ALL BOOKED UP. WHAT A PAIN IN THE (YOU FILL THE BLANK). IF I HAD ENOUGH $$ TO REPLACE THE CAR, I WOULD HAVE THIS CAR CRUSHED SO THAT I WOULD NO LONGER BE RESPONSIBLE FOR ANY ACCIDENTS IT MAY CAUSE. *TR
NHTSA ODI #10606338
74,000 miles · Jun 26, 2014
Electrical SystemSteering
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED HIS VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBERS: 14V171000 (ELECTRICAL SYSTEM) 14V047000 (AIR BAGS, ELECTRICAL SYSTEM) HOWEVER, IMMEDIATELY AFTER THE REPAIRS THE KEY FAILED TO COME OUT OF THE IGNITION SWITCH. THE FAILURE WAS BROUGHT UP TO THE SERVICE MANAGER'…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED HIS VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBERS: 14V171000 (ELECTRICAL SYSTEM) 14V047000 (AIR BAGS, ELECTRICAL SYSTEM) HOWEVER, IMMEDIATELY AFTER THE REPAIRS THE KEY FAILED TO COME OUT OF THE IGNITION SWITCH. THE FAILURE WAS BROUGHT UP TO THE SERVICE MANAGER'S ATTENTION BUT HE DECLINED TO REPAIR THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 74,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10606145
Mileage unknown · Jun 25, 2014
Air BagsElectrical System
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT RECEIVED A RECALL NOTIFICATION UNDER NHTSA CAMPAIGN ID NUMBER 14V047000 (AIR BAGS, ELECTRICAL SYSTEM). HOWEVER, THE PART WAS NOT AVAILABLE TO DO THE REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #10605975
Mileage unknown · Jun 25, 2014
Air BagsElectrical System
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT RECEIVED A NOTIFICATION FOR RECALL NHTSA CAMPAIGN NUMBER: 14V047000 (AIR BAGS, ELECTRICAL SYSTEM). THE CONTACT MENTIONED THAT AFTER THE RECALL REPAIRS WERE PERFORMED THE KEY WOULD WORK IN THE IGNITION SWITCH BUT FAILED TO UNLOCK THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. …
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT RECEIVED A NOTIFICATION FOR RECALL NHTSA CAMPAIGN NUMBER: 14V047000 (AIR BAGS, ELECTRICAL SYSTEM). THE CONTACT MENTIONED THAT AFTER THE RECALL REPAIRS WERE PERFORMED THE KEY WOULD WORK IN THE IGNITION SWITCH BUT FAILED TO UNLOCK THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10605971
93,805 miles · Jun 25, 2014
Electrical SystemPower TrainCrash
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE PARKED IN A RESIDENTIAL GARAGE, THE VEHICLE STARTED ROLLING BACKWARDS AND THE DRIVER DOOR CRASHED INTO THE WALL. THERE WERE NO INJURIES WERE REPORTED. ALSO, THE CONTACT MENTIONED THAT SHE WAS ABLE TO REMOVE THE KEY OUT OF THE IGNITION SWITCH WHILE THE VE…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE PARKED IN A RESIDENTIAL GARAGE, THE VEHICLE STARTED ROLLING BACKWARDS AND THE DRIVER DOOR CRASHED INTO THE WALL. THERE WERE NO INJURIES WERE REPORTED. ALSO, THE CONTACT MENTIONED THAT SHE WAS ABLE TO REMOVE THE KEY OUT OF THE IGNITION SWITCH WHILE THE VEHICLE WAS IN PARK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 93,805. UPDATED 10/7/14*CN THE CONSUMER STATED THE STEREO HAS HAD MANY PROBLEMS, IT FAILED INTERMITTENTLY. TAKING THE KEY OUT OF THE IGNITION WAS DIFFICULT AND STRANGE NOISES COULD BE HEARD UPON ATTEMPTING TO DO SO. THERE WERE ALSO TO INCIDENTS THAT WHILE DRIVING THE VEHICLE WOULD LOSE ALL POWER. UPDATED 5/13/2015 *JS
NHTSA ODI #10605873
94,548 miles · Jun 25, 2014
Electrical SystemElectronic Stability Control (esc)Steering
DRIVING ON HIGHWAY AND HEARD THREE DINGS AND MY CAR FLASHES POWER STEERING, IT WAS DIFFICULT TO STEERING TO THE NEXT LANE TO TRY AND GET OFF THE FREEWAY THEN IT JUST SUDDENLY STARTED WORKING FINE. BUT NOW I'M WORRIED THAT IT WILL HAPPEN AGAIN. I'VE RECEIVED TWO LETTER ABOUT THE RECALL BUT NO DEALER IN MY AREA HAS THE PARTS, WAS …
Read full complaint
DRIVING ON HIGHWAY AND HEARD THREE DINGS AND MY CAR FLASHES POWER STEERING, IT WAS DIFFICULT TO STEERING TO THE NEXT LANE TO TRY AND GET OFF THE FREEWAY THEN IT JUST SUDDENLY STARTED WORKING FINE. BUT NOW I'M WORRIED THAT IT WILL HAPPEN AGAIN. I'VE RECEIVED TWO LETTER ABOUT THE RECALL BUT NO DEALER IN MY AREA HAS THE PARTS, WAS TOLD I'D BE CALLED WHEN THEY ARRIVE. *TR
NHTSA ODI #10605831
Mileage unknown · Jun 23, 2014
Air BagsElectrical System
TL ' THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V047000 (AIR BAGS, ELECTRICAL); HOWEVER, THE PART WAS UNAVAILABLE FOR THE REPAIR. THE MANUFACTURER WAS NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. JCC
NHTSA ODI #10605205
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration