NHTSA owner reports · September 18, 2026 snapshot.
Air Bags complaints
146 reportsClear category filterMileage unknown · Mar 27, 2015
Air BagsElectrical System
TL*THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT THE KEY BECAME STUCK IN THE IGNITION SWITCH AND RELEASED AFTER NUMEROUS ATTEMPTS. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V047000 (AIR BAGS , ELECTRICAL SYSTEM). AFTER THE RECALL REMEDY WAS PERFORMED THE IGNITION KEY WOULD ONLY RELEAS…
Read full complaint
TL*THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT THE KEY BECAME STUCK IN THE IGNITION SWITCH AND RELEASED AFTER NUMEROUS ATTEMPTS. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V047000 (AIR BAGS , ELECTRICAL SYSTEM). AFTER THE RECALL REMEDY WAS PERFORMED THE IGNITION KEY WOULD ONLY RELEASED WHEN THE STEERING COLUMN BUTTON KEY RELEASE WAS ENGAGED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.
NHTSA ODI #10702109
90,000 miles · Mar 23, 2015
Air BagsElectrical System
I HAVE READ ON MULTIPLE FORUMS ONE BEING, HTTP://WWW.CARPROBLEMZOO.COM/CHEVROLET/COBALT/AIR-BAG-LIGHT-ON-PROBLEMS.PHP ASIDE FROM JUST ONE WEBSITE BEING EVIDENT OF REPORTS FOR MY REQUEST I TO HAVE FOUND THAT MY VEHICLE'S AIR BAG LIGHT TURNS ON WHEN THERE IS NO ONE IN THE SEAT (PASSENGER) AS WELL AS TURNS OFF WHEN THERE ARE PERS…
Read full complaint
I HAVE READ ON MULTIPLE FORUMS ONE BEING, HTTP://WWW.CARPROBLEMZOO.COM/CHEVROLET/COBALT/AIR-BAG-LIGHT-ON-PROBLEMS.PHP ASIDE FROM JUST ONE WEBSITE BEING EVIDENT OF REPORTS FOR MY REQUEST I TO HAVE FOUND THAT MY VEHICLE'S AIR BAG LIGHT TURNS ON WHEN THERE IS NO ONE IN THE SEAT (PASSENGER) AS WELL AS TURNS OFF WHEN THERE ARE PERSON'S IN THE SEAT. NOT ONLY THAT, BUT AT RANDOM TIMES ON THE MAIN CONSOLE WHILE DRIVING, IT WILL SAY "SERVICE AIR BAG" WHILE ALSO ILLUMINATING THE RED AIR BAG DISPLAY ON THE DRIVER'S HUD (ASSUMING THAT IS FOR THE DRIVER'S AIR BAG) PLEASE PLEASE LOOK INTO THIS. PREFERABLY THE PASSENGER SIDE, IT WOULD BE NICE TO HAVE THE AIR BAG ON AT ALL TIMES OR TO ALLOW THE DRIVER/PASSENGER TO TURN IT ON OR OFF. I HAVE CALLED SEVERAL MECHANICS AT CHEVY DEALERSHIPS WHO ALL SAY THEY CAN'T JUST TURN IT ON AND TO SERVICE IT THEY WOULD ONLY MAKE THE SEAT SENSOR MORE SENSITIVE, I DON'T BELIEVE THAT WILL SOLVE THIS ISSUE. AS FAR AS I KNOW THE AIR BAG WON'T DEPLOY WHEN THE "SERVICE AIR BAG" SHOWS UP. *TR
NHTSA ODI #10701015
116,427 miles · Mar 11, 2015
Air BagsEngineSteering
STARTING ON SUNDAY I WAS DRIVING DOWN THE HIGHWAY AND MY CAR SUDDENLY SHUT OFF. THE POWER STEERING LIGHT FLASHED AND THEN THE SERVICE AIR BAG LIGHT AS WELL. I PULLED OVER, STOPPED COMPLETELY, AND TURNED MY CAR BACK ON AND TOOK THE BACK ROADS HOME. AFTER TURNING THE CAR BACK ON THE WARNING LIGHTS ON THE DISPLAY WERE GONE. THE NEX…
Read full complaint
STARTING ON SUNDAY I WAS DRIVING DOWN THE HIGHWAY AND MY CAR SUDDENLY SHUT OFF. THE POWER STEERING LIGHT FLASHED AND THEN THE SERVICE AIR BAG LIGHT AS WELL. I PULLED OVER, STOPPED COMPLETELY, AND TURNED MY CAR BACK ON AND TOOK THE BACK ROADS HOME. AFTER TURNING THE CAR BACK ON THE WARNING LIGHTS ON THE DISPLAY WERE GONE. THE NEXT DAY I WAS ON A DIFFERENT HIGHWAY AND THE SAME THING HAPPENED EXCEPT WHEN I TURNED MY CAR BACK ON THE SERVICE AIR BAG LIGHT STAYED ON UNTIL I RETURNED HOME. I HAD THE RECALL ON THE IGNITION SWITCH REPLACED LAST YEAR. *TR
NHTSA ODI #10693442
85,685 miles · Jan 20, 2015
Air Bags
WHEN THE COMPANY RECALLED THE IGNITION SWITCH, WHICH AFFECTS THE AIRBAG SYSTEM, WE TOOK THE VEHICLE IN FOR SERVICE AND THEY REPLACED THE IGNITION SWITCH BUT DIDN'T FIX THE AIRBAG SYSTEM PROBLEM. IN THE VEHICLE'S DASHBOARD DISPLAY SCREEN THE SERVICE AIRBAG LIGHT IS STILL ON. THE MECHANIC SAID IT WASN'T RELATED. HE WROTE ON THE…
Read full complaint
WHEN THE COMPANY RECALLED THE IGNITION SWITCH, WHICH AFFECTS THE AIRBAG SYSTEM, WE TOOK THE VEHICLE IN FOR SERVICE AND THEY REPLACED THE IGNITION SWITCH BUT DIDN'T FIX THE AIRBAG SYSTEM PROBLEM. IN THE VEHICLE'S DASHBOARD DISPLAY SCREEN THE SERVICE AIRBAG LIGHT IS STILL ON. THE MECHANIC SAID IT WASN'T RELATED. HE WROTE ON THE SERVICE INVOICE FOR THE IGNITION SWITCH RECALL, "AIR BAG WARNING RELATED TO NO COMMUNICATION FROM AIRBAG MODULE".
NHTSA ODI #10676686
100,098 miles · Nov 13, 2014
Air Bags
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT THERE WAS AN ABNORMAL NOISE COMING FROM THE VEHICLE. THE CONTACT ALSO STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V171000 (ELECTRICAL SYSTEM) BUT THE FAILURE PERSISTED. THE …
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT THERE WAS AN ABNORMAL NOISE COMING FROM THE VEHICLE. THE CONTACT ALSO STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V171000 (ELECTRICAL SYSTEM) BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 100,098.
NHTSA ODI #10654795
32,150 miles · Nov 11, 2014
Air BagsElectrical SystemService Brakes
I HAVE OWNED MY 2006 CHEVY COBALT SINCE 2008. STARTING IN 2009 ALL THE WAY UNTIL NOW 2014 I HAVE HAD ISSUES WITH THE CAR THAT ARE RELATED TO THE IGNITION SWITCH RECALL. I TOOK MY CAR IN TO THE CHEVY DEALER TO TAKE CARE OF THE IGNITION SWITCH RECALL ON NOVEMBER 5, 2014. I GOT MY CAR BACK THE SAME DAY, THEY REPLACED THE IGNITION S…
Read full complaint
I HAVE OWNED MY 2006 CHEVY COBALT SINCE 2008. STARTING IN 2009 ALL THE WAY UNTIL NOW 2014 I HAVE HAD ISSUES WITH THE CAR THAT ARE RELATED TO THE IGNITION SWITCH RECALL. I TOOK MY CAR IN TO THE CHEVY DEALER TO TAKE CARE OF THE IGNITION SWITCH RECALL ON NOVEMBER 5, 2014. I GOT MY CAR BACK THE SAME DAY, THEY REPLACED THE IGNITION SWITCH AND GAVE ME TWO NEW KEYS. SURPRISE! TWO DAYS LATER ON NOVEMBER 7, 2014 MY CAR AGAIN HAD THE EXACT SAME PROBLEMS RELATED TO THE IGNITION SWITCH RECALL THAT IT DID BEFORE I TOOK IT IN FOR THE RECALL FIX. HENCE, CHEVY'S "RECALL IGNITION SWITCH FIX" DOES NOT SOLVE THE PROBLEM WITH THESE CARS! MY CAR STILL DOES THE FOLLOWING THINGS EVEN AFTER THE IGNITION SWITCH FIX THAT IS SUPPOSED TO SOLVE THESE PROBLEMS. WHENEVER IT PLEASES IT WILL LOSE ELECTRICAL POWER AND TURN OFF THE ENGINE, LEAVING ME STUCK IN THE MIDDLE OF A BUSY HIGHWAY, THIS HAS HAPPENED ON NUMEROUS OCCASIONS!! AS IF THAT ISN'T BAD ENOUGH THERE'S MORE! THE POWER STEERING LIGHT FLASHES, THE CHECK ENGINE LIGHT COMES ON, THE SERVICE AIRBAG LIGHT COMES ON, THE GAUGES ON THE DASH COMPLETELY STOP WORKING PROPERLY THE SPEEDOMETER NEEDLE GOES HAYWIRE MOVING FROM 0 MPH TO 60 MPH BACK AND FORTH NON-STOP WHEN I'M NOT EVEN ACCELERATING TO THOSE SPEEDS. THE RPM GAUGE DOES THE EXACT SAME THING. THE CAR JOLTS FORWARD UNCONTROLLABLY,LIKE IT IS HAVING A PROBLEM SHIFTING ESPECIALLY WHEN THE RPM IS BETWEEN 2000 AND 3000. WHEN YOU GO TO BRAKE YOU HAVE TO SLAM THE BRAKES ALL THE WAY DOWN BECAUSE YOU LOSE YOUR NORMAL BRAKING POWER THE CAR SKIDS AS YOU'RE BRAKING AND CONTINUES TO JOLT FORWARD UNCONTROLLABLY. OH AND ON TOP OF ALL OF THIS SOMETIMES THE POWER STEERING COMPLETELY GOES OUT LEAVING YOU WITH ALL OF THE PROBLEMS MENTIONED ABOVE AND YOU CAN'T STEER PROPERLY! SOMETHING NEEDS TO BE DONE IMMEDIATELY! THE IGNITION SWITCH RECALL FIX DOES NOT WORK! THESE CARS SHOULD NOT BE ON THE ROAD PERIOD. *TR
NHTSA ODI #10654168
101,000 miles · Nov 6, 2014
Air BagsEngineCrashInjury
I WAS DRIVING THE CAR AT ABOUT 32 MPH WHEN THE ENGINE SHUT DOWN. I TRAVELED ACROSS FOUR LANES HITTING THE CURB HEAD ON THEN HITTING A CONCRETE FLOWER BED( APPROXIMATE HIT 12-14 INCHES), TRAVELING OVER THIS AGAIN HITTING A CURB IN A PARKING LOT AND THEN THE CAR CAME TO A REST. THE AIRBAGS DID NOT DEPLOY AND THE CAR WAS NOT RUNN…
Read full complaint
I WAS DRIVING THE CAR AT ABOUT 32 MPH WHEN THE ENGINE SHUT DOWN. I TRAVELED ACROSS FOUR LANES HITTING THE CURB HEAD ON THEN HITTING A CONCRETE FLOWER BED( APPROXIMATE HIT 12-14 INCHES), TRAVELING OVER THIS AGAIN HITTING A CURB IN A PARKING LOT AND THEN THE CAR CAME TO A REST. THE AIRBAGS DID NOT DEPLOY AND THE CAR WAS NOT RUNNING. THIS IS NOT THE FIRST TIME THE CAR HAS STOPPED RUNNING LIKE THIS. WHEN I FIRST PURCHASED IT IN FEBRUARY 0F 2006 WITHIN THE FIRST WEEK THE IGNITION WOULD NOT TURN OVER REQUIRING A TRIP TO THE DEALERSHIP. THE IGNITION HAS BEEN REPLACED AT LEAST 5 TIMES. ABOUT THREE MONTHS INTO OWING IT I WAS DRIVING DOWN THE ROAD AND THE ENGINE WAS TRYING TO RESTART IT SELF. IT THEN STOPPED AND I ENDED UP IN A DITCH. AGAIN THE AIRBAGS DID NOT DEPLOY. FINALLY, IN 2012 A SCHOOL BUS BACKED INTO THE FRONT OF THE CAR WITH IT RUNNING AND THE AIRBAGS DID NOT DEPLOY. THE IGNITON WAS REPLACED ON 6/04/2014 UNDER THE MANDATORY RECALL. WITHIN 3 DAYS THE IGNITION ONCE AGAIN WOULD NOT TURN ON AND THEN WHEN IT DID THE ENGINE DRAGGED AS IF THE BATTERY WAS BAD. THE BATTERY IS ONE YEAR OLD. I HAVE HAD THIS PROBLEM NON-STOP SINCE THE REPLACEMENT PART. I CALLED GRAFF CHEVROLET IN MT. PLEASANT AND I GOT THE STANDARD RESPONSE, "WE CAN"T DUPLICATE IT". WHEN I INSISTED THE CAR NEEDED TO BE LOOKED AT I WAS TOLD, WE HAVE THE RIGHT TO REFUSE SERVICE AND WE CAN NO LONGER SERVICE YOUR CAR". I'VE CALLED OTHER DEALERSHIPS ONLY TO BE TOLD THE CAR NEEDS TO GO BACK TO WHERE THE RECALL PART WAS REPLACED. *TR
NHTSA ODI #10653003
75,000 miles · Oct 21, 2014
Air Bags
MY VEHICLE AIRBAG WARNING LIGHT HAS BEEN ON FOR YEARS. GM HAS REFUSED TO COVER THE COST TO REPAIR IT, STATING IT WAS MY RESPONSIBILITY, EVEN THO THE AIRBAG HAS NEVER DEPLOYED. THE WARNING LIGHT BEING ON INDICATES THAT IF I NEED THE AIRBAG IT WILL NOT DEPLOY. THEY ISSUED A RECALL AND MY CAR WASN'T INCLUDED IN IT. *TR
NHTSA ODI #10649103
48,000 miles · Sep 9, 2014
Air Bags
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT THE AIR BAG INDICATOR ILLUMINATED AFTER THE VEHICLE WAS REPAIRED ACCORDING TO NHTSA CAMPAIGN NUMBER: 14V171000 (ELECTRICAL SYSTEM). THE DEALER STATED THAT THE AIR BAG MODULE NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT STATED THAT THE AIR BAG INDICATOR ILLUMINATED AFTER THE VEHICLE WAS REPAIRED ACCORDING TO NHTSA CAMPAIGN NUMBER: 14V171000 (ELECTRICAL SYSTEM). THE DEALER STATED THAT THE AIR BAG MODULE NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 48,000.
NHTSA ODI #10631972
Mileage unknown · Sep 4, 2014
Air BagsElectrical System
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT RECEIVED A NOTIFICATION FOR RECALL NHTSA CAMPAIGN NUMBER: 14V047000 (AIR BAGS, ELECTRICAL SYSTEM) AND NHTSA CAMPAIGN NUMBER: 14V171000 (ELECTRICAL SYSTEM). HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE A…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET COBALT. THE CONTACT RECEIVED A NOTIFICATION FOR RECALL NHTSA CAMPAIGN NUMBER: 14V047000 (AIR BAGS, ELECTRICAL SYSTEM) AND NHTSA CAMPAIGN NUMBER: 14V171000 (ELECTRICAL SYSTEM). HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED THE FAILURE.
NHTSA ODI #10630613
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration