NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,649 reports157,000 miles · Mar 26, 2014
Steering
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH, THE STEERING WHEEL FRACTURED WHILE THE CONTACT WAS MAKING A TURN INTO A PARKING SPACE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 157,000.…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH, THE STEERING WHEEL FRACTURED WHILE THE CONTACT WAS MAKING A TURN INTO A PARKING SPACE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 157,000.
NHTSA ODI #10574981
154,000 miles · Mar 25, 2014
Electrical System
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED THAT THE VEHICLE STALLED WHILE DRIVING 45 MPH. THE FAILURE WAS RECURRING. THE VEHICLE WAS TAKEN FOR UNKNOWN REPAIRS HOWEVER, THE FAILURE WAS NOT CORRECTED. THE FAILURE MILEAGE WAS 154,000.
NHTSA ODI #10574750
139,671 miles · Mar 19, 2014
Electrical SystemSteering
THERE IS NO ACCIDENT INCIDENT IN THIS REPORT. I DID RECEIVE THE COBALT NOTICE ABOUT THE "KEY IN THE IGNITION SWITCH MAY MOVE OUT OF THE 'RUN' POSITION" LETTER AND I FEEL I SHOULD REPORT ANOTHER PROBLEM WITH THE IGNITION SWITCH THAT MAY ALSO BE A SAFETY ISSUE. HOWEVER, I HAVE NOT EXPERIENCED ANY ADVERSE IMPACT OF THE CONDIT…
Read full complaint
THERE IS NO ACCIDENT INCIDENT IN THIS REPORT. I DID RECEIVE THE COBALT NOTICE ABOUT THE "KEY IN THE IGNITION SWITCH MAY MOVE OUT OF THE 'RUN' POSITION" LETTER AND I FEEL I SHOULD REPORT ANOTHER PROBLEM WITH THE IGNITION SWITCH THAT MAY ALSO BE A SAFETY ISSUE. HOWEVER, I HAVE NOT EXPERIENCED ANY ADVERSE IMPACT OF THE CONDITION I AM ABOUT TO DESCRIBE BELOW. I AM REPORTING THIS BECAUSE IT MIGHT BE AN ISSUE FOR OTHERS AND THAT HOPEFULLY MAY BE FIXED BY THE LATEST COBALT IGNITION SWITCH RECALL. FOR A COUPLE YEARS I HAVE NOTICED THAT AFTER I START THE COBALT AND LET THE KEY MOVE BACK TO THE RUN POSITION THAT I CAN REMOVE THE KEY COMPLETELY FROM THE IGNITION SWITCH AND PUT THE KEY IN MY POCKET AND THE CAR CONTINUES TO RUN. I HAVE ONLY DONE THIS WHILE THE CAR IS NOT MOVING. I NOTICED THAT THE STEERING WHEEL DOES NOT LOCK UP IN THIS CASE, SO THEORETICALLY I COULD DRIVE AND STEER THE CAR WHILE IT IS MOVING ON THE ROAD WITHOUT A PROBLEM. HOWEVER, I DON'T WANT TO TEST THAT POSSIBILITY, BECAUSE THE THOUGHT IS SCARY. SO IF THIS INFORMATION CAN HELP OTHERS AVOID AN ACCIDENT WHEN THE IGNITION SWITCHED IS REPLACED, THIS REPORT WILL BE WORTHWHILE. I AM NOW DRIVING THE COBALT WITHOUT ANY ATTACHMENTS TO THE IGNITION KEY AND AM WAITING TO BRING THE CAR IN FOR THE IGNITION AND POWER STEERING RECALL. I AM EXPECTING THAT THE REPLACEMENT IGNITION SWITCH WILL ALSO FIX THE PROBLEM OF BEING ABLE TO REMOVE THE IGNITION KEY IN THE SWITCH WHEN IT WAS IN THE IN THE RUN POSITION. IF YOU WANT ME TO SEND YOU A PICTURE OF THE KEY REMOVED FROM THE IGNITION SWITCH WHILE THE TACHOMETER SHOWS THAT THE ENGINE IS RUNNING, LET ME KNOW. *TR
NHTSA ODI #10573610
158,000 miles · Mar 19, 2014
Electrical SystemSteering
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE SUDDENLY STALLED. THE ENGINE WAS RESTARTED AND THE VEHICLE OPERATED NORMALLY. THE CONTACT ALSO INDICATED THAT THE POWER STEERING MALFUNCTIONED AND MADE THE STEERING WHEEL VERY DIFFICULT TO TURN. IN ADDITION, THE …
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE SUDDENLY STALLED. THE ENGINE WAS RESTARTED AND THE VEHICLE OPERATED NORMALLY. THE CONTACT ALSO INDICATED THAT THE POWER STEERING MALFUNCTIONED AND MADE THE STEERING WHEEL VERY DIFFICULT TO TURN. IN ADDITION, THE KEY BECAME STUCK IN THE IGNITION SWITCH AND WAS UNABLE TO BE REMOVED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 158,000.
NHTSA ODI #10573584
31,000 miles · Mar 19, 2014
Air BagsElectrical System
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE STALLED AS THE POWER STEERING WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEH…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE STALLED AS THE POWER STEERING WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE APPROXIMATE FAILURE MILEAGE WAS 31,000 AND THE CURRENT MILEAGE WAS 71,155.
NHTSA ODI #10573579
151,894 miles · Mar 19, 2014
Electrical SystemElectronic Stability Control (esc)
I WENT TO CRANK MY VEHICLE THEN PROCEEDED TO PUT IT INTO DRIVE TO TAKE OFF, BUT I HAD NO POWER NOTHING. TURNED MY KEY OVER TO RECRANK AND IT CRANK WITH NO PROBLEM. THIS TIME ALLOWING ME TO TAKE OFF AND DRIVE. NOW IF I HAVE THE KEY IN THE IGNITION AND TURN IT TO THE ON POSITION IT SPUTTERS FOR ATLEAST 50 TO 60 SECS BEFORE CRANKIN…
Read full complaint
I WENT TO CRANK MY VEHICLE THEN PROCEEDED TO PUT IT INTO DRIVE TO TAKE OFF, BUT I HAD NO POWER NOTHING. TURNED MY KEY OVER TO RECRANK AND IT CRANK WITH NO PROBLEM. THIS TIME ALLOWING ME TO TAKE OFF AND DRIVE. NOW IF I HAVE THE KEY IN THE IGNITION AND TURN IT TO THE ON POSITION IT SPUTTERS FOR ATLEAST 50 TO 60 SECS BEFORE CRANKING. *TR
NHTSA ODI #10573491
9,000 miles · Mar 19, 2014
Electrical System
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND RESUME DRIVING. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE …
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND RESUME DRIVING. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 9,000.
NHTSA ODI #10573462
31,000 miles · Mar 19, 2014
Suspension
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, THERE WAS AN ABNORMAL NOISE COMING FROM THE FRONT END OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE PASSENGER AND DRIVER'S SIDE FRONT LOWER CONTROL ARM WAS DEFECTIVE AND NEEDED T…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, THERE WAS AN ABNORMAL NOISE COMING FROM THE FRONT END OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE PASSENGER AND DRIVER'S SIDE FRONT LOWER CONTROL ARM WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 31,000 AND THE CURRENT MILEAGE WAS 31,500.
NHTSA ODI #10573439
100,000 miles · Mar 18, 2014
Air BagsElectrical System
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED THAT THE IGNITION MODULE FAILED AND CAUSED THE VEHICLE TO STALL SPORADICALLY AND WITHOUT WARNING. THE FAILURE WAS RECURRING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TWICE, WHO WAS UNABLE TO DIAGNOSE THE FAILURE BOTH TIMES. THE VEHICLE WAS NOT REPAIRED. THE…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED THAT THE IGNITION MODULE FAILED AND CAUSED THE VEHICLE TO STALL SPORADICALLY AND WITHOUT WARNING. THE FAILURE WAS RECURRING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TWICE, WHO WAS UNABLE TO DIAGNOSE THE FAILURE BOTH TIMES. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER:14V047000 (AIR BAGS , ELECTRICAL SYSTEM) AFTER THE FAILURE AND WAS AWAITING THE PARTS NEEDED TO REPAIR THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
NHTSA ODI #10573192
39,000 miles · Mar 17, 2014
Steering
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER 10V073000 (STEERING) WAS PERFORMED HOWEVER, THE VEHICLE STALLED NUMEROUS TIMES AFTER THE REPAIRS. ADDITIONALLY, THE VEHICLE EXHIBITED AN ABNORMAL AND SPORADIC CLICKING NOISE. THE INSTRUMENT PANEL LIGHTS WERE ABNORMALLY DIM AND THE TRANSM…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER 10V073000 (STEERING) WAS PERFORMED HOWEVER, THE VEHICLE STALLED NUMEROUS TIMES AFTER THE REPAIRS. ADDITIONALLY, THE VEHICLE EXHIBITED AN ABNORMAL AND SPORADIC CLICKING NOISE. THE INSTRUMENT PANEL LIGHTS WERE ABNORMALLY DIM AND THE TRANSMISSION EXHIBITED A LOUD NOISE. THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 39,000.
NHTSA ODI #10572761
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Nov 22, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE BULB SHIELDS INSIDE OF THE HEADLAMPS CAN LOOSEN DUE TO VIBRATION.
Consequence & remedy
Consequence: THE BULB SHIELD CAN LOOSEN OR BREAK BECAUSE OF VIBRATION. IF THIS OCCURRED ON A HEADLAMP INSTALLED IN A VEHICLE, ONCOMING DRIVERS MAY NOTICE ADDITIONAL GLARE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL TWO NEW HEADLAMP ASSEMBLIES. THE RECALL BEGAN ON NOVEMBER 17, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration