IllustrationI HAD SEVERE POWER STEERING FAILURE AND MY MAP SENSOR IS ALSO DEFECTIVE EVEN THOUGH IT HAS BEEN REPLACED TWICE. I HAVE A VERY LOW MPG ITS A 15MPG AT BEST. MY CAR ALSO ACCELERATES WITHOUT MY FOOT ON THE PEDAL AND I HAVE HAD SEVERE BRAKE FAILURE , TO THE EXTENT THAT I HAVE HAD TO USE MY HAND BRAKE TO STOP. *TR
2005 Chevrolet Cobalt
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cobalt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1780–25K
29325–50K
41350–75K
22775–100K
198100–150K
98150K+
1,407 reports with mileage · 242 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 1,143 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 323 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 99 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
97 crash reports12 fire reports57 injury reports
Vehicle Speed Control complaints
40 reportsTL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. SHE STATED THAT WHILE DRIVING 5 MPH WITH HER FOOT HER ON THE BRAKE PEDAL, THE VEHICLE ACCELERATED ON ITS OWN. SHE THEN LOST ALL POWER TO THE VEHICLE INCLUDING THE STEERING WHICH MADE IT VERY DIFFICULT TO CONTROL THE STEERING WHEEL. SHE APPLIED THE EMERGENCY BRAKE IN ORDER TO STOP THE…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. SHE STATED THAT WHILE DRIVING 5 MPH WITH HER FOOT HER ON THE BRAKE PEDAL, THE VEHICLE ACCELERATED ON ITS OWN. SHE THEN LOST ALL POWER TO THE VEHICLE INCLUDING THE STEERING WHICH MADE IT VERY DIFFICULT TO CONTROL THE STEERING WHEEL. SHE APPLIED THE EMERGENCY BRAKE IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER. THEY WERE UNABLE TO DUPLICATE, DIAGNOSE OR REPAIR THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 42312.
I HAVE A 2005 CHEVY COBALT AND PERIODICALLY IT STARTS SHIFTING REALLY HARD AND THE POWER STEERING GOES! I HAVE TO STOP THE CAR, SHUT IT OFF, LET IT SIT, START IT, SHUT IT OFF, REPEAT THREE TIMES, THEN IT IS OKAY FOR A WHILE. *TR
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING 70 MPH ON THE FREEWAY, THE "REDUCE ENGINE SPEED" INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE SHIFTED INTO LOW GEAR AND THE CONTACT COULD NOT ACCELERATE BEYOND 40 MPH, WHICH SHE CONSIDERED VERY DANGEROUS ON A HIGHWAY ALLOWING 70 MPH SPEEDS. THE VEHICLE B…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING 70 MPH ON THE FREEWAY, THE "REDUCE ENGINE SPEED" INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE SHIFTED INTO LOW GEAR AND THE CONTACT COULD NOT ACCELERATE BEYOND 40 MPH, WHICH SHE CONSIDERED VERY DANGEROUS ON A HIGHWAY ALLOWING 70 MPH SPEEDS. THE VEHICLE BEGAN OPERATING NORMALLY. PRIOR TO THE FAILURE, SHE NOTICED THAT THE VEHICLE BEGAN STALLING WHEN SHE WOULD SLOW DOWN AT TRAFFIC LIGHTS OR STOP SIGNS. OCCASIONALLY, THE CONTACT WOULD HAVE TO SHIFT THE VEHICLE INTO NEUTRAL SO THAT IT COULD PERFORM CORRECTLY. ON THREE OCCASIONS, A MECHANIC STATED THAT MULTIPLE CODES WERE PRESENT AFTER DIAGNOSING THE VEHICLE. THE MANUFACTURER STATED THAT THERE WAS NO RELEVANT RECALL TO-DATE. THE CURRENT MILEAGE WAS APPROXIMATELY 82,000 AND FAILURE MILEAGE WAS APPROXIMATELY 80,000. UPDATED 4/23/09 *CN UPDATED 04/27/09*JB
I WAS TRAVELING HOME FROM WORK YESTERDAY WHEN A CAME UPON A SLOW VEHICLE GOING AT 55 MPH. I WAS GOING AT 65 MPH. I TURNED OFF THE CRUISE CONTROL WHEN I CAME UPON THE SLOW VEHICLE AND SOME ONCOMING TRAFFIC WENT BY. WHEN IT WAS CLEAR I STARTED ACCELERATING TO PASS THE SLOW VEHICLE. AS I WAS ACCELERATING THE GAS PEDAL COMPLETE…
Read full complaint
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
1) MONTHS PRIOR TO THE ACCIDENT AT HIGH WAY SPEED (65 TO 75 MPH) AFTER SEVERAL HOUR (FROM 1 TO 4) WITH THE CRUISE CONTROL ENGAGED, WHEN DISENGAGING THE CRUISE CONTROL, THE CAR WOULD VIBRATE VIOLENTLY. GM CLAIMS THEY CAN NOT DUPLICATE THE PROBLEM. 2) BRAKES FAILED - APPLIED BRAKES IN TRAFFIC, PEDAL WAS SOFT AND THEN WENT HARD L…
Read full complaint
1) MONTHS PRIOR TO THE ACCIDENT AT HIGH WAY SPEED (65 TO 75 MPH) AFTER SEVERAL HOUR (FROM 1 TO 4) WITH THE CRUISE CONTROL ENGAGED, WHEN DISENGAGING THE CRUISE CONTROL, THE CAR WOULD VIBRATE VIOLENTLY. GM CLAIMS THEY CAN NOT DUPLICATE THE PROBLEM. 2) BRAKES FAILED - APPLIED BRAKES IN TRAFFIC, PEDAL WAS SOFT AND THEN WENT HARD LIKE THE POWER BRAKES WAS NOT WORKING, BUT THE CAR DID NOT SLOW DOWN, CAUSING THE IMPACT IN THE REAR OF A PICK-UP TRUCK. 3) ACCORDING TO THE AIR BAG REPORT THE CAR WAS TRAVELING OVER 30 MPH, BUT THE AIR BAGS DID NOT DEPLOY ON THE FRONTAL CRASH. *JB
DT: 2005 CHEVROLET COBALT. THE CONSUMER STATED THE VEHICLE SHUT DOWN AND STOPPED WHILE DRIVING AT 20 MPH. THEN, SHE HAD TO TURN THE VEHICLE OFF, PUT IT IN PARK, AND TURNED IT BACK ON. THE DEALERSHIP STATED IT WOULD HAVE TO HAPPEN AGAIN BEFORE THEY WOULD KNOW WHAT WAS WRONG WITH IT. GENERAL MOTORS TOLD HER SHE COULD TAKE TH…
Read full complaint
DT: 2005 CHEVROLET COBALT. THE CONSUMER STATED THE VEHICLE SHUT DOWN AND STOPPED WHILE DRIVING AT 20 MPH. THEN, SHE HAD TO TURN THE VEHICLE OFF, PUT IT IN PARK, AND TURNED IT BACK ON. THE DEALERSHIP STATED IT WOULD HAVE TO HAPPEN AGAIN BEFORE THEY WOULD KNOW WHAT WAS WRONG WITH IT. GENERAL MOTORS TOLD HER SHE COULD TAKE THE VEHICLE IN TO THE DEALERSHIP. THERE WAS NO ACCIDENT WHEN THIS HAPPENED AND THIS IS THE ONLY TIME THIS HAS OCCURRED. *AK
DT: WHILE DRIVING DOWN THE ROAD POWERING STEERING LOCKED, VEHICLE WOULD THROW CONSUMER FORWARD AND BACKWARD IN THE SEAT. COMING TO A STOP LIGHT AND PRESS THE BRAKES IT WAS LIKE THE CAR LUNGED FORWARD. JUST GOT THE VEHICLE BACK FROM THE SHOP YESTERDAY AND IT STARTED DOING THE SAME THING. POWER STEERING WAS LOCKING BUT WAS N…
Read full complaint
DT: WHILE DRIVING DOWN THE ROAD POWERING STEERING LOCKED, VEHICLE WOULD THROW CONSUMER FORWARD AND BACKWARD IN THE SEAT. COMING TO A STOP LIGHT AND PRESS THE BRAKES IT WAS LIKE THE CAR LUNGED FORWARD. JUST GOT THE VEHICLE BACK FROM THE SHOP YESTERDAY AND IT STARTED DOING THE SAME THING. POWER STEERING WAS LOCKING BUT WAS NOT ACTUALLY LOCKED. WILL STOP AND RESTART THE VEHICLWAS AND ITS LIKE HAVING FOOT ON THE GAS PEDAL AND BRAKE PEDAL AT THE SAME TIME. *AK
I WAS DRIVING ABOUT 40MPH WITH MY TWO KIDS IN THE CAR AND THEN THE VEHICLE SLOWED DOWN AND WOULDN'T ACELARATE I WAS ABLE TO PULL OVER TO THE SIDE OF THE ROAD AND THEN THE CAR JUST STALLED. I THEN PUT THE CAR IN PARK AND WAITED A FEW MINUTES. I THEN TRIED STARTING THE CAR AGAIN AND IT DID START. MY VEHICLE HAS 600 MILES.TODAY …
Read full complaint
I WAS DRIVING ABOUT 40MPH WITH MY TWO KIDS IN THE CAR AND THEN THE VEHICLE SLOWED DOWN AND WOULDN'T ACELARATE I WAS ABLE TO PULL OVER TO THE SIDE OF THE ROAD AND THEN THE CAR JUST STALLED. I THEN PUT THE CAR IN PARK AND WAITED A FEW MINUTES. I THEN TRIED STARTING THE CAR AGAIN AND IT DID START. MY VEHICLE HAS 600 MILES.TODAY I RECEIVED A NOTICE FROM CHEVROLET MOTOR DIVISION CENTRAL OFFICE STATING THAT THEY ARE CONDUCTING A VOLUNTARY CUSTOMER SATISFACTION PROGRAM THAT AFFECTS CERTAIN 2005 MODEL YEAR CHEVROLET COBALT VEHICLES EQUIPPED WITH A 2.2L ENGINE AND AIR CONDITIONING. I CALLED THE DEALERSHIP SERVICE DEPARTMENT AND ALSO THE 800 NUMBER ON MY LETTER AND TOLD THEM ABOUT MY VEHICLE STALLING AND TO LET THEM NOW I RECEIVED THE LETTER. I'M SCHEDULED FOR AN APPOINTMENT TO CORRECT THE PROBLEM AND TO LOOK INTO WHY MY VEHICLE STALLED. ALTHOUGH THEY STATE THIS IS "VOLUNTARY CUSTOMER STATISFACTION PROGRAM" I THINK THEY SHOULD JUST CALL IT A RECALL AND HAVE ALL CUSTOMERS WHO PURCHASED THIS MODEL BRING THEIR VEHICLE IN NOW RATHER THAN WHEN THEY EXPERIENCE A PROBLEM.
I PURCHASED THE CAR LITERALLY OFF THE SHOWROOM FLOOR. ONE DAY AND 38 MILES LATER IT STALLED OUT ON MY WIFE ON THE WAY TO CHURCH. TWO WEEKS LATER I GOT IT BACK. IT TURNED OUT TO BE A PROBLEM IN THE ACCELERATOR PEDAL. THE DEALER HAD TO FINALLY TAKE ONE FROM ANOTHER CAR TO HELP SOLVE MY PROBLEM. TWO DAYS LATER I NOW HAVE A PROBLEM…
Read full complaint
I PURCHASED THE CAR LITERALLY OFF THE SHOWROOM FLOOR. ONE DAY AND 38 MILES LATER IT STALLED OUT ON MY WIFE ON THE WAY TO CHURCH. TWO WEEKS LATER I GOT IT BACK. IT TURNED OUT TO BE A PROBLEM IN THE ACCELERATOR PEDAL. THE DEALER HAD TO FINALLY TAKE ONE FROM ANOTHER CAR TO HELP SOLVE MY PROBLEM. TWO DAYS LATER I NOW HAVE A PROBLEM WITH THE REAR "THIRD EYE" BRAKE LIGHT. IT WILL NOT GO OFF. I AM RETURNING THE VEHICLE ON MONDAY AND WILL WAIT TO SEE WHAT THIS PROBLEM IS. I KNOW THE COBLAT IS NEW BUT I SHOULDN'T BE HAVING THESE KIND OF PROBLEMS. *AK
Official recalls
514V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
10V073000 · Steering:electric Power Assist System
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
07V014000 · Structure
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
04V560000 · Exterior Lighting:headlights
Nov 22, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE BULB SHIELDS INSIDE OF THE HEADLAMPS CAN LOOSEN DUE TO VIBRATION.
Consequence & remedy
Consequence: THE BULB SHIELD CAN LOOSEN OR BREAK BECAUSE OF VIBRATION. IF THIS OCCURRED ON A HEADLAMP INSTALLED IN A VEHICLE, ONCOMING DRIVERS MAY NOTICE ADDITIONAL GLARE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL TWO NEW HEADLAMP ASSEMBLIES. THE RECALL BEGAN ON NOVEMBER 17, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.