IllustrationMY MOM WAS DRIVING THE CAR AS NORMAL DOWN THE ROAD ONE DAY AND ALL THE GUAGES IN THE ENTIRE DASH SUDDENLY STOPPED WORKING. SOME CAME BACK ON AND OFF A COUPLE WEEKS. SOME NEVER DID. BUT AFTER A COUPLE MONTHS ALL STOPPED WORKING AND NOW NOTHING WORKS. NO HEAT GUAGE, NO FUEL GUAGE, NO TEMP GUAGE, NO SPEEDOMETER, AND NO FUEL GUAGE.
2005 Chevrolet Cavalier
Owner reports · Recalls · Investigations
More warning signs than most Cavalier years
Owner complaints for the 2005 Chevrolet Cavalier are substantially higher than the model-year median of 140.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cavalier years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
180–25K
4825–50K
7350–75K
4675–100K
37100–150K
8150K+
230 reports with mileage · 57 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 211 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports0 fire reports5 injury reports
What owners actually said
287 reportsTL* THE CONTACT OWNS A 2005 CHEVROLET CAVALIER. ON SEVERAL OCCASIONS, WHILE DRIVING, THE INSTRUMENT PANEL FAILED TO OPERATE AS INTENDED. THE CONTACT STATED THAT THE FUEL GAUGE, ENGINE TEMPERATURE GAUGE, AND TACHOMETER WERE INOPERABLE. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE DEALER WAS NOT NOTIFIED. THE MANUFAC…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET CAVALIER. ON SEVERAL OCCASIONS, WHILE DRIVING, THE INSTRUMENT PANEL FAILED TO OPERATE AS INTENDED. THE CONTACT STATED THAT THE FUEL GAUGE, ENGINE TEMPERATURE GAUGE, AND TACHOMETER WERE INOPERABLE. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE DEALER WAS NOT NOTIFIED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.
TL* THE CONTACT OWNS A 2005 CHEVROLET CAVALIER. WHILE DRIVING 45 MPH, THE VEHICLE STALLED AND THE FUEL GAUGE DISPLAYED THE INCORRECT FUEL LEVEL. WHILE THE VEHICLE WAS PARKED, A FAMILY MEMBER NOTICED FUEL LEAKING ONTO THE GROUND. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE DEALER WAS NOT CONTACTED. THE FAILURE WAS NOT DIAGN…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET CAVALIER. WHILE DRIVING 45 MPH, THE VEHICLE STALLED AND THE FUEL GAUGE DISPLAYED THE INCORRECT FUEL LEVEL. WHILE THE VEHICLE WAS PARKED, A FAMILY MEMBER NOTICED FUEL LEAKING ONTO THE GROUND. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE DEALER WAS NOT CONTACTED. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 45,000.
NONE OF THE GAGES WORK DON'T KNOW HOW FAST I'M GOING
GAUGES FOR TEMPERATURE DO NOT WORK, SOMETIMES READS BELOW ZERO, SOMETIMES SLIGHTLY ABOVE THERE IS NO CHANGE IN READING WHETHER COLD, OR RUNNING FOR SEVERAL HOURS - AT ANY SPEED SPEED GAUGE WORKS INTERMITTENTLY, SOMETIMES RECORDING 100 MPH, WHEN THE CAR IS DOING NO MORE THAT 20-30 MPH. AT OTHER TIMES, IT SEEMS TO BE RUNNING AB…
Read full complaint
GAUGES FOR TEMPERATURE DO NOT WORK, SOMETIMES READS BELOW ZERO, SOMETIMES SLIGHTLY ABOVE THERE IS NO CHANGE IN READING WHETHER COLD, OR RUNNING FOR SEVERAL HOURS - AT ANY SPEED SPEED GAUGE WORKS INTERMITTENTLY, SOMETIMES RECORDING 100 MPH, WHEN THE CAR IS DOING NO MORE THAT 20-30 MPH. AT OTHER TIMES, IT SEEMS TO BE RUNNING ABOUT THE SPEED LIMIT, WHEN COMPARED WITH OTHER TRAFFIC, THEN RECORD 100+MPH.AT OTHER TIMES, WHEN GOING WITH TRAFFIC, THE GAUGE READS 0MPH THERE IS NO WAY TO KNOW IF THE CAR IS OVERHEATING, OR WHAT SPEED THE CAR IS GOING. THIS HAS BEEN THE CASE FOR ABOUT TWO MONTHS, AND I WAS TOLD IT WAS THE 'SETTER', AND WOULD COST ME $900. WHICH I DID NOT HAVE. IT IS VERY UPSETTING .
ALL GAUGES DON'T WORK. SPEEDOMETER,FUEL,TEMPERATURE.
THERE IS A KNOWN ISSUE WITH THE GAUGES IN THE 2005 CHEVROLET CAVALIER CAUSING THEM TO MALFUNCTION OR NOT FUNCTION AT ALL INTERMITTENTLY. THIS IS A SAFETY HAZARD BECAUSE YOU DO NOT KNOW HOW MUCH FUEL YOU HAVE, THE TEMPERATURE OF YOUR ENGINE, OR YOUR SPEED WHEN THE GAUGES FAIL.
TL* THE CONTACT OWNS A 2005 CHEVROLET CAVALIER. WHILE THE VEHICLE WAS PARKED OR WHILE DRIVING, THE FUEL AND TEMPERATURE GAUGES FAILED TO DISPLAY THE CORRECT INFORMATION. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET CAVALIER. WHILE THE VEHICLE WAS PARKED OR WHILE DRIVING, THE FUEL AND TEMPERATURE GAUGES FAILED TO DISPLAY THE CORRECT INFORMATION. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000.
TL* THE CONTACT OWNS A 2005 CHEVROLET CAVALIER. WHILE DRIVING 25 MPH, ALL THE INSTRUMENT PANEL GAUGES ILLUMINATED WITHOUT WARNING. IT WAS DIAGNOSED THAT THE ELECTRONIC INSTRUMENT CLUSTER FAILED AND NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APP…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET CAVALIER. WHILE DRIVING 25 MPH, ALL THE INSTRUMENT PANEL GAUGES ILLUMINATED WITHOUT WARNING. IT WAS DIAGNOSED THAT THE ELECTRONIC INSTRUMENT CLUSTER FAILED AND NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.
TAKATA RECALL AIR BAGS DID NOT DEPLOY IN A REAR END COLLISION THAT TOTALLED CAR. ALSO PASSENGERS SEAT BROKE CAUSING NECK AND RIB INJURY.VEHICLE WAS STATIONARY WAITING FOR CONSTRUCTION FLAGMAN.
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.