IllustrationBRAKE LIGHT/TURN SIGNAL BULBS HAVE BURNED OUT 4 TIMES(LEFT 2 TIMES, RIGHT 2 TIMES) IN THE LAST 2 MONTHS.*AK
2003 Chevrolet Cavalier
Owner reports · Recalls · Investigations
More warning signs than most Cavalier years
Owner complaints for the 2003 Chevrolet Cavalier are substantially higher than the model-year median of 140.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cavalier years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
810–25K
9225–50K
19750–75K
10875–100K
58100–150K
17150K+
553 reports with mileage · 125 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 340 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 106 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 57 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
31 crash reports6 fire reports16 injury reports
Exterior Lighting complaints
57 reportsWHILE DRIVING AT ANY SPEED HEATER DID NOT WORK. VEHICLE WAS TAKEN TO THE DEALER, AND HEATER WAS REPLACED. ALSO, ON TWO DIFFERENT OCCASIONS DEALER REPLACED WIRING HARNESS AND CONNECTION WIRES. ON ANOTHER OCCASION ENTIRE BRAKE LIGHT ASSEMBLY WAS REPLACED ALONG WITH THE SOCKETS. IN ALL, VEHICLE HAD BEEN TO THE DEALER SIX…
Read full complaint
WHILE DRIVING AT ANY SPEED HEATER DID NOT WORK. VEHICLE WAS TAKEN TO THE DEALER, AND HEATER WAS REPLACED. ALSO, ON TWO DIFFERENT OCCASIONS DEALER REPLACED WIRING HARNESS AND CONNECTION WIRES. ON ANOTHER OCCASION ENTIRE BRAKE LIGHT ASSEMBLY WAS REPLACED ALONG WITH THE SOCKETS. IN ALL, VEHICLE HAD BEEN TO THE DEALER SIX TIMES IN SEVEN MONTHS.*AK
2003 CHEVROLET CAVALIER PURCHASED NEW AUGUST 23, 2003 BILL HEARD CHEVROLET,COLUMBUS GA. BRAKE LIGHT HAVE BURNED OUT TWICE SINCE THAT DATE. ONCE IN NOVEMBER 2003 AND AGAIN IN FEBRUARY 2004.*AK
I BOUGHT THE CAR BRAND NEW ARROUND 04/2003 CHEVROLET CAVALIER 2003 SINCE THEN I REPORTED SEVERAL TIMES BACK TO THE DEALER SHIP WITH THE FOLLOWING PROBLEMS:DRIVETRAIN - CLUNK NOISE DURING LOW SPEED TURNS A/C - DIFFICULT MODE/TEMPERATURE SETTING OPERATION . STEERING - MOMENTARY LOSS OF POWER ASSIST. STEERING - RATTLE/KNOCK WHEN…
Read full complaint
I BOUGHT THE CAR BRAND NEW ARROUND 04/2003 CHEVROLET CAVALIER 2003 SINCE THEN I REPORTED SEVERAL TIMES BACK TO THE DEALER SHIP WITH THE FOLLOWING PROBLEMS:DRIVETRAIN - CLUNK NOISE DURING LOW SPEED TURNS A/C - DIFFICULT MODE/TEMPERATURE SETTING OPERATION . STEERING - MOMENTARY LOSS OF POWER ASSIST. STEERING - RATTLE/KNOCK WHEN TURNING WHEELS - FRONT/REAR WHEEL SQUEAKING NOISE ---ALL THOSE COMPLAINTS ARE NEVER BEEN TAKEN CARE OFF - THEY ALLWAYS HAD SOME "LOW EXCUSES FOR ME - LIKE THE WHEATER/RAIN/DIRT ON THE WHEELS (I LIVE IN THE CITY ...NOT ON A DIRT ROAD..) ANYWAY THE ONLY COMPLAINT THEY TAKEN SERIOUS IS THAT I BROUGHT IN THE CAR NOW FOR THE 3RD TIME TO REPAIR THE RIGHT SIGNAL LIGHT - LAST TIME JUST TODAY! I REPORTED AGAIN ALL THE OTHER PROBLEMS, WITH THE SUCESS THAT THEY AT LEAST ORDERD NOW A "NEW PART" FOR THE A/C, EVERYTHING ELSE IS AGAIN BEEN "PLAYED" DOWN. HONESTLY, I'M GETTING TIRED OF HAVING SO MUCH TROUBLE WITH A NEW CAR. BRINGING IT TO THE DEALERSHIP ALWAYS COST ME A NEARLY A WHOLE DAY OF MISSING WORK. I WOULD LIKE TO KNOW IF THERE IS ANY WAY TO FIX ALL TJOSE PROBLEMS FOR ONCE AND ALL OR DOES A CUSTOMER FROM CHEVROLET JUST HAS TO SUFFER AND PUT UP WITH SUCH A POOR QUALITY?!*AK
THE RIGHT TURN SIGNAL LIGHT BURNED OUT 3 TIMES WITHIN THIS YEAR. TOOK VEHICLE TO DEALER, AND THE DEALER INDICATED THAT THE SOCKETS WERE CORRODED. *AK *SC
THE REAR TURN SIGNAL FAILS INTERMITTENTLY. HAS TAKEN VEHICLE TO DEALERSHIP. THE MECHANIC STATES THAT THE LIGHT BURNS THROUGH THE SOCKET WHICH CAUSES FAILURE. *PH
2003 CHEVROLET CAVALIER ONLY 6 MONTHS OLD AND ALREADY BOTH OF THE BACK TURN SIGNALS/BRAKE LIGHT BULBS HAVE BURNT OUT. *AK
Official recalls
104V524000 · Exterior Lighting:turn Signal
Nov 1, 2004
ON CERTAIN PASSENGER VEHICLES, THE REAR LAMPS THAT PROVIDE STOP AND TURN SIGNALS AND TAIL LAMP FUNCTIONS STOP WORKING BECAUSE OF INADEQUATE CONTACT BETWEEN THE BULB AND SOCKET. IN ADDITION, IF ONE BULBS WERE TO BECOME INOPERATIVE WHILE THE VEHICLE WAS OPERATING IN CRUISE CONTROL, THE CRUISE CONTROL WOULD DISENGAGE WHEN THE REMAINING BULB WAS ACTIVATED. IF BOTH LAMPS WERE TO BECOME INOPERATIVE, THE CRUISE CONTROL WOULD NOT ENGAGE.
Consequence & remedy
Consequence: AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR LAMP BULB SOCKET ASSEMBLIES AND APPLY GREASE OR REPLACE THEM IF NECESSARY. THE RECALL BEGAN ON JANUARY 18, 2005. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA07015 · Engine Stalling - Fuel Pump Failure
Opened Nov 1, 2007 · Closed Oct 28, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump
ODI'S ANALYSIS OF THE STALLING INCIDENTS THAT HAVE RESULTED FROM SUBJECT COMPONENT FAILURES FOUND THAT THEY CAN OCCUR AT ANY SPEED AND GENERALLY RESULT IN A NO RESTART CONDITION.THESE ARE GENERALLY CONSIDERED TO BE FACTORS THAT INCREASE THE POTENTIAL SEVERITY OF STALLING INCIDENTS.HOWEVER, THESE INCIDENTS HAVE OCCURRED AT RELATIVELY LOW RATES IN THE SUBJECT VEHICLE POPULATION WHEN COMPARED WITH PRIOR INVESTIGATIONS INVOLVING SIMILAR CATEGORIES OF ENGINE STALL CONSEQUENCES.EVEN FOR THE EARLY MY 2003 PRODUCTION, WHERE HIGHER FAILURE RATES WERE NOTED, THE RATES OF PUMP FAILURES RESULTING IN ENGINE STALL ARE LOWER THAN RATES RECORDED IN PRIOR INVESTIGATIONS OF POPULATIONS THAT WERE NOT RECALLED.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR MORE INFORMATION ABOUT THIS CLOSING RESUME.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
ODI'S ANALYSIS OF THE STALLING INCIDENTS THAT HAVE RESULTED FROM SUBJECT COMPONENT FAILURES FOUND THAT THEY CAN OCCUR AT ANY SPEED AND GENERALLY RESULT IN A NO RESTART CONDITION.THESE ARE GENERALLY CONSIDERED TO BE FACTORS THAT INCREASE THE POTENTIAL SEVERITY OF STALLING INCIDENTS.HOWEVER, THESE INCIDENTS HAVE OCCURRED AT RELATIVELY LOW RATES IN THE SUBJECT VEHICLE POPULATION WHEN COMPARED WITH PRIOR INVESTIGATIONS INVOLVING SIMILAR CATEGORIES OF ENGINE STALL CONSEQUENCES.EVEN FOR THE EARLY MY 2003 PRODUCTION, WHERE HIGHER FAILURE RATES WERE NOTED, THE RATES OF PUMP FAILURES RESULTING IN ENGINE STALL ARE LOWER THAN RATES RECORDED IN PRIOR INVESTIGATIONS OF POPULATIONS THAT WERE NOT RECALLED.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR MORE INFORMATION ABOUT THIS CLOSING RESUME.
Fuel System, Gasoline:delivery
ODI'S ANALYSIS OF THE STALLING INCIDENTS THAT HAVE RESULTED FROM SUBJECT COMPONENT FAILURES FOUND THAT THEY CAN OCCUR AT ANY SPEED AND GENERALLY RESULT IN A NO RESTART CONDITION.THESE ARE GENERALLY CONSIDERED TO BE FACTORS THAT INCREASE THE POTENTIAL SEVERITY OF STALLING INCIDENTS.HOWEVER, THESE INCIDENTS HAVE OCCURRED AT RELATIVELY LOW RATES IN THE SUBJECT VEHICLE POPULATION WHEN COMPARED WITH PRIOR INVESTIGATIONS INVOLVING SIMILAR CATEGORIES OF ENGINE STALL CONSEQUENCES.EVEN FOR THE EARLY MY 2003 PRODUCTION, WHERE HIGHER FAILURE RATES WERE NOTED, THE RATES OF PUMP FAILURES RESULTING IN ENGINE STALL ARE LOWER THAN RATES RECORDED IN PRIOR INVESTIGATIONS OF POPULATIONS THAT WERE NOT RECALLED.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR MORE INFORMATION ABOUT THIS CLOSING RESUME.
Fuel System, Gasoline
ODI'S ANALYSIS OF THE STALLING INCIDENTS THAT HAVE RESULTED FROM SUBJECT COMPONENT FAILURES FOUND THAT THEY CAN OCCUR AT ANY SPEED AND GENERALLY RESULT IN A NO RESTART CONDITION.THESE ARE GENERALLY CONSIDERED TO BE FACTORS THAT INCREASE THE POTENTIAL SEVERITY OF STALLING INCIDENTS.HOWEVER, THESE INCIDENTS HAVE OCCURRED AT RELATIVELY LOW RATES IN THE SUBJECT VEHICLE POPULATION WHEN COMPARED WITH PRIOR INVESTIGATIONS INVOLVING SIMILAR CATEGORIES OF ENGINE STALL CONSEQUENCES.EVEN FOR THE EARLY MY 2003 PRODUCTION, WHERE HIGHER FAILURE RATES WERE NOTED, THE RATES OF PUMP FAILURES RESULTING IN ENGINE STALL ARE LOWER THAN RATES RECORDED IN PRIOR INVESTIGATIONS OF POPULATIONS THAT WERE NOT RECALLED.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.SEE DOCUMENT FILE FOR MORE INFORMATION ABOUT THIS CLOSING RESUME.
PE07033 · Fuel Pump Failure
Opened Jun 28, 2007 · Closed Nov 1, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump
AN ENGINEERING ANALYSIS HAS BEEN OPENED TO FURTHER INVESTIGATE THE SCOPE, FREQUENCY AND POTENTIAL SAFETY-RELATED CONSEQUENCES OF THE ALLEGED DEFECT.GENERAL MOTORS (GM) HAS IDENTIFIED AN ISSUE WITH ACCELERATED MOTOR BRUSH WEAR IN THE FUEL PUMP ASSEMBLY OF MODEL YEAR (MY) 2001 THROUGH 2003 CHEVROLET VEHICLES THAT CAN CAUSE THE PUMP TO STOP OPERATING.GENERAL MOTORS INDICATED THAT PEROXIDE OR SULFUR, WHICH ARE BOTH PRESENT IN VARYING AMOUNTS IN GASOLINE, CAN REACT WITH THE COPPER COMMUTATOR OF THE PUMP MOTOR AND CORRODE/ROUGHEN THE SURFACE.A ROUGH COMMUTATOR SURFACE INCREASES THE RATE OF BRUSH WEAR.THE INCREASED ELECTRICAL RESISTANCE CAUSED BY DEGRADATION OF THE BRUSH-COMMUTATOR INTERFACE INHIBITS CURRENT FLOW THROUGH THE MOTOR WINDINGS.ACCORDING TO GM, THE CONDITION WILL USUALLY RESULT IN A NO-START CONDITION BECAUSE OF THE HIGH CURRENT REQUIRED DURING START-UP.WHEN THE ALLEGED DEFECT DOES CAUSE A STALL WHILE DRIVING INCIDENT, THE VEHICLE TYPICALLY CANNOT BE RESTARTED.GM'S ANALYSIS OF WARRANT CLAIMS SHOWED THAT NO START/HARD START WAS THE MOST COMMON CONDITION AND THE FREQUENCY OF CLAIMS ASSOCIATED WITH STALL WHILE DRIVING INCIDENTS WAS TOO LOW TO WARRANT FIELD ACTION. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-015) TO FURTHER ASSESS THE COMPLAINT AND WARRANTY CLAIM DATA AND THE ANALYSES PROVIDED BY GM.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
AN ENGINEERING ANALYSIS HAS BEEN OPENED TO FURTHER INVESTIGATE THE SCOPE, FREQUENCY AND POTENTIAL SAFETY-RELATED CONSEQUENCES OF THE ALLEGED DEFECT.GENERAL MOTORS (GM) HAS IDENTIFIED AN ISSUE WITH ACCELERATED MOTOR BRUSH WEAR IN THE FUEL PUMP ASSEMBLY OF MODEL YEAR (MY) 2001 THROUGH 2003 CHEVROLET VEHICLES THAT CAN CAUSE THE PUMP TO STOP OPERATING.GENERAL MOTORS INDICATED THAT PEROXIDE OR SULFUR, WHICH ARE BOTH PRESENT IN VARYING AMOUNTS IN GASOLINE, CAN REACT WITH THE COPPER COMMUTATOR OF THE PUMP MOTOR AND CORRODE/ROUGHEN THE SURFACE.A ROUGH COMMUTATOR SURFACE INCREASES THE RATE OF BRUSH WEAR.THE INCREASED ELECTRICAL RESISTANCE CAUSED BY DEGRADATION OF THE BRUSH-COMMUTATOR INTERFACE INHIBITS CURRENT FLOW THROUGH THE MOTOR WINDINGS.ACCORDING TO GM, THE CONDITION WILL USUALLY RESULT IN A NO-START CONDITION BECAUSE OF THE HIGH CURRENT REQUIRED DURING START-UP.WHEN THE ALLEGED DEFECT DOES CAUSE A STALL WHILE DRIVING INCIDENT, THE VEHICLE TYPICALLY CANNOT BE RESTARTED.GM'S ANALYSIS OF WARRANT CLAIMS SHOWED THAT NO START/HARD START WAS THE MOST COMMON CONDITION AND THE FREQUENCY OF CLAIMS ASSOCIATED WITH STALL WHILE DRIVING INCIDENTS WAS TOO LOW TO WARRANT FIELD ACTION. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-015) TO FURTHER ASSESS THE COMPLAINT AND WARRANTY CLAIM DATA AND THE ANALYSES PROVIDED BY GM.
Fuel System, Gasoline:delivery
AN ENGINEERING ANALYSIS HAS BEEN OPENED TO FURTHER INVESTIGATE THE SCOPE, FREQUENCY AND POTENTIAL SAFETY-RELATED CONSEQUENCES OF THE ALLEGED DEFECT.GENERAL MOTORS (GM) HAS IDENTIFIED AN ISSUE WITH ACCELERATED MOTOR BRUSH WEAR IN THE FUEL PUMP ASSEMBLY OF MODEL YEAR (MY) 2001 THROUGH 2003 CHEVROLET VEHICLES THAT CAN CAUSE THE PUMP TO STOP OPERATING.GENERAL MOTORS INDICATED THAT PEROXIDE OR SULFUR, WHICH ARE BOTH PRESENT IN VARYING AMOUNTS IN GASOLINE, CAN REACT WITH THE COPPER COMMUTATOR OF THE PUMP MOTOR AND CORRODE/ROUGHEN THE SURFACE.A ROUGH COMMUTATOR SURFACE INCREASES THE RATE OF BRUSH WEAR.THE INCREASED ELECTRICAL RESISTANCE CAUSED BY DEGRADATION OF THE BRUSH-COMMUTATOR INTERFACE INHIBITS CURRENT FLOW THROUGH THE MOTOR WINDINGS.ACCORDING TO GM, THE CONDITION WILL USUALLY RESULT IN A NO-START CONDITION BECAUSE OF THE HIGH CURRENT REQUIRED DURING START-UP.WHEN THE ALLEGED DEFECT DOES CAUSE A STALL WHILE DRIVING INCIDENT, THE VEHICLE TYPICALLY CANNOT BE RESTARTED.GM'S ANALYSIS OF WARRANT CLAIMS SHOWED THAT NO START/HARD START WAS THE MOST COMMON CONDITION AND THE FREQUENCY OF CLAIMS ASSOCIATED WITH STALL WHILE DRIVING INCIDENTS WAS TOO LOW TO WARRANT FIELD ACTION. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-015) TO FURTHER ASSESS THE COMPLAINT AND WARRANTY CLAIM DATA AND THE ANALYSES PROVIDED BY GM.
Fuel System, Gasoline
AN ENGINEERING ANALYSIS HAS BEEN OPENED TO FURTHER INVESTIGATE THE SCOPE, FREQUENCY AND POTENTIAL SAFETY-RELATED CONSEQUENCES OF THE ALLEGED DEFECT.GENERAL MOTORS (GM) HAS IDENTIFIED AN ISSUE WITH ACCELERATED MOTOR BRUSH WEAR IN THE FUEL PUMP ASSEMBLY OF MODEL YEAR (MY) 2001 THROUGH 2003 CHEVROLET VEHICLES THAT CAN CAUSE THE PUMP TO STOP OPERATING.GENERAL MOTORS INDICATED THAT PEROXIDE OR SULFUR, WHICH ARE BOTH PRESENT IN VARYING AMOUNTS IN GASOLINE, CAN REACT WITH THE COPPER COMMUTATOR OF THE PUMP MOTOR AND CORRODE/ROUGHEN THE SURFACE.A ROUGH COMMUTATOR SURFACE INCREASES THE RATE OF BRUSH WEAR.THE INCREASED ELECTRICAL RESISTANCE CAUSED BY DEGRADATION OF THE BRUSH-COMMUTATOR INTERFACE INHIBITS CURRENT FLOW THROUGH THE MOTOR WINDINGS.ACCORDING TO GM, THE CONDITION WILL USUALLY RESULT IN A NO-START CONDITION BECAUSE OF THE HIGH CURRENT REQUIRED DURING START-UP.WHEN THE ALLEGED DEFECT DOES CAUSE A STALL WHILE DRIVING INCIDENT, THE VEHICLE TYPICALLY CANNOT BE RESTARTED.GM'S ANALYSIS OF WARRANT CLAIMS SHOWED THAT NO START/HARD START WAS THE MOST COMMON CONDITION AND THE FREQUENCY OF CLAIMS ASSOCIATED WITH STALL WHILE DRIVING INCIDENTS WAS TOO LOW TO WARRANT FIELD ACTION. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-015) TO FURTHER ASSESS THE COMPLAINT AND WARRANTY CLAIM DATA AND THE ANALYSES PROVIDED BY GM.
EA04028 · Turn Signal Malfunction
Opened Sep 14, 2004 · Closed Nov 22, 2004
Status: closed (inferred from source dates) · Exterior Lighting:turn Signal
ON MAY 14, 2004 THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE04-043) BASED ON CONSUMER COMPLAINTS ALLEGING THAT THE BRAKE/TAIL TURN SIGNAL LAMPS WOULD NOT OPERATE PROPERLY WHEN EITHER THE TAIL LIGHTS WERE TURNED ON, THE BRAKE PEDAL WAS DEPRESSED, OR WHEN THE TURN SIGNAL SWITCH WAS ACTIVATED.ON SEPTEMBER 14, 2004 ODI UPGRADED PE 04-043 TO AN ENGINEERING ANALYSIS (EA04-028).GM STATES THAT SOME BRAKE/TAIL/TURN SIGNAL LAMP BULBS CAN PREMATURELY BECOME INOPERATIVE DUE TO EXCESSIVE HEAT BUILDUP WITHIN THE BULB SOCKETS.THE CAUSE OF THE EXCESSIVE HEAT BUILD UP WAS DETERMINED TO BE A LACK OF THERMAL GREASE PLACED IN BETWEEN THE BULB AND THE SOCKET. BY LETTER DATED OCTOBER 27, 2004 GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA # 04V524) COVERING ALL MY 2003 VEHICLES.GM DEALERS WILL INSPECT THE REAR LAMP BULB SOCKET ASSEMBLIES AND APPLY THERMAL GREASE TO THEM OR REPLACE THEM WITH NEW ASSEMBLIES WITH THERMAL GREASE ALREADY ATTACHED.MODEL YEAR 2004 AND NEWER VEHICLES HAVE THE THERMAL GREASE INSTALLED FROM THE FACTORY. THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE04043 · Turn Signal Malfunction
Opened May 14, 2004 · Closed Sep 14, 2004
Status: closed (inferred from source dates) · Exterior Lighting:turn Signal
COMPLAINANTS ALLEGE THAT THE REAR TURN SIGNALS FAIL TO ILLUMINATE AND DO NOT PROVIDE A SIGNAL TO DRIVERS IN FOLLOWING VEHICLES.ODI HAS RECEIVED ONE REPORT OF A CRASH WHERE THE COMPLAINANT BRAKED AND ATTEMPTED TO MAKE A LEFT TURN AND THE FOLLOWING VEHICLE IMPACTED THE COMPLAINANT'S VEHICLE IN THE DRIVER-SIDE DOOR.IN MAY 2002, GM'S SUPPLIER MADE CHANGES TO THE BULB SOCKET THAT INCLUDED STOPPING THE USE OF THERMAL-MASTIC GREASE IN THE BULB SOCKET.GM REPORTS THAT THE GREASE REDUCES ARCING AT THE CONTACTS AND DISSIPATES HEAT THUS PREVENTING MELTING OF THE SOCKET MATERIAL OR BURNING OF THE CONTACTS.MOST OF THE SUBJECT VEHICLES WERE PRODUCED WITHOUT GREASE APPLIED TO THE BULB SOCKET.IN JUNE 2003, GM DIRECTED THE SUPPLIER TO RESUME THE USE OF GREASE IN THE SOCKET.GM ISSUED TECHNICAL SERVICE BULLETIN (TSB) 04-08-42-004A ON JULY 15, 2004 ADVISING TECHNICIANS TO MAKE SURE THAT ADEQUATE AMOUNTS OF GREASE WERE ADDED TO THE BULB SOCKETS ON ALL SERVICE PARTS.ODI WILL UPGRADE THIS INVESTIGATION TO EA 04-028 TO FURTHER EXAMINE THE ISSUE.