IllustrationTIMING TENSIONER KEEPS GOING OUT ON CAR. HAS BEEN REPAIRED 3 TIMES. *AK
1999 Chevrolet Cavalier
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1999 Chevrolet Cavalier do not stand out strongly from the model-year median of 140.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cavalier years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
30–25K
1625–50K
1650–75K
1375–100K
7100–150K
10150K+
65 reports with mileage · 175 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 47 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 45 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
27 crash reports2 fire reports15 injury reports
Engine And Engine Cooling complaints
44 reportsCAR OVERHEATED, CAUSING ENGINE DAMAGE, NO INDICATION OF OVERHEATING PROBLEM. *AK
WHEN DRIVING, CONSUMER DEPRESSED BRAKE PEDAL TWICE SUCCESSIVELY AND ENGINE SHUDDERED, THEN STALLED.. 1999, CHEVROLET, CAVALIER Z24.*AK
CAR CUTS OFF AT ANY GIVEN TIME. CAN BE RUNNING AT 60 MPH OR SITTING AT A STOP LIGHT, JUST COMPLETELY CUTS OFF. WILL NOT RESTART, HAVE TO PARK IT AND LET IT SIT, COULD ONLY TAKE 10 MINUTES OR COULD TAKE A FEW HOURS BEFORE IT WILL RUN AGAIN. *JB
WHEN THE CONSUMER SLOWED DOWN TO MAKE A TURN, THE ENGINE STALLED.*JB ON NUMEROUS OCCASIONS CONSUMER SLOWS DOWN VEHICLE AND THE ENGINE WILL STALL. *MR
VALVE COVER GASKET AND HEAD GASKET BOTH FAULTY ON ENGINE AT ONLY 60,000 MILES. THIS IS A VERY COMMON COMPLAINT YET I HAVE NOT FOUND ANY RECALLS. CHEVROLET FAILS TO ADMIT TO THESE FAILURES, AND WILL NOT ASSIST. IN SAME NEIGHBORHOOD, THREE OTHER CAVALIER OWNERS HAVE REPLACED HEAD GASKETS AND CHEVROLET DOES NOTHING.*JB
THE ENGINE STOPPED RUNNING WHILE DRIVING ON THE INTERSTATE, WHICH CAUSED THE VEHICLE TO HAVE NO POWER. *PH *JB
WHILE TRAVELING 72 MPH ENGINE BLEWOUT WITHOUT ANY INDICATION. VEHICLE WAS SERVICED BY DEALER, TECHNICIAN NOTICED EXHAUST BLEW INTO COOLANT SYSTEM WHICH BLEW THE ENGINE. PLEASE PROVIDER FURTHER INFORMATION. TS...*AK
WHEN I BOUGHT THE CAR IN SPRINGFIELD MO., I ONLY HAD 8 MILES ON THE CAR WHEN I DROVE IT OFF THE LOT. I LIVE IN ROLLA WHICH IS ONLY 110 MILES AT THE MOST. I DROVE STRAIGHT HOME AND THE MILEAGE SHOWED 265 MILES, TWICE THE MILEAGE. ALSO, THE CAR SHAKES AND GRINDS WHEN STARTING. THEY FOUND NOTHING WRONG WITH IT. THAT WAS WHEN IT H…
Read full complaint
WHEN I BOUGHT THE CAR IN SPRINGFIELD MO., I ONLY HAD 8 MILES ON THE CAR WHEN I DROVE IT OFF THE LOT. I LIVE IN ROLLA WHICH IS ONLY 110 MILES AT THE MOST. I DROVE STRAIGHT HOME AND THE MILEAGE SHOWED 265 MILES, TWICE THE MILEAGE. ALSO, THE CAR SHAKES AND GRINDS WHEN STARTING. THEY FOUND NOTHING WRONG WITH IT. THAT WAS WHEN IT HAD LESS THAN 1000 MILES. FUEL LINES OR SOMETHING SMELLS HEAVY WITH GAS. MY CAR EATS GAS MORE THAN MY ASTRO VAN. THEY SAID NOTHING WAS WRONG. I HAVE PUT THREE COOLING SYSTEMS IN THIS CAR THEY SAID WAS WRONG. FUSES KEEP BURNING OUT. I HAVE REPLACED 65 BULBS, THEY SAID NOTHING IS WRONG. IT'S MUCH WORSE NOW. WHEN I TURN THE CAR THE STEERING STICKS THEN GOES INTO THE TURN, THEY SAID NOTHING WAS WRONG. THIS CAR HAS BEEN NOTHING BUT TROUBLE SINCE I BOUGHT IT. PH **DIMSII IVOQ ENTRY POSTED AFTER 12/12/02 CUT OVER TO ARTEMIS**770836
CAR TEMPERATURE GAUGE INDICATED CAR RUNNING HOT, DROVE IT 3 MILES TO SAFETY, ENGINE CEASED, WARPED HEADS. NO PRIOR NOTICE OF OVERHEATING, NEVER OVERHEATED BEFORE THIS INCIDENT; ENGINE HAD TO BE REPLACED. WARRANTY COMPANY INSPECTED, SAID WATER PUMP AND THERMOSTAT FAILED, BOTH WERE MANUFACTURER PARTS, WHICH CAUSED ENGINE TO OVER…
Read full complaint
CAR TEMPERATURE GAUGE INDICATED CAR RUNNING HOT, DROVE IT 3 MILES TO SAFETY, ENGINE CEASED, WARPED HEADS. NO PRIOR NOTICE OF OVERHEATING, NEVER OVERHEATED BEFORE THIS INCIDENT; ENGINE HAD TO BE REPLACED. WARRANTY COMPANY INSPECTED, SAID WATER PUMP AND THERMOSTAT FAILED, BOTH WERE MANUFACTURER PARTS, WHICH CAUSED ENGINE TO OVERHEAT AND SEVERE DAMAGE. I WAS NOT REIMBURSED BY WARRANTY FOR ENGINE, I HAD TO PAY MYSELF, $3000.00 - IF MANUFACTURER DEFECTS THAN WARRANTY CO SHOULD PAY!*AK
Official recalls
204V036000 · Electrical System:ignition:switch
Jan 27, 2004
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED. THE FIRE COULD SPREAD TO THE INTERIOR OF THE CAR, WHICH COULD INJURE OCCUPANTS OR CAUSE DAMAGE TO ADJOINING STRUCTURES.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH, AND CHECK THAT YOUR CAR WILL START WITH A PROPERLY CHARGED BATTERY AND, IF NECESSARY, REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION WILL BEGIN ON MARCH 1, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, BUICK AT 1-866-608-8080, OR OLDSMOBILE AT 1-800-630-6537. CUSTOMERS CAN ALSO CHECK THEIR VEHICLE ONLINE BY GOING TO WWW.MYGMLINK.COM AND ENTERING THE VEHICLE'S IDENTIFICATION NUMBER.
99V218000 · Interior Lighting
Aug 11, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 101, "CONTROL LOCATION, IDENTIFICATION, AND ILLUMINATION." THE INSTRUMENT PANEL BACKLIGHTING MAY NOT FUNCTION AFTER ADJUSTING THE INTERIOR LIGHT INTENSITY.
Consequence & remedy
Consequence: IF THE INSTRUMENT PANEL IS NOT LIT AT NIGHT, THE DRIVER MAY NOT BE ABLE TO SEE THE CONTROLS AND DISPLAYS.
Remedy: DEALERS WILL TEST THE BODY CONTROL MODULE, AND IF NECESSARY, REPLACE IT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.