AFTER LISTENING TO A SQUEEK NOISE FROM TRUNK AREA PROCEED TO A CLUNKING NOISE, I TOOK VEHICLE IN FOR SERVICE. WAS ADVISED BY DEALER THAT REAR STRUT AND IT'S MOUNT HAD FAILED REQUIRING BOTH TO BE REPLACED AT A COST OF OVER $800. I FEEL THE FAILURE OF THIS ASSEMBLY TO BE A MANUFACTURERS DEFECT. MUFFLER FAILED PREMATURELY. WATER P…
Read full complaint
AFTER LISTENING TO A SQUEEK NOISE FROM TRUNK AREA PROCEED TO A CLUNKING NOISE, I TOOK VEHICLE IN FOR SERVICE. WAS ADVISED BY DEALER THAT REAR STRUT AND IT'S MOUNT HAD FAILED REQUIRING BOTH TO BE REPLACED AT A COST OF OVER $800. I FEEL THE FAILURE OF THIS ASSEMBLY TO BE A MANUFACTURERS DEFECT. MUFFLER FAILED PREMATURELY. WATER PUMP FAILED PREMATURLEY. STARTING TO THINK 1996 CAVALIER WAS NOT ENGINEERED VERY WELL.
NHTSA ODI #753443
Mileage unknown · Sep 9, 2001
Suspension
SHOCKS COMPRESS ALL THE WAY AND MAKE A LOUD SLAMMING NOISE, HAPPENS AT VERY SLOW RATE OF TRAVEL ON VERY SMALL BUMPS, AND GETS WORSE AT HIGHER SPEEDS OR LARGER BUMPS.*JB
NHTSA ODI #785582
Mileage unknown · Feb 28, 2001
Suspension
REAR STRUTS & MOUNTS & EXHAUST HANGERS REPLACED AT 47,000 MILES. PROBLEM NOT RESOLVED.
NHTSA ODI #741712
Mileage unknown · Aug 28, 2000
Suspension
CONSUMER CAN HEAR A BUMPING IN REAR DRIVERS SIDE OF VEHICLE.*AK
NHTSA ODI #868901
Mileage unknown · Jun 18, 2000
Exterior LightingSuspension
I HAVE HAD REOCCURRING PROBLEMS WITH THE LIGHTS AND THE START UP LIGHT ON SUSPENSION SINCE THE DAY I PURCHASED THE AUTOMOBILE. EVERYTIME I TOOK IT IN FOR REPAIR, I GOT A "CANNOT DUPLICATE" IN THE PLACE OF REPAIR. I KNEW NOTHING OF THE RECALL ON THIS ITEMS UNTIL 6/18/2000, WHEN I WAS RESEARCHING OTHER ITEMS ON THE CAVALIER. I WOU…
Read full complaint
I HAVE HAD REOCCURRING PROBLEMS WITH THE LIGHTS AND THE START UP LIGHT ON SUSPENSION SINCE THE DAY I PURCHASED THE AUTOMOBILE. EVERYTIME I TOOK IT IN FOR REPAIR, I GOT A "CANNOT DUPLICATE" IN THE PLACE OF REPAIR. I KNEW NOTHING OF THE RECALL ON THIS ITEMS UNTIL 6/18/2000, WHEN I WAS RESEARCHING OTHER ITEMS ON THE CAVALIER. I WOULD APPRECIATE GETTING THIS REPAIRED AS OPPOSSED TO "CANNOT DUPLICATE." I DO KNOW THE SUSPENSION HAPPENS FAR MORE OFTEN THAN A VEHICLE THIS YOUNG AGE SHOULD. THANK YOU.
NHTSA ODI #724171
Mileage unknown · Feb 19, 2000
Electrical SystemEngine And Engine CoolingExterior Lighting
KNOCKING NOISE NEAR TRUNK AREA, BURNING SMELL CONSTANTLY, PANEL LIGHTS ALWAYS SHOW SOMETHING WRONG, ETS OFF LIGHT BLINKING, TILT STICKS, HORN DEFECTIVE, DON'T START IN WARM WEATHER,POPPING NOISE IN REAR SIDE, COOLANT LEAKS, POWER STEERING HOSES HAD TO BE REPLACED BECAUSE THEY BURNED UP AND LEAKED FLUID ONTO EXHAUST SYSTEM, WINDO…
Read full complaint
KNOCKING NOISE NEAR TRUNK AREA, BURNING SMELL CONSTANTLY, PANEL LIGHTS ALWAYS SHOW SOMETHING WRONG, ETS OFF LIGHT BLINKING, TILT STICKS, HORN DEFECTIVE, DON'T START IN WARM WEATHER,POPPING NOISE IN REAR SIDE, COOLANT LEAKS, POWER STEERING HOSES HAD TO BE REPLACED BECAUSE THEY BURNED UP AND LEAKED FLUID ONTO EXHAUST SYSTEM, WINDOW RATTLES WHEN COMING DOWN, WINDOW NOT ALIGNED RIGHT AIR COMES THROUGH ON BOTH SIDES,ALARM DOESN'T WORK 85% OF THE TIME EVEN WITH NEW BATTERIES, NOTHING BUT PROBLEMS SINCE JUNE 1, 1999.
NHTSA ODI #718978
Mileage unknown · Feb 11, 2000
Electrical SystemEngine And Engine CoolingInterior Lighting
ENGINE HEAD GASKET/STRUTS/STARTER/TRANSMISSION/ DOME LIGHT/ PAINT/,MUFFLER/SEATS AND ABS BRAKES HAVE ALL GONE BADLY AT LEAST ONCE, AND SOME HAVE BEEN REPLACED TWICE AND ARE BAD AGAIN. DEALER WAS NOTIFIED SEVERAL TIMES, BUT REFUSED TO CHECK OR REPLACE. NO LONGER DOING BUSINESS WITH THEM DUE TO THE SERVICE. I HAVE BEEN HAVING T…
Read full complaint
ENGINE HEAD GASKET/STRUTS/STARTER/TRANSMISSION/ DOME LIGHT/ PAINT/,MUFFLER/SEATS AND ABS BRAKES HAVE ALL GONE BADLY AT LEAST ONCE, AND SOME HAVE BEEN REPLACED TWICE AND ARE BAD AGAIN. DEALER WAS NOTIFIED SEVERAL TIMES, BUT REFUSED TO CHECK OR REPLACE. NO LONGER DOING BUSINESS WITH THEM DUE TO THE SERVICE. I HAVE BEEN HAVING TO PAY FOR ALL OF THE SERVICES. *AK
NHTSA ODI #718613
Mileage unknown · Jan 20, 2000
Suspension
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #717580
Mileage unknown · May 18, 1999
Suspension
VEHICLE EXPERIENCES PROBLEMS WITH SUSPENSION RECALL COMPONENT, HOWEVER IS HAVING DIFFICULTY RECEIVING REPAIR WORK. MJS (98V-319)
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN MARCH 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, BUICK AT 1-800-521-7300, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. BECAUSE OF CERTAIN CALIBRATIONS IN THE AIR BAG'S SENSING AND DIAGNOSTIC MODULE, AN INADVERTENT AIR BAG DEPLOYMENT COULD OCCUR IN A LOW SPEED CRASH OR WHEN AN OBJECT STRIKES THE FLOOR PAN.
Consequence & remedy
Consequence: AIR BAGS DEPLOY WITH GREAT FORCE AND CAN SERIOUSLY INJURE UNRESTRAINED OCCUPANTS WHO ARE TOO CLOSE TO THEM.
Remedy: DEALERS WILL RECALIBRATE THE AIR BAG SENSING AND DIAGNOSTIC MODULE.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES WERE BUILT WITH THE POTENTIAL FOR THE INTERIOR LAMPS TO COME ON UNEXPECTEDLY WHILE THE VEHICLES ARE BEING DRIVEN. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 101, "CONTROLS AND DISPLAYS."
Consequence & remedy
Consequence: THE INTERIOR LAMPS COMING ON UNEXPECTEDLY COULD STARTLE A DRIVER CAUSING A MOMENTARY LOSS OF CONTROL INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL RUN A DIAGNOSTIC TEST ON THE LAMP CONTROL MODULE AND, IF NECESSARY, REPLACE IT.
THE FRONT AND/OR REAR HAZARD WARNING LAMPS (FOUR-WAY FLASHERS) DO NOT FLASH WHEN THE HAZARD SWITCH IS ACTIVATED. THIS FAILS TO COMPLY WITH FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THESE LAMPS WERE NOT FLASHING, OTHER VEHICLES WOULD NOT BE AWARE THAT THIS VEHICLE WAS STOPPED INCREASING THE RISK OF AN ACCIDENT.
Remedy: DEALERS OR VEHICLE OWNERS WILL INSPECT FOR PROPER FUNCTION OF THE HAZARD WARNING LAMPS. IF NECESSARY, DEALERS WILL REPLACE THE HAZARD LAMP SWITCH.
THE ACCELERATOR CONTROL CABLE COULD HAVE BEEN KINKED DURING ASSEMBLY CAUSING HIGH ACCELERATOR PEDAL EFFORT, STICKING ACCELERATOR CONTROL CABLE, OR A BROKEN ACCELERATOR CONTROL CABLE.
Consequence & remedy
Consequence: IF THE ACCELERATOR CONTROL CABLE STICKS OR BREAKS, UNWANTED ACCELERATION AND/OR LOSS OF THROTTLE CONTROL CAN RESULT INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE ACCELERATOR CONTROL CABLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
DP03007 · Unintended Vehicle Acceleration
Opened Oct 14, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Fuel System, Other:delivery
ON SEPTEMBER 23, 2003, THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) RECEIVED A LETTER DATED SEPTEMBER 8, 2003 FROM MR. DONALD FRIEDMAN, PETITIONING THE AGENCY TO OPEN A DEFECT INVESTIGATION INTO UNINTENDED ACCELERATION INVOLVING [MODEL YEAR] 1996 AND 1997 GENERAL MOTORS J-CARS.IN SUPPORT OF HIS PETITION, MR. FRIEDMAN CITED A REPORT HE RECEIVED FOR GM SHOWING IT HAD RECEIVED FAR MORE REPORTS OF ALLEGED UNINTENDED ACCELERATION FOR THESE MODELS THAN FOR OTHERS.AFTER ASSESSING THE DATA CLAIMED BY THE PETITIONER TO JUSTIFY HIS REQUEST, ODI FOUND NO INDICATION THAT DEFECT TREND RELATED TO THE PETITIONER'S ALLEGATIONS EXISTS AT THIS TIME.THEREFORE, THERE IS NO REASONABLE POSIBILITY THAT AN ORDER CONCERNING THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT WOULD BE ISSUED AS A RESULT OF GRANTING MR. FRIEDMAN'S PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.FOR ADDITIONAL INFORMATION CONCERNING THIS ANALYSIS, PLEASE REFER TO THE ATTACHED FEDERAL REGISTER NOTICE.
PE02001 · Fire In Steering Column Area
Opened Jan 3, 2002 · Closed Mar 15, 2002
Status: closed (inferred from source dates) · Electrical System
No summary supplied.
EA98001 · Oversensitive Air Bag Deployments
Opened Jan 23, 1998 · Closed Jul 31, 1998
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE97041 · Inadvertent Air Bag Deployments
Opened Sep 9, 1997 · Closed Jan 23, 1998
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
1996 Chevrolet Cavalier Problems, Complaints & Recalls | Skip That Year
Illustration