IllustrationREAR TIRES MEASURE APPROX. 96 FRONT TIRES APPROX 91. DT
1994 Chevrolet C3500
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all C3500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 18 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Visibility. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
Power Train complaints
4 reportsWHILE PULLING A HEAVY LOAD WITH VEHICLE CLUTCH PEDAL WILL GO TO FLOOR, CAUSING CONSUMER TO LOSE CLUTCH. CONSUMER FEELS THAT THIS IS THE RESULT OF HEAT COMING FROM EXHAUST PIPE IN ENGINE BEING TOO EXCESSIVE, AND CAUSING SLAVE CYLINDER TO MALFUNCTION.*AK CONSUMER STATES THE ENTIRE HYDRAULIC SYSTEM HAS BEEN FLUSHED SEVERAL…
Read full complaint
WHILE PULLING A HEAVY LOAD WITH VEHICLE CLUTCH PEDAL WILL GO TO FLOOR, CAUSING CONSUMER TO LOSE CLUTCH. CONSUMER FEELS THAT THIS IS THE RESULT OF HEAT COMING FROM EXHAUST PIPE IN ENGINE BEING TOO EXCESSIVE, AND CAUSING SLAVE CYLINDER TO MALFUNCTION.*AK CONSUMER STATES THE ENTIRE HYDRAULIC SYSTEM HAS BEEN FLUSHED SEVERAL TIMES, ALSO THE SLAVE CYLINDER HAS BEEN REPLACED, BUT PROBLEM IS STILL NOT RESOLVED. *JB
CLUTCH PEDAL IS HARD TO PUSH DOWN AND THERE'RE DIFFICULTIES SHIFTING GEARS. THE CLUTCH BALL AND FORK WERE BROKEN. ALSO, PROBLEMS EXISTED WITH THE HYDRAULIC SYSTEM.
TRANSMISSION DISINTEGRATED/WOULD NOT GO INTO GEAR DUE TO INSUFFICIENT LUBRICANT.
Official recalls
199V025000 · Exterior Lighting:brake Lights:switch
Feb 5, 1999
VEHICLE DESCRIPTION: PICKUP TRUCKS, CREW CABS, UTILITY TRUCKS AND SPORT UTILITY VEHICLES. THESE VEHICLES WERE BUILT WITH THE POLARITY OF THE WIRING FOR THE ZERO ADJUST BRAKE SWITCH REVERSED FROM WHAT WAS SPECIFIED ON THE SWITCH DRAWING. WITH THE REVERSED POLARITY, THE CONTACTS IN THE BRAKE SWITCH CAN WEAR OUT PREMATURELY. THE BRAKE SWITCH WILL PERFORM NORMALLY UNTIL THE BRAKE SWITCH CONTACTS WEAR OUT, RESULTING IN LOSS OF THE BRAKE LAMPS WITHOUT ANY WARNING TO THE DRIVER.
Consequence & remedy
Consequence: THIS WOULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND COULD LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE BRAKE SWITCH AND REVERSE THE WIRING.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA97023 · Driver's Seat Frame Failure
Opened Oct 31, 1997 · Closed Jun 1, 1999
Status: closed (inferred from source dates) · Seats
THE OFFICE OF DEFECTS INVESTIGATION HAS RECEIVED 375 REPORTS ALLEGING FAILURE OF THE DRIVER'S SEAT FRAME WHICH IS PRONE TO BREAKAGE AT THE LEFT FRONT ATTACHING POINT.WHEN THIS OCCURS, THE SEAT MAY TILT AWAY FROM THE RISER DURING ACCELERATING OR BRAKING.(SEE CLOSING REPORT)