ENGINE REVS UP WHEN ENGINE IS COLD AND IDLES DOWN THE ROAD AT 35 MPH I FIRST REPORTED THIS TO THE DEALER SOON AFTER I BOUGHT THIS TRUCK AND WAS TOLD THAT IT WAS THE WAY A 5.0 L. ENGINE OPERATED AND NOTHING COULD BE DONE ABOUT IT AFTER SEVERAL NEAR CRASHES BECAUSE OF THE RPMS OF THE ENGINE AS I HAVE APPROACHED ICY INTERSECTIONS B…
Read full complaint
ENGINE REVS UP WHEN ENGINE IS COLD AND IDLES DOWN THE ROAD AT 35 MPH I FIRST REPORTED THIS TO THE DEALER SOON AFTER I BOUGHT THIS TRUCK AND WAS TOLD THAT IT WAS THE WAY A 5.0 L. ENGINE OPERATED AND NOTHING COULD BE DONE ABOUT IT AFTER SEVERAL NEAR CRASHES BECAUSE OF THE RPMS OF THE ENGINE AS I HAVE APPROACHED ICY INTERSECTIONS BECAUSE THE WHEELS WOULD BE PUSHING ME AND THE BRAKES WOULD LOCK UP I WOULD HAVE TO SHIFT INTO NETURAL TO KEEP FROM RUNNNG INTO THE INTERSECTION, AFTER 5 YEARS I HAVE THIS IS A SAFETY HAZARD AND THE DEALER MAY HAVE BEEN IN ERROR AS THO THE PROBLEM OR OTHERWISE. THIS HAS HAPPENED SEVERAL TIMES (THE ICY ROADS) AM I THE ONLY ONE HAVING THIS PROBLEM?*AK
NHTSA ODI #743036
Mileage unknown · Jul 22, 1999
Service Brakes, Hydraulic
CONSUMER EXPERIENCING EXCESSIVE WEAR OF THE FRONT BRAKE SHOES AND PADS, REPLACED THE PADS FOUR TIMES IN ONE YEAR .ALSO, BRAKE DUST ON THE BRAKE WHEELS, AND BRAKE HOSE HAS BEEN REPLACED ON TWO OCCASIONS. PLEASE PROVIDE ANY FURTHER DETAILS. *AK
VEHICLE DESCRIPTION: CREW CAB PICKUP TRUCKS. THE FRONT, INNER CORNER OF THE FUEL TANK CAN CONTACT THE BODY SILL EITHER INTERMITTENTLY OR CONSTANTLY. THIS MOVEMENT CAN CAUSE A DISCERNIBLE NOISE AND, OVER TIME, CAN WEAR A HOLE IN OR CRACK THE FUEL TANK AT POINT OF CONTACT.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN FUEL LEAKAGE AND A DISTINCT FUEL ODOR IF THE TANK WERE FILLED ABOVE THE LEVEL OF THE HOLE OR CRACK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD RESULT.
Remedy: DEALERS WILL INSPECT THE FUEL TANK FOR WEAR AND, EITHER INSTALL A SPACER BETWEEN THE FUEL TANK AND THE FRONT CROSSMEMBER, OR IF NECESSARY, REPLACE THE FUEL TANK.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
VEHICLE DESCRIPTION: EXTENDED CAB AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH RECLINING SEATS AND THE EASY-ENTRY FEATURE. THESE VEHICLES EXHIBIT A CONDITION IN WHICH A PINCH POINT EXISTS IN THE RECLINER MECHANISM THAT CAN TRAP AND PINCH A PERSON'S HAND OR FINGER(S) WHEN THE EASY-ENTRY FEATURE IS ACTIVATED.
Consequence & remedy
Consequence: THIS PINCHING CAN CUT THE HAND OR POSSIBLY SEVER THE FINGER(S) WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSTALL A PROTECTOR COVER OVER THE RECLINER MECHANISM.
THE FOUR U-BOLTS NUTS ON EITHER SIDE OF THE REAR AXLE WERE UNDER-TORQUED.
Consequence & remedy
Consequence: VEHICLE USAGE COULD CAUSE THE NUTS TO LOOSEN AND EVENTUALLY FALL OFF THE U-BOLT. THIS COULD RESULT IN SUDDEN LOSS OF VEHICLE CONTROL INCREASING THE POTENTIAL FOR A VEHICLE CRASH.
Remedy: DEALERS WILL CHECK THE U-BOLT NUT TORQUE AND RE-TORQUE ANY LOOSE U-BOLTS TO SPECIFICATION.
THESE VEHICLES WERE ASSEMBLED WITH THE THROTTLE CABLE CONTACTING THE DASH MAT WHICH COULD BIND THE THROTTLE. THIS DOES NOT MEET WITH THE MAXIMUM RETURN TIMES REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, "ACCELERATOR CONTROL SYSTEMS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT FOR ADEQUATE THROTTLE CABLE TO DASH MAT CLEARANCE, AND IF THERE IS INSUFFICIENT CLEARANCE, CUT OUT A PORTION OF THE DASH MAT TO PROVIDE PROPER CLEARANCE.
Illustration