I AM ONE OF THE THE LUCKY ONES. I WAS PULLING IN MY DRIVEWAY AND THE REAR BRAKE LINE BLEW AND THE BRAKE PEDAL WENT TO THE FLOOR! I'M VERY LUCKY I DID NOT GO THROUGH MY GARAGE DOOR! I HAVE THE TRUCK AT SUTHERLAND CHEVROLET WAITING FOR THE DAMAGES $$$$ I CAN'T GIVE YOU THE MILEAGE BECAUSE IT AT THE DEALERSHIP. CORRODED …
Read full complaint
I AM ONE OF THE THE LUCKY ONES. I WAS PULLING IN MY DRIVEWAY AND THE REAR BRAKE LINE BLEW AND THE BRAKE PEDAL WENT TO THE FLOOR! I'M VERY LUCKY I DID NOT GO THROUGH MY GARAGE DOOR! I HAVE THE TRUCK AT SUTHERLAND CHEVROLET WAITING FOR THE DAMAGES $$$$ I CAN'T GIVE YOU THE MILEAGE BECAUSE IT AT THE DEALERSHIP. CORRODED BRAKE LINES!
NHTSA ODI #10722512
102,000 miles · Sep 16, 2014
Air BagsService BrakesCrashInjury
I WAS INVOLVED IN A HEAD ON COLLISION WITH ANOTHER VEHICLE, A LARGER GMC DUALLY. I WAS TRAVELING AT 55 MPH WHEN THE OTHER VEHICLE ENTERED MY LANE AT NEAR OR EQUAL SPEED AND STRUCK ME HEAD ON. I HAD TIME TO REACT BY STOMPING THE BRAKES BUT I SEEMED TO NOT SLOW DOWN. I HAD NO WHERE TO TURN ALL POSSIBLE LANES OF AVOIDANCE WERE BLOC…
Read full complaint
I WAS INVOLVED IN A HEAD ON COLLISION WITH ANOTHER VEHICLE, A LARGER GMC DUALLY. I WAS TRAVELING AT 55 MPH WHEN THE OTHER VEHICLE ENTERED MY LANE AT NEAR OR EQUAL SPEED AND STRUCK ME HEAD ON. I HAD TIME TO REACT BY STOMPING THE BRAKES BUT I SEEMED TO NOT SLOW DOWN. I HAD NO WHERE TO TURN ALL POSSIBLE LANES OF AVOIDANCE WERE BLOCKED WITH SMALLER CARS. THE AIRBAGS DID NOT DEPLOY... IT IS MY UNDERSTANDING THAT BY LAW CARS/LIGHT TRUCKS ARE REQUIRED BY LAW TO HAVE AIRBAGS IF THEY ARE 1998 OR NEWER. I UNDERSTAND A LIGHT TRUCK TO BE UP TO 8,600 LBS GROSS WEIGHT WITH PAYLOAD. THIS STANDARD INCLUDES MY TRUCK, I SUSTAINED SEVER INJURIES TO MY NECK/CHEST AND RUPTURED DISCS IN MY BACK RESULTING IN EMERGENCY BACK SURGERY. IF I HAD AIRBAGS I AM SURE MY INJURIES WOULD NOT HAVE BEEN NEARLY AS SERVER AND I MY HAVE NOT LOST SO MUCH. SOMEONE IS RESPONSIBLE FOR THIS AND I WOULD APPRECIATE ANY AND ALL ASSISTANCE YOU CAN OFFER ME. THANK YOU *TR
NHTSA ODI #10633791
53,874 miles · Sep 25, 2013
Service BrakesCrash
RUSTED THRU BREAK LINES. *JS
NHTSA ODI #10545327
69,854 miles · Mar 16, 2013
Service Brakes
APPROACHING INTERSECTION GREEN LITE CHANGED TO RED BEING FIRST TO GET TO CROSSING I APPLIED MY BRAKES AND PEDAL WENT TO FLOOR!!! NEEDLESS TO SAY I DID NOT STOP FOR RED LITE FOR 4 LANE HI-WAY, PULLED OVER A SAW PUDDLE FORMING FROM BRAKE LINE, LOOKING ACROSS THE INTERSECTION THERE WAS A LARGER PUDDLE APPR. WHERE BRAKE WAS AP…
Read full complaint
APPROACHING INTERSECTION GREEN LITE CHANGED TO RED BEING FIRST TO GET TO CROSSING I APPLIED MY BRAKES AND PEDAL WENT TO FLOOR!!! NEEDLESS TO SAY I DID NOT STOP FOR RED LITE FOR 4 LANE HI-WAY, PULLED OVER A SAW PUDDLE FORMING FROM BRAKE LINE, LOOKING ACROSS THE INTERSECTION THERE WAS A LARGER PUDDLE APPR. WHERE BRAKE WAS APPLIED. THANK GOD NO CARS WERE CLOSE, I SURE IF I HIT SOME ONE THE FIRST WOULD BE SAID, A OLD MAN WENT THROUGH RED LITE, CORRECT, NO BRAKES!!!!!!! [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10503270
102,000 miles · Sep 21, 2012
Service Brakes
WAS MOVING TRUCK INTO DRIVE WAY AFTER IT HAD BEEN PARKED IN THE STREET. UPON PULLING INTO THE DRIVE WAY I NOTICED I HAD NO BRAKES. TURNED TRUCK OFF AND CHECKED UNDER TRUCK TO FIND THAT THERE WAS BRAKE FLUID LEAKING FROM UNDER THE TRUCK BY THE LEFT REAR WHEEL. UPON CALLING MY MECHANIC I AM TOLD THAT THIS IS A NORMAL THING WITH MY…
Read full complaint
WAS MOVING TRUCK INTO DRIVE WAY AFTER IT HAD BEEN PARKED IN THE STREET. UPON PULLING INTO THE DRIVE WAY I NOTICED I HAD NO BRAKES. TURNED TRUCK OFF AND CHECKED UNDER TRUCK TO FIND THAT THERE WAS BRAKE FLUID LEAKING FROM UNDER THE TRUCK BY THE LEFT REAR WHEEL. UPON CALLING MY MECHANIC I AM TOLD THAT THIS IS A NORMAL THING WITH MY YEAR TRUCK AND THAT IT WAS BEING INVESTIGATED BY THE NHTSA BECAUSE OF THE AMOUNT OF COMPLAINTS. OH AND ALSO IT WOULD COST ALMOST 800.00 DOLLARS TO REPAIR BECAUSE THE MECHANIC WILL NOT JUST REPLACE ONE LINE BECAUSE ONCE ONE GOES THEY ALL START TO GO BASED ON HIS EXPERIENCE WITH MY YEAR TRUCK. HE DOES THIS FOR SAFETY REASONS. I HAVE HAD THE CAR TOWED TO MY MECHANIC TO BE REPAIRED. ANOTHER 94.00 DOLLARS. AFTER AGAIN TALKING TO MY MECHANIC HE TELLS ME THE BRAKE LINE HAS CORRODED. *TR
SOME PICKUP TRUCKS, VANS, AND SPORT UTILITY VEHICLES EQUIPPED WITH A HYDRAULIC PUMP DRIVESHAFT THAT CAN FRACTURE, RESULTING IN IMMEDIATE LOSS OF HYDRAULIC POWER STEERING ASSIST. ON CERTAIN VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, THE SAME CONDITION CAN RESULT IN LOSS OF POWER ASSIST FOR BRAKING AFTER THE RESERVE PRESSURE IS DEPLETED.
Consequence & remedy
Consequence: AN INOPERATIVE PUMP CAN CAUSE INCREASED STEERING EFFORT, AND IN HYDRO-BOOST EQUIPPED VEHICLES ALSO INCREASED BRAKING EFFORT, BUT DOES NOT COMPLETELY ELIMINATE THE ABILITY TO STEER OR SLOW THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE HYDRAULIC PUMP. THE CAMPAIGN BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Additional source detail variants (3)
Parking Brake:conventional
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Parking Brake:conventional:mechanical
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
Parking Brake
ODI'S REVIEW OF COMPLAINT DATA RECEIVED SINCE THE CLOSE OF EA04-011 REVEALED NO INDICATION THAT THE INVESTIGATION SHOULD BE RE-OPENED.MORE DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE ENCLOSED IN THE DP05-009 PUBLIC FILE.ODI RESERVES THE RIGHT TO REOPEN THE INVESTIGATION IN THE FUTURE SHOULD CONDITIONS WARRANT.
EA04012 · Hydraulic Pump Failres
Opened Apr 30, 2004 · Closed Feb 28, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist; Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
EA04011 · Parking Brake Failure
Opened Apr 9, 2004 · Closed May 10, 2005
Status: closed (inferred from source dates) · Parking Brake; Parking Brake:conventional; Parking Brake:conventional:mechanical; Parking Brake:conventional:mechanical:linkage And Cable
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (4)
Parking Brake:conventional
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake:conventional:mechanical
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake:conventional:mechanical:linkage And Cable
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Parking Brake
IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE03057 · Parking Brake Failure
Opened Dec 8, 2003 · Closed Apr 9, 2004
Status: closed (inferred from source dates) · Parking Brake
ODI OPENED PE03-057 TO ASSESS PARKING BRAKE INEFFECTIVENESS IN THE SUBJECT VEHICLES.THESE VEHICLES ARE EQUIPPED WITH FOUR WHEEL DISC BRAKES THAT INCORPORATE A SINGLE-SHOE DRUM-IN-HAT PARKING BRAKE INDEPENDENT OF THE SERVICE BRAKES.COMPLAINT AND WARRANTY DATA INDICATE THAT THE PARKING BRAKE LININGS TEND TO WEAR OUT EARLY IN THE LIFE OF THE VEHICLE (AT AN AVERAGE OF 24 MONTHS IN SERVICE), REDUCING THE PARKING BRAKE SYSTEM'S TORQUE BELOW THAT NEEDED TO IMMOBILIZE THE VEHICLE.GM HAS ATTRIBUTED THIS ACCELERATED WEAR TO FOREIGN MATERIAL INTRUSION AND A FAILURE OF THE BRAKE SHOE TO PROPERLY SELF-CENTER WITHIN ITS BRAKE DRUM.EFFECTIVE WITH THE START OF MY 2003 PRODUCTION, A NEWER REDUCED FORCE HOLD-DOWN CLIP WAS INTRODUCED TO FACILITATE BRAKE SHOE DISENGAGEMENT FROM THE DRUM SURFACE.THIS PART IS ALSO AVAILABLE AT THE SERVICE LEVEL FOR THE MY 1999-2002 VEHICLES.GM HAS INDICATED THAT THE PAKING BRAKE IS INTENDED TO OPERATE IN CONJUNCTION WITH THE TRANSMISSION TO IMMOBILZE PARKED VEHICLES, AND THAT IN MANY CASES, ACCELERATED PARKING BRAKE LINING WEAR IS CAUSED BY ROUGH USE, VEHICLE MODIFICATIONS, AND DRIVING WITH THE PARKING ENGAGED. ODI HAS UPGRADED THE PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING PARKING BRAKE USAGE FACTORS AND THE CIRCUMSTANCES SURROUNDING THE SEVENTEEN REPORTED VEHICLE CRASHES.
THE AUTOMATIC LOCKING RETRACTOR (ALR) IS A FEATURE INCORPORATED IN THE SUBJECT VEHICLE FOR LOCKING THE WEBBING TO PROPERLY SECURE A CHILD SAFETY SEAT INTO A VEHICLE.THIS PE WAS OPENED BASED ON A GM TECHNICAL SERVICE BULLETIN STATING THAT WITH CERTAIN CHILD SAFETY SEATS THE WEBBING MAY NOT REMAIN LOCKED.THERE ARE NO COMPLAINTS IN THE ODI DATABASE AND ONLY TWO COMPLAINTS TO GM.GM'S INSTRUCTIONS STATE FOR THE FINAL STEP IN USING THE WEBBING LOCK FEATURE TO PUSH AND PULL THE CHILD RESTRAINT TO BE SURE IT IS SECURE. IF THE ALR IS NOT LOCKED, THE USER WOULD BE FULLY AWARE OF THIS CONDITION PRIOR TO COMPLETING PROPER INSTALLATION OF THE CHILD SAFETY SEAT IN THIS VEHICLE.THIS INVESTIGATION DID NOT UNCOVER ANY COMPLAINTS OF THE ALR INADVERTENTLY UNLOCKING WHILE THE VEHICLE IS IN MOTION.THE EMERGENCY LOCKING RETRACTOR (ELR) FEATURE REMAINS AVAILABLE TO LOCK THE RETRACTOR IN A CRASH.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY FOR ADDITIONAL INFORMATION.
Additional source detail variants (2)
Seat Belts
THE AUTOMATIC LOCKING RETRACTOR (ALR) IS A FEATURE INCORPORATED IN THE SUBJECT VEHICLE FOR LOCKING THE WEBBING TO PROPERLY SECURE A CHILD SAFETY SEAT INTO A VEHICLE.THIS PE WAS OPENED BASED ON A GM TECHNICAL SERVICE BULLETIN STATING THAT WITH CERTAIN CHILD SAFETY SEATS THE WEBBING MAY NOT REMAIN LOCKED.THERE ARE NO COMPLAINTS IN THE ODI DATABASE AND ONLY TWO COMPLAINTS TO GM.GM'S INSTRUCTIONS STATE FOR THE FINAL STEP IN USING THE WEBBING LOCK FEATURE TO PUSH AND PULL THE CHILD RESTRAINT TO BE SURE IT IS SECURE. IF THE ALR IS NOT LOCKED, THE USER WOULD BE FULLY AWARE OF THIS CONDITION PRIOR TO COMPLETING PROPER INSTALLATION OF THE CHILD SAFETY SEAT IN THIS VEHICLE.THIS INVESTIGATION DID NOT UNCOVER ANY COMPLAINTS OF THE ALR INADVERTENTLY UNLOCKING WHILE THE VEHICLE IS IN MOTION.THE EMERGENCY LOCKING RETRACTOR (ELR) FEATURE REMAINS AVAILABLE TO LOCK THE RETRACTOR IN A CRASH.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY FOR ADDITIONAL INFORMATION.
Seat Belts:rear/other
THE AUTOMATIC LOCKING RETRACTOR (ALR) IS A FEATURE INCORPORATED IN THE SUBJECT VEHICLE FOR LOCKING THE WEBBING TO PROPERLY SECURE A CHILD SAFETY SEAT INTO A VEHICLE.THIS PE WAS OPENED BASED ON A GM TECHNICAL SERVICE BULLETIN STATING THAT WITH CERTAIN CHILD SAFETY SEATS THE WEBBING MAY NOT REMAIN LOCKED.THERE ARE NO COMPLAINTS IN THE ODI DATABASE AND ONLY TWO COMPLAINTS TO GM.GM'S INSTRUCTIONS STATE FOR THE FINAL STEP IN USING THE WEBBING LOCK FEATURE TO PUSH AND PULL THE CHILD RESTRAINT TO BE SURE IT IS SECURE. IF THE ALR IS NOT LOCKED, THE USER WOULD BE FULLY AWARE OF THIS CONDITION PRIOR TO COMPLETING PROPER INSTALLATION OF THE CHILD SAFETY SEAT IN THIS VEHICLE.THIS INVESTIGATION DID NOT UNCOVER ANY COMPLAINTS OF THE ALR INADVERTENTLY UNLOCKING WHILE THE VEHICLE IS IN MOTION.THE EMERGENCY LOCKING RETRACTOR (ELR) FEATURE REMAINS AVAILABLE TO LOCK THE RETRACTOR IN A CRASH.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY FOR ADDITIONAL INFORMATION.
PE01001 · Vacuum Brake Booster
Opened Jan 8, 2001 · Closed May 22, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
ALLEGED THAT THE VACUUM BRAKE BOOSTER CAN FAIL RESULTING IN LOSS OF BRAKE EFFECTIVENESS AND EXTENDED STOPPING DISTANCES.
2000 Chevrolet C/K Pickups Problems, Complaints & Recalls | Skip That Year
Illustration