Without any warning or physical impact, the central infotainment screen completely blanked out and suffered an irreversible hardware failure. This screen acts as the mandatory display terminal for the vehicle's rear-visibility backup camera, as well as the audio generation module for the vehicle's driver alerts. Because of this…
Read full complaint
Without any warning or physical impact, the central infotainment screen completely blanked out and suffered an irreversible hardware failure. This screen acts as the mandatory display terminal for the vehicle's rear-visibility backup camera, as well as the audio generation module for the vehicle's driver alerts. Because of this component failure, the vehicle is in direct non-compliance with Federal Motor Vehicle Safety Standards (FMVSS): 1.FMVSS 111 (Rear Visibility): The vehicle completely fails to display a rear-view image when shifted into reverse, creating an immediate blind-spot hazard for pedestrians. 2. FMVSS 101 (Controls and Displays): All critical audible safety alerts, pedestrian alerts, and driver warning chimes have been entirely silenced. The manufacturer (General Motors) and the authorized franchise dealership (F.H. Dailey Chevrolet) have acknowledged the failure and have the part on backorder, but refuse to fully cover the safety restoration under warranty or provide a temporary loaner vehicle. This forces the primary driver, a [XXX] senior citizen, to choose between total isolation or operating a hazardous, federally non-compliant vehicle. This appears to be a systemic manufacturing or design defect inherently tied to the internal HMI module architecture on the late-model Chevrolet Bolt EV platform, rather than individual wear and tear. A formal investigation is requested to mandate a safety recall and enforce full manufacturer accountability. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11740712
Mileage unknown · Jun 11, 2024
Air BagsForward Collision AvoidanceCrash
Electric pole broken onto the street and hit the car, cause severe damage to the front-left-corner on the Chevy Bolt EV 2023. The airbags did not deploy. Safety of the driver and infant was diminished greatly.
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. This recall includes certain vehicles previously repaired incorrectly under NHTSA recall number 22V-930. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence & remedy
Consequence: A fire increases the risk of injury.
Remedy: Dealers will inspect both front seat belt pretensioners and, if necessary, install metal foil at the carpet near the pretensioner exhaust. Certain vehicles will also need a pretensioner cover installed. Repairs will be performed free of charge. Owner notification letters were mailed January 24, 2024. These vehicles were previously recalled for this same issue under recall number 22V-930 and will need to have the new remedy performed. Owners may contact GM EV Concierge at 1-833-EVCHEVY (1-833-382-4389) (TTY 711 / 1-800-833-2438) or Customer Service at 1-800-222-1020. GM's number for this recall is N232421970.
Additional source detail variants (2)
Seat Belts:pretensioner
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. This recall includes certain vehicles previously repaired incorrectly under NHTSA recall number 22V-930. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence: A fire increases the risk of injury.
Remedy: Dealers will inspect both front seat belt pretensioners and, if necessary, install metal foil at the carpet near the pretensioner exhaust. Certain vehicles will also need a pretensioner cover installed. Repairs will be performed free of charge. Owner notification letters were mailed January 24, 2024. These vehicles were previously recalled for this same issue under recall number 22V-930 and will need to have the new remedy performed. Owners may contact GM EV Concierge at 1-833-EVCHEVY (1-833-382-4389) (TTY 711 / 1-800-833-2438) or Customer Service at 1-800-222-1020. GM's number for this recall is N232421970.
Structure:body:roof And Pillars
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. This recall includes certain vehicles previously repaired incorrectly under NHTSA recall number 22V-930. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence: A fire increases the risk of injury.
Remedy: Dealers will inspect both front seat belt pretensioners and, if necessary, install metal foil at the carpet near the pretensioner exhaust. Certain vehicles will also need a pretensioner cover installed. Repairs will be performed free of charge. Owner notification letters were mailed January 24, 2024. These vehicles were previously recalled for this same issue under recall number 22V-930 and will need to have the new remedy performed. Owners may contact GM EV Concierge at 1-833-EVCHEVY (1-833-382-4389) (TTY 711 / 1-800-833-2438) or Customer Service at 1-800-222-1020. GM's number for this recall is N232421970.
General Motors, LLC (GM) is recalling certain 2022-2023 Chevrolet Bolt EV vehicles. The instrument panel may be missing the perforation on the underside of the panel cover that allows the passenger-side air bag to deploy properly.
Consequence & remedy
Consequence: An air bag that does not deploy properly in a crash increases the risk of injury.
Remedy: Dealers will replace the instrument panel, free of charge. Owner notification letters were mailed December 21, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N232414710.
Additional source detail variants (2)
Electrical System: Instrument Cluster/panel
General Motors, LLC (GM) is recalling certain 2022-2023 Chevrolet Bolt EV vehicles. The instrument panel may be missing the perforation on the underside of the panel cover that allows the passenger-side air bag to deploy properly.
Consequence: An air bag that does not deploy properly in a crash increases the risk of injury.
Remedy: Dealers will replace the instrument panel, free of charge. Owner notification letters were mailed December 21, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N232414710.
Air Bags:frontal
General Motors, LLC (GM) is recalling certain 2022-2023 Chevrolet Bolt EV vehicles. The instrument panel may be missing the perforation on the underside of the panel cover that allows the passenger-side air bag to deploy properly.
Consequence: An air bag that does not deploy properly in a crash increases the risk of injury.
Remedy: Dealers will replace the instrument panel, free of charge. Owner notification letters were mailed December 21, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N232414710.
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence & remedy
Consequence: A vehicle fire can increase the risk of injury.
Remedy: Dealers will install metal foil at the carpet near the pretensioner exhaust, and install a pretensioner cover as necessary, free of charge. Owner notification letters were mailed between January 23, 2023 and April 25, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N222383790.
Additional source detail variants (2)
Seat Belts:pretensioner
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence: A vehicle fire can increase the risk of injury.
Remedy: Dealers will install metal foil at the carpet near the pretensioner exhaust, and install a pretensioner cover as necessary, free of charge. Owner notification letters were mailed between January 23, 2023 and April 25, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N222383790.
Structure:body:roof And Pillars
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence: A vehicle fire can increase the risk of injury.
Remedy: Dealers will install metal foil at the carpet near the pretensioner exhaust, and install a pretensioner cover as necessary, free of charge. Owner notification letters were mailed between January 23, 2023 and April 25, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N222383790.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2023 Chevrolet Bolt Ev Problems, Complaints & Recalls | Skip That Year
Illustration