2020 Chevrolet Blazer

The thermostat is getting stuck open and giving me a reduced steering assist error. My safety was put at risk because of the steering assist being reduced. The problem has not been reproduced but there are many issues online about the same model, year, and mileage all having the same issue. The component is going to be inspected by a service manufacturer. There were no warning lamps prior to error.

What component or system failed or malfunctioned, and is it available for inspection upon request? Multiple components in the engine timing and transmission system have failed. These include: Camshaft actuator solenoid valve failed twice (at ~30,000 and ~60,000 miles), each time with different DTC codes. Camshaft positioning sensor failed, triggering P0024 (“timing advanced and bouncing around”). Timing chain tensioner spring failed, requiring re-timing. Camshaft carrier case gasket experienced a major oil leak at 59,000 miles. Thermostat failed. Battery was replaced, but no diagnostic testing was performed—only code clearing. At 82,000 miles: Torque converter has failed, transmission fluid is tarnished, and the radiator is leaking internally. Yes, the vehicle is available for inspection upon request and has been registered as non-operational. How was your safety or the safety of others put at risk? The vehicle exhibited repeated hesitation, delays when accelerating, and revving while braking. In stop-and-go traffic, it now sputters as if it may stall. These behaviors create unsafe driving conditions, especially at intersections and in congested areas, putting both myself and other drivers at risk. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The torque converter failure and transmission issues were confirmed by National Transmission in Long Beach, CA. Prior component failures were confirmed by Martin Chevrolet, who performed both camshaft actuator solenoid valve replacements under warranty. Multiple DTC codes were recorded and cleared, but no electrical testing was performed. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle has been serviced by authorized GM dealerships, but GM did not escalate the issue to their TAC (Technical Assistance Center) or assign a field engineer, in violation of GM's internal escalation policy. No inspections

In March 2025 a Steering assist reduced warning came on briefly. Over the next several weeks intermittent. April 2025 Engine warning light came on. 4-14-25 Went to ToddWenzel Chevrolet for diagnosis to be told the Thermostat needs to be changed and due to a small amount of crystallization on the radiator that as well. I had just had oil changed and fluid levels topped off that morning at Parkway express who did not identify concerns. 4-15-25 brought to Parker Brake who diagnosed and identified there was a glitch that prompted the warning and they can tell that fired when not driving, temp 125Degrees. "it may have been parked cooling down". They noted not need for additional service. Thermostat fine and no evidence of radiator leak. They cleared codes/engine warning. After about a week experiencing intermittent assist reduced warning again. I am understanding that this is a known problem w/ these Blazers and changing thermostat for many does not work. Where does this leave me? GM needs to help with the cost and figuring this out. I am concerned about sudden failure of something while driving that could be unsafe for myself/others.

To whom it may concern, I purchased a new 2020 Chevy Blazer from the dealership five years ago. Since then I have had to replace my battery twice, radiator and now the thermostat all of which have been done at the dealership. The car and all receipts of the repairs are available for inspection if requested. This most recent mechanical issue with the thermostat included the following; fans blowing on high, no AC, check engine light, steering assist reduced message, and temp gauge on C. The car was immediately (same day) taken to the dealership for investigation. Upon inspecting the car the mechanic found the thermostat sticking open and indicated that it would need to be replaced as it was unsafe to drive. A total cost of $1400. It seemed odd that my car is only 5 years old with 75k miles and needing to have the thermostat replaced so I started researching this issue further. I found several complaints on the www.chevyblazer.org forum from other 2020 Chevy Blazer owners with the same mechanical issue. There is one comment on the forum from a mechanic stating that this issue is caused by a faulty wire harness and will continue to cause similar issues until the wiring is fixed. You can find those comments in the forum on www.chevyblazer.org This continues to be an ongoing issue with this make and model of Blazer with no consistent fix from the dealer. I believe my previous battery and radiator issues are all related. I am reaching out to you for assistance and/or guidance to help get this mechanical issue reported as a recall by the dealer and properly fixed at dealer cost. I am happy to provide any additional support you may need to research this further. Thank you in advance.

Cooling ran would never shut off, 'Steering Assist Reduced Drive with Care', the smell of sweet syrup (coolant), and the temp gauge would not leave 'C'. All of this happened at once. Brought it in as it was subsequently throwing codes. Chevy Heiderbrecht dealership said that the radiator seal at 53k is completely eroded away and needs to be replaced. They said this is a very common issue with these cars (2020 Blazer/Original Owner), and looking online there is a plethora of people with the exact same issue (low mileage, complete radiator replacement due to seal going bad on upper driver side). This is insane, you spend 40k on a car, maintain it well, and the parts fail this prematurely with no available recall? Now I am stuck with an $1,800 bill with no legal recourse? I mean the dealership said it is a widely known issue, and GM has admitted that the seal is bad, but there's no consumer protection from this big of a company? Only thing covered under powertrain warranty is the thermostat (wow thanks GM!) Thanks for any help you can provide.

On Saturday, March 8, 2025 I was crossing a busy intersection when my car shut off completely and accelerated into oncoming traffic almost causing a collision or fatality. My brakes locked and steering wheel locked. I had to put the emergency brake on in order for the car to come to a stop. We got out of the car in the middle of the street and ran for safety. Scariest experience I’ve ever been in especially with my family in the car!!