IllustrationCONSUMER STATES VEHICLE HAS AN ENGINE COOLING SYSTEM PROBLEM.(DEX-COOL ENGINE COOLANT). NLM BECAUSE OF CRYSTALIZATION, THE COOLING SYSTEM NEEDS REPAIR. GM REFUSES TO OFFER ANY TYPE OF ASSISTANCE. *JG
1996 Chevrolet Blazer
Owner reports · Recalls · Investigations
More warning signs than most Blazer years
Owner complaints for the 1996 Chevrolet Blazer are substantially higher than the model-year median of 32.
About this comparison →How this year compares
Owner complaints by model year
Compare all Blazer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 105 of 1,153 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 420 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 182 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 149 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
156 crash reports31 fire reports77 injury reports
Engine And Engine Cooling complaints
149 reportsRADIATOR CLOGGED WITH GUNK CAUSED VEHICLE TO OVERHEAT. THIS HAS REOCCURRED WITHIN A YEAR AFTER DEALERSHIP REPAIRED THE PROBLEM. PLEASE DESCRIBE DETAILS. *AK
THE CONSUMER STATES THAT HE SUFFERED LOSS OF BRAKING AFTER THE ABS WAS FIXED ON RECALL DUE TO THE DEALER USING DEFECTIVE PARTS. EVERY LIGHT ON THE VEHICLE WENT OUT WHILE THE CONSUMER WAS DRIVING, CONSUMER BELIEVES THE SERVICE DEPARTMENT IMPROPERLY INSTALLED THE WIRES WHILE PERFORMING THE RECALL. *YH
WHILE DRIVING ENGINE DOES NOT HEAT UP TO PROPER TEMPERATURE IN THE WINTER MONTHS, AND IN SUMMER MONTHS IT OVERHEATS. CHEVROLET HAS ADMITTED TO THE PROBLEM, BUT WILL NOT DO ANYTHING ABOUT IT. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK
ENTIRE COOLING SYSTEM CLOGGED WITH A SANDY SUBSTANCE. MECHANIC SAYS RADIATOR, WATER PUMP, THERMOSTATED, AND A NUMBER OF OTHER COMPONETS NEED TO BE REPLACED AT A COST OF OVER $1500.00. MECHANIC SAYS HE IS SEEING THIS ON A REGULAR BASIS WITH 1996 BLAZERS. WHILE A NUMBER OF COMPLAINTS IN YOUR DATABASE POINT TO PROBLEMS WITH THE …
Read full complaint
ENTIRE COOLING SYSTEM CLOGGED WITH A SANDY SUBSTANCE. MECHANIC SAYS RADIATOR, WATER PUMP, THERMOSTATED, AND A NUMBER OF OTHER COMPONETS NEED TO BE REPLACED AT A COST OF OVER $1500.00. MECHANIC SAYS HE IS SEEING THIS ON A REGULAR BASIS WITH 1996 BLAZERS. WHILE A NUMBER OF COMPLAINTS IN YOUR DATABASE POINT TO PROBLEMS WITH THE DEXI-COOL COOLANT, THE MECHANIC SAYS IN HIS VIEW IT IS NOT THE COOLANT AS THIS PROBLEM IS ONLY WITH 1996 BLAZERS. HE BELIEVES IT IS SAND FROM A FAULTY PROBLEM WITH THE ENGINE BLOCKS WERE CAST. THE EXCESS SAND IS NOW BREAKING OFF AND CLOGGING THE COOLANT SYSTEMS CAUSING MAJOR REPAIRS. GM HAS IGNORED ALL COMPLAINTS. THIS IS A MAJOR PROBLEM AS THE VEHICLES ARE OVERHEATING AND RESULTING IN PEOPLE GETTING STRANDED ON HIGHWAYS, ETC.
HTTP://WWW.GEOCITIES.COM/B_GILLIE/DEXCOOL_PROBLEMS.HTML & HTTP://WWW.BIGCLASSACTION.COM
THIS COOLING SYSTEM FAILURE HAS RESULTED IN MY HAVING TO REPLACE THE HEATER CORE AND HOSES AS WELL AS THE RADIATOR DUE TO THE AMOUNT AND THICKNESS OF THE CORROSION/RUST INSIDE. THE SYSTEM WILL HAVE TO BE FLUSHED...CHEVY IS AWARE OF THIS ISSUE AS REFERENCED BY THEIR REPAIR BULLETINS...THE EXTEND AND COST OF THE DAMAGE IS UNDERSTA…
Read full complaint
THIS COOLING SYSTEM FAILURE HAS RESULTED IN MY HAVING TO REPLACE THE HEATER CORE AND HOSES AS WELL AS THE RADIATOR DUE TO THE AMOUNT AND THICKNESS OF THE CORROSION/RUST INSIDE. THE SYSTEM WILL HAVE TO BE FLUSHED...CHEVY IS AWARE OF THIS ISSUE AS REFERENCED BY THEIR REPAIR BULLETINS...THE EXTEND AND COST OF THE DAMAGE IS UNDERSTATED.... IM OUT OF POCKET $1400 TO REPLACE A RADIATOR A HEATING CORE AND OTHER COMPONENT DUE TO NOT BEING NOTIFIED SOONER ABOUT THE POSSIBILITY OF THE PROBLEM OCCURRING AND THEREBY HAVING THE VEHICLE INSPECTED FOR THE PROBABLY ISSUE!
THERE IS A CONSTANT OIL LEAK COMING FROM UNDER THE HOOD, MECHANIC STATES OIL GASKET MALFUNCTIONED. *AK *JB
MANY PROBLEMS ARE CONTINUING. CURRENTLY, THE FRONT SUSPENSION NEEDS REPAIRED, THE BRAKES WERE REPLACED AT 18000 AND ARE NOW GONE AGAIN, THE REAR SEALS ARE LEAKING DAMAGING THE REAR BRAKES, THE DRIVE LIGHTS STILL FLASH INTERMITTENTLY, A SMELL OF GASOLINE IS IN THE VEHICLE AFTER REFUELING, THE ENGINE PINGS NO MATTER WHAT FUEL IS …
Read full complaint
MANY PROBLEMS ARE CONTINUING. CURRENTLY, THE FRONT SUSPENSION NEEDS REPAIRED, THE BRAKES WERE REPLACED AT 18000 AND ARE NOW GONE AGAIN, THE REAR SEALS ARE LEAKING DAMAGING THE REAR BRAKES, THE DRIVE LIGHTS STILL FLASH INTERMITTENTLY, A SMELL OF GASOLINE IS IN THE VEHICLE AFTER REFUELING, THE ENGINE PINGS NO MATTER WHAT FUEL IS USED. NOTHING THE DEALER HAS DONE HAS SOLVED THE MULTITUDE OF PROBLEMS. SEAT BELT PROBLEMS ON PASSENGER SIDE, INTERIOR TRIM FELL OFF, ON AND ON.
DIP STICK IS EXTREMELY RUSTY. CONSUMER FEELS RUST THAT BUILD UP COULD BE A RESULT OF DIRT FALLING INTO THE OIL PAN. DEALER HAS BEEN CONTACTED. PLEASE GIVE ANY FURTHER DETAILS. *AK
Official recalls
603V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
01V200000 · Suspension:front:control Arm:upper Ball Joint
Jun 28, 2001
ON CERTAIN SPORT UTILITY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN, AND IN THE DISTRICT OF COLUMBIA. FAILURE OF AN UPPER CONTROL ARM BALL JOINT ASSEMBLY COULD OCCUR DUE TO CORROSION.
Consequence & remedy
Consequence: THIS CAN RESULT IN IMPAIRED STEERING OR STEERING LOSS, OR A PARTIAL OR COMPLETE COLLAPSE OF THE FRONT SUSPENSION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE BOTH UPPER BALL JOINTS. OWNER NOTIFICATION BEGAN SEPTEMBER 4, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
99V193000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Jul 19, 1999
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence & remedy
Consequence: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
98V150001 · Visibility:windshield Wiper/washer
Jul 1, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
97V096001 · Seat Belts
Jun 12, 1997
VEHICLE DESCRIPTION: EXTENDED CAB PICKUP TRUCKS EQUIPPED WITH 60/40 FRONT BENCH SEATS AND EXTENDED CAB PICKUP TRUCKS AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH MANUAL LOCKING RECLINER BUCKET SEATS. THE OUTBOARD SAFETY BELT WEBBING ON THE DRIVER'S AND/OR PASSENGER'S SEAT CAN SEPARATE DURING A FRONTAL IMPACT.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THERE WERE SECONDARY CRASH EVENTS OR VEHICLE ROLLOVER, THERE WOULD BE NO BELT RESTRAINT OF THE OCCUPANT AND INCREASED INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE RECLINER MECHANISM.
96V234000 · Fuel System, Gasoline:storage:tank Assembly
Nov 14, 1996
VEHICLE DESCRIPTION: 4-DOOR, 4-WHEEL DRIVE AND ALL-WHEEL DRIVE MULTI-PURPOSE PASSENGER VEHICLES. DURING DEVELOPMENT TESTING, THE PROP SHAFT CONTACTED THE INBOARD SIDE OF THE FUEL TANK ALLOWING FUEL LEAKAGE. THIS LEAKAGE WAS IN EXCESS OF THE AMOUNT PERMITTED BY FMVSS 301, "FUEL SYSTEM INTEGRITY."
Consequence & remedy
Consequence: IF AN IGNITION SOURCE IS PRESENT, AND THERE IS A FUEL LEAK, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL ADDITIONAL SHIELDING OF THE FUEL TANK. THIS WILL BE ADDED WITHOUT REMOVING OR DISASSEMBLING THE FUEL SYSTEM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA99022 · Upper And Lower Control Arm Ball Joint
Opened Jul 30, 1999 · Closed Aug 28, 2001
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
Additional source detail variants (2)
Suspension
There is no summary currently available
Suspension
There is no summary currently available
RQ99015 · Front Seat Recliner Bolt Failure
Opened Jul 14, 1999 · Closed Dec 28, 2001
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
No summary supplied.
PE99021 · Upper Control Arm Ball Joint Breakage
Opened Mar 5, 1999 · Closed Jul 30, 1999
Status: closed (inferred from source dates) · Power Train
AN UPPER CONTROL ARM BALL JOINT FAILS, RESULTING IN THE FRONT SUSPENSION COLLAPSING ON THE FAILED SIDE.
EA97007 · Steering Shaft Separations
Opened Apr 17, 1997 · Closed Mar 12, 1998
Status: closed (inferred from source dates) · Steering
COUPLING BOLTS, JOINING THE STEERING SHAFT, MAY SEPARATE.IN SOME CASES, TOTAL UNFORESEEN, LOSS OF STEERING CONTROL MAY RESULT.
EA97004 · Seat Belt Webbing Separation
Opened Feb 28, 1997 · Closed Aug 5, 1997
Status: closed (inferred from source dates) · Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Additional source detail variants (2)
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.