IllustrationWHILE DRIVING VEHICLE STALLS FOR NO REASON. NUMEROUS PARTS HAVE BEEN REPLACED, SUCH AS FUEL PUMP/ SPARK PLUGS/ CPI INJECTOR AND EGR VALVE, SENSOR, LOCK CYLINDER, BATTERY, 3-2 SHIFT SOLENOID, FUEL FILTER, AND PERFORMED FUEL PRESSURE TEST. PROBLEM REMAINS. *AK *TT
1995 Chevrolet Blazer
Owner reports · Recalls · Investigations
More warning signs than most Blazer years
Owner complaints for the 1995 Chevrolet Blazer are substantially higher than the model-year median of 32.
About this comparison →How this year compares
Owner complaints by model year
Compare all Blazer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 64 of 1,224 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 513 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 213 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 178 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
152 crash reports25 fire reports63 injury reports
Engine And Engine Cooling complaints
213 reportsTHE DEFECTIVE EGR VALVE, CAUSING THE CARBON TO BREAK UP IN VALVE IN WHICH IT CLOGS THE VALVE, CAUSING LOSS OF PRESSURE, RESULTING IN LOSS OF BRAKING ABILITY. DEALER REPLACED EGR VALVE. DEALER CANNOT DETERMINE PROBLEM. *AK
THIS IS A DOCUMENTED PROBLEM WITH THE GMC JIMMY, WHICH IS THE SAME VEHICLE AS THE S10 BLAZER. GMC HAS ISSUED A TECHNICAL SERVICE BULLETIN FOR THE JIMMY. I AM ONCE AGAIN REPLACING THIS EXPENSIVE PART. WHEN THE EGR VALVE FAILS, THE VEHICLE SHUTS DOWN OR RUNS ROUGHLY CAUSING THE POWER BRAKES TO LOSE THEIR VACUUM, WHICH IN TURN M…
Read full complaint
THIS IS A DOCUMENTED PROBLEM WITH THE GMC JIMMY, WHICH IS THE SAME VEHICLE AS THE S10 BLAZER. GMC HAS ISSUED A TECHNICAL SERVICE BULLETIN FOR THE JIMMY. I AM ONCE AGAIN REPLACING THIS EXPENSIVE PART. WHEN THE EGR VALVE FAILS, THE VEHICLE SHUTS DOWN OR RUNS ROUGHLY CAUSING THE POWER BRAKES TO LOSE THEIR VACUUM, WHICH IN TURN MAKES THE VEHICLE UNSAFE AND POTENTIALLY DANGEROUS.
WHEN EGR VALVE FAILS VEHICLE LOSES POWER BRAKE CAPABILITIES. PROBLEM OCCURS WITHOUT WARNING. CAUSE UNKNOWN. *AK
ENGINE CHECK LIGHT CAME ON. WHEN TAKEN IN FOR THE SERVICE, THE MECHANIC STATED THAT THE EGR VALVE WAS STUCK. THE VALVE WAS TAKEN OUT, CLEANED AND REPLACED AT OWNER'S EXPENSE. A WEEK LATER THE LIGHT WAS ON BACK AGAIN. THE PROBLEM HAS NOT BEEN CORRECTED. THE MANUFACTURER IS NOT WILLING TO REPLACED THE EGR VALVE BECAUSE THE BLAZE…
Read full complaint
ENGINE CHECK LIGHT CAME ON. WHEN TAKEN IN FOR THE SERVICE, THE MECHANIC STATED THAT THE EGR VALVE WAS STUCK. THE VALVE WAS TAKEN OUT, CLEANED AND REPLACED AT OWNER'S EXPENSE. A WEEK LATER THE LIGHT WAS ON BACK AGAIN. THE PROBLEM HAS NOT BEEN CORRECTED. THE MANUFACTURER IS NOT WILLING TO REPLACED THE EGR VALVE BECAUSE THE BLAZER IS OUT OF THE WARRANTY. *AK
VEHICLE CONTINUOUSLY CUTS OFF WHILE DRIVING, UNABLE TO DETERMINE CAUSE.
WINDSHIELD WIPERS STOPPED WORKING.
DRIVING 60MPH WHEN VEHICLE STALLED OUT OR DIED. HAD TO TAKE TO DEALER & MECHANIC REPLACED FUEL PUMP. PROBLEM HAD REOCCURRED SINCE 3/6/98 WHEN PUMP WAS REPLACED. ALSO, STEERING WHEEL WOULD LOCK UP. PROBLEM HAPPENED AFTER FUEL PUMP WAS REPLACED. *AK
VEHICLE HESITATES WHEN MERGING. FAN CLUTCH CAUSES VEHICLE TO HESITATE & MAKES A LOT OF NOISE. ONGOING INTERMITTENT PROBLEM. WOULD PERIODICALLY SHIFT ITSELF FROM 2 WHEEL DRIVE TO 4 WHEEL DRIVE. TOOK TO DEALER & MECHANIC SAID KNEW ABOUT FAN CLUTCH, BUT UNABLE TO REPAIR. *AK
WHENEVER THE BRAKE PEDAL IS DEPRESSED, THE ABS BRAKING SYSTEM WOULD LOCK UP. VEHICLE WOULD CONTINUE AT SAME RATE OF SPEED. TOOK TO DEALER & HAD IT CHECKED. HAD EGR VALVE REPLACED. WAS AN INTERMITTENT, RANDOM PROBLEM. *AK
Official recalls
699V193000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Jul 19, 1999
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence & remedy
Consequence: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
98V150001 · Visibility:windshield Wiper/washer
Jul 1, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
96V234000 · Fuel System, Gasoline:storage:tank Assembly
Nov 14, 1996
VEHICLE DESCRIPTION: 4-DOOR, 4-WHEEL DRIVE AND ALL-WHEEL DRIVE MULTI-PURPOSE PASSENGER VEHICLES. DURING DEVELOPMENT TESTING, THE PROP SHAFT CONTACTED THE INBOARD SIDE OF THE FUEL TANK ALLOWING FUEL LEAKAGE. THIS LEAKAGE WAS IN EXCESS OF THE AMOUNT PERMITTED BY FMVSS 301, "FUEL SYSTEM INTEGRITY."
Consequence & remedy
Consequence: IF AN IGNITION SOURCE IS PRESENT, AND THERE IS A FUEL LEAK, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL ADDITIONAL SHIELDING OF THE FUEL TANK. THIS WILL BE ADDED WITHOUT REMOVING OR DISASSEMBLING THE FUEL SYSTEM.
95V180000 · Engine And Engine Cooling:cooling System:fan
Sep 22, 1995
FAN BLADE RIVET BREAKAGE CAN OCCUR CAUSING THE FAN BLADE TO SEPARATE FROM THE SPIDER.
Consequence & remedy
Consequence: IF THIS OCCURRED WHILE THE HOOD WAS OPEN, A PERSON WORKING UNDER THE HOOD OF THE VEHICLE OR IN THE VICINITY OF THE VEHICLE COULD BE STRUCK BY THE FAN BLADE AND INJURED.
Remedy: DEALERS WILL INSPECT AND REPLACE, IF NECESSARY, THE FAN WITH A NEWER FAN HAVING THICKER-HEADED RIVETS.
95V080000 · Suspension:front:control Arm:upper Ball Joint
Apr 24, 1995
THE UPPER BALL JOINT NUTS WERE UNDER-TORQUED RESULTING IN IMPROPER SEATING IN THE STEERING KNUCKLE.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE BALL JOINT STUD TO LOOSEN, AND FRACTURE RESULTING IN A LOSS OF STEERING CONTROL.
Remedy: DEALERS WILL RETORQUE THE UPPER BALL JOINT NUT ON BOTH SIDES OF THE VEHICLE TO THE CORRECT TORQUE VALUES.
94V242000 · Service Brakes, Hydraulic:pedals And Linkages
Dec 12, 1994
THE BRAKE PEDAL PIVOT BOLT WAS STARTED IN THE WELD NUT, BUT WAS NOT TORQUED CORRECTLY CAUSING THE BOLT TO DISENGAGE FROM THE WELD NUT.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN A TOTAL LOSS OF BRAKINGCAPABILITY.
Remedy: DEALERS WILL INSPECT FOR HAND-STARTED BRAKE PEDAL BOLTS AND TORQUE THEM TO CORRECT SPECIFICATIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
8EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA01019 · Front Seat Recliner Bolt
Opened Dec 28, 2001 · Closed Sep 27, 2002
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
There is no summary currently available
EA00008 · Loss Of Power Assist
Opened Mar 16, 2000 · Closed Aug 31, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
RQ99015 · Front Seat Recliner Bolt Failure
Opened Jul 14, 1999 · Closed Dec 28, 2001
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
No summary supplied.
PE99024 · Loss Of Power Assist Braking
Opened Apr 5, 1999 · Closed Mar 16, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
CONSUMERS ALLEGE A PARTIAL LOSS OF BRAKING ABILITY
EA97022 · Windshield Wiper Failure
Opened Oct 23, 1997 · Closed Jul 2, 1998
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
Additional source detail variants (2)
Visibility
There is no summary currently available
Visibility
There is no summary currently available
PE97028 · Windshield Wiper
Opened Jun 17, 1997 · Closed Oct 23, 1997
Status: closed (inferred from source dates) · Visibility
DURING THIS PRELIMINARY EVALUATION, OVER 400 ADDITIONAL COMPLAINTS WERE FURNISHED BY GM.IN ADDITION GM REPORTED OVER 3000 WIPER SYSTEM WARRANTY REPAIRS ON THE SUBJECT VEHICLES.
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.