IllustrationTHE FUEL INJECTOR HOUSING FAILED, CAUSING ENGINE TO LOCK UP AND ENGINE COMPONENTS TO FAIL.
1992 Chevrolet Blazer
Owner reports · Recalls · Investigations
More warning signs than most Blazer years
Owner complaints for the 1992 Chevrolet Blazer are substantially higher than the model-year median of 32.
About this comparison →How this year compares
Owner complaints by model year
Compare all Blazer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 13 of 278 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 197 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
47 crash reports9 fire reports11 injury reports
What owners actually said
278 reportsBRAKES FAILED.
WHILE DRIVING THE TRUCK THERE ARE SEVERAL PROBLEMS ON THIS VEHICLE. THE ABS LIGHT COMES ON AND THERE ARE NO ABS BRAKES. WHEN THE ABS LIGHT COMES ON THAT MEANS THAT THE COMPUTER MODULE HAS FAILED. *AK
ABS COMPUTER MODULE FAILED.
THE WIRING HARNESS CAUGHT ON FIRE FOR NO REASON. OWNER SPOKE WITH VARIOUS PEOPLE WHO HAD SAME PROBLEM. THE EXACT CAUSE HAS NOT BEEN DETERMINED. *AK
THE ABS SYSTEM ON THE TRUCK FAILED TO STOP THE TRUCK, AND THE TRUCK ROLLED OVER AS A RESULT. *AK
ABS BRAKING SYSTEM FAILED 2 TIMES, CAUSING CRASHES. THE CAR WOULD NOT STOP, NO WARNING OR PEDAL PROBLEM. IN BETWEEN THESE CRASHES CAR HAD EXTENDED STOPPING DISTANCE PROBLEMS, RUNNING THROUGH LIGHTS AND HAVING NEAR MISSES. *AK
CONSUMER LEFT VEHICLE TO WARM UP, UPON RETURNING DISCOVERED THAT VEHICLE WAS ON FIRE IN THE ENGINE COMPARTMENT. FIRE DEPARTMENT STATED THAT FIRE WAS ELECTRICAL. CONSUMER IS WAITING TO HEAR FROM INSURANCE COMPANY. *AK
ABS BRAKE FAILURE, DRIVING AT SPEED 30MPH, APPLIED THE BRAKES AND EXPERIENCED COMPLETE LOSS OF EFFECTIVENESS AND EXTENDED STOPPING DISTANCE. REPLACED DRFECTIVE ABS PRESSURE REGULATOR VALVE. EA94-038 ACTIVE. *AK
DELCO FREEDOM BATTERY POSITIVE TERMINAL POST BROKE ,CAUSING BATTERY TO SPILL ACID AND CORRODING BATTERY CABLE, 1ST VEHICLE ON 515741.
Official recalls
299V193000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Jul 19, 1999
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence & remedy
Consequence: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
93V119000 · Service Brakes, Hydraulic:foundation Components:disc:rotor
Aug 2, 1993
SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.
Consequence & remedy
Consequence: SEPARATION OF THE ROTOR SECTIONS CAN CAUSE LOSS OFBRAKING ABILITY IN THE AFFECTED WHEEL. THIS COULD RESULT IN INCREASED STOPPINGDISTANCE AND/OR LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Remedy: REPLACE THE FRONT BRAKE ROTORS WITH NEW ROTORS WITH A CORROSION PROTECTION COATING. HOWEVER, IF REPLACEMENT OF BRAKE LININGS ARE NECESSARY, IT WILL BE DONE AT OWNER'S EXPENSE SINCE BRAKE LININGS ARE NORMAL MAINTENANCE ITEMS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA01019 · Front Seat Recliner Bolt
Opened Dec 28, 2001 · Closed Sep 27, 2002
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
There is no summary currently available
RQ99015 · Front Seat Recliner Bolt Failure
Opened Jul 14, 1999 · Closed Dec 28, 2001
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
No summary supplied.
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
EA94029 · Engine Compartment Fires
Opened Jul 29, 1994 · Closed Jul 31, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
AN ALLEGED MALFUNCTION IN THE ATLERNATOR RESULTING IN ENGINE COMPARTMET FIRES.
PE94046 · Abs Braking System Fails
Opened Jun 17, 1994 · Closed Oct 31, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available