The contact owns a 2007 Chevrolet Aveo. The contact was made aware of NHTSA Campaign Number: 06V398000 (Fuel System, Gasoline) however, the VIN was not included in the recall. The contact stated that after the vehicle was involved in an accident, the vehicle lost motive power and failed to restart on various occasions. No warnin…
Read full complaint
The contact owns a 2007 Chevrolet Aveo. The contact was made aware of NHTSA Campaign Number: 06V398000 (Fuel System, Gasoline) however, the VIN was not included in the recall. The contact stated that after the vehicle was involved in an accident, the vehicle lost motive power and failed to restart on various occasions. No warning lights were illuminated, and the vehicle was towed to the contact's residence. The vehicle was then towed to an independent mechanic, where it was diagnosed that the fuel pump needed to be replaced. The vehicle was repaired; however, the contact stated that the failure had reoccurred, and the vehicle failed to restart. The manufacturer was made aware of the failure. The failure mileage was unknown.
NHTSA ODI #11504723
106,000 miles · Jul 31, 2014
Fuel System, GasolineCrashFireInjury
FRONT END CRASH RESULTING IN ENGINE FIRE. FIRE MIGRATED INTO PASSENGER COMPARTMENT. DRIVER SUFFERED BURNS TO FACE, CHEST AND HANDS. *TR
THE DASHBOARD OVER THE SPEEDOMETER BECOMES VERY HOT AND THE KEY IS HOT WHEN REMOVED. I FEEL THIS MAY BE RELATED TO RECALL 14236 REGARDING RUNNING LIGHTS. I AM CONCERNED ABOUT THE RECALL 06133 REGARDING FUEL LINE/FUSE BLOCK AS WELL. *TR
NHTSA ODI #10610799
3,319 miles · Nov 28, 2006
Fuel System, Gasoline
DT*: THE CONTACT STATED A RECALL LETTER #06V398000 WAS RECEIVED REGARDING THE FUEL SYSTEM, GASOLINE. THE VEHICLE WAS TAKEN TO THE DEALER FOR THE REMEDY REPAIR HOWEVER THE PARTS WERE NOT AVAILABLE. THE DEALER STATED THAT THEY WILL ALERT THE CONTACT WHEN THE PARTS ARE AVAILABLE. THE MANUFACTURER HAS NOT BEEN CONTACTED.
General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module.
Consequence & remedy
Consequence: If the DRL module melts due to the heat generation, it could cause a vehicle fire.
Remedy: GM will notify owners, and dealers will install a revised DRL module, inspect the wiring connector for heat damage, and clean the DRL circuit grounds. Owners were sent interim notices on August 14, 2014. The recall began on February 6, 2015. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet). General Motors recall number for this campaign is 14236.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 1.6L ENGINE, DURING A NCAP SEVERE FRONTAL CRASH TEST, THE FUEL LINE IN THE ENGINE COMPARTMENT DEVELOPED A FRACTURE. IN ADDITION, THE CRASH DAMAGE CAUSED FOUR SHORT CIRCUITS IN THE FUSE BLOCK, THE COMBINATION OF WHICH ALLOWED THE FUEL PUMP TO CONTINUE RUNNING AND FUEL LEAKED ONTO THE GROUND.
Consequence & remedy
Consequence: IF THESE CONDITIONS OCCURRED IN AN ACTUAL CRASH, A VEHICLE FIRE COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE FUSE BLOCK AND INSTALL A NEW SECTION OF FUEL LINE THAT HAS BEEN REDESIGNED FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 16, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2007 Chevrolet Aveo Problems, Complaints & Recalls | Skip That Year
Illustration