IllustrationFront subframe. Pulls one way during acceleration and pulling the opposite way during braking
2006 Chevrolet Aveo
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2006 Chevrolet Aveo do not stand out strongly from the model-year median of 169.
About this comparison →How this year compares
Owner complaints by model year
Compare all Aveo years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
320–25K
2825–50K
3350–75K
2375–100K
25100–150K
7150K+
148 reports with mileage · 41 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 67 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
13 crash reports16 fire reports6 injury reports
Unknown Or Other complaints
6 reportsMY CAR JUST NOT RUNNING RIGHT I JUST BOUGHT IT AND SEEN A RECALL
IT DOESN'T RUN AFTER THE SIDE DRIVER FRONT LIGHT GOT MESSED UP, IT OVER HEATS. *TR
SO I WAS AT HOME AND MY CAR WAS PARKED OUTSIDE AND IT CAUGHT ON FIRE IN THE INSIDE. THE FIRE DEPARTMENT CAME AND PUT OUT THE FIRE. IT DAMAGED THE DASHBOARD AND THE WINDOW. I HAVE READ THAT IT IS A RECALL ON MY VEHICLE WHICH CAUSES IT TO CATCH ON FIRE. MANUFACTURER RECALL NUMBERA140093 NHTSA RECALL NUMBER14V261 RECALL STATUS…
Read full complaint
SO I WAS AT HOME AND MY CAR WAS PARKED OUTSIDE AND IT CAUGHT ON FIRE IN THE INSIDE. THE FIRE DEPARTMENT CAME AND PUT OUT THE FIRE. IT DAMAGED THE DASHBOARD AND THE WINDOW. I HAVE READ THAT IT IS A RECALL ON MY VEHICLE WHICH CAUSES IT TO CATCH ON FIRE. MANUFACTURER RECALL NUMBERA140093 NHTSA RECALL NUMBER14V261 RECALL STATUSRECALL INCOMPLETE
TL* THE CONTACT OWNS A 2006 CHEVROLET AVEO. THE CONTACT RECEIVED A NOTIFICATION FOR AN UNKNOWN RECALL AND STATED THAT THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE REPAIR. THE MANUFACTURER WAS NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
DT*: THE CONTACT STATED THE LOCATION OF THE HORN IS HARD TO FIND AND EXCESSIVE PRESSURE IS REQUIRED TO ACTIVATE THE HORN. THE OWNER'S MANUAL STATES THE HORN NEEDS TO BE TAPPED TO ACTIVATE. THE MANUFACTURER HAS BEEN ALERTED.
Official recalls
114V261000 · Exterior Lighting:headlights
May 19, 2014
General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module.
Consequence & remedy
Consequence: If the DRL module melts due to the heat generation, it could cause a vehicle fire.
Remedy: GM will notify owners, and dealers will install a revised DRL module, inspect the wiring connector for heat damage, and clean the DRL circuit grounds. Owners were sent interim notices on August 14, 2014. The recall began on February 6, 2015. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet). General Motors recall number for this campaign is 14236.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.