Electrical System. Review the 67 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

13 crash reports16 fire reports6 injury reports

Suspension complaints

11 reports

Clear category filter

15,000 miles · Apr 9, 2007

Power TrainStructureSuspension

Read full complaint

TL*- THE CONTACT OWNS A 2006 CHEVROLET AVEO WITH A CURRENT AND FAILURE MILEAGE OF 15,000 MILES. THE CONTACT WAS HEARING A CRUNCHING SOUND COMING FROM THE REAR OF THE VEHICLE. THE CONTACT HAD THE VEHICLE TAKEN TO THE DEALER, SERPENTINE CHEVROLET , SEVERAL TIMES, BUT THEY COULD NOT FIND THE CAUSE OF THE PROBLEM. WHEN THE CONTACT TOOK THE VEHICLE TO THE LOCAL MECHANIC THEY FOUND THAT THE REAR AXLE WAS BENT, WHICH CAUSED THE COIL SPRING TO RUB AGAINST THE BODY OF THE VEHICLE. ALSO, THE MECHANIC STATED THAT THE BENT AXLE COULD HAVE HAPPENED AT THE TIME THE VEHICLE WAS MANUFACTURED. THE CONTACT TOOK THE VEHICLE BACK TO THE DEALER FOR REPAIR, AT WHICH TIME, IT WAS DISCOVERED THAT THE FRONT SUSPENSION SYSTEM WAS LOOSE AS WELL. THE DEALER REPLACED THE FRONT SWAY BAR, AND THE BUSHING, AND TIGHTEN ALL THE BOLTS. WHEN THE DEALER TEST DROVE THE VEHICLE AFTER THE REPAIRS THEY FOUND THAT THE ENGINE CRADLE NEEDED TO BE REPLACED. *AK THE CONSUMER STATED THERE WAS A SQUEAKING NOISE COMING FROM THE FRONT OF THE VEHICLE, THE SWAY BAR BUSHINGS AND LOWER BALL JOINTS WERE REPLACED. UPDATED 04/30/07. *JB

NHTSA ODI #10187398

Official recalls

14V261000 · Exterior Lighting:headlights

May 19, 2014

General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module.

Consequence & remedy

Consequence: If the DRL module melts due to the heat generation, it could cause a vehicle fire.

Remedy: GM will notify owners, and dealers will install a revised DRL module, inspect the wiring connector for heat damage, and clean the DRL circuit grounds. Owners were sent interim notices on August 14, 2014. The recall began on February 6, 2015. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet). General Motors recall number for this campaign is 14236.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.