IllustrationFIRST, THE STRUTS CAME OFF, THEN THE PIECE HOLDING THE AIR FILTER BROKE AWAY, NOW THE PULLEY HAS EXPLODED AND HAS DESTROYED THE TIMING BELT AND SERPENTINE BELT. THIS CAR IS JUNK MADE WITH CHEAP PARTS. NOT GOOD FOR SOMEONE WITH CHILDREN. *LN
2004 Chevrolet Aveo
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Chevrolet Aveo do not stand out strongly from the model-year median of 169.
About this comparison →How this year compares
Owner complaints by model year
Compare all Aveo years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
380–25K
2025–50K
5250–75K
2575–100K
22100–150K
3150K+
160 reports with mileage · 46 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 62 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports9 fire reports17 injury reports
Unknown Or Other complaints
4 reportsMY COMPLAINT INVOLVES A REPLACEMENT TIMING BELT MANUFACTURED BY GENERAL MOTORS DETROIT AND PURCHASED ON MY BEHALF FROM THE PARTS DEPARTMENT OF STEVE RAYMAN CHEVROLET ON MARCH 29, 2010 BY KEN BLACK OF FAIRGROUND AUTO AND BODY SHOP FOR INSTALLATION ON MY 2004 CHEVROLET AVEO. THE REPLACEMENT OF THE TIMING BELT WAS ROUTINE MAINTENA…
Read full complaint
MY COMPLAINT INVOLVES A REPLACEMENT TIMING BELT MANUFACTURED BY GENERAL MOTORS DETROIT AND PURCHASED ON MY BEHALF FROM THE PARTS DEPARTMENT OF STEVE RAYMAN CHEVROLET ON MARCH 29, 2010 BY KEN BLACK OF FAIRGROUND AUTO AND BODY SHOP FOR INSTALLATION ON MY 2004 CHEVROLET AVEO. THE REPLACEMENT OF THE TIMING BELT WAS ROUTINE MAINTENANCE AND WAS INTENDED TO PROTECT MY AUTO FROM DAMAGE THAT MIGHT OCCUR WHEN A TIMING BELT FAILS. AT THAT TIME MY CAR MILEAGE WAS 69631. ON OCTOBER 1, 2010, THIS REPLACEMENT TIMING BELT FAILED AFTER ONLY 4327 MILES AND 6 MONTHS OF SERVICE. A SECTION OF THE TEETH WHICH ENGAGED THE TIMING BELT SEPARATED FROM THE BODY OF THE BELT. THE DEFECTIVE BELT FLEW INTO MY ENGINE CAUSING EXTENSIVE DAMAGE. I HAD THE VEHICLE TOWED TO FAIRGROUND AUTO WHERE THIS DAMAGE WAS REPAIRED AT A COST TO ME OF $2098.30. MR. KEN BLACK ADVISED ME THAT SINCE THE BELT WAS DEFECTIVE HE BELIEVED THAT GENERAL MOTORS SHOULD REIMBURSE ME FOR THE REPAIR. HE TOOK THE BELT BACK TO STEVE RAYMAN CHEVROLET WHERE HE SHOWED IT TO THE PARTS MANAGER MIKE STEWART WHO CONCURRED THAT THE BELT DEFINITELY HAD A MANUFACTURING DEFECT AND MADE ATTEMPTS TO GET GM IN DETROIT TO STAND BEHIND THE PART AND TAKE CARE OF MY DAMAGES. GM REFUSED TO DO ANYTHING. THESE DETAILS CAN BE VERIFIED WITH KEN BLACK OF FAIRGROUND AUTO AT 770 429 8473 AS WELL AS MIKE STEWART, PARTS MANAGER AT STEVE RAYMAN CHEVROLET, AT 770 953 0100 EXT 3047.
WHILE ON MY WAY HOME, I NOTICED THAT MY VEHICLE STARTED SMOKING FROM THE HOOD AND WITHOUT WARNING THE "CHECK" DASH LIGHTS CAME ON. I NOTICED THAT MY CAR STARTED SLOWING DOWN AND I COASTED IT TO THE SIDE OF THE ROAD. AT THIS POINT MY VEHICLE CUT OFF AND WOULDN'T START. ONCE, MY VEHICLE WAS TRANSPORTED HOME, I HAD MY MECHANIC …
Read full complaint
WHILE ON MY WAY HOME, I NOTICED THAT MY VEHICLE STARTED SMOKING FROM THE HOOD AND WITHOUT WARNING THE "CHECK" DASH LIGHTS CAME ON. I NOTICED THAT MY CAR STARTED SLOWING DOWN AND I COASTED IT TO THE SIDE OF THE ROAD. AT THIS POINT MY VEHICLE CUT OFF AND WOULDN'T START. ONCE, MY VEHICLE WAS TRANSPORTED HOME, I HAD MY MECHANIC TO COME OUT AND INSPECT MY VEHICLE. MY MECHANIC LOOKED UNDER MY HOOD AND SAW THAT MY VEHICLE HAD LOST ALOT OF ANTIFREEZE/COOLANT. HE LOOKED TO SEE WHAT CAUSE THIS AND REALIZED THAT THE THERMOSTAT HOUSING UNIT HAD BUSTED-ACTUALLY IT WAS SPLIT IN HALF. MY MECHANIC ALSO STATED THAT THE BUSTED THERMOSTAT HOUSING HAD CAUSED THE LEAKAGE OF THE ANTIFREEZE/COOLANT. MY MECHANIC INFORMED ME THAT THE THERMOSTAT HOUSING HAD TO BE REPLACED. AFTER HAVING THE THERMOSTAT HOUSING REPLACED, MY MECHANIC TRIED TO START THE CAR, BUT IT WOULDN'T TURN OVER. I HAD MY VEHICLE JUMPED, AND EVEN THE BATTERY INSPECTED BUT IT WOULDN'T START. IN ADDITION, THE STARTER, TIMING BELT WERE INSPECTED AS WELL AND WERE IN GOOD CONDITION. PLEASE BE ADVISED THAT I ONLY HAVE 53,000 MILES ON MY VEHICLE. MY MECHANIC DID A THOROUGH CHECK OF MY VEHICLE AND REALIZED THAT SOME WATER HAD LEAKED INTO MY OIL AND THAT ANTIFREEZE/COOLANT HAD SPILLED INTO AN ENGINE VALVE. FROM MY OWN RESEARCH, I'VE FOUND THAT CHEVY HAS HAD NUMEROUS PROBLEMS FROM THE 2004 CHEVY AVEOS-THERMOSTAT HOUSING UNITS FROM OTHER CUSTOMERS. IN ADDITION, ORIGINALLY THE THERMOSTAT HOUSING WAS PLASTIC, BUT CHEVY CHANGED IT TO AN ALUMINUM ONE BECAUSE THE "PLASTIC THERMOSTAT HOUSING" THAT ORIGINALLY CAME WITH THE VEHICLE WAS EXTREMELY FAULTY. IT IS VERY DISHONEST AND A SHAME THAT GM/CHEVY NEVER NOTIFIED ME THAT I NEEDED TO BRING MY 2004 CHEVY AVEO IN TO GET THE PLASTIC THERMOSTAT HOUSING REPLACED WITH THE NEW ALUMINUM ONE. I BOUGHT THIS VEHICLE BRAND NEW IN 2005. IT WAS CHEVY'S RESPONSIBILITY TO NOTIFY ME OF THIS SITUATION. ALSO, FROM WHAT I'VE GATHERED, THE PLASTIC THERMOSTAT HOUSING WAS UNSAFE. *TR
FOUR DAYS AGO I RECEIVED A LETTER REGARDING SERVICE THAT WAS REQUIRED TO BE PERFORMED UNDER THE EXTENDED WARRANTY AGREEMENT I PURCHASED WITH MY CAR. THE SERVICE NEEDED WAS ON THE TIMING BELT. ON SUNDAY, TWO DAYS AFTER RECEIVING THE LETTER THE TIMING BELT BROKE ON MY CAR, CAUSING FURTHER DAMAGE TO THE ENGINE. MY EXTENDED WARRA…
Read full complaint
FOUR DAYS AGO I RECEIVED A LETTER REGARDING SERVICE THAT WAS REQUIRED TO BE PERFORMED UNDER THE EXTENDED WARRANTY AGREEMENT I PURCHASED WITH MY CAR. THE SERVICE NEEDED WAS ON THE TIMING BELT. ON SUNDAY, TWO DAYS AFTER RECEIVING THE LETTER THE TIMING BELT BROKE ON MY CAR, CAUSING FURTHER DAMAGE TO THE ENGINE. MY EXTENDED WARRANTY ENDED AT 60,700 MILES AND I CURRENTLY HAVE 67,000 MILES ON THE CAR. THE LETTER WAS TOO LATE IN ARRIVING FOR ME TO PREVENT THIS DAMAGE BEING DONE, AS IT SEEMS THAT THE TIMING BELT WAS SUPPOSED TO BE REPLACED AT 60,000 MILES. THE CAR IS CURRENTLY AT THE DEALER WITH THE ENGINE HAVING BEEN SENT TO A "SPECIALIST" FOR FURTHER WORK. *TR
Official recalls
214V261000 · Exterior Lighting:headlights
May 19, 2014
General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module.
Consequence & remedy
Consequence: If the DRL module melts due to the heat generation, it could cause a vehicle fire.
Remedy: GM will notify owners, and dealers will install a revised DRL module, inspect the wiring connector for heat damage, and clean the DRL circuit grounds. Owners were sent interim notices on August 14, 2014. The recall began on February 6, 2015. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet). General Motors recall number for this campaign is 14236.
04V407000 · Seat Belts:rear/other
Aug 17, 2004
ON CERTAIN PASSENGER VEHICLES, THE REAR SAFETY BELT CAN BECOME TWISTED.
Consequence & remedy
Consequence: IF THIS OCCURS THE SAFETY BELT RETRACTOR MAY LOCK IN POSITION SO THAT THE BELT CANNOT BE USED. IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO THE SEAT OCCUPANT COULD OCCUR.
Remedy: DEALERS WILL INSTALL A SAFETY BELT WEBBING GUIDE TO PREVENT THE BELT FROM TWISTING. THE RECALL BEGAN ON OCTOBER 15, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438. VEHICLE OWNERS LOCATED IN GUAM SHOULD CONTACT GM CUSTOMER ASSISTANCE AT 1-671-648-8453.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA08005 · Stuck Throttle Valve
Opened Feb 14, 2008 · Closed Oct 14, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv); Vehicle Speed Control
TO DATE, THE OFFICE OF DEFECTS INVESTIGATION (ODI) IS AWARE OF 29 NON-DUPLICATIVE COMPLAINTS/FIELD REPORTS AND 52 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT AFFECTING 69 UNIQUE SUBJECT VEHICLES.BECAUSE THE ALLEGED DEFECT CONDITION IS MOST LIKELY TO OCCUR DURING WINTER MONTHS WHEN AMBIENT TEMPERATURES ARE BELOW FREEZING, ODI UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS ON FEBRUARY 14, 2008 SO THAT IT COULD CONTINUE TO MONITOR THE FIELD EXPERIENCE DURING THE 2007/2008 WINTER SEASON.BY LETTER DATED MAY 22, 2008, GENERAL MOTORS CORP. (GM) SUPPLEMENTED ITS PREVIOUS INFORMATION REQUEST RESPONSE WITH FIELD DATA RECEIVED BY GM THROUGH MAY 1, 2008.ACCORDING TO GM, WHEN MOISTURE FREEZES IN THE POSITIVE CRANKCASE VENTILATION (PCV) SYSTEM AND/OR THE ENGINE AIR INTAKE TRACT IT IS MOST OFTEN OBSERVED AS A HARD TO START/NO START CONDITION, THROTTLE STUCK CLOSED, ROUGH RUNNING ENGINE, STALLING AT IDLE, OR OIL LEAKAGE.OF THE 29 COMPLAINTS RELATED TO STUCK THROTTLE, ODI IDENTIFIED 5 REPORTS THAT ALLEGE UNWANTED ACCELERATION, 13 REPORTS DESCRIBE AN APPARENT HIGH-IDLE CONDITION AT START UP OR WHEN SLOWING THE VEHICLE TO A STOP WITHOUT ANY ALLEGATION OF UNWANTED ACCELERATION OR DIMINISHED BRAKING PERFORMANCE, AND THE REMAINING 11 REPORTS DESCRIBE AMBIGUOUS ALLEGATIONS OF STUCK THROTTLE WITHOUT REGARD TO SEVERITY OR CONSEQUENCE.ODI ANALYSIS OF FIELD INCIDENT DATA SHOWS THAT THE COMPLAINT AND WARRANTY TRENDS APPEAR TO BE IN DECLINE, WITH ONLY 1 ADDITIONAL COMPLAINT AND 6 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT RECEIVED BY GM SINCE APRIL 2007. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)
TO DATE, THE OFFICE OF DEFECTS INVESTIGATION (ODI) IS AWARE OF 29 NON-DUPLICATIVE COMPLAINTS/FIELD REPORTS AND 52 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT AFFECTING 69 UNIQUE SUBJECT VEHICLES.BECAUSE THE ALLEGED DEFECT CONDITION IS MOST LIKELY TO OCCUR DURING WINTER MONTHS WHEN AMBIENT TEMPERATURES ARE BELOW FREEZING, ODI UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS ON FEBRUARY 14, 2008 SO THAT IT COULD CONTINUE TO MONITOR THE FIELD EXPERIENCE DURING THE 2007/2008 WINTER SEASON.BY LETTER DATED MAY 22, 2008, GENERAL MOTORS CORP. (GM) SUPPLEMENTED ITS PREVIOUS INFORMATION REQUEST RESPONSE WITH FIELD DATA RECEIVED BY GM THROUGH MAY 1, 2008.ACCORDING TO GM, WHEN MOISTURE FREEZES IN THE POSITIVE CRANKCASE VENTILATION (PCV) SYSTEM AND/OR THE ENGINE AIR INTAKE TRACT IT IS MOST OFTEN OBSERVED AS A HARD TO START/NO START CONDITION, THROTTLE STUCK CLOSED, ROUGH RUNNING ENGINE, STALLING AT IDLE, OR OIL LEAKAGE.OF THE 29 COMPLAINTS RELATED TO STUCK THROTTLE, ODI IDENTIFIED 5 REPORTS THAT ALLEGE UNWANTED ACCELERATION, 13 REPORTS DESCRIBE AN APPARENT HIGH-IDLE CONDITION AT START UP OR WHEN SLOWING THE VEHICLE TO A STOP WITHOUT ANY ALLEGATION OF UNWANTED ACCELERATION OR DIMINISHED BRAKING PERFORMANCE, AND THE REMAINING 11 REPORTS DESCRIBE AMBIGUOUS ALLEGATIONS OF STUCK THROTTLE WITHOUT REGARD TO SEVERITY OR CONSEQUENCE.ODI ANALYSIS OF FIELD INCIDENT DATA SHOWS THAT THE COMPLAINT AND WARRANTY TRENDS APPEAR TO BE IN DECLINE, WITH ONLY 1 ADDITIONAL COMPLAINT AND 6 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT RECEIVED BY GM SINCE APRIL 2007. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Vehicle Speed Control
TO DATE, THE OFFICE OF DEFECTS INVESTIGATION (ODI) IS AWARE OF 29 NON-DUPLICATIVE COMPLAINTS/FIELD REPORTS AND 52 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT AFFECTING 69 UNIQUE SUBJECT VEHICLES.BECAUSE THE ALLEGED DEFECT CONDITION IS MOST LIKELY TO OCCUR DURING WINTER MONTHS WHEN AMBIENT TEMPERATURES ARE BELOW FREEZING, ODI UPGRADED THIS INVESTIGATION TO AN ENGINEERING ANALYSIS ON FEBRUARY 14, 2008 SO THAT IT COULD CONTINUE TO MONITOR THE FIELD EXPERIENCE DURING THE 2007/2008 WINTER SEASON.BY LETTER DATED MAY 22, 2008, GENERAL MOTORS CORP. (GM) SUPPLEMENTED ITS PREVIOUS INFORMATION REQUEST RESPONSE WITH FIELD DATA RECEIVED BY GM THROUGH MAY 1, 2008.ACCORDING TO GM, WHEN MOISTURE FREEZES IN THE POSITIVE CRANKCASE VENTILATION (PCV) SYSTEM AND/OR THE ENGINE AIR INTAKE TRACT IT IS MOST OFTEN OBSERVED AS A HARD TO START/NO START CONDITION, THROTTLE STUCK CLOSED, ROUGH RUNNING ENGINE, STALLING AT IDLE, OR OIL LEAKAGE.OF THE 29 COMPLAINTS RELATED TO STUCK THROTTLE, ODI IDENTIFIED 5 REPORTS THAT ALLEGE UNWANTED ACCELERATION, 13 REPORTS DESCRIBE AN APPARENT HIGH-IDLE CONDITION AT START UP OR WHEN SLOWING THE VEHICLE TO A STOP WITHOUT ANY ALLEGATION OF UNWANTED ACCELERATION OR DIMINISHED BRAKING PERFORMANCE, AND THE REMAINING 11 REPORTS DESCRIBE AMBIGUOUS ALLEGATIONS OF STUCK THROTTLE WITHOUT REGARD TO SEVERITY OR CONSEQUENCE.ODI ANALYSIS OF FIELD INCIDENT DATA SHOWS THAT THE COMPLAINT AND WARRANTY TRENDS APPEAR TO BE IN DECLINE, WITH ONLY 1 ADDITIONAL COMPLAINT AND 6 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT RECEIVED BY GM SINCE APRIL 2007. A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE07051 · Stuck Throttle Valve
Opened Oct 19, 2007 · Closed Feb 14, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv); Vehicle Speed Control
ON OCTOBER 19, 2007, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED STUCK THROTTLE INCIDENTS DUE TO ICE FORMATION WITHIN THE ENGINE AIR INTAKE TRACT IN CERTAIN MODEL YEAR (MY) 2004-2005 CHEVROLET AVEO VEHICLES MANUFACTURED FOR SALE OR LEASE IN THE UNITED STATES.THIS INVESTIGATION WAS PROMPTED BY A SAFETY RECALL CAMPAIGN (05F-069) CONDUCTED BY GENERAL MOTORS CORP. (GM) INVOLVING SUBSTANTIALLY SIMILAR VEHICLES MANUFACTURED FOR SALE OR LEASE IN CANADA.AT THAT TIME, GM ISSUED A TECHNICAL SERVICE BULLETIN (TSB #05-06-04-065) TO ADDRESS THE ALLEGED DEFECT CONDITION IN U.S. VEHICLES.GM SUBSEQUENTLY REVISED THE CANADIAN RECALL CAMPAIGN TO INCLUDE MORE DETAILED INSTRUCTIONS AFTER IT DISCOVERED CERTAIN VEHICLES WERE NOT PROPERLY SERVICED UNDER THE ORIGINAL RECALL CAMPAIGN.GM REVISED THE CANADIAN RECALL CAMPAIGN A SECOND TIME TO INCLUDE MORE SUBSTANTIAL CHANGES TO THE THROTTLE BODY, INTAKE MANIFOLD, POSITIVE CRANKCASE VENTILATION (PCV) AND ENGINE COOLING SYSTEMS TO FURTHER REDUCE THE LIKELIHOOD OF ICING WITHIN THE ENGINE AIR INTAKE TRACT.AGAIN, GM ISSUED A TECHNICAL SERVICE BULLETIN (TSB #08-06-04-009) TO ADDRESS THE ALLEGED DEFECT CONDITION IN U.S. VEHICLES USING THE REVISED PROCEDURE.ODI IS AWARE OF 28 NON-DUPLICATIVE COMPLAINTS/FIELD REPORTS AND 46 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT AFFECTING 63 UNIQUE SUBJECT VEHICLES.THE ALLEGED DEFECT CONDITION IS MOST LIKELY TO OCCUR DURING THE WINTER MONTHS WHEN AMBIENT TEMPERATURES ARE BELOW FREEZING.HOWEVER, THE INFORMATION PROVIDED IN GM'S RESPONSE TO ODI'S INFORMATION REQUEST LETTER DATED NOVEMBER 2, 2007, DOES NOT CAPTURE EVENTS THAT MAY HAVE OCCURRED DURING THE MOST RECENT WINTER MONTHS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-005) TO FURTHER STUDY THE FREQUENCY OF THE ALLEGED DEFECT.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)
ON OCTOBER 19, 2007, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED STUCK THROTTLE INCIDENTS DUE TO ICE FORMATION WITHIN THE ENGINE AIR INTAKE TRACT IN CERTAIN MODEL YEAR (MY) 2004-2005 CHEVROLET AVEO VEHICLES MANUFACTURED FOR SALE OR LEASE IN THE UNITED STATES.THIS INVESTIGATION WAS PROMPTED BY A SAFETY RECALL CAMPAIGN (05F-069) CONDUCTED BY GENERAL MOTORS CORP. (GM) INVOLVING SUBSTANTIALLY SIMILAR VEHICLES MANUFACTURED FOR SALE OR LEASE IN CANADA.AT THAT TIME, GM ISSUED A TECHNICAL SERVICE BULLETIN (TSB #05-06-04-065) TO ADDRESS THE ALLEGED DEFECT CONDITION IN U.S. VEHICLES.GM SUBSEQUENTLY REVISED THE CANADIAN RECALL CAMPAIGN TO INCLUDE MORE DETAILED INSTRUCTIONS AFTER IT DISCOVERED CERTAIN VEHICLES WERE NOT PROPERLY SERVICED UNDER THE ORIGINAL RECALL CAMPAIGN.GM REVISED THE CANADIAN RECALL CAMPAIGN A SECOND TIME TO INCLUDE MORE SUBSTANTIAL CHANGES TO THE THROTTLE BODY, INTAKE MANIFOLD, POSITIVE CRANKCASE VENTILATION (PCV) AND ENGINE COOLING SYSTEMS TO FURTHER REDUCE THE LIKELIHOOD OF ICING WITHIN THE ENGINE AIR INTAKE TRACT.AGAIN, GM ISSUED A TECHNICAL SERVICE BULLETIN (TSB #08-06-04-009) TO ADDRESS THE ALLEGED DEFECT CONDITION IN U.S. VEHICLES USING THE REVISED PROCEDURE.ODI IS AWARE OF 28 NON-DUPLICATIVE COMPLAINTS/FIELD REPORTS AND 46 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT AFFECTING 63 UNIQUE SUBJECT VEHICLES.THE ALLEGED DEFECT CONDITION IS MOST LIKELY TO OCCUR DURING THE WINTER MONTHS WHEN AMBIENT TEMPERATURES ARE BELOW FREEZING.HOWEVER, THE INFORMATION PROVIDED IN GM'S RESPONSE TO ODI'S INFORMATION REQUEST LETTER DATED NOVEMBER 2, 2007, DOES NOT CAPTURE EVENTS THAT MAY HAVE OCCURRED DURING THE MOST RECENT WINTER MONTHS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-005) TO FURTHER STUDY THE FREQUENCY OF THE ALLEGED DEFECT.
Vehicle Speed Control
ON OCTOBER 19, 2007, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED STUCK THROTTLE INCIDENTS DUE TO ICE FORMATION WITHIN THE ENGINE AIR INTAKE TRACT IN CERTAIN MODEL YEAR (MY) 2004-2005 CHEVROLET AVEO VEHICLES MANUFACTURED FOR SALE OR LEASE IN THE UNITED STATES.THIS INVESTIGATION WAS PROMPTED BY A SAFETY RECALL CAMPAIGN (05F-069) CONDUCTED BY GENERAL MOTORS CORP. (GM) INVOLVING SUBSTANTIALLY SIMILAR VEHICLES MANUFACTURED FOR SALE OR LEASE IN CANADA.AT THAT TIME, GM ISSUED A TECHNICAL SERVICE BULLETIN (TSB #05-06-04-065) TO ADDRESS THE ALLEGED DEFECT CONDITION IN U.S. VEHICLES.GM SUBSEQUENTLY REVISED THE CANADIAN RECALL CAMPAIGN TO INCLUDE MORE DETAILED INSTRUCTIONS AFTER IT DISCOVERED CERTAIN VEHICLES WERE NOT PROPERLY SERVICED UNDER THE ORIGINAL RECALL CAMPAIGN.GM REVISED THE CANADIAN RECALL CAMPAIGN A SECOND TIME TO INCLUDE MORE SUBSTANTIAL CHANGES TO THE THROTTLE BODY, INTAKE MANIFOLD, POSITIVE CRANKCASE VENTILATION (PCV) AND ENGINE COOLING SYSTEMS TO FURTHER REDUCE THE LIKELIHOOD OF ICING WITHIN THE ENGINE AIR INTAKE TRACT.AGAIN, GM ISSUED A TECHNICAL SERVICE BULLETIN (TSB #08-06-04-009) TO ADDRESS THE ALLEGED DEFECT CONDITION IN U.S. VEHICLES USING THE REVISED PROCEDURE.ODI IS AWARE OF 28 NON-DUPLICATIVE COMPLAINTS/FIELD REPORTS AND 46 WARRANTY CLAIMS RELATED TO THE ALLEGED DEFECT AFFECTING 63 UNIQUE SUBJECT VEHICLES.THE ALLEGED DEFECT CONDITION IS MOST LIKELY TO OCCUR DURING THE WINTER MONTHS WHEN AMBIENT TEMPERATURES ARE BELOW FREEZING.HOWEVER, THE INFORMATION PROVIDED IN GM'S RESPONSE TO ODI'S INFORMATION REQUEST LETTER DATED NOVEMBER 2, 2007, DOES NOT CAPTURE EVENTS THAT MAY HAVE OCCURRED DURING THE MOST RECENT WINTER MONTHS.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-005) TO FURTHER STUDY THE FREQUENCY OF THE ALLEGED DEFECT.