IllustrationTHE FUEL LINES RUBBING TOGETHER CAUSING FUEL TO DUMP EVERY WHERE RIGHT NEXT TO THE CAT ON THE DRIVER SIDE OF THE TRUCK N THIS IS NOT A RECALL. THEN I SAY ITS ATTEPMED MURDER CHARGE AGAISNT CHEVY....
2005 Chevrolet Avalanche
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Chevrolet Avalanche do not stand out strongly from the model-year median of 82.
About this comparison →How this year compares
Owner complaints by model year
Compare all Avalanche years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
70–25K
1425–50K
1050–75K
1175–100K
16100–150K
4150K+
62 reports with mileage · 9 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports0 fire reports3 injury reports
Unknown Or Other complaints
3 reportsTHE INSTRUMENT PANEL CLUSTER DOES NOT LIGHT UP. CANNOT TELL WHAT GEAR I AM SHIFTING IN AND OUT OF. THE DIC BUTTONS ON MY STEERING WHEEL DO NOT LIGHT UP, CANNOT TELL IF I HAVE A MALFUNCTION WHEN DRIVING DURING THE DARK. I DID CHECK FOR A RECALL ON THIS AND SAW THAT THERE WAS AN OLDER ONE ISSUED IN 2005 AND THAT IT CLOSED IN 2011.…
Read full complaint
THE INSTRUMENT PANEL CLUSTER DOES NOT LIGHT UP. CANNOT TELL WHAT GEAR I AM SHIFTING IN AND OUT OF. THE DIC BUTTONS ON MY STEERING WHEEL DO NOT LIGHT UP, CANNOT TELL IF I HAVE A MALFUNCTION WHEN DRIVING DURING THE DARK. I DID CHECK FOR A RECALL ON THIS AND SAW THAT THERE WAS AN OLDER ONE ISSUED IN 2005 AND THAT IT CLOSED IN 2011. I WAS NOT AWARE OF ANY RECALLS BUT NONE THE LESS I FEEL THAT WITH BOTH COMPONENTS FAILING AND NOT WORKING PROPERLY CAN CAUSE A POTENTIAL PROBLEM WHEN IN OPERATION (DRIVING)
AT APPROX 47000 MI TRAVELING AT 65MPH A HEAVY THUD IN THE ENGINE COMPARTMENT THAT SOUNDED LIKE THE WHOLE ENGINE BLOCK HAD DROPPED OUT, WAS ABLE TO COAST OFF ROAD TO A VACANT LOT. TRANSMISSION TOAST WITH DAMAGE TO RING AND PINION GEARS,NEVER TOWED ANYTHING, CITY DRIVING TO WORK AND HOME MOSTLY.(47K) MILES. REALLY? 3500$ REPAIR. N…
Read full complaint
AT APPROX 47000 MI TRAVELING AT 65MPH A HEAVY THUD IN THE ENGINE COMPARTMENT THAT SOUNDED LIKE THE WHOLE ENGINE BLOCK HAD DROPPED OUT, WAS ABLE TO COAST OFF ROAD TO A VACANT LOT. TRANSMISSION TOAST WITH DAMAGE TO RING AND PINION GEARS,NEVER TOWED ANYTHING, CITY DRIVING TO WORK AND HOME MOSTLY.(47K) MILES. REALLY? 3500$ REPAIR. NEXT SPEEDOMETER FAILURE AT ABOUT 53K MILES, IM EITHER GOING 0MPH OR 120MPH. ALSO HAVE LOST ALOT OF BACKLIGHTING ON MY DASHBOARD INSTRUMENTATION ALONG WITH CD PLAYER. SEEMS THE CD PLAYER CANNOT EJECT A NON EXISTENT CD, JUST MAKES CLICKING NOISE AND SAYS CHECK DISC. NOW AT 59K MILES IM EXPERIENCING THE POPPING FRONT END SOUND WHEN TURNING SHARPLY IN REVERSE, POSSIBLY SUSPENSION OR A-ARM RELATED HAVE NOT LOOKED INTO YET. *TR
Official recalls
305V163000 · Seat Belts:rear/other
Apr 22, 2005
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Consequence & remedy
Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
05V055000 · Power Train:manual Transmission:shift Pattern Indicator
Feb 14, 2005
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER CERTAIN VEHICLE STARTING CONDITIONS, THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER MAY NOT ILLUMINATE. IF THE SHIFT LEVER POSITION INDICATOR DOES NOT ILLUMINATE, THE DRIVER MAY NOT KNOW WHICH GEAR THE VEHICLE IS IN.
Consequence & remedy
Consequence: THE VEHICLE MAY MOVE IN AN UNINTENDED DIRECTION RESULTING IN POSSIBLE INJURY TO OTHERS OUTSIDE OF THE VEHICLE.
Remedy: DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, AND GMC AT 1-866-996-9463.
05V043000 · Service Brakes, Hydraulic
Feb 8, 2005
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.