IllustrationAIRBAG SERVICE LIGHT. *TR
2003 Chevrolet Avalanche 1500
Owner reports · Recalls · Investigations
More warning signs than most Avalanche 1500 years
Owner complaints for the 2003 Chevrolet Avalanche 1500 are substantially higher than the model-year median of 38.
About this comparison →How this year compares
Owner complaints by model year
Compare all Avalanche 1500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
70–25K
1525–50K
3650–75K
3775–100K
39100–150K
20150K+
154 reports with mileage · 28 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 84 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports3 fire reports2 injury reports
What owners actually said
182 reportsSERVICE AIR BAG LIGHT STAYS ON BEEN THIS WAY FOR A COUPLE OF YEARS CHEVROLET KNOWS OF THE PROBLEM BUT WILL NOT DO A RECALL. *TR
SAME PROBLEM AS FOUND IN NHTSA ID # 05V37900 IN 2002 CHEVY AVALANCHE IS OCCURRING IN MY 2003 CHEVY AVALANCHE. THE ABS IS ACTIVATED WHEN REACHING A SPEED OF 5 MPH OR LESS. THIS IS CAUSING MY AVALANCHE TO NOT STOP IMMEDIATELY AT STOP SIGNS OR RED LIGHTS. MY AVALANCHE WILL TRAVEL APPROXIMATELY 2 TO 3 FEET CLOSER TO THE CAR OR IN…
Read full complaint
SAME PROBLEM AS FOUND IN NHTSA ID # 05V37900 IN 2002 CHEVY AVALANCHE IS OCCURRING IN MY 2003 CHEVY AVALANCHE. THE ABS IS ACTIVATED WHEN REACHING A SPEED OF 5 MPH OR LESS. THIS IS CAUSING MY AVALANCHE TO NOT STOP IMMEDIATELY AT STOP SIGNS OR RED LIGHTS. MY AVALANCHE WILL TRAVEL APPROXIMATELY 2 TO 3 FEET CLOSER TO THE CAR OR INTERSECTION I AM STOPPING AT. IF I ROLL THROUGH THE STOP SIGN OR NOT GO BELOW 5 MPH WHILE TURNING, THE ABS DO NOT COME ON. *TR
SERVICE BRAKE SYSTEM LIGHT COMES ON IN INFORMATION CENTER, BRAKE AND ABS LIGHTS ARE ON. THE GARAGE SAYS THE BRAKE COMPUTER FOR THE ABS IS NOT FUNCTIONS DISABLING THE ABS ON THE VEHICLE. THE COMPUTER PART FOR THE VEHICLE IS UNAVAILABLE. THE ABS BRAKE SYSTEM REMAINS DISABLED. IT IS A 2003 MODEL YEAR VEHICLE. BRAKE PARTS SHOULD BE …
Read full complaint
SERVICE BRAKE SYSTEM LIGHT COMES ON IN INFORMATION CENTER, BRAKE AND ABS LIGHTS ARE ON. THE GARAGE SAYS THE BRAKE COMPUTER FOR THE ABS IS NOT FUNCTIONS DISABLING THE ABS ON THE VEHICLE. THE COMPUTER PART FOR THE VEHICLE IS UNAVAILABLE. THE ABS BRAKE SYSTEM REMAINS DISABLED. IT IS A 2003 MODEL YEAR VEHICLE. BRAKE PARTS SHOULD BE AVAILABLE FOR THE ABS SYSTEM. *TR
SPEEDOMETER ON 2003 CHEVROLET AVALANCHE NOT WORKING, STUCK AT 120MPH. COMPLETE CLUSTER NEEDS TO BE REPLACED. I NEVER RECEIVED ANY RECALL NOTICE AFTER PURCHASING VEHICLE IN 2003. GM WILL NOT CORRECT PROBLEM BECAUSE IT IS OUT OF WARRANTY. *TR
ENGINE STALLS SHORTLY AFTER STARTING. UNABLE TO GET ANY RESPONSE AFTER THE INITIAL STALL (IT WOULD NOT CRACK). BATTERY CABLES MUST BE DISCONNECTED FROM THE BATTERY AND RECONNECTED AFTER TWO TO THREE MINUTES IN ORDER TO RESTART THE VEHICLE. NO ENGINE TROUBLE CODE DISPLAYED AFTER THE INCIDENT. *TR
I HAVE A 2003 CHEVY AVALANCHE AND THE BACK WINDOW IS CRACK WHEN I TALKED TO GM THEY SAID THAT IT WAS OUT OF WARRANTY AND WOULD NOT DO ANYTHING. *TR
MY SPEEDOMETER ISN'T WORKING PROPERLY. IT GETS STUCK WHILE I DRIVE AND I DON'T KNOW THE SPEED OF MY TRUCK WHEN I DRIVE AND I SEEN THAT THIS IS A KNOWN ISSUE TO CHEVROLET. *TR
WWW-ODI.NHTSA.DOT.GOV. *TR
(2003 CHEVY AVALANCHE 1500 ~ 67,000 MILES) 1. THIS WAS A SPONTANEOUS FAILURE - THAT IS TO SAY, THERE WAS NO EVENT LEADING UP TO IT. 2. THERE IS A SPRING-CLIP THAT RETAINS THE EMERGENCY BRAKE SHOE. THIS SPRING-CLIP (ON THE DRIVER-SIDE, REAR WHEEL) CAME APART, ALLOWING THE E-BRAKE SHOE TO COME LOOSE. THIS HAD 2 RESULTS:…
Read full complaint
(2003 CHEVY AVALANCHE 1500 ~ 67,000 MILES) 1. THIS WAS A SPONTANEOUS FAILURE - THAT IS TO SAY, THERE WAS NO EVENT LEADING UP TO IT. 2. THERE IS A SPRING-CLIP THAT RETAINS THE EMERGENCY BRAKE SHOE. THIS SPRING-CLIP (ON THE DRIVER-SIDE, REAR WHEEL) CAME APART, ALLOWING THE E-BRAKE SHOE TO COME LOOSE. THIS HAD 2 RESULTS: 1) THE E-BRAKE SHOE FELL OUT OF POSITION, WEDGED ITSELF SOMEWHERE INSIDE OF THE DRUM, AND THEN THE BRAKE-SHOE & DRUM GROUND AGAINST EACH OTHER UNTIL THEY WERE BOTH EXTENSIVELY DAMAGED AND/OR DESTROYED, 2) THE ENTIRE EMERGENCY-BRAKE SYSTEM WAS RENDERED COMPLETELY USELESS. 3. THE DAMAGE FROM THE FAILURE CAN BE REPAIRED BY REPLACING THE EMERGENCY BRAKE SHOE, BRAKE ROTOR AND SPRING-CLIP. (I WILL PRO-ACTIVELY REPLACE THE SPRING-CLIP ON THE PASSENGER SIDE WHICH HAS NOT YET FAILED). THE OLD PARTS ARE STILL AVAILABLE. I DO NOT KNOW IF THIS SPRING-CLIP HAS BEEN REDESIGNED OR NOT. *TR
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA11001 · Brake Line Corrosion Failure
Opened Jan 5, 2011 · Closed Apr 8, 2015
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t
Service Brakes, Hydraulic
On January 11, 2011, ODI opened EA11-001 to investigate allegations of premature brake line corrosion failure in model year (MY) 1999 through 2003 General Motors (GM) full-size pickup trucks and sport utility vehicles sold or registered in the following region of the United States that NHTSA has viewed as salt states for investigations of corrosion related issues:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin.The subject vehicles represent the first five MY's of GM's GMT800 platform production, of which approximately 2,038,504 vehicles were sold in salt states (the subject vehicles).The GMT800 platform includes the following vehicles:1999-2007 Chevrolet Silverado and GMC Sierra 1500, 2500 and 3500 series pick-up trucks; 2000-2006 Chevrolet Suburban, Chevrolet Tahoe and GMC Yukon sport utility vehicles; and 2002-2006 Cadillac Escalade and Chevrolet Avalanche sport-utility vehicles.General Motors produced a total of approximately 10,427,062 GMT800 vehicles for sales in the United States, including almost 5 million that were sold in salt states.Although there are over 60 different brake pipe routing configuration used in GMT800 vehicles, with the exception of the rear crossover pipes in MY 200x-2007 vehicles that changed from rear disc to drum brakes, all of the vehicles use brake pipes from the same supplier with a common double-wall, brazed steel pipe design with a combination of hot dip Zinc-Aluminum corrosion protection coating and Aluminum paint outer layer known in the industry as AlGal (ASTM-B750). ODI analysis of field data regarding GMT800 vehicles identified a total of 3,645 complaints of brake pipe corrosion failures, including 107 alleging crashes, and 40 injuries.Though only 20% of total GMT800 production, due to age and region the subject vehicles account for a disproportionate share of the failure experience; with 2,702 of the complaints (75%), 88 of the crashes (82%) and 20 of the injuries (50%) reported in those vehicles.Analysis of the complaints showed strong correlations to vehicle age and region.For vehicles with less than 8 years of service, the complaint rates were minimal for all regions.In the salt states the failure rates begin to climb as the vehicles advance in age, particularly in the Northeast corner of the United States.The complaint rates in the salt states go from less than 0.1 incident per thousand vehicles (IPTV) at 7 years in service to over 1.0 IPTV after the 12th year of service for the subject pickup trucks and utility vehicles.Most of the failures reported to ODI occurred in vehicles with more than 10 years in service.ODI?s investigation did not identify any specific defect conditions that were causing or contributing to the brake pipe failures.Nor did the analysis isolate the problem to any subject vehicle sub-populations when analyzed by vehicle type or production range.The investigation found that vehicles experiencing brake pipe corrosion failures were likely to have general patterns of excessive corrosion on the majority of the brake pipe assembly and appear to be occurring due to expected wear out for the brake pipe coating material used in the subject vehicles and the environmental conditions in severe corrosion states.A safety-related defect has not been identified at this time.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor t