SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

2004 Chevrolet Astro

Owner reports · Recalls · Investigations

Limited comparison data

There is not enough comparable history to draw a useful model-year comparison.

About this comparison →
14Owner complaints

Model-year median: 69

0Recall campaigns

View recall details →

0Investigations

View investigation details →

How this year compares

Owner complaints by model year

Other model years Selected year
91
200170
200262
200314
20049
2005
Compare all Astro years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

Service Brakes, Hydraulic
4Electrical System
2Service Brakes
2Vehicle Speed Control
2Air Bags
1
All reported categories
Engine
1Fuel System, Gasoline
1Latches/locks/linkages
1Parking Brake
1Suspension
1Visibility
1

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

Limited mileage data: 13 of 14 reports include usable mileage. There isn’t enough coverage to show a useful chart.

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Service Brakes, Hydraulic. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Service Brakes. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

1 crash reports1 fire reports1 injury reports

Fuel System, Gasoline complaints

1 reports
Clear category filter
133,000 miles · Jun 20, 2014
Electrical SystemEngineFuel System, Gasoline

TL* THE CONTACT OWNS A 2004 CHEVROLET ASTRO. THE CONTACT STATED THAT THE VEHICLE FAILED TO START UNTIL AFTER THREE ATTEMPTS. THE CONTACT SHIFTED INTO DRIVE AND THEN THE VEHICLE LOST ALL POWER. THE CONTACT PUMPED THE ACCELERATOR PEDAL, WAITED TEN MINUTES AND THE VEHICLE RESUMED ITS NORMAL OPERATION. THE FAILURE OCCURRED ON A RE…

Read full complaint

TL* THE CONTACT OWNS A 2004 CHEVROLET ASTRO. THE CONTACT STATED THAT THE VEHICLE FAILED TO START UNTIL AFTER THREE ATTEMPTS. THE CONTACT SHIFTED INTO DRIVE AND THEN THE VEHICLE LOST ALL POWER. THE CONTACT PUMPED THE ACCELERATOR PEDAL, WAITED TEN MINUTES AND THE VEHICLE RESUMED ITS NORMAL OPERATION. THE FAILURE OCCURRED ON A REGULAR BASIS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE DEALER DIAGNOSED THE FAILURE AND STATED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE DEALER ASSURED THE CONTACT THAT AFTER PAYING FOR THE REPAIR, THE FAILURE WOULD BE RESOLVED. THE FUEL PUMP, STARTER, MOTOR MOUNTS, AND GENERATOR WERE ALL REPLACED; HOWEVER, THE FAILURE RECURRED. THE FAILURE MILEAGE WAS 133,000. THE CURRENT MILEAGE WAS 134,249.

NHTSA ODI #10604713

Official recalls

0

No recalls in this snapshot.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

0

No exact-year investigations in this snapshot.