2003 Chevrolet Astro

I AM COMPLAINING OF THE SAFETY ISSUES REGARDING THE ABS COMPUTER SYSTEM. I HAVE PUT MY VEHICLE IN THE SHOP TO BE CHECKED OUT BY A FEW CAR REPAIR FACILITIES AND ALL HAVE SAID THE SAME THING MY ABS CPU. MY VAN IS HESITATING TERRIBLY AND CAUSING THE VAN TO NOT ACCELERATE PROPERLY. I HAVE NEARLY BEEN IN THREE ACCIDENTS SINCE THE PROBLEM HAS BEEN OCCURRING. I HAVE ALSO DONE SOME RESEARCH ON THIS ISSUE VIA INTERNET AND FOUND THAT MANY PEOPLE ARE HAVING THE SAME PROBLEM ACROSS THE USA. AND GM IS BLAMING IT ON THE WEATHER CONDITIONS IN THE NORTH BUT THE PROBLEMS ARE HAPPENING TO ASTRO VANS(2003) ACROSS THE ENTIRE US. THIS IS A PROBLEM THAT SHOULD BE ADDRESSED AS SOON AS POSSIBLE.. THE CONTACT STATED WHILE APPLYING BRAKE PRESSURE AT 20MPH OR LESS, THE ABS ACTIVATED WITH AN INCREASED STOPPING DISTANCE. THE VEHICLE WAS SEEN BY AN INDEPENDENT REPAIR SHOP. A DIAGNOSTIC TEST WAS PERFORMED WHICH INDICATED A FAILURE IN THE RIGHT FRONT WHEEL SPEED SENSOR. THE MECHANIC DETERMINED THE WHEEL SPEED SENSOR OF THE ANTILOCK BRAKES NEEDED TO BE REPLACED. THERE IS A NHTSA RECALL, # 05V379000, REGARDING THE ANTILOCK BRAKES. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THIS VEHICLE CURRENTLY HAS THIS ISSUE, AND WAS CHECKED BY A REPAIR SHOP. THEY DESCRIBED THE PROBLEM UNDETECTABLE; THE RECALL WAS ON MODELS UP TO 2002. IT SEEMS THAT IT CARRIED OVER TO THIS MODEL, CAN THE DEALER ASSIST IN REPLACING THE PARTS. I WOULD PAY THE LABOR BUT THE PARTS INVOLVED ARE ABOUT $1500.00 FROM THE DEALER ALONE. CAN I GET HELP FROM THE NHTSA TO GET THIS CRITICAL ISSUE RESOLVED. *TR

I WAS DRIVING APPROXIMATELY 30 MILES PER HOUR ALONG SLIGHTLY SNOW-COVERED ROAD TOWARDS STOPPED TRAFFIC AT RED LIGHT ON A SLIGHT DOWNGRADE. I STEPPED ON THE BRAKES GENTLE, AS REQUIRED BY THE CONDITIONS, BUT THE ABS SYSTEM STARTED TO SHUDDER AND THE VEHICLE DID NOT BRAKE AT ALL. I HIT A STOPPED VEHICLE AT THE INTERSECTION AND EVEN WITH A RELATIVELY SLOW SPEED IMPACT, OUR VEHICLE WAS WRITTEN OFF AND THE OTHER WAS TOWED AWAY BECAUSE IT COULD NOT BE DRIVEN. OUR VAN WAS DRIVABLE, BUT JUST BARELY, AND WAS SUBSEQUENTLY WRITTEN OFF BY THE INSURANCE COMPANY. I WAS CHARGED WITH CARELESS DRIVING WHICH WAS ABSOLUTELY NOT THE CASE. WE HAVE ANOTHER VEHICLE OF THE SAME YEAR AND SIMILAR MODEL AND IT DOES THE SAME THING OCCASIONALLY BUT SO FAR THIS HAS NOT RESULTED IN ANY FURTHER COLLISIONS. WE HAVE OWNED ASTRO VANS SINCE THEY WERE FIRST MARKETED IN 1985 AND THIS IS THE FIRST ONE TO ACT LIKE THIS. WE PURCHASED 1985, 1992, 1998, AND 2003 MODELS (2). I AM ASKING MY WIFE, ROSE, WHO IS ALSO THE REGISTERED OWNER OF THE VEHICLE TO SUBMIT THIS REPORT ON MY BEHALF. PLEASE RESPOND TO HER WITH ANY RESOLUTIONS. WE PURCHASED THE SALVAGE FROM THE INSURANCE COMPANY SO IT IS STILL IN OUR POSSESSION ALTHOUGH NOT ON THE ROAD. *TR

VEHICLE: 2003 CHEVY ASTRO VAN DEFECT SUMMARY: FACTORY DESIGN DIRECTS LEAKED BATTERY ACID TO DRIP DOWN ON A STEEL BRAKE LINE. DETAILS: THE (+) BATTERY TERMINAL SPONTANEOUSLY BROKE OFF THIS VEHICLE'S OEM DELCO BATTERY. THE BREAKAGE WAS DUE TO EITHER: 1) CABLE CONNECTOR BEING OVER-TORQUED AT THE GM FACTORY, OR 2) AN INTEGRAL FAULT WITHIN THE BATTERY. THE DESIGN OF THIS YEAR-MODEL OF ASTRO IS SUCH THAT THE NATURAL PATH FOR ACID DRIP-PAGE IS ON TO A STEEL BRAKE LINE LOCATED BELOW, AND IN FRONT, OF THE BATTERY. I AM GOING TO HAVE THE BRAKE LINE REPLACED BY A LOCAL CERTIFIED MECHANIC BECAUSE THE LINE IS SEVERELY CORRODED DUE TO THE ACID EXPOSURE. BECAUSE OF THE INACCESSIBILITY OF THE BRAKE LINE AND ITS CONNECTIONS, THE REPAIR COST WILL NOT BE CHEAP. PLEASE NOTE THAT THE BATTERY AND CABLE HAVE NOT BEEN EXPOSED TO ANY POST-MANUFACTURE MISUSE OR DISTURBANCE. THE PROBLEM IS SOLELY DUE TO POOR PLACEMENT OF THE HYDRAULIC LINE, COUPLED WITH THE FACTORY INDUCED BATTERY BREAKAGE. I HAVE DIGITAL PHOTOGRAPHS FOR YOUR INSPECTION OF THE BROKEN BATTERY TERMINAL, THE GEOMETRY OF THE BATTERY COMPARTMENT, THE (BRAKE) HYDRAULIC LINE, AND THE RESULTING CORROSION. *TR

ON SEVERAL OCCASIONS OVER THE PAST FEW MONTHS, THE ABS LIGHT ON MY VAN HAS BEEN COMING ON AND WHEN I APPLY THE BRAKES, THE VAN JERKS AROUND ON THE ROAD AND PULLS TO THE LEFT. I HAVE ALMOST HIT OTHER CARS ON MANY OF THESE OCCASIONS. I HAD MY MECHANIC LOOK AT IT RECENTLY AND HE SAID HE CHECKED OUT THE BRAKING SYSTEM AND CAN SEE NO VISIBLE REASON FOR THIS HAPPENING. *TR

I AM COMPLAINING OF THE SAFETY ISSUES REGARDING THE ABS COMPUTER SYSTEM. I HAVE PUT MY VEHICLE IN THE SHOP TO BE CHECKED OUT BY A FEW CAR REPAIR FACILITIES AND ALL HAVE SAID THE SAME THING MY ABS CPU. MY VAN IS HESITATING TERRIBLY AND CAUSING THE VAN TO NOT ACCELERATE PROPERLY. I HAVE NEARLY BEEN IN THREE ACCIDENTS SINCE THE PROBLEM HAS BEEN OCCURRING. I HAVE ALSO DONE SOME RESEARCH ON THIS ISSUE VIA INTERNET AND FOUND THAT MANY PEOPLE ARE HAVING THE SAME PROBLEM ACROSS THE USA. AND GM IS BLAMING IT ON THE WEATHER CONDITIONS IN THE NORTH BUT THE PROBLEMS ARE HAPPENING TO ASTRO VANS(2003) ACROSS THE ENTIRE US. THIS IS A PROBLEM THAT SHOULD BE ADDRESSED AS SOON AS POSSIBLE.. *JB

TL* - THE CONTACT HAS A 2003 CHEVROLET ASTRO VAN WHICH HAS BEEN IN THE DEALER SERVICE SHOP SINCE DECEMBER 19, 2006. WHEN DRIVING AND TURNING THE VEHICLE LOST POWER IN BOTH THE STEERING SYSTEM AND THE BRAKES. THE DEALER RAN THE VEHICLE TROUGH DIAGNOSTIC TESTS, AND COULD NOT DETERMINE THE CAUSE OF THE FAILURE. THE CONTACT FOUND RECALL INFORMATION FOR VEHICLES WITH SIMILAR FAILURES. ON DECEMBER 29 2006 THEY RECEIVED A CALL FROM THE DEALER STATING THAT THEY WERE CHECKING TO SEE IF THE PROBLEM WAS COVERED UNDER THE VEHICLE'S WARRANTY IF NOT THE COST OF THE REPAIR WILL BE $552.10. *AK