IllustrationWHILE TRAVELING ABOUT 30MPH ON THE HIGHWAY WITHOUT PRIOR WARNING. THE GAS PEDAL WAS STUCK AND EXCESSIVE SPEEDING AND SHE WAS ABLE TO STOP BY TURNING OFF THE VEHICLE. PLEASE PROVIDE ADDITIONAL INFORMATION. DEALER IS AWARE OF THE PROBLEM. TS
2002 Chevrolet Astro
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Chevrolet Astro do not stand out strongly from the model-year median of 69.
About this comparison →How this year compares
Owner complaints by model year
Compare all Astro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
70–25K
1225–50K
650–75K
775–100K
8100–150K
5150K+
45 reports with mileage · 25 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports3 fire reports3 injury reports
What owners actually said
70 reportsI HAVE 10 VANS ALL WITH DRIVER SIDE WINDOW PROBLEMS AND THEY ALL NEW 2002, CHEVY ASTRO VANS. DT
I HAVE RECENTLY PURCHASED A NEW CUSTOM VAN FROM THIS DEALERSHIP. MY REAR SEATBELTS ARE NOT INSTALLED PROPERLY, THEREFORE, I CAN NOT PROVIDE SAFE TRANSPORTATION FOR MY GRANDCHILDREN. THE DEALER AND THE GM REPRESENTATIVE HAVE BEEN EXTREMELY NON-COOPERATIVE AS WELL AS GM CONTRACTOR WHO CUSTOMIZED THE VAN. I AM TURNING TO YOU FOR A…
Read full complaint
I HAVE RECENTLY PURCHASED A NEW CUSTOM VAN FROM THIS DEALERSHIP. MY REAR SEATBELTS ARE NOT INSTALLED PROPERLY, THEREFORE, I CAN NOT PROVIDE SAFE TRANSPORTATION FOR MY GRANDCHILDREN. THE DEALER AND THE GM REPRESENTATIVE HAVE BEEN EXTREMELY NON-COOPERATIVE AS WELL AS GM CONTRACTOR WHO CUSTOMIZED THE VAN. I AM TURNING TO YOU FOR ANY ASSISTANCE. I PRAY THAT YOU CAN HELP MY WIFE AND I WITH A RESOLUTION TO THIS PROBLEM. I FEEL WE ARE BEING TAKEN ADVANTAGE OF BECAUSE OF OUR AGE AND WE CAN NOT FIGHT BACK (ATTORNEY) BECAUSE OF OUR LIMITED INCOME. THANK YOU. DT
CONSUMER STATES THAT WHILE DRIVING AND NO WARNING THE REAR WINDSHIELD HAD CRACK STARTING FROM THE DRIVER SIDE BOTTOM ALL THE WAY TO THE TOP OF THE WINDSHIELD CAUSING DISTRACTION FROM THE CONSUMER VIEW OF SEEING. DEALER NOTIFIED. NLM
THE CONSUMER STATES THAT WHEN THE SEAT BELTS ARE PULLED ALL THE WAY OUT, THEY WILL NOT LOCK. THE SEAT BELTS WILL NOT RESTRAINT CHILD CAR SEATS. *AK *SCC
WHY DOES THE LEFT FRONT TIRE ONLY SQUEAL WHEN TURNING RIGHT OR LEFT THE DEALERS SAY ITS NORMAL I LIKE A SECOND OPINION. *AK
BUCKLES OF REAR SEATS ON THE VEHICLE ARE ABOUT 6-7 INCHES FROM THE SEAT, WHEN CHILD IS SEATING, BUCKLE IS UP TO CHEST OR AROUND STOMACH AREA. CONTACTED DEALER, AND THE DEALER IS NOT WILLING TO DO ANYTHING WITH THE VEHICLE.*AK
CONSUMER STATES THAT THE BACK BENCH SEAT BELTS ARE TOO LONG, WHEN THE SEAT BELTS ARE PUT ON, THEY LAY OFF OF THE CHILDRENS RIB CAGES NEAR THEIR SIDES, THE SEAT BELTS DO NOT FIT CHILDREN OR ADULTS CORRECTLY, THEY WERE REPLACED WITH SHORTER BELTS, BUT THEY ARE STILL TOO LONG, DEALER STATED THAT THEY WOULD MOVE THE BOLTS BACK TO MA…
Read full complaint
CONSUMER STATES THAT THE BACK BENCH SEAT BELTS ARE TOO LONG, WHEN THE SEAT BELTS ARE PUT ON, THEY LAY OFF OF THE CHILDRENS RIB CAGES NEAR THEIR SIDES, THE SEAT BELTS DO NOT FIT CHILDREN OR ADULTS CORRECTLY, THEY WERE REPLACED WITH SHORTER BELTS, BUT THEY ARE STILL TOO LONG, DEALER STATED THAT THEY WOULD MOVE THE BOLTS BACK TO MAKE THEM SHORTER, HOWEVER LATER STATED THEY COULD NOT DUE TO LIABILITY REASONS. *SLC
UNIROYAL,HIDE A WAY, T155/80D18, ON A 2002, CHEVROLET, ASTRO, SPARE TIRE HAS DEEP CRACKS ALL AROUND THE SIDEWALL.*AK.*JB
UNIROYAL, HIDE A WAY, T155/80D18, ON A 2002 CHEVROLET, ASTRO WITH 28 MILES. SPARE TIRE HAS DEEP CRACKS ALL AROUND THE SIDEWALL.*AK.*JB
Official recalls
105V099000 · Exterior Lighting:brake Lights:switch
Mar 14, 2005
ON CERTAIN MINIVANS, THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT CONDITION IN THE STOP LAMP OR HAZARD LAMP CIRCUIT THAT RESULTS IN THE STOP LAMPS AND HAZARD LAMPS BEING INOPERATIVE.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING FLASHER SWITCH AND APPLY SPECIAL GREASE TO THE CONTACTS AT THE TIME OF INSTALLATION OF THE MODULE FREE OF CHARGE. THE REPAIR WOULD BE USED IN VEHICLES IN WHICH THE HAZARD SLIDER BUTTON IS STILL MOVABLE. IF A VEHICLE HAS A HAZARD SLIDER BUTTON THAT IS NOT MOVABLE (FROZEN), THE ENTIRE MULTIFUNCTION SWITCH WILL BE REPLACED. THE RECALL BEGAN ON APRIL 13, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE04072 · Loss Of Brake Lamp Illumination
Opened Oct 19, 2004 · Closed Mar 21, 2005
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:hazard Flashing Warning Lights
IN ITS LETTER DATED MARCH 9, 2005, GM STATED THAT IT WOULD CONDUCT A SAFETY RECALL TO REMEDY A FAULTY MULTIFUNCTION SWITCH IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 CHEVROLET ASTRO AND GMC SAFARI VEHICLES; SPECIFICALLY, ALL MY 2001 VEHICLES AND EARLY MY 2002 VEHICLES BUILT BETWEEN MARCH AND AUGUST 2001.SEE NHTSA RECALL NO. 05V-099 FOR DETAILS.THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT IN THE BRAKE LAMP OR HAZARD LAMP CIRCUIT RESULTING IN INOPERATIVE BRAKE LAMPS AND HAZARD LAMPS.THIS IS DUE TO THE COMBINED EFFECTS OF THE MATERIAL AND LUBRICATION FOR THE HAZARD SWITCH CONTACTOR THAT RESULT IN INCREASED RESISTANCE IN THE HAZARD SWITCH AND STUCK HAZARD SLIDER BUTTON IN OPEN (NO CONTACT) CONDITION.DEALERS ARE TO REPLACE THE HAZARD SWITCH AND APPLY SPECIAL GREASE TO THE HAZARD SWITCH CONTACTOR.IF A VEHICLE HAS A STUCK HAZARD SLIDER BUTTON, DEALERS ARE TO REPLACE THE ENTIRE MULTIFUNCTION SWITCH.
Additional source detail variants (2)
Exterior Lighting:brake Lights
IN ITS LETTER DATED MARCH 9, 2005, GM STATED THAT IT WOULD CONDUCT A SAFETY RECALL TO REMEDY A FAULTY MULTIFUNCTION SWITCH IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 CHEVROLET ASTRO AND GMC SAFARI VEHICLES; SPECIFICALLY, ALL MY 2001 VEHICLES AND EARLY MY 2002 VEHICLES BUILT BETWEEN MARCH AND AUGUST 2001.SEE NHTSA RECALL NO. 05V-099 FOR DETAILS.THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT IN THE BRAKE LAMP OR HAZARD LAMP CIRCUIT RESULTING IN INOPERATIVE BRAKE LAMPS AND HAZARD LAMPS.THIS IS DUE TO THE COMBINED EFFECTS OF THE MATERIAL AND LUBRICATION FOR THE HAZARD SWITCH CONTACTOR THAT RESULT IN INCREASED RESISTANCE IN THE HAZARD SWITCH AND STUCK HAZARD SLIDER BUTTON IN OPEN (NO CONTACT) CONDITION.DEALERS ARE TO REPLACE THE HAZARD SWITCH AND APPLY SPECIAL GREASE TO THE HAZARD SWITCH CONTACTOR.IF A VEHICLE HAS A STUCK HAZARD SLIDER BUTTON, DEALERS ARE TO REPLACE THE ENTIRE MULTIFUNCTION SWITCH.
Exterior Lighting:hazard Flashing Warning Lights
IN ITS LETTER DATED MARCH 9, 2005, GM STATED THAT IT WOULD CONDUCT A SAFETY RECALL TO REMEDY A FAULTY MULTIFUNCTION SWITCH IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 CHEVROLET ASTRO AND GMC SAFARI VEHICLES; SPECIFICALLY, ALL MY 2001 VEHICLES AND EARLY MY 2002 VEHICLES BUILT BETWEEN MARCH AND AUGUST 2001.SEE NHTSA RECALL NO. 05V-099 FOR DETAILS.THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT IN THE BRAKE LAMP OR HAZARD LAMP CIRCUIT RESULTING IN INOPERATIVE BRAKE LAMPS AND HAZARD LAMPS.THIS IS DUE TO THE COMBINED EFFECTS OF THE MATERIAL AND LUBRICATION FOR THE HAZARD SWITCH CONTACTOR THAT RESULT IN INCREASED RESISTANCE IN THE HAZARD SWITCH AND STUCK HAZARD SLIDER BUTTON IN OPEN (NO CONTACT) CONDITION.DEALERS ARE TO REPLACE THE HAZARD SWITCH AND APPLY SPECIAL GREASE TO THE HAZARD SWITCH CONTACTOR.IF A VEHICLE HAS A STUCK HAZARD SLIDER BUTTON, DEALERS ARE TO REPLACE THE ENTIRE MULTIFUNCTION SWITCH.