The contact owns a 2002 Chevrolet Astro. The contact stated that while driving at an undetermined speed, the accelerator throttle cable fractured in the stuck open position, causing the vehicle to accelerate to approximately 100 MPH independently. There were no warning lights illuminated. The local dealer was not contacted. The …
Read full complaint
The contact owns a 2002 Chevrolet Astro. The contact stated that while driving at an undetermined speed, the accelerator throttle cable fractured in the stuck open position, causing the vehicle to accelerate to approximately 100 MPH independently. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted and notified of the failure. The approximate failure mileage was 258,300.
NHTSA ODI #11490984
172,777 miles · Jan 15, 2010
Vehicle Speed Control
TL*THE CONTACT OWNS A 2002 CHEVROLET ASTRO VAN. WHILE DRIVING 30 TO 35 MPH, THE VEHICLE BEGAN ACCELERATING ON ITS OWN. THE VEHICLE WOULD NOT SLOW DOWN BY APPLYING THE BRAKES WHICH FORCED THE CONTACT TO SHIFT GEARS INTO NEUTRAL AND THEN INTO THIRD GEAR. WITHIN A FEW MINUTES, THE CONTACT WAS ABLE TO SLOW DOWN THE VEHICLE ENGAGING…
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET ASTRO VAN. WHILE DRIVING 30 TO 35 MPH, THE VEHICLE BEGAN ACCELERATING ON ITS OWN. THE VEHICLE WOULD NOT SLOW DOWN BY APPLYING THE BRAKES WHICH FORCED THE CONTACT TO SHIFT GEARS INTO NEUTRAL AND THEN INTO THIRD GEAR. WITHIN A FEW MINUTES, THE CONTACT WAS ABLE TO SLOW DOWN THE VEHICLE ENGAGING THE BRAKE PEDAL AND SHUT THE ENGINE OFF. THE CONTACT WAS INFORMED TO ENGAGE THE ACCELERATOR PEDAL TO LOOSEN THE THROTTLE; HOWEVER, WHEN HE RESTARTED THE VEHICLE THE RPM'S INCREASED RAPIDLY. THE POLICE HELPED THE CONTACT PUSH THE VEHICLE ONTO THE EMERGENCY LANE. THE VEHICLE WAS TOWED TO THE DEALER. THE DEALER STATED THAT THE RAPID ACCELERATION WAS DUE TO A FRAYED ACCELERATOR CABLE. THE DEALER REPLACED THE ACCELERATOR CABLE AND ADJUSTED THE IDLE AND THROTTLE PLATE. THE VEHICLE IS DRIVING NORMALLY. THE CONTACT REQUESTED THE PARTS FROM THE DEALER WHO STATED THAT THEY WERE NOT LONGER AVAILABLE. THE CONTACT IS CONCERNED ABOUT THE SAFETY RISK SINCE A CRASH COULD HAVE OCCURRED. THE FAILURE MILEAGE WAS 172,777.
NHTSA ODI #10299850
22,000 miles · Jul 19, 2004
Vehicle Speed Control
CONSUMER COMPLAINED ABOUT A SUDDEN ACCELERATION PROBLEM. THIS PROBLEM OCCURRED INTERMITTENTLY AND WITH OR WITHOUT THE AIR CONDITIONING BEING ON. DEALERSHIP TRIED TO RESOLVE THE PROBLEM. HOWEVER THE PROBLEM RECURRED. *AK *NM
NHTSA ODI #10075899
26,647 miles · Dec 14, 2003
Vehicle Speed Control
2002 CHEVROLET ASTRO VAN, APPROXIMATLEY 27,000 MILES ON ODOMETER. VEHICLE WILL NOT START FOR FOURTH TIME OVER A PERIOD OF ABOUT 6 MONTHS.*AK
NHTSA ODI #10049709
Mileage unknown · Nov 20, 2002
Vehicle Speed Control
WHILE TRAVELING ABOUT 30MPH ON THE HIGHWAY WITHOUT PRIOR WARNING. THE GAS PEDAL WAS STUCK AND EXCESSIVE SPEEDING AND SHE WAS ABLE TO STOP BY TURNING OFF THE VEHICLE. PLEASE PROVIDE ADDITIONAL INFORMATION. DEALER IS AWARE OF THE PROBLEM. TS
ON CERTAIN MINIVANS, THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT CONDITION IN THE STOP LAMP OR HAZARD LAMP CIRCUIT THAT RESULTS IN THE STOP LAMPS AND HAZARD LAMPS BEING INOPERATIVE.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING FLASHER SWITCH AND APPLY SPECIAL GREASE TO THE CONTACTS AT THE TIME OF INSTALLATION OF THE MODULE FREE OF CHARGE. THE REPAIR WOULD BE USED IN VEHICLES IN WHICH THE HAZARD SLIDER BUTTON IS STILL MOVABLE. IF A VEHICLE HAS A HAZARD SLIDER BUTTON THAT IS NOT MOVABLE (FROZEN), THE ENTIRE MULTIFUNCTION SWITCH WILL BE REPLACED. THE RECALL BEGAN ON APRIL 13, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
IN ITS LETTER DATED MARCH 9, 2005, GM STATED THAT IT WOULD CONDUCT A SAFETY RECALL TO REMEDY A FAULTY MULTIFUNCTION SWITCH IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 CHEVROLET ASTRO AND GMC SAFARI VEHICLES; SPECIFICALLY, ALL MY 2001 VEHICLES AND EARLY MY 2002 VEHICLES BUILT BETWEEN MARCH AND AUGUST 2001.SEE NHTSA RECALL NO. 05V-099 FOR DETAILS.THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT IN THE BRAKE LAMP OR HAZARD LAMP CIRCUIT RESULTING IN INOPERATIVE BRAKE LAMPS AND HAZARD LAMPS.THIS IS DUE TO THE COMBINED EFFECTS OF THE MATERIAL AND LUBRICATION FOR THE HAZARD SWITCH CONTACTOR THAT RESULT IN INCREASED RESISTANCE IN THE HAZARD SWITCH AND STUCK HAZARD SLIDER BUTTON IN OPEN (NO CONTACT) CONDITION.DEALERS ARE TO REPLACE THE HAZARD SWITCH AND APPLY SPECIAL GREASE TO THE HAZARD SWITCH CONTACTOR.IF A VEHICLE HAS A STUCK HAZARD SLIDER BUTTON, DEALERS ARE TO REPLACE THE ENTIRE MULTIFUNCTION SWITCH.
Additional source detail variants (2)
Exterior Lighting:brake Lights
IN ITS LETTER DATED MARCH 9, 2005, GM STATED THAT IT WOULD CONDUCT A SAFETY RECALL TO REMEDY A FAULTY MULTIFUNCTION SWITCH IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 CHEVROLET ASTRO AND GMC SAFARI VEHICLES; SPECIFICALLY, ALL MY 2001 VEHICLES AND EARLY MY 2002 VEHICLES BUILT BETWEEN MARCH AND AUGUST 2001.SEE NHTSA RECALL NO. 05V-099 FOR DETAILS.THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT IN THE BRAKE LAMP OR HAZARD LAMP CIRCUIT RESULTING IN INOPERATIVE BRAKE LAMPS AND HAZARD LAMPS.THIS IS DUE TO THE COMBINED EFFECTS OF THE MATERIAL AND LUBRICATION FOR THE HAZARD SWITCH CONTACTOR THAT RESULT IN INCREASED RESISTANCE IN THE HAZARD SWITCH AND STUCK HAZARD SLIDER BUTTON IN OPEN (NO CONTACT) CONDITION.DEALERS ARE TO REPLACE THE HAZARD SWITCH AND APPLY SPECIAL GREASE TO THE HAZARD SWITCH CONTACTOR.IF A VEHICLE HAS A STUCK HAZARD SLIDER BUTTON, DEALERS ARE TO REPLACE THE ENTIRE MULTIFUNCTION SWITCH.
Exterior Lighting:hazard Flashing Warning Lights
IN ITS LETTER DATED MARCH 9, 2005, GM STATED THAT IT WOULD CONDUCT A SAFETY RECALL TO REMEDY A FAULTY MULTIFUNCTION SWITCH IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 CHEVROLET ASTRO AND GMC SAFARI VEHICLES; SPECIFICALLY, ALL MY 2001 VEHICLES AND EARLY MY 2002 VEHICLES BUILT BETWEEN MARCH AND AUGUST 2001.SEE NHTSA RECALL NO. 05V-099 FOR DETAILS.THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT IN THE BRAKE LAMP OR HAZARD LAMP CIRCUIT RESULTING IN INOPERATIVE BRAKE LAMPS AND HAZARD LAMPS.THIS IS DUE TO THE COMBINED EFFECTS OF THE MATERIAL AND LUBRICATION FOR THE HAZARD SWITCH CONTACTOR THAT RESULT IN INCREASED RESISTANCE IN THE HAZARD SWITCH AND STUCK HAZARD SLIDER BUTTON IN OPEN (NO CONTACT) CONDITION.DEALERS ARE TO REPLACE THE HAZARD SWITCH AND APPLY SPECIAL GREASE TO THE HAZARD SWITCH CONTACTOR.IF A VEHICLE HAS A STUCK HAZARD SLIDER BUTTON, DEALERS ARE TO REPLACE THE ENTIRE MULTIFUNCTION SWITCH.
2002 Chevrolet Astro Problems, Complaints & Recalls | Skip That Year
Illustration